Yamaha-YSP-4100-Service-Manual电路原理图.pdf

YSP-4100/YSP-5100 SERVICE MANUAL IMPORTANT NOTICE This manual has been provided for the use of authorized YAMAHA Retailers and their service personnel. It has been assumed that basic service procedures inherent to the industry, and more specifi cally YAMAHA Products, are already known and understood by the users, and have therefore not been restated. WARNING: Failure to follow appropriate service and safety procedures when servicing this product may result in personal injury, destruction of expensive components, and failure of the product to perform as specifi ed. For these reasons, we advise all YAMAHA product owners that any service required should be performed by an authorized YAMAHA Retailer or the appointed service representative. IMPORTANT: The presentation or sale of this manual to any individual or fi rm does not constitute authorization, certifi cation or recognition of any applicable technical capabilities, or establish a principle-agent relationship of any form. The data provided is believed to be accurate and applicable to the unit(s) indicated on the cover. The research, engineering, and service departments of YAMAHA are continually striving to improve YAMAHA products. Modifications are, therefore, inevitable and specifi cations are subject to change without notice or obligation to retrofi t. Should any discrepancy appear to exist, please contact the distributors Service Division. WARNING: Static discharges can destroy expensive components. Discharge any static electricity your body may have accumulated by grounding yourself to the ground buss in the unit (heavy gauge black wires connect to this buss). IMPORTANT: Turn the unit OFF during disassembly and part replacement. Recheck all work before you apply power to the unit. CONTENTS TO SERVICE PERSONNEL .2 FRONT PANELS .3 REAR PANELS .47 BOTTOM PANELS .8 REMOTE CONTROL PANELS .9 SPECIFICATIONS / 参考仕様 .1015 INTERNAL VIEW .16 DISASSEMBLY PROCEDURES / 分解手順 .1721 UPDATING FIRMWARE / .2238 SELF-DIAGNOSTIC FUNCTION / （自己診断機能） .3959 DISPLAY DATA .60 IC DATA .6166 PIN CONNECTION DIAGRAMS .6769 BLOCK DIAGRAM .7071 PRINTED CIRCUIT BOARDS .7288 SCHEMATIC DIAGRAMS . 89101 REPLACEMENT PARTS LIST .103129 REMOTE CONTROL .130132 ADVANCED SETUP / 拡張 .133135 This service manual is for the YSP-4100/5100. For service manual of the SWK-W10 and YIT-W10 (PDX-50TX), please refer to the following publication number: SWK-W10: , YIT-W10: DIGITAL SOUND PROJECTOR YSP-4100/YSP-5100 101160101163 2 YSP-4100/YSP-5100 YSP-4100/YSP-5100 This product contains chemicals known to the State of California to cause cancer, or birth defects or other reproductive harm. DO NOT PLACE SOLDER, ELECTRICAL/ELECTRONIC OR PLASTIC COMPONENTS IN YOUR MOUTH FOR ANY REASON WHATSOEVER! Avoid prolonged, unprotected contact between solder and your skin! When soldering, do not inhale solder fumes or expose eyes to solder/flux vapor! If you come in contact with solder or components located inside the enclosure of this product, wash your hands before handling food. 1. Critical Components Information Components having special characteristics are marked and must be replaced with parts having specifications equal to those originally installed. 2. Leakage Current Measurement (For 120V Models Only) When service has been completed, it is imperative to verify that all exposed conductive surfaces are properly insulated from supply circuits. Meter impedance should be equivalent to 1500 ohms shunted by 0.15 F. 本機搭載基板付 接合部無鉛付。 無鉛種類、修理時 下記無鉛使用推奨。 Sn+Ag+Cu（錫 + 銀 + 銅） Sn+Cu（錫 + 銅） Sn+Zn+Bi（錫 + 亜鉛 + ） 注意： 無鉛融点温度通常鉛入比 30 40程度高、 合 使用。 All of the P.C.B.s installed in this unit and solder joints are soldered using the lead free solder. Among some types of lead free solder currently available, it is recommended to use one of the following types for the repair work. Sn + Ag + Cu (tin + silver + copper) Sn + Cu (tin + copper) Sn + Zn + Bi (tin + zinc + bismuth) Caution: As the melting point temperature of the lead free solder is about 30C to 40C (50F to 70F) higher than that of the lead solder, be sure to use a soldering iron suitable to each solder. TO SERVICE PERSONNEL Leakage current must not exceed 0.5mA. Be sure to test for leakage with the AC plug in both polarities. WALL OUTLET EQUIPMENT UNDER TEST AC LEAKAGE TESTER OR EQUIVALENT INSULATING TABLE WARNING: CHEMICAL CONTENT NOTICE! About lead free solder / 無鉛 For U model “CAUTION” “F501: FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE ONLY WITH SAME TYPE 6A, 125V FUSE.” For C model CAUTION F501: REPLACE WITH SAME TYPE 6A, 125V FUSE. ATTENTION F501: UTILISER UN FUSIBLE DE RECHANGE DE MME TYPE DE 6A, 125V. 3 YSP-4100/YSP-5100 YSP-4100/YSP-5100 U, C, T, A, B, G, L, V, J models U, C, T, K, A, B, G, L, V, J models FRONT PANELS YSP-4100 YSP-5100 4 YSP-4100/YSP-5100 YSP-4100/YSP-5100 REAR PANELS YSP-4100 U, C models T, A, B, G, L, V models J model U, C, T, A, B, G, L, V modelsJ model Label U, C, T, A, B, G, L, V models J model U, C, A, B, G, L, V models T model 5 YSP-4100/YSP-5100 YSP-4100/YSP-5100 Labels U, C models T model A model B, G models L model V model J model 6 YSP-4100/YSP-5100 YSP-4100/YSP-5100 YSP-5100 U, C, T, K, A, B, G, L, V modelsJ model U, C, T, K, A, B, G, L, V models J model U, C, K, A, B, G, L, V models T model U, C models T, K, A, B, G, L, V models J model Label 7 YSP-4100/YSP-5100 YSP-4100/YSP-5100 Labels U, C models T model K model A model B, G models L model V model J model 8 YSP-4100/YSP-5100 YSP-4100/YSP-5100 BOTTOM PANELS YSP-4100 U, C, T, A, B, G, L, V models J model YSP-5100 U, C, T, K, A, B, G, L, V models J model 9 YSP-4100/YSP-5100 YSP-4100/YSP-5100 REMOTE CONTROL PANELS FSR101 (U, C models) FSR102 (T, K, A, B, G, L, V models) FSR100 (J model) 10 YSP-4100/YSP-5100 YSP-4100/YSP-5100 SPECIFICATIONS / 参考仕様 Amplifier Section / 部 Maximum Power / 実用最大出力 (JEITA) (4 ohms, 10% THD) Woofer (100 Hz) .20 W/ch Array (1 kHz) .2 W/ch Total Maximum Output Power / 総合最大出力 .120 W Minimum RMS Output Power / 定格出力 (4 ohms, 0.9% THD) Woofer (100 Hz) .14 W/ch Array (1 kHz) .1.7 W/ch Input Sensitivity/Impedance / 入力感度 (Pro Logic, 5 Beam mode) Analog input . 1.0 Vrms / 32 k-ohms Maximum Input Signal / 最大許容入力 (1 kHz, 0.5% THD) Analog input .2.2 Vrms or more Output Level/Impedance / 出力電圧出力 (Pro Logic, 5 Beam mode, input 1 V/100 Hz, crossover = 120 Hz) Subwoofer PRE OUT .1.5 V / 1.1 k-ohms (less then 120 Hz) Total Harmonic Distortion / 全高調波歪率 (1 W) Woofer (100 Hz) .0.2% or less Array (1 kHz) .0.1% or less Video Section / 部 Composite Video Signal Level / 信号 .1 Vp-p / 75 ohms Component Video Signal Level / 信号 Y .1 Vp-p / 75 ohms Pb, Pr .0.7 Vp-p / 75 ohms Frequency Characteristics / 周波数特性 Composite video signal .5 Hz to 10 MHz Component video signal .5 Hz to 60 MHz Speaker Section / 部 Type / 型式 .2-way acoustic suspension Magnetic type Driver / Woofer .11 cm (4-3/8) cone x 2 Tweeter (YSP-5100) .2.5 cm (1) blanced dome x 2 Array . 4 cm (1-5/8) cone magnetic shielding type x 40 Frequency Response / 再生周波数帯域 (-10 dB, stereo mode) YSP-4100 .80 Hz to 20 kHz YSP-5100 .70 Hz to 20 kHz Crossover Frequency / 周波数 (Beam / Stereo mode) YSP-4100 .350 Hz / 1 kHz YSP-5100 .350 Hz / 4 kHz Input/Output / 入力出力 Audio Input Jack / 入力端子 (7 series: TV, AUX1, AUX2, HDMI IN1 4) Analog . TV, AUX1 Digital (optical) (Fs= 32 / 44.1 / 48 / 64 / 88.2 / 96 kHz) . TV, AUX1 Digital (coaxial) (Fs= 32 / 44.1 / 48 / 64 / 88.2 / 96 kHz) .AUX2 Video (composite) .AUX1 U, C, K, V, J models .NTSC T, A, B, G, F, L models .PAL Video (component) .AUX2 HDMI . IN1 IN4 Output Jack / 出力端子 Video (composite) U, C, K, V, J models .NTSC T, A, B, G, F, L models .PAL Subwoofer .PRE OUT HDMI .OUT1 Antenna Connection / 端子 U, C models .FM antenna / SIRIUS antenna T, K, A, B, G, F, L, V, J models . FM antenna Wireless IF / 無線接続 Input .For iPod Output . For subwoofer Microphone Input Jack / 入力 .Automated system calibration / 自動調整 System Connector / 接続 .Monaural mini jack (for subwoofer ON/OFF control) Remote IN/OUT / 入力 / 出力 Input .Standard IR remote input / 標準赤外入力 External wired-in (Monaural mini jack) / 外部電気信号入力 RS-232C Output .IR pass through out Function Section / 機能部 Decode Format / . Dolby Digital, Dolby Digital EX, Dolby Digital Plus/TruHD, Dolby Pro Logic, Dolby Pro Logic II, Dolby Pro Logic IIx dts, dts Neo6 (Cinema, Music), dts ES (Discrete, Matrix) dts-HD High Resolution, dts-HD Master Audio AAC (J model) Listening Mode / 視聴 . Stereo, Surround Surround Beam variation . 5Beam, Stereo + 3Beam, 3Beam 5BeamPlus2, Stereo + 3BeamPlus2 Cinema DSP / DSP Music .Music Video, Concert Hall, Jazz Club Movie .Sci-Fi, Adventure, Spectacle Entertainment .Sport, Talk Show, Drama, Game, MchStereo Music Enhancer / .High/Low Bass Extension / 低音増強 .Bass EXT Volume Mode / 音量 .UniVolume 11 YSP-4100/YSP-5100 YSP-4100/YSP-5100 Language for Menu Display / 表示言語 U, C, T, K, A, B, G, F, L, V, J models .English, French, German, Spanish, Italy, Dutch, Russian J model .Japanese, English Beam Setting Method / 調整 .Auto setup, Manual setup FM Tuning Range / FM 受信周波数範囲 U, C models .87.5 to 107.9 MHz T, K, A, B, G, F, L, V models .87.50 to 108.00 MHz J model .76.0 to 90.0 MHz RDS B, G, F models .PS / PTY / RT / CT SIRIUS U, C models .Activate / All channel search / Category search Preset search / Preset / Parental lock HDMI HDMI Specification / HDMI 規格 .Version 1.3a Audio Format / 音声 .Dolby TruHD, Dolby Digital Plus, Dolby Digital DTS HD Master Audio, DTS HD High Resolution, DTS M-ch LPCM AAC (J model) Content Protection / 著作権保護 . HDCP (High-bandwidth Digital Content Protection System) Video Format / 映像 Repeater mode . VGA, 480i60Hz, 576i50Hz, 480p60Hz 576p50Hz, 1080i50/60Hz, 720p50/60Hz, 1080p24/50/60Hz Deep Color, xv color Analog up conversion .480i 480p, 576i 576p Link Function / 機能 HDMI contorl .Standby/on, Volume up/down mute, TV/YSP sound select, Input select Auto Lip Sync / .ON Wireless Communication U, T, A models Frequency Band .2.4 GHz Transmission Range (without interference) . Approx. 20 m (66 ft) Latency .12 ms General / 総合 Power Supply / 電源電圧 U, C models .AC 120 V, 60 Hz T, K, A, B,