Pioneer-VSXS510-avr-sm 电路图 维修手册.pdf

ORDER NO. PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION2013 2013 Printed in Japan VSX-S510-K RRV4490 AV RECEIVER VSX-S510-K VSX-S510-S VSX-S310-K VSX-S310-S THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). ModelTypePower RequirementRemarks VSX-S510-KSYXE8AC 220 V to 230 V VSX-S510-SSYXE8AC 220 V to 230 V VSX-S310-KSYXE8AC 220 V to 230 V VSX-S310-SSYXE8AC 220 V to 230 V K-FZV OCT. RadioFans.CN 收音机爱 好者资料库 2VSX-S510-K 1234 A B C D E F 1234 SAFETY INFORMATION This service manual is intended for qualified service technicians; it is not meant for the casual do-it- yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. RadioFans.CN 收音机爱 好者资料库 3VSX-S510-K 5678 5678 A B C D E F CONTENTS SAFETY INFORMATION.2 1. SERVICE PRECAUTIONS.4 1.1 NOTES ON SOLDERING.4 2. SPECIFICATIONS.5 2.1 ACCESSORIES.5 2.2 SPECIFICATIONS.5 3. BASIC ITEMS FOR SERVICE .6 3.1 CHECK POINTS AFTER SERVICING .6 3.2 PCB LOCATIONS.7 3.3 JIGS LIST.8 4. BLOCK DIAGRAM .10 4.1 OVERALL CONNECTION DIAGRAM.10 4.2 BLOCK DIAGRAM FOR AUDIO BLOCK.12 4.3 BLOCK DIAGRAM FOR DMAIN ASSY (1) (VSX-S510).14 4.4 BLOCK DIAGRAM FOR DMAIN ASSY (2) (VSX-S510).16 4.5 BLOCK DIAGRAM FOR DMAIN ASSY (VSX-S310).18 4.6 BLOCK DIAGRAM FOR POWER BLOCK (1) .20 4.7 BLOCK DIAGRAM FOR POWER BLOCK (2) .22 4.8 BLOCK DIAGRAM FOR GND BLOCK.24 5. DIAGNOSIS .26 5.1 TROUBLESHOOTING.26 5.2 PROTECTION CIRCUIT DESCRIPTION.36 6. SERVICE MODE.38 6.1 SERVICE MODE .38 7. DISASSEMBLY .42 8. EACH SETTING AND ADJUSTMENT.56 8.1 UPDATING OF THE FIRMWARE (VSX-S510).56 8.2 UPDATING OF THE FIRMWARE (VSX-S310).60 9. EXPLODED VIEWS AND PARTS LIST.66 9.1 PACKING SECTION.66 9.2 EXTERIOR SECTION .68 9.3 FRONT SECTION .70 10. SCHEMATIC DIAGRAM.72 10.1 MAIN ASSY (1/3).72 10.2 MAIN ASSY (2/3).74 10.3 MAIN ASSY (3/3).76 10.4 DMAIN ASSY (1/6) (VSX-S510).78 10.5 DMAIN ASSY (2/6) (VSX-S510).80 10.6 DMAIN ASSY (3/6) (VSX-S510).82 10.7 DMAIN ASSY (4/6) (VSX-S510).84 10.8 DMAIN ASSY (5/6) (VSX-S510).86 10.9 DMAIN ASSY (6/6) (VSX-S510).88 10.10 DMAIN ASSY (1/3) (VSX-S310).90 10.11 DMAIN ASSY (2/3) (VSX-S310).92 10.12 DMAIN ASSY (3/3) (VSX-S310).94 10.13 BT ASSY.96 10.14 FHDMI ASSY.98 10.15 USB ASSY and FRONT ASSY.100 10.16 DAMP ASSY.102 10.17 POWER TRANS ASSY.104 10.18 SIDE CNT ASSY .106 10.19 BRIDGE, AMP GUARD, MAIN GUARD,CABLE and CLAMP ASSYS.108 11. PCB CONNECTION DIAGRAM.110 11.1 MAIN ASSY.110 11.2 DMAIN ASSY (VSX-S510) .114 11.3 DMAIN ASSY (VSX-S310) and BT ASSY (VSX-S510).118 11.4 FHDMI ASSY (VSX-S510) and USB ASSY (VSX-S310) .122 11.5 FRONT ASSY.124 11.6 DAMP ASSY.128 11.7 POWER TRANS ASSY.132 11.8 SIDE CNT ASSY and BRIDGE ASSY.134 11.9 AMP GUARD, MAIN GUARD, CABLE (VSX-S510) and CLAMP ASSYS .136 12. PCB PARTS LIST.138 RadioFans.CN 收音机爱 好者资料库 4VSX-S510-K 1234 A B C D E F 1234 1. SERVICE PRECAUTIONS 1.1 NOTES ON SOLDERING For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Do NOT use a soldering iron whose tip temperature cannot be controlled. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. 5VSX-S510-K 5678 5678 A B C D E F 2. SPECIFICATIONS 2.1 ACCESSORIES 2.2 SPECIFICATIONS Setup microphone : APM7011 Remote control unit (AXD7719) : 8300771900010-IL AM loop antenna : E601019000010-IL FM wire antenna : E605010140010-IL Power cord : L068250160020-IL Quick start guide : 5707000008480-IL Speaker caution sheet : 5227000001050-IL Operating instructions (CD-ROM) : 6517000001550-IL Warranty card : ARY7158 AAA size IEC R03 dry cell batteries x2 Audio section Rated power output (Front, Center, Surround and Surround back for VSX-S510) . . . . . . . . . . . . . . . . . . . 110 W per channel (1 kHz, 4 , 1 %) 65 W per channel (20 Hz to 20 kHz, 8 , 0.5 %) Total Harmonic Distortion . . . . . 0.08 % (20 Hz to 20 kHz, 8 , Rated Ouput 3 dB/ch) Frequency response (Pure Direct mode) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 Hz to 20 kHz 3 dB Guaranteed speaker impedance . . . . . . . . . . . . . . . 4 to 16 Input Sensitivity CD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 200 mV Signal-to-Noise Ratio (IHF, short circuited, A network) CD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95 dB Video Section (VSX-S310 only) Signal level Composite Output . . . . . . . . . . . . . . . . . . . . . . 1 Vp-p (75 ) Tuner Section Frequency Range (FM) . . . . . . . . . . . . . . 87.5 MHz to 108 MHz Antenna Input (FM) . . . . . . . . . . . . . . . . . . . . . 75 unbalanced Frequency Range (AM) . . . . . . . . . . . . . . 531 kHz to 1602 kHz Antenna (AM) . . . . . . . . . . . . . . . . . . . . . . . . . . . .Loop antenna Digital In/Out Section HDMI terminal . . . . . . . . . . . . . . . . . . . . . . . . . .Type A (19-pin) HDMI input/MHL terminal (VSX-S510 only). . . . . . . . .5 V, 0.9 A USB terminal . . . . . . . . . USB2.0 High Speed (Type A) 5 V, 2.1 A (VSX-S510) . . . . . . . . . . . USB2.0 Full Speed (Type A) 5 V, 1 A (VSX-S310) iPod terminal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .