McIntosh-MC2KW-pwr-sm 维修电路原理图.pdf

Performance Specifications . 2Notes MC2KW. 3POWER MODULERear Panel . 3Section Location . 3Block Diagram . 4Interconnection Diagram . 5 - 6Amp Schematic and PCB . 7 - 9Heatsink Schematic and PCB . 10 - 11Heatsink Slave Schematic and PCB . 12 - 13Capacitor Schematic and PCB . 14Logo Schematic and PCB . 15Logo Schematic and PCB . 16Parts List . 17 - 19OUTPUT MODULERear Panel . 20Section Location . 20Interconnection Diagram . 21 - 22Main Schematic and PCB . 23 - 28Meter Power Supply Schematic and PCB. 29 - 32Meter Led Schematic and PCB . 33 - 34Parts List . 35 - 37Repacking Instruction . 39POWERMODULECONTENTSOUTPUTMODULESERVICE MANUALPOWER AMPLIFIERPRELIMINARYSERIAL NO.POWER MODULE WJ-A001 And AbovePOWER MODULE WJ-B001 And AboveOUTPUT MODULE WJ-C001 And AboveRadioFans.CN 收音机爱 好者资料库PERFORMANCE SPECIFICATIONSPower Output2000 watts into an 8, 4 or 2 ohm load is the minimum sinewave continuous average power output. The output RMSvoltage is:126.5V across 8 ohms89.5V across 4 ohms62.2V across 2 ohmsOutput Load Impedance8, 4 and 2 ohms (with three paors of terminals each forimpedance)Rated Power Band20Hz to 20,000HzTotal Harmonic Distortion0.005% maximum harmonic distortion at any power level from250 milliwatts to 2000 watts, 20Hz to 20,000HzDynamic Headroom2dBFrequency Response+0, -0.25dB from 20Hz to 20,000Hz+0, -3dB from 10Hz to 100,000HzSensitivity5.0 Volts Balanced Input2.5 Volts Unbalanced InputA-Weighted Signal To Noise Ratio90dB Unbalanced (123dB below rated output)94dB Balanced (127dB below rated output)Intermodulation Distortion0.005% maximum, if instantaneous peak power output doesnot exceed 4000 watts, for any combination of frequenciesfrom 20Hz to 20kHz.Wide Band Damping FactorGreater than 40Input Impedance10,000 ohmsPower GuardLess than 2% THD with up to 14dB overdriveGeneral SpecificationsMC2KW Output Module Power Requirements100 Volts, 50/60Hz at 35 watts110 Volts, 50/60Hz at 35 watts120 Volts, 50/60Hz at 35 watts220 Volts, 50/60Hz at 35 watts230 Volts, 50/60Hz at 35 watts240 Volts, 50/60Hz at 35 wattsMC2KW Power Module Power Requirements1100 Volts, 50/60Hz at 1440 watts110 Volts, 50/60Hz at 13.0 amps120 Volts, 50/60Hz at 12 amps220 Volts, 50/60Hz at 7.5 amps230 Volts, 50/60Hz at 6.5 amps240 Volts, 50/60Hz at 6.5 ampsNote: Refer to the rear panels of the MC2KW Output Module andMC2KW Power Modules for the correct voltage.Overall DimensionsMC2KW Output Module: Width is 17-3/4 inches (45.09cm),Height us 12-5/16 inches (31.27cm) including feet, Depth is 26-5/8 inches (62.54cm) including the front panel, handles, knobs andinterconnect cables2MC2KW Power Module: Width is 17-3/4 inches (45.09cm),Height us 12-5/16 inches (31.27cm) including feet, Depth is 26-5/8 inches (62.54cm) including the front panel, handles andinterconnect cables2WeightMC2KW Output Module is 121 poulds (54.9kg) net, 146 pounds(66.2kg) in shipping cartonMC2KW Power Module is 158 poulds (71.7kg) net, 183 pounds(83.0kg) in shipping carton1 The power requirements listed are for each MC2KW PowerModule, two are required for each MC2KW Power Amplifier2 Interconnect cables are supplied with the MC2KW OutputModule and both MC2KW Power Modules connect to theMC2KW Output Module.21. The heavy notes on the schematic denote the primarysignal path.2. Unless otherwise noted, all voltages indicated on theschematics are measured under the following conditions:a. AC input at 120 volts, 50/60Hz.b. All voltages are +/-10% with respect to ground. Ahigh impedance (10 megaohm) voltmeter must be used.3. Unless otherwise specified:a. Resistor values are in ohms.b. Capacitor values are microfarads (uF).c. Inductor values are in microhenries (uH).4. On PC board drawings, Square pad indicates:a. Polarized Capacitors - Positiveb. Diodes - Cathodec. Others - Pin 15. WARNINGParts marked with the symbol have criticalcharacteristics. Use only replacement parts recom-mended by the manufacturer.6. Soft startup procedure for servicing:1. Interconnect output module and power modules2. Connect Output Module to 120VAC3. Connect Power Modules to variac and set theoutput to zero.4. Turn Output Module power switch to on. (This willenergize the power relays in the Power Modules.)5. Gradually advance the variac to 120VAC whilemonitoring the AC current.NOTESRadioFans.CN 收音机爱 好者资料库3REAR PANELSECTION LOCATIONTOP VIEW WITH COVER REMOVEDMC2KWPOWER4BLOCK DIAGRAMINTERCONNECTMC2KWOUTPUT56178AMP 050215 SCH2AMP 050215 PCB2910HEATSINK 050216 SCH3AMC2KWPOWER3BHEATSINK 050216 PCB3A11123BHEATSINK SLAVE 050282 SCH4A 4BJ2R2R5129610J4J6GP2GP3R4R7R1GP1R3J1R6GP4J5R13R15Q11R21R23Q19C10R14Q10R16R20RT1R22Q18C11J3Q9R19R17Q17Q15Q13R12Q8R18Q12Q14Q16TOREDRev.ABLUMASTER HSGRNMC2KWPOWERHEATSINK SLAVE 0502824A 4B134343113434-80VJ6-80VJ680VJ580VJ5GRNREDGP180V-80V-80V-80VJ6J680V80VJ5J5RECT-J2RECT+J1J7J8J9J10J3J4J5J6C167000uFC267000uF+J7J8J10129592J1J3J5J4J9J6J2GP1REDREDGRNGRNREDGRNRev.AREDREDGRNGRN5CAPACITOR 05021714LOGO 0502186AB+15V6B6B22NC15V6B2215V15V15VGREENGREENJ5:2J5:1J5:2J5:115VGREENDS71.65kR4DS51.65kR3GREENDS11.65kR11kR915VJ5:3J5:4J5:3DS21.65kR2GREENGREENLOGO1J2:1LOGO1LOGO1J1:1GREENDS8DS6GREENDS3J2:3J2:215VJ1:4J1:2J1:3DS4MC2KWPOWER15S9B+NCLOGO26AJ2:36AJ2:2D6AJ2:1J5:3J5:1J5:2LOGO 0502186B16PARTS LISTINTERCONNECTT1POWER TRANSFORMER050230D1DIODE BRIDGE RECT070181RT1ASSY THERMISTOR052017RT2ASSY THERMISTOR052017CBCIRCUIT BREAKER 20A 240V088022AMPLIFIER PCB 050215C1CAP MONO 10PF 200V 10%061297C2CAP ELECT 100UF 25V066447C3CAP MONO .1UF 50V 20%061305C4CAP MONO .1UF 50V 20%061305C5CAP MONO .1UF 50V 20%061305C6CAP ELECT 10UF 50V066445C7CAP ELECT 22UF 100V066506C8CAP MONO .1UF 50V 20%061305C9CAP MONO .1UF 50V 20%061305C10CAP ELECT 10UF 50V066445C11CAP ELECT 100UF 25V066447C12CAP ELECT 10UF 100VDC066462C13CAP MONO 1PF 100V NPO061319C14CAP ELECT 10UF 100VDC066462C15CAP MONO 220PF 200V 10%061301C16CAP MONO 470PF 100V 10%061302C17CAP MONO 1000PF 50V 10%061303C18CAP MONO 1000PF 50V 10%061303C19CAP MONO 100PF 100V 10%061300C20CAP MONO 100PF 100V 10%061300C21CAP ELECT 220UF 25V066507C22CAP MONO 47PF 200V 10%061299C23CAP MONO 47PF 200V 10%061299C24CAP MONO 47PF 200V 10%061299C25CAP MONO .1UF 50V 20%061305C26CAP MONO .1UF 50V 20%061305D1DIODE SILICON070047D2DIODE SILICON070047D3DIODE SILICON070047D4DIODE SILICON070047D5DIODE SILICON070047D6DIODE SIL 400 PIV 1.5A070031D7DIODE SIL 400 PIV 1.5A070031D8DIODE SILICON070047D9DIODE SILICON070047D10DIODE SILICON070047J1HDR SHROUDED 2ROW 26PIN V117870J2CONN 3 POS M MTS100 NRML117214J3CONN 8 POS M FRICTION LOCK117275J4CONN 8 POS M FRICTION LOCK117275J5CONN 3 POS M MTS100 NRML117214J6BLADE FASTON W/FEET117708J7BLADE FASTON W/FEET117708J8HEADER 8 PIN MTA-156117717J9HEADER 8 PIN MTA-156117717J10BLADE FASTON W/FEET117708J11BLADE FASTON W/FEET117708J12BLADE FASTON W/FEET117708J13BLADE FASTON W/FEET117708J15CONN 4 PIN117215J16BLADE FASTON W/FEET117708K1RELAY POWER 24VDC/TV-15087042Q1TRANSISTOR PNP132224Q2TRANSISTOR PNP POWER132255Q3TRANSISTOR NPN132223Q4TRANSISTOR PNP132224Q5TRANSISTOR NPN132223Q6TRANSISTOR PNP132224Q7TRANSISTOR PNP132224Q8TRANSISTOR PNP 2SA1321C132286Q9TRANSISTOR NPN 2SC3334C132285Q10TRANSISTOR N JFET132222Q11TRANSISTOR N JFET132222Q12TRANSISTOR SI NPN 25V132254Q13TRANSISTOR PNP POWER132255Q14TRANSISTOR PNP132224Q15TRANSISTOR NPN132223Q16TRANSISTOR SI NPN 25V132254Q17TRANSISTOR PNP POWER132255Q18TRANSISTOR NPN132223Q19TRANSISTOR PNP132224Q20TRANSISTOR SI NPN 25V132254Q21TRANSISTOR PNP POWER132255Q22TRANSISTOR NPN 2SC3334C132285Q23TRANSISTOR PNP SILICON132172Q24TRANSISTOR PNP 2SA1321C132286Q25TRANSISTOR NPN 2SC3334C132285Q26TRANSISTOR NPN SILICON132171Q27TRANSISTOR PNP 2SA1321C132286Q28TRANSISTOR PNP 2SA1321C132286Q29TRANSISTOR NPN 2SC3334C132285Q30TRANSISTOR NPN132223Q31TRIAC OPTOCOUPLER131024Q32TRANSISTOR PNP SILICON132172Q33TRANSISTOR PNP 2SA1321C132286Q34TRANSISTOR NPN 2SC3334C132285Q35TRANSISTOR NPN SILICON132171Q36TRANSISTOR NPN132223R1RES MF 47.5K 1% 1/4W144108R2RES MF 2.21K .5% 1/4W144396R3RES MF 2.21K .5% 1/4W144396R4RES MET OX 430 OHM .5W 5%137095R5RES MF 47.5K 1% 1/4W144108R6RES MF 4.75K 1% 1/4W144097R7RES MF 475 OHM 1% 1/4W144086R8RES MF 47.5K 1% 1/4W144108R9RES MF 1.91K .5% 1/4W144395R10RES MF 47.5K 1% 1/4W144108R11RES MF 1.91K .5% 1/4W144395R12RES MF 221K 1% 1/4W144421R13RES MF 475 OHM 1% 1/4W144086R14RES MF 100 OHM 1% 1/4W144196R15RES MET OX 430 OHM .5W 5%137095R16RES MF 100 OHM 1% 1/4W144196R17RES MF 1K 1% 1/4W144090R18RES MF 100 OHM 1% 1/4W144196R19RES MF 100 OHM 1% 1/4W144196R20RES MF 3.32K 1% 1/4W144095R21RES MF 2.21M 1/4W144265R22RES MF 1K 1% 1/4W144090R23RES MF 475K 1% 1/4W144364R24RES MET OX 47 OHM .5W 5%137096R25RES MET OX 680 OHM .5W 5%137093MC2KWPOWER17Ref. No.DescriptionPart No.12R26RES MF 1K 1% 1/4W144090R27RES MF 475K 1% 1/4W144364R28RES MET OX 47 OHM .5W 5%137096R29RES MF 47.5K 1% 1/4W144108R30RES MF 47.5K 1% 1/4W144108R31RES MF 2.21K 1% 1/4W144298R32RES MF 2.21K 1% 1/4W144298R33RES MF 221 OHM 1% 1/4W144172R34RES MF 221 OHM 1% 1/4W144172R35RES MF 806 OHM 1% 1/4W144089R36RES MF 806 OHM 1% 1/4W144089R37RES MF 221 OHM 1% 1/4W144172R38RES MF 221 OHM 1% 1/4W144172R39RES MF 681 OHM 1% 1/4W144195R40RES MF 681 OHM 1% 1/4W144195R41RES MF 267K 1% 1/4W144118R42RES MF 1.5K 1% 1/4W144128R43RES MF 365 OHM 1% 1/4W144071R44RES MF 221 OHM 1% 1/4W144172R45RES MF 221 OHM 1% 1/4W144172R46RES MF 6.49K .5% 1/4W144401R47RES MF 5.36K .5% 1/4W144399R48RES MET OX 680 OHM .5W 5%137093R49RES MF 5.36K .5% 1/4W144399R50RES FP 10 OHM 5% 1/4W137025R51RES FP 10 OHM 5% 1/4W137025R52RES FP 10 OHM 5% 1/4W137025R53RES FP 10 OHM 5% 1/4W137025R54POT 500 OHMS LINEAR 20%134396R55RES MF 22.1K 1% 1/4W144187R56RES MET OX 1.8k .5W 5%137094R57RES MF 22.1K 1% 1/4W144187R58RES MF 1.5K 1% 1/4W144128R59RES MF 475 OHM 1% 1/4W144086R60RES MF 10K 1% 1/4W144053R61RES MET OX 430 OHM .5W 5%137095R62RES MF 221 OHM 1% 1/4W144172R63RES MF 221 OHM 1% 1/4W144172R64RES MET OX 1.8k .5W 5%137094R65RES MF 15K 1% 1/4W144412R66RES MET OX 430 OHM .5W 5%137095R67POT 500 OHMS LINEAR 20%134396U1IC OPERTIONAL AMP LOW NSE133067U2IC OPERTIONAL AMP LOW NSE133067HEATSINK PCB 050216C2CAP MONO .01UF 50V 20% X7R061304C3CAP ELECT 47UF 35V066446C4CAP ELECT 47UF 35V066446C5CAP MONO .01UF 50V 20% X7R061304C8CAP DISC MONO .47UF 50V061249C10CAP POLYPROP 1uF 160V 5%064451C11CAP POLYPROP 1uF 160V 5%064451D1DIODE SILICON070047D2DIODE SILICON070047D3DIODE SILICON070047D4DIODE SILICON070047D5DIODE SILICON070047D6DIODE SILICON070047D7DIODE SILICON070047GP1STANDOFF 6-32 X 1/4 PCB MNT112130GP2STANDOFF 6-32 X 1/4 PCB MNT112130GP3STANDOFF 6-32 X 1/4 PCB MNT112130GP4STANDOFF 6-32 X 1/4 PCB MNT112130HS1HEATSINK018787J1CONN 8 POS M FRICTION LOCK117275J2BLADE FASTON W/FEET117708J3CONN 3 POS M MTS100 NRML117214J4CONN 2 POS RIGHT ANGLE117274J5BLADE FASTON W/FEET117708J6BLADE FASTON W/FEET117708Q2TRANSISTOR NPN SILICON132171Q3TRANSISTOR PNP SILICON132172Q6TRANSISTOR MJE15032 NPN132288Q7TRANSISTOR MJE15033 PNP132289Q8TRANS NPN THERMTRAK132300Q9TRANS PNP THERMTRAK132301Q10TRANS NPN THERMTRAK132300Q11TRANS PNP THERMTRAK132301Q12TRANS NPN THERMTRAK132300Q13TRANS PNP THERMTRAK132301Q14TRANSR NPN THERMTRAK132300Q15TRANSR PNP THERMTRAK132301Q16TRANSR NPN THERMTRAK132300Q17TRANS PNP THERMTRAK132301Q18TRANS NPN THERMTRAK132300Q19TRANS PNP THERMTRAK132301R1RES MF 1K 1% 1/4W144090R2RES MF 2.21 OHM 1% 1/4W144378R3RES MF 1K 1% 1/4W144090R4RES MET OX 220 OHM .5W 5%137097R5RES MET OX 220 OHM .5W 5%137097R6RES MF 22.1K 1% 1/4W144187R7RES MF 22.1K 1% 1/4W144187R8RES MET OX 680 OHM .5W 5%137093R9RES MET OX 680 OHM .5W 5%137093R11RES MET OX 47 OHM .5W 5%137096R12RES WW .68 OHM 5W 5%139245R13RES WW .68 OHM 5W 5%139245R14RES WW .68 OHM 5W 5%139245R15RES WW .68 OHM 5W 5%139245R16RES WW .68 OHM 5W 5%139245R17RES WW .68 OHM 5W 5%139245R18RES WW .68 OHM 5W 5%139245R19RES WW .68 OHM 5W 5%139245R20RES WW .68 OHM 5W 5%139245R21RES WW .68 OHM 5W 5%139245R22RES WW .68 OHM 5W 5%139245R23RES WW .68 OHM 5W 5%139245R25RES MF 2.21 OHM 1% 1/4W144378R26RES MF 2.21 OHM 1% 1/4W144378R27RES MF 2.21 OHM 1% 1/4W144378RT1SENSOR THERMAL144249HEATSINK SLAVE PCB 050282C10CAP POLYPROP 1uF 250V 5%064451C11CAP POLYPROP 1uF 250V 5%064451GP1STANDOFF 6-32 X 1/4 PCB MNT112130GP2STANDOFF 6-32 X 1/4 PCB MNT112130GP3STANDOFF 6-32 X 1/4 PCB MNT112130GP4STANDOFF 6-32 X 1/4 PCB MNT112130HS1HEATSINK018787J1CONN 3 POS M MTS100 NRML117214J2BLADE FASTON W/FEET117708PARTS LIST cont183A3B4A4BJ3CONN 3 POS M MTS100 NRML117214J4CONN 2 POS RIGHT ANGLE117274J5BLADE FASTON W/FEET117708J6BLADE FASTON W/FEET117708Q8TRANS NPN THERMLTRAK132300Q9TRANS PNP THERMLTRAK132301Q10TRANS NPN THERMLTRAK132300Q11TRANS PNP THERMLTRAK132301Q12TRANS NPN THERMLTRAK132300Q13TRANS PNP THERMLTRAK132301Q14TRANS NPN THERMLTRAK132300Q15TRANS PNP THERMLTRAK132301Q16TRANS NPN THERMLTRAK132300Q17TRANS PNP THERMLTRAK132301Q18TRANS NPN THERMLTRAK132300Q19TRANS PNP THERMLTRAK132301R1RES MF 1K 1% 1/4W144090R2RES MF 2.21 OHM 1% 1/4W144378R3RES MF 1K 1% 1/4W144090R4RES MF 2.21 OHM 1% 1/4W144378R5RES MF 2.21 OHM 1% 1/4W144378R6RES MF 2.21 OHM 1% 1/4W144378R7RES MET OX 47 OHM .5W 5%137096R12RES WW .68 OHM 5W 5%139245R13RES WW .68 OHM 5W 5%139245R14RES WW .68 OHM 5W 5%139245R15RES WW .68 OHM 5W 5%139245R16RES WW .68 OHM 5W 5%139245R17RES WW .68 OHM 5W 5%139245R18RES WW .68 OHM 5W 5%139245R19RES WW .68 OHM 5W 5%139245R20RES WW .68 OHM 5W 5%139245R21RES WW .68 OHM 5W 5%139245R22RES WW .68 OHM 5W 5%139245R23RES WW .68 OHM 5W 5%139245RT1SENSOR THERMAL144249CAPACITOR PCB 050217C2CAP MONO .01UF 50V 20% X7R061304C3CAP ELECT 47UF 35V066446C4CAP ELECT 47UF 35V066446C5CAP MONO .01UF 50V 20% X7R061304C8CAP DISC MONO .47UF 50V061249C10CAP POLYPROP 1uF 160V 5%064451C11CAP POLYPROP 1uF 160V 5%064451D1DIODE SILICON070047D2DIODE SILICON070047D3DIODE SILICON070047D4DIODE SILICON070047D5DIODE SILICON070047D6DIODE SILICON070047D7DIODE SILICON070047GP1STANDOFF 6-32 X 1/4 PCB MNT112130GP2STANDOFF 6-32 X 1/4 PCB MNT112130GP3STANDOFF 6-32 X 1/4 PCB MNT112130GP4STANDOFF 6-32 X 1/4 PCB MNT112130HS1HEATSINK018787J1CONN 8 POS M FRICTION LOCK117275J2BLADE FASTON W/FEET117708J3CONN 3 POS M MTS100 NRML117214J4CONN 2 POS RIGHT ANGLE117274J5BLADE FASTON W/FEET117708J6BLADE FASTON W/FEET117708Q2TRANSISTOR NPN SILICON132171Q3TRANSISTOR PNP SILICON132172Q6TRANSISTOR MJE15032 NPN132288Q7TRANSISTOR MJE15033 PNP132289Q8TRANS NPN THERMLTRAK132300Q9TRANS PNP THERMLTRAK132301Q10TRANS NPN THERMLTRAK132300Q11TRANS PNP THERMALTRAK132301Q12TRANS NPN THERMALTRAK132300Q13TRANS PNP THERMLTRAK132301Q14TRANS NPN THERMLTRAK132300Q15TRANS PNP THERMLTRAK132301Q16TRANS NPN THERMLTRAK132300Q17TRANS PNP THERMLTRAK132301Q18TRANS NPN THERMLTRAK132300Q19TRANS PNP THERMLTRAK132301R1RES MF 1K 1% 1/4W144090R2RES MF 2.21 OHM 1% 1/4W144378R3RES MF 1K 1% 1/4W144090R4RES MET OX 220 OHM .5W 5%137097R5RES MET OX 220 OHM .5W 5%137097R6RES MF 22.1K 1% 1/4W144187R7RES MF 22.1K 1% 1/4W144187R8RES MET OX 680 OHM .5W 5%137093R9RES MET OX 680 OHM .5W 5%137093R11RES MET OX 47 OHM .5W 5%137096R12RES WW .68 OHM 5W 5%139245R13RES WW .68 OHM 5W 5%139245R14RES WW .68 OHM 5W 5%139245R15RES WW .68 OHM 5W 5%139245R16RES WW .68 OHM 5W 5%139245R17RES WW .68 OHM 5W 5%139245R18RES WW .68 OHM 5W 5%139245R19RES WW .68 OHM 5W 5%139245R20RES W