Sony-TAFE300R-int-sm 电路图 维修手册.pdf

MICROFILM TA-FE300R/FE500R INTEGRATED STEREO AMPLIFIER AEP Model E Model TA-FE300R/FE500R UK Model Australian Model TA-FE300R SERVICE MANUAL SPECIFICATIONS Photo: TA-FE500R Amplifier section DIN power output TA-FE500R: 75 W+75 W (4 ohms at 1 kHz) 55 W+55 W (8 ohms at 1 kHz) TA-FE300R: 50 W+50 W (4 ohms at 1 kHz) 40 W+40 W (8 ohms at 1 kHz) Frequency response PHONO (20 Hz-20 kHz): RIAA equalization curve 0.5 dB TUNER, CD, AUX, TAPE1/DAT, TAPE2/MD: 7 Hz-70 kHz dB S/N (network A) PHONO: 80dB TUNER, CD, AUX, TAPE1/DAT, TAPE2/MD: 105 dB Output voltage/ impedance REC OUT: 200 mV, 1 kilohm PHONES: 5 mW (at 8 ohms) Speakers impedance: 4-16 ohms, 8-16 ohms (SPEAKERS A+B) Damping factor TA-FE500R: 60 (8 ohms, 1 kHz) General System Power amplifier: Pure-complementary SEPP OCL power amplifier with all stages directly coupled Preamplifier. Low-noise, equalizer amplifier Power requirements Models not supplied with a voltage selector: 220-230 V AC, 50/60 Hz Models supplied with a voltage selector: 120, 220, or 240 V AC, 50/60 Hz Power consumption TA-FE500R: 160 W TA-FE300R: 120 W Dimensions (approx.) (w/h/d): 430105290 mm incl. projecting parts and controls Mass (approx.) TA-FE500R: 4.7 kg TA-FE300R: 4.3 kg Supplied accessories Remote commander (remote) (1) RM-S315 Sony batteries SUM-3 (NS) (2) Design and specifications are subject to change without notice. +0 3 RadioFans.CN 收音机爱 好者资料库 2 TABLE OF CONTENTS 1.GENERAL 1-1.Index to Parts and Controls .2 2.DIAGRAMS 2-1.Circuit Boards Location .3 2-2.IC Pin Function Description.4 2-3.Schematic Diagram.7 2-4.Printed Wiring Boards . 11 3.EXPLODED VIEWS. 15 4.ELECTRICAL PARTS LIST. 17 MODEL IDENTIFICATION Specification Label Printed on Back Panel MODEL NO. INTEGRATED STEREO AMPLIFIER TA-FE300R/FE500R AEP, German, Malaysia, Singapore model: AC: 220 V-230 V 50/60 Hz UK model: AC: 220 V-230 V 50 Hz E, Saudi Arabia, Australian model: AC: 120/220/240 V 50/60 Hz SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- LISHED BY SONY. SECTION 1 GENERAL 1-1.INDEX TO PARTS AND CONTROLS Front Panel Rear Panel 1234567 !09 8 1 SYSTEM POWER switch 2 BASS control 3 TREBLE control 4 BALANCE control 5 INPUT SELECTOR indicators 6 INPUT SELECTOR 7 VOLUME control 8 PHONES jack 9 LOUDNESS switch ! TAPE 1 MONITOR switch (TA-FE500R only) ! SOURCE DIRECT switch ! EON LINK switch (TA-FE500R only) This section is extracted from instruction manual. RadioFans.CN 收音机爱 好者资料库 3 SECTION 2 DIAGRAMS 2-1.CIRCUIT BOARDS LOCATION RELAY AC board SIRCS board HP board FUNCTION SW board CONTROL board EON board (FE500R) MAIN board OUTLET board (AEP, G, MY, SP) OUTLET board (E, EA, AUS) VOL SEL board (E, EA, AUS) AC SW board RELAY DC board Abbreviation G: Germany MY : Malaysia SP: Singapore EA: Saudi Arabia AUS : Australian RadioFans.CN 收音机爱 好者资料库 4 2-2.IC PIN FUNCTION DESCRIPTION CONTROL BOARD IC801 TMP47C103N (INPUT CONTROL, LED DRIVE) Pin No.Pin NameI/OFunction 1X OUTOSystem clock. (4 MHz) 2X INISystem clock. (4 MHz) 3RESETIRESET input. 4PMDIMODE select input. 5VOL+OMotor drive output (+). 6VOL OMotor drive output (). 7SW0IRotary switch input (CD). 8SW1IRotary switch input (TUNER). 9SW2IRotary switch input (PHONO). 10EONIEON signal input. 11PHONOOPHONO LED drive output. 12TUNEROTUNER LED drive output. 13CDOCD LED drive output. 14GNDGround. 15AUXOAUX LED drive output. 16DATOTAPE “Z” LED drive output. 17TAPEOTAPE “1” LED drive output. 18MONOMONITOR output. 19PRYOPower relay output. 20PKYIPower key input. 21MONIMONITOR input. 22SIRCSISIRCS input. 23MUTEOMuting output. 24SCEOChip enable output. 25SDTOSerial data output. 26SCKOSerial clock output. 27STOPIStop input. 28+3 V+3 V power supply. 15 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of the electrical parts list. * 101-659-964-11 HP BOARD * 114-980-777-41 CASE (409526) 123-704-366-01 SCREW (CASE) (M3X8) * 131-659-958-11 FUNCTION SW BOARD 141-769-983-11 WIRE (FLAT TYPE) (13 CORE) * 15A-4389-381-A CONTROL BOARD, COMPLETE (FE300R) * 15A-4389-385-A CONTROL BOARD, COMPLETE (FE500R) * 161-659-961-11 EON BOARD (FE500R) 174-980-189-01 KNOB (DIA. 6) Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 1X-4946-800-1 KNOB (VOL) ASSY 2X-4947-336-1 KNOB (DIA. 47) ASSY 34-980-204-01 KNOB (DIA. 24) 4X-4946-797-3 PANEL ASSY, FRONT (FE500R) 4X-4946-798-3 PANEL ASSY, FRONT (FE300R) 54-963-404-21 EMBLEM (5-A), SONY 64-980-199-01 BUTTON (POWER) * 71-659-960-11 SIRCS BOARD * 81-659-959-11 AC SW BOARD 94-951-620-01 SCREW (2.6X8), +BVTP 12 11 12 12 7 8 not supplied #2 6 5 3 4 2 1 supplied with S801 supplied with RV202 17 14 14 15 13 9 not supplied 9 16 #1 9 #1 10 #1 FE500R (1) CASE, FRONT PANEL SECTION 9 supplied with J501 not supplied 17 SECTION 3 EXPLODED VIEWS NOTE: -XX and -X mean standardized parts, so they may have some difference from the original one. Color Indication of Appearrance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) Parts Color Cabinets Color Abbrevation G: GermanMY: MalaysiaSP: Singapore EA: Saudi ArabiaAUS: Australian 16 (2) CHASSIS SECTION Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark * 601-659-967-11 OUTLET BOARD (AEP, G, MY, SP) 614-956-370-02 BAND, PLUG FIXED (UK) !621-569-007-11 ADAPTER, CONVERSION 2P (E, EA, AUS) !CN81-526-794-11 OUTLET, AC (AEP, G, MY, SP) !CN81-540-043-11 OUTLET, AC (NONPLAR) (3P)(E, EA, AUS) !CP11-558-943-41 CORD, POWER (E, EA, AUS) !CP11-575-651-21 CORD, POWER (AEP, G, MY, SP) !CP11-696-586-11 CORD, POWER (UK) !T11-429-448-11 TRANSFORMER, POWER (FE500R: AEP, G, MY, SP) !T11-429-449-11 TRANSFORMER, POWER (FE500R: E, EA) !T11-429-452-11 TRANSFORMER, POWER (FE300R: AEP, UK, G, MY, SP) !T11-429-453-11 TRANSFORMER, POWER (FE300R: E, EA, AUS) 51X-4947-207-1 FOOT ASSY (F50150S) * 521-659-963-11 RELAY DC BOARD * 531-659-962-11 RELAY AC BOARD * 54A-4389-380-A MAIN BOARD, COMPLETE (FE300R) * 54A-4389-384-A MAIN BOARD, COMPLETE (FE500R) * 553-703-244-00 BUSHING (2104), CORD (AEP, UK, G, MY, SP) * 553-703-571-11 BUSHING (S) (4516), CORD (E, EA, AUS) 563-704-515-11 SCREW (BV/RING) * 574-980-192-01 PANEL, BACK (FE500R: AEP, G, MY, SP) * 574-980-192-11 PANEL, BACK (FE500R: E, EA) * 574-980-201-01 PANEL, BACK (FE300R: AEP, G, MY, SP) * 574-980-201-11 PANEL, BACK (FE300R: UK) * 574-980-201-21 PANEL, BACK (FE300R: E, EA, AUS) * 581-659-966-11 OUTLET BOARD (E, EA, AUS) * 591-659-965-11 VOL SEL BOARD (E, EA, AUS) #1 not supplied #4 #1 #1 #1 #1 #1 #1 53 52 #3 not supplied T1 51 51 55 54 56 CN8 58 57 60 CN8 AEP, G, MY, SPUK 61 E, EA, AUS UK E, EA, AUS AEP, G, MY, SP CP1 CP1 62 CP1 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. 59 #2 17 SECTION 4 ELECTRICAL PARTS LIST NOTE: Due to standardization, replacements in the parts list may be different from the parts speci- fied in the diagrams or the components used on the set. -XX and -X mean standardized parts, so they may have some difference from the original one. RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable Abbreviation G: German EA: Saudi Arabia SP: Singapore MY: Malaysia AUS : Australian Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when order- ing these items. SEMICONDUCTORS In each case, u: , for example: uA. . : A. .uPA. . : PA. . uPB. . : PB. .uPC. . : PC. . uPD. . : PD. . CAPACITORS uF: F COILS uH: H The components identified by mark ! or dotted line with mark ! are criti- cal for safety. Replace only with part number speci- fied. AC SWCONTROL When indicating parts by reference number, please include the board. Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark *1-659-959-11 AC SW BOARD * * CN9531-564-506-11 PLUG, CONNECTOR 3P CN9551-564-505-11 PLUG, CONNECTOR 2P S11-554-920-11 SWITCH, PUSH (AC POWER)(1 KEY) (POWER) * *A-4389-381-A CONTROL BOARD, COMPLETE (FE300R) *A-4389-385-A CONTROL BOARD, COMPLETE (FE500R) * C2011-136-153-00 FILM0.01uF5%50V C2021-136-165-00 FILM0.1uF5%50V C2031-130-477-00 MYLAR0.0033uF5%50V C2041-136-159-00 FILM0.033uF5%50V C2051-130-473-00 MYLAR0.0015uF5%50V C2511-136-153-00 FILM0.01uF5%50V C2521-136-165-00 FILM0.1uF5%50V C2531-130-477-00 MYLAR0.0033uF5%50V C2541-136-159-00 FILM0.033uF5%50V C2551-130-473-00 MYLAR0.0015uF5%50V C8011-126-096-11 ELECT10uF20%35V C8021-126-916-11 ELECT1000uF20%6.3V C8031-164-159-11 CERAMIC0.1uF50V C8061-162-294-31 CERAMIC0.001uF10%50V C8071-126-096-11 ELECT10uF20%35V C8081-124-463-00 ELECT0.1uF20%50V C8091-126-301-11 ELECT1uF20%50V * CN8011-568-832-11 SOCKET, CONNECTOR 13P CN8021-562-087-00 SOCKET, CONNECTOR 4P CN8041-562-087-00 SOCKET, CONNECTOR 4P CN8061-774-913-11 PIN, CONNECTOR 4P * CN8141-568-832-11 SOCKET, CONNECTOR 13P D8018-719-985-59 DIODE HZS4CLL D8028-719-987-63 DIODE 1N4148M D8038-719-987-63 DIODE 1N4148M D8048-719-987-63 DIODE 1N4148M D8058-719-987-63 DIODE 1N4148M D8068-719-987-63 DIODE 1N4148M D8078-719-313-72 DIODE SEL3810A-CD (SOURCE DIRECT) D8088-719-313-72 DIODE SEL3810A-CD (PHONO) D8098-719-313-72 DIODE SEL3810A-CD (TUNER) D8108-719-313-72 DIODE SEL3810A-CD (CD) D8118-719-313-72 DIODE SEL3810A-CD (AUX) D8128-719-313-72 DIODE SEL3810A-CD (TAPE2/MD) D8138-719-313-72 DIODE SEL3810A-CD (TAPE1/DAT) D8148-719-987-63 DIODE 1N4148M D8168-719-987-63 DIODE 1N4148M D8178-719-987-63 DIODE 1N4148M D8198-719-987-63 DIODE 1N4148M D8208-719-200-82 DIODE 11ES2 D8238-719-313-72 DIODE SEL3810A-CD (TAPE1 MONITOR) (FE500R) IC8018-759-392-41 IC TMP47C103N-JP47 IC8028-759-962-08 IC BA6208 Q8018-729-119-78 TRANSISTOR 2SC2785-HFE Q8028-729-620-05 TRANSISTOR 2SC2603-EF Q8038-729-900-61 TRANSISTOR DTA114ES (FE500R) Q8048-729-900-61 TRANSISTOR DTA114ES Q8068-729-620-05 TRANSISTOR 2SC2603-EF Q8078-729-620-05 TRANSISTOR 2SC2603-EF Q8088-729-620-05 TRANSISTOR 2SC2603-EF Q8108-729-900-80 TRANSISTOR DTC114ES Q8118-729-900-80 TRANSISTOR DTC114ES R2011-249-433-11 CARBON22K5%1/4W 18 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark R2021-249-421-11 CARBON2.2K5%1/4W R2031-249-427-11 CARBON6.8K5%1/4W R2041-249-415-11 CARBON6805%1/4W R2051-249-421-11 CARBON2.2K5%1/4W R2061-249-441-11 CARBON100K5%1/4W R2081-249-439-11 CARBON68K5%1/4W R2511-249-433-11 CARBON22K5%1/4W R2521-249-421-11 CARBON2.2K5%1/4W R2531-249-427-11 CARBON6.8K5%1/4W R2541-249-415-11 CARBON6805%1/4W R2551-249-421-11 CARBON2.2K5%1/4W R2561-249-441-11 CARBON100K5%1/4W R2581-249-439-11 CARBON68K5%1/4W R3171-247-750-11 CARBON6805%1/2W R3671-247-750-11 CARBON6805%1/2W R8011-249-411-11 CARBON3305%1/4W R8021-247-807-31 CARBON1005%1/4W R8031-249-429-11 CARBON10K5%1/4W R8041-249-429-11 CARBON10K5%1/4W R8051-249-425-11 CARBON4.7K5%1/4W R8061-249-423-11 CARBON3.3K5%1/4W R8071-249-423-11 CARBON3.3K5%1/4W R8081-249-429-11 CARBON10K5%1/4W R8091-249-429-11 CARBON10K5%1/4W R8101-249-429-11 CARBON10K5%1/4W R8111-249-429-11 CARBON10K5%1/4W R8121-249-399-11 CARBON335%1/4W R8141-249-413-11 CARBON4705%1/4W (FE500R) R8151-249-429-11 CARBON10K5%1/4W R8161-249-429-11 CARBON10K5%1/4W R8171-249-429-11 CARBON10K5%1/4W R8181-249-423-11 CARBON3.3K5%1/4W R8191-249-429-11 CARBON10K5%1/4W R8201-249-429-11 CARBON10K5%1/4W R8211-249-429-11 CARBON10K5%1/4W R8221-249-429-11 CARBON10K5%1/4W R8231-249-437-11 CARBON47K5%1/4W R8241-249-441-11 CARBON100K5%1/4W R8261-249-399-11 CARBON335%1/4W R8271-249-393-11 CARBON105%1/4W (FE500R) R8281-249-429-11 CARBON10K5%1/4W R8291-249-429-11 CARBON10K5%1/4W R8301-249-429-11 CARBON10K5%1/4W R8341-249-413-11 CARBON4705%1/4W R8371-249-407-11 CARBON1505%1/4W RV2011-223-396-11 RES, VAR, CARBON 100K/100K (BALANCE) RV2021-241-426-21 RES, VAR, CARBON 100KX2 (VOLUME) RV2031-223-397-11 RES, VAR, CARBON 100K/100K (BASS) RV2041-223-397-11 RES, VAR, CARBON 100K/100K (TREBLE) S2011-571-112-21 SWITCH, PUSH (1 KEY) (LOUDNESS) S2021-571-828-11 SWITCH, PUSH (1 KEY) (SOURCE DIRECT) S8021-554-303-21 SWITCH, TACTILE (TAPE1 MONITOR)(FE500R) X8011-577-358-21 VIBRATOR, CERAMIC (4MHz) * *1-659-961-11 EON BOARD (FE500R) * * CN8101-564-506-11 PLUG, CONNECTOR 3P (FE500R) D8218-719-313-72 DIODE SEL3810A-CD (EON LINK) (FE500R) Q8098-729-900-80 TRANSISTOR DTC114ES (FE500R) Q8128-729-620-05 TRANSISTOR 2SC2603-EF (FE500R) Q8138-729-620-05 TRANSISTOR 2SC2603-EF (FE500R) R8311-249-399-11 CARBON335%1/4W (FE500R) R8351-249-429-11 CARBON10K5%1/4W (FE500R) R8361-249-425-11 CARBON4.7K5%1/4W (FE500R) R8381-249-407-11 CARBON1505%1/4W (FE500R) S8031-571-112-21 SWITCH, PUSH (1 KEY)(EON LINK) (FE500R) * *1-659-958-11 FUNCTION SW BOARD * CN8051-774-913-11 PIN, CONNECTOR 4P S8011-692-974-11 SWITCH, ROTARY (INPUT SELECTOR) * CONTROLEONFUNCTION SW 19 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark *1-659-964-11 HP BOARD * CN8031-560-941-11 PIN, CONNECTOR 4P J5011-774-933-11 JACK (LARGE TYPE) (PHONES) * *A-4389-380-A MAIN BOARD, COMPLETE (FE300R) *A-4389-384-A MAIN BOARD, COMPLETE (FE500R) * *1-537-738-21 TERMINAL, EARTH C1011-162-286-31 CERAMIC220PF10%50V C1031-126-963-11 ELECT4.7uF20%50V C1041-126-967-11 ELECT47uF20%16V C1051-162-282-31 CERAMIC100PF10%50V C1061-130-480-00 MYLAR0.0056uF5%50V C1071-130-473-00 MYLAR0.0015uF5%50V C1081-126-964-11 ELECT10uF20%50V C1091-126-964-11 ELECT10uF20%50V C1121-162-294-31 CERAMIC0.001uF10%50V C1141-162-306-11 CERAMIC0.01uF30%16V C1151-126-963-11 ELECT4.7uF20%50V C1511-162-286-31 CERAMIC220PF10%50V C1531-126-963-11 ELECT4.7uF20%50V C1541-126-967-11 ELECT47uF20%16V C1551-162-282-31 CERAMIC100PF10%50V C1561-130-480-00 MYLAR0.0056uF5%50V C1571-130-473-00 MYLAR0.0015uF5%50V C1581-126-964-11 ELECT10uF20%50V C3011-126-964-11 ELECT10uF20%50V C3021-162-290-31 CERAMIC470PF10%50V C3051-126-933-11 ELECT100uF20%10V C3061-