Sony-STRV777ES-rec-sm 电路图 维修手册.pdf
STR-DA777ES/V777ES US Model Canadian Model E Model Australian Model PX Model STR-DA777ES Chinese Model STR-V777ES SERVICE MANUAL FM STEREO FM-AM RECEIVER MICROFILM Continued on next page SPECIFICATIONS Manufactured under license from Dolby Laboratories Licensing Corporation. Dolby, “DOLBY”, the double-D symbol ;, AC-3 and “Pro Logic” are trademarks of Dolby Laboratories Licensing Corporation. Photo : STR-DA777ES AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION: With 8 loads, both channels driven, from 20 - 20,000 Hz; rated 120 watts per channel minimum RMS power, with no more than 0.05% total harmonic distortion from 250 milliwatts to rated output. (US model only) Audio section POWER OUTPUT Stereo mode 8 120 W + 120 W 4 100 W + 100 W (THD 0.05%, 20 Hz - 20 kHz)* (DIN 1 kHz) Surround mode 8 Front: 120W + 120W Centera): 120W Reara): 120W + 120W 4 Front: 100W + 100W Centera): 100W Reara): 100W + 100W (THD 0.05%, 20 Hz - 20 kHz)* (DIN 1 kHz) * US/Canadian models only . a) Depending on the sound field settings and the source, there may be no sound output. Frequency response PHONO: 20 Hz 20 kHz RIAA 0.5 dB LINE (TUNER, CD, MD/DAT, TAPE, TV/SAT or TV/LD, DVD/LD or DVD, VIDEO 1, 2, and VIDEO 3): 10 Hz 100 kHz +0.5/2.0 dB (ANALOG DIRECT) Signal-to-noise ratio DIGITAL: 100 dB (A, 20 kHz LPF) PHONO: 86 dB* (A, 5 mV) LINE: 100 dB* (A, 20 kHz LPF) * ANALOG DIRECT Inputs (Analog) PHONO: Sensitivity: 4 mV Impedance: 50 k LINE (TUNER, CD, MD/DAT, TAPE, TV/SAT or TV/LD, DVD/LD or DVD, VIDEO 1, 2, and VIDEO 3): Sensitivity: 200 mV Impedance: 50 k Inputs (Digital) Coaxial (DVD/LD or DVD, CD) : Sensitivity: Impedance: 75 Optical (DVD/LD or DVD, TV/SAT or TV/LD, MD/DAT) : Sensitivity: Impedance: Outputs (Analog) REC OUT (MD/DAT, TAPE, VIDEO 1, 2, 3): Voltage: 200 mV, Impedance: 1 k PRE OUT (FRONT L/R, CENTER, REAR L/R, SUB WOOFER): Voltage: 2 V Impedance: 1 k PHONES: Accepts low- and high-impedance headphones RadioFans.CN 收音机爱 好者资料库 2 MODEL DA777ES: US model DA777ES: Canadian model DA777ES: E, PX models DA777ES: Malaysia, Singapore, Australian models V777ES:Chinese model PARTS No. 4-222-054-0s 4-222-054-1s 4-222-054-2s 4-222-054-3s 4-222-054-4s PART NO. MODEL IDENTIFICATION BACK PANEL FM tuner section Tuning range87.5 - 108.0 MHz Antenna terminals 75 , unbalanced SensitivityMono: 18.3 dBf, 2.2 V/75 Stereo: 38.3 dBf, 22.5 V/75 Usable sensitivity 11.2 dBf, 1 V/75 S/NMono: 76 dB Stereo: 70 dB Harmonic distortion at 1 kHz Mono: 0.3% Stereo: 0.5% Separation45 dB at 1 kHz Frequency response 30 Hz - 15 kHz +0.5/2 dB Selectivity60 dB at 400 kHz AM tuner section Tuning rangeUS/Canadian models: With 10-kHz tuning scale: 530 - 1710 kHz With 9-kHz tuning scale: 531 - 1710 kHz Singapore/Malaysia models: 5311602 kHz (9 kHz interval) Other models: 5311602 kHz (9 kHz interval) 5301610 kHz (10 kHz interval) AntennaLoop antenna Usable sensitivity 50 dB/m (at 1,000 kHz or 999 kHz) S/N54 dB (at 50 mV/m) Harmonic distortion 0.5 % (50 mV/m, 400 kHz) SelectivityAt 9 kHz: 35 dB At 10 kHz: 40 dB Video section InputsVideo: 1 Vp-p 75 S-video: Y: 1 Vp-p 75 C: 0.286 Vp-p 75 OutputsVideo: 1 Vp-p 75 S-video: Y: 1 Vp-p 75 C: 0.286 Vp-p 75 General Power requirements US/Canadian models: 120 V AC, 60Hz Singapore/Malaysia models: 220 - 230 V AC, 50/60 Hz Other models: 120/220/240 V AC, 50/60 Hz Power consumption US model: 450 W Canadian model: 650 VA Singapore/Malaysia models: 420 W Other models: 450 W AC outletsUS/Canadian models: 2 switched, total 120 W/1 A Other models: 2 switched, total 100 W Dimensions 430 174 462 mm (17 6 7/8 18 1/4 inches) including projecting parts and controls Mass (Approx.) 24.5 kg (54 lbs. 1 oz.) Supplied accessories Design and specifications are subject. to change without notice. FM wire antenna (1) AM loop antenna (1) Remote commander RM-TP503 (remote) (1) LR6 (size-AA) alkaline batteries (4) Coin shaped lithium battery (CR-2032) (1) US/Canadian models only: Audio/video/control S connecting cord (1) CONTROL S connecting cord (1) Outputs (Digital) Optical (MD/DAT) Sampling Frequency 48 kHz EQBASS: 99 Hz 1.0 kHz (21 steps) MID: 198 Hz 10 kHz (37 steps) TREBLE: 1.0 kHz 10 kHz (23 steps) Gain levels: 10 dB, 0.5 dB step Decodable Digital Fomats Dolby Digital (AC-3), DTS RadioFans.CN 收音机爱 好者资料库 3 SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1.A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers instructions to use these instruments. 2.A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3.Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A) SAFETY CHECK-OUT To Exposed Metal Parts on Set 0.15 F 1.5 k AC Voltmeter (0.75 V) Earth Ground Fig. A. Using an AC voltmeter to check AC leakage. ATTENTION AU COMPOSANT AYANT RAPPORT LA SCURIT! LES COMPOSANTS IDENTIFS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHMATIQUES ET LA LISTE DES PICES SONT CRITIQUES POUR LA SCURIT DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PISES SONY DONT LES NUMROS SONT DONNS DANS CE MANUEL OU DANS LES SUPPMENTS PUBLIS PAR SONY. TABLE OF CONTENTS 1.GENERAL 4 2.ADJUSTMENT 6 3.DIAGRAMS7 3-1.Circuit Board Location 7 3-2.Block Diagram Main Section 8 3-3.Block Diagram Digital Section 9 3-4.Block Diagram Control Section 10 3-5.Block Diagram Power Section 11 3-6.Printed Wiring Board Audio Section12 3-7.Schematic Diagram Audio Section13 3-8.Printed Wiring Board Video Section 14 3-9.Schematic Diagram Video Section 15 3-10. Printed Wiring Board Volume Section(SIDE A) 16 3-11. Printed Wiring Board Volume Section(SIDE B) 17 3-12. Schematic DiagramVolume Section(1/2) 18 3-13. Schematic DiagramVolume Section(2/2) 19 3-14. Printed Wiring Board Digital Section(SIDE A) 20 3-15. Printed Wiring Board Digital Section(SIDE B) 21 3-16. Schematic Diagram Digital Section(1/7) 22 3-17. Schematic Diagram Digital Section(2/7) 23 3-18. Schematic Diagram Digital Section(3/7) 24 3-19. Schematic Diagram Digital Section(4/7) 25 3-20. Schematic Diagram Digital Section(5/7) 26 3-21. Schematic Diagram Digital Section(6/7) 27 3-22. Schematic Diagram Digital Section(7/7) 28 3-23. Printed Wiring Board AMP Section 29 3-24. Schematic Diagram AMP Section(1/2) 30 3-25. Schematic Diagram AMP Section(2/2) 31 3-26. Printed Wiring Board Display Section(SIDE A) 32 3-27. Printed Wiring Board Display Section(SIDE B) 33 3-28. Schematic Diagram Display Section(1/2) 34 3-29. Schematic Diagram Display Section(2/2) 35 3-30. Printed Wiring Board Switch Section 36 3-31. Printed Wiring Board Control Jack Section 37 3-32. Schematic Diagram Control Jack Section 37 3-33. Printed Wiring Board Speaker Terminal Section 38 3-34. Schematic Diagram Speaker Terminal Section 39 3-35. Printed Wiring Board Power Supply Section 40 3-36. Printed Wiring Board AC Power Supply Section 41 3-37. Schematic Diagram Power Supply Section 42 3-38. IC Block Diagrams43 3-39. IC Pin Function Description 47 4.EXPLODED VIEWS 4-1.Case Section 52 4-2.Chassis Section 53 4-3.Front Panel Section 54 4-4.Back Panel Section 56 5.ELECTRICAL PARTS LIST57 RadioFans.CN 收音机爱 好者资料库 4 SECTION 1 GENERAL FRONT PANEL SECTION 1?/1 switch 2INPUT SELECTOR knob 3AUDIO SPLIT button 4DIGITAL/ANALOG button 55.1CH INPUT button 6IR emitter 7IR receptor 8MEMORY button 9TUNER PRESET +/ button FM/AM button 0SOUND FIELD PRESET +/ button qaMULTICHANNEL DECODING indicator qsA.F.D button MODE +/ buttons 2CH button ANALOG DIRECT button qf wgqg2 qd534qaqs wfwh wd ws w;qk qj qlwa qh 9q;687 PHONES SPEAKERS A OFF A+B B MEMORY+A.F.D FM / AMTUNER PRESET 010 MULTI CHANNEL DECODING OPEN/ CLOSE MASTER VOLUME 19 8 7 2 3 6 5 4 AUDIO SPLITDIGITAL / ANALOG 1 / u + ENTER EQSURLEVEL TUNERCUSTOMSET UP VIDEOS-VIDEOL AUDIO R 2 CHANALOG DIRECTEQ BANK5.1CH INPUT SOUND FIELD PRESETSOUND FIELD INPUT SELECTOR MODE 1 qdEQ BANK button qfMASTER VOLUME knob qgOPEN/CLOSE button qhENTER button qjCursor buttons (I/i) qkJog dial qlSET UP button w;LEVEL button waCUSTOM button wsSUR button wdTUNER button wfEQ button wgSPEAKERS selector knob PHONES jack whVIDEO 3 jack 5 REAR PANEL SECTION 1DIGITAL jack 2MONITOR OUT jack 3VIDEO 1 jack 4VIDEO 2 jack 5DVD/LD jack 6TAPE jack 7MD/DAT jack 8ANTENNA 9PHONO jack 0CONTROL A1 II jack qaRS-232C qsVOLTAGE SELECRTOR switch (E,PX model) AC OUTLET B + SPEAKERS IMPEDANCE USE 4 - 16 FRONTREARCENTERALRLRLR R L R L R IN REC OUT IN IN OUT IN IN IN OUT IN CENTER SUB WOOFERREARFRONT CENTER SUB WOOFERREARFRONT TV/ SAT DVD/ LD VIDEO 1 MONITOR OUT VIDEO 2 REC OUT L RAUDIO S-VIDEO DVD/LD IN COAX CD IN COAX DVD/LD IN OPT TV/SAT IN OPT MD/DAT IN OPT MD/DAT OUT OPT CD IN OPT MONITOR CTRL S IN STATUS IN CTRL S OUT VIDEO 1 DVD/ LD TV/ SAT VIDEO L 2ND AUDIO OUT PRE OUT5.1CH INPUT 4 8 IMPEDANCE SELECTOR CONTROL A1 TAPE MD/ DAT CD L SIGNAL GND AM y y FM 75 COAXIAL ANTENNA PHONO R 345 678 9q;1 2qsqa wfwd qd wswa w;qlqk qjqhqgqf qdAC OUTLET qfPower cord qgIMPEDANCE SELECTOR switch qhFRONT SPEAKER terminal qjCENTER SPEAKER terminal qkREAR SPEAKER terminal qlCD jack w;2ND AUDIO OUT jack waPRE OUT jack wsTV/SAT jack wd5.1CH INPUT jack wfCONTROL S jack (US,Canadian model) 6 SECTION 2 ADJUSTMENT RV4101 BIAS BIAS BOARD RV4101 BIAS BIAS BOARD RV4101 BIAS BIAS BOARD RV4101 BIAS BIAS BOARD RV4101 BIAS BIAS BOARD AMP BOARD CN4153CN4203CN4103 CN4353CN4303 Electrical adjustments BIAS adjustment Conditions : VOLUME: MIN Input signal: No signal (no load) Procedure : Adjust RV4101 on the BIAS board so that 10mV is obtained across the CN4103, CN4153, CN4203, CN4303 and CN4353 on the AMP board respectively. STR-DA777ES/V777ES 77 Caution: Pattern face side:Parts on the pattern face side seen from (SIDE B)the pattern face are indicated. Parts face side:Parts on the parts face side seen from (SIDE A)the parts face are indicated. For schematic diagrams. Note: All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified. %: indicates tolerance. 2 : nonflammable resistor. 1 : fusible resistor. C : panel designation. U : B+ Line. V : B Line. H : adjustment for repair. Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. No mark : FM Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal produc- tion tolerances. Waveforms are taken with a oscilloscope. Circled numbers refer to waveforms. Signal path. F: FM J: CD c: DIGITAL I : PHONO Abbreviation CND:Canadian model AUS:Australian model MY:Malaysia model SP:Singapore model CH:Chinese model THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this necessary note is printed in each block.) Waveform DIGITAL Board DISPLAY Board For printed wiring boards. Note: X : parts extracted from the component side. a: Through hole. b : Pattern from the side which enables seeing. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifis par une marque 0 sont cri- tiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi. 1 IC347 <z/ (CLKO) 2 IC357 3 (EXTAL) 3 IC352 qh (XOUT) 3.8Vp-p 4.3Vp-p 4.8Vp-p 10MHz 20MHz 7.28MHz IC348 <z/ (CLKO) 4 IC335 1 3Vp-p 12.288MHz 5 IC103 3 (EXTAL) 4Vp-p 20MHz VIDEO3 Board GEAR Board JOG Board DISPLAY Board SP SEL Board HP Board MOTOR Board BLUE LED Board FUNCTION SW Board DIGITAL Board VOLUME Board E VOL Board AMP Board PS Board AC Board CTRL-A1 Board BIAS Board SP TM Board PHONO Board AUDIO A Board VOL SEL Board ( E, PX ) AUDIO V Board C VIDEO Board S VIDEO Board 3-1. CIRCUIT BOARDS LOCATION SECTION 3 DIAGRAMS STR-DA777ES/V777ES 88 3-2. BLOCK DIAGRAM MAIN SECTION ANA CLK 11A0 L R PHONO R-CH 31 EQ AMP IC1301 J1301 CD L R L R OUTPUT R-CH R-CH J1101 L R L R OUTPUT R-CH R-CH J1102 INPUT DAT/MD L R INPUT R-CH TAPE L R VIDEO3 J1201 L R L R DVD/LD R-CH R-CH J102(1/2) L R OUTPUT R-CH R-CH TV/SAT J1202 L R L R OUTPUT R-CH R-CH L R INPUT R-CH INPUT VIDEO 1 VIDEO 2 VIDEO3 IN8 TAPE IN3 TAPE OUT10 DAT/MD IN2 DAT/MD OUT11 CD IN4 PHONO IN6 TUNER IN75COM 9COM 12REC COM 15CLK 13LAT 16DAT FUNCTION SWITCH IC1101 75 IC1103 31 IC1104 CLOCK DATA FUNLAT VIDEO1 IN4 VIDEO1 OUT8 VIDEO2 IN2 VIDEO2 OUT7 DVD/LD IN3 TV/SAT IN56COM 9REC COM 15CLK 13LAT 16DAT FUNCTION SWITCH IC1201 CLOCK DATA FUNLAT MUTE CONT Q2602,2603 MUTE Q2601 BUFFER Q3156 67 IC2601 2 3 6 5 7 1 IC2602 IC342 IR LINK DET IC318 31 DVD 56 IC342 IR LINK DET IC319 31 TV 34 IC342 IR LINK DET IC331 31 MD 12 IC342 IR LINK DET IC337 31 CD 1312 IR LINK DET IC332 23 MD-REC +5D2 J301 DVD (COAX) IC330 35 IC334 35 J302 CD (COAX) IC330 17 IC334 17 D31 D613 D514 D415 D13 D22 D04 DATA SELECT IC341 5Y 4 1 2 IC343 ANA DATA 10A1 9A2 SYSTEM CONTROL IC357(1/3) DSEL A018 DSEL A119 DSEL A220 ANA DAT11 MD RECO10 ANA CLK13 FUN LAT17 4 1 2 IC364 DATA CLOCK FUN LAT ADM ANA DATA A (Page 9) ANA DATA ANA CLK 67DIR RES 68DIR LAT 70DIG ANA 69DIG ERR 72DIG DAT D312 37DIR SIG 74DIG DIN 71DIG CLK IC335 17 X301 12.288MHz IC335 35 IC335 62 DIN03 XMODE48 CE37 ERROR34 DI36 DO35 CLK38 XIN22 138110 6 CLOCK DRIVER IC336 16DATAO 13CK OUT 14BCK 15LRCK IC363 24 DIR IC349 11 15 13 17 4 6 2 9 5 7 3 16 14 18 119 IC346 AB INL M15 INL P56 PDD16 MCKI15 SCLKI11 LRCKI10 A/D CONV. IC307 12AD OUT 812 IC346 SDIA084 SDIA185 SDIB312 SDBCK083 SDWCK082 XI8 47SDOB0 DSP IC354 46SDOB1 45SDOB2 18SDOB3 14 2 4 6 10 12 13 3 5 7 9 11 IC351 DIGITAL L LINE L MCK BCK LRCK BCK0 LRCK0 SIA SIB SIC SID B (Page 9) 81361 CLOCK DRIVER IC362 MUTE SI68 SO67 SCK69 XCSA66 XCSB65 IS62 43ADC RES 80ESRATE 75DSOCSA 76DSOCSB 77DSORES 24OE 23LE 22CLOCK 25DATA14 11 12 13 2 3 4 5 SHIFT REGISTER /LATCH IC5203 1 SW1 SW2 SW3 SW4 SW5 J5103 INPUT MONITOR OUTPUT J5102 OUTPUT OUTPUT INPUT SW52 SW46 SW34 SW210 SW114 1MON 13V1 IN 15V1 OUT 9V2 IN
