索尼SONY WM-EX170电路图.pdf
《索尼SONY WM-EX170电路图.pdf》由会员分享,可在线阅读,更多相关《索尼SONY WM-EX170电路图.pdf(19页珍藏版)》请在收音机爱好者资料库上搜索。
1、WM-EX170/EX172 Canadian Model WM-EX170 AEP Model E Model WM-EX170/172 SERVICE MANUAL CASSETTE PLAYER MICROFILM SPECIFICATIONS Model Name Using Similar MechanismNEW Tape Transport Mechanism TypeMT-WMEX170-114 Manufactured under license from Dolby Laboratories Licensing Corporation. “DOLBY” and the do
2、uble-D symbol a are trademarks of Dolby Laboratories Licensing Corporation. Power requirements 3V DC batteries R6 (AA) 2 / External DC 3V power sources Dimensions 88.5 111.5 37.6 mm (3 1/2 4 1/2 1 1/2 inches) (w / h/ d) incl. projecting parts and controls Mass EX170 : Approx. 125 g (4.5 oz) / Approx
3、. 185 g (6.6 oz) incl. batteries and a cassette EX172 : Approx. 130 g (4.6 oz) / Approx. 190g (6.8 oz) incl. batteries and a cassette Supplied accessories Stereo headphones or Stereo earphones (1) / Belt clip (1) Design and specifications are subject to change without notice. Photo : WM-EX172 ? ? ?
4、? ? ? ? ? ? ? 2 TABLE OF CONTENTS Flexible Circuit Board Repairing Keep the temperature of the soldering iron aroud 270 C during repairing. Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). Be careful not to apply force on the conductor when soldering or un
5、soldering. Notes on chip component replacement Never reuse a disconnected chip component. Notice that the minus side of a tantalum capacitor may be damaged by heat. SECTION 1 GENERAL 1.GENERAL2 2.DISASSEMBLY 2-1.Cabinet (Front) Assy 3 2-2.Main Board4 2-3.Cassette Lid 4 2-4.Mechanism Deck 5 2-5.Belt,
6、 Motor (Reel/Capstan) 5 3.MECHANICAL ADJUSTMENT6 4.ELECTRICAL ADJUSTMENT6 5.DIAGRAMS 5-1.Block Diagram 7 5-2.Printed Wiring Board (EX170 Model) 9 5-3.Schematic Diagram (EX170 Model) 11 5-4.Printed Wiring Board (EX172 Model) 13 5-5.Schematic Diagram (EX172 Model) 15 5-6.IC Block Diagrams 17 6.EXPLODE
7、D VIEWS 6-1.Cabinet Section18 6-2.Main Board Section 19 6-3.Mechanism Section-1 (MT-WMEX170-114) 20 6-4.Mechanism Section-2 (MT-WMEX170-114) 21 7.ELECTRICAL PARTS LIST22 This section is extracted from instruction manual. EX172 MODEL ? ? ? ? ? ? ? ? ? ? 3 Cassette, lid Cabinet (front) assy A 1 Two sc
8、rews Screw (B1.7 9), tapping SECTION 2 DISASSEMBLY Note :Follow the disassembly procedure in the numerical order given. 2-1. CABINET (FRONT) ASSY 2 Insert the precision screwdriver (1.4 mm flat-blade) into the slit at claw A and release the claw. 3 Remove the cabinet (front) assy. (Release all claws
9、 B to L in alphabetical order.) This set can be disassembled in the order shown below. 2-1. CABINET (FRONT) ASSY2-2. MAIN BOARD 2-3. CASSETTE LID 2-4. MECHANISM DECK2-5. BELT, MOTOR (REEL/CAPSTAN) B L K C D E F G H I J ? ? ? ? ? ? ? ? ? ? 4 5 Spring (torsion) B A 1 Open the cassette lid. 4 Cassette
10、lid. 2-2. MAIN BOARD 2-3. CASSETTE LID 2 Insert a precision screwdriver (1.4 mm flat-blade) vertically into portion A to release the hinge plate. 3 Portion B to release the hinge plate. 1 Head flexible board (CN301) 5 Two claws 6 MAIN board 3 Remove the four solders. 4 Screw (M1.4), toothed lock (WH
11、) 2 Flexible board (CN302) ? ? ? ? ? ? ? ? ? ? 5 2 Two screw screw (M1.4), special head 3 Motor (reel/capstan) 1 Belt 2-4. MECHANISM DECK 2-5. BELT, MOTOR (REEL/CAPSTAN) 1 Insert the precision screwdriver (1.4 mm flat-blabe) in to the slit and release two claws. 2 Remove the mechanism deck in the di
12、rection of the arrow. ? ? ? ? ? ? ? ? ? ? 6 SECTION 3 MECHANICAL ADJUSTMENT SECTION 4 ELECTRICAL ADJUSTMENT PRECAUTION 1.Clean the following parts with a denatured-alcahol-moistened sweb : Playback headPinch roller Rubber beltCapstan 2.Demagnetize the playback head using a demagnetizer. 3.Do not use
13、 a magnetized screwdriver for adjustments. 4.After adjusting, apply screw-locking compound onto the adjusted parts. 5.Unless specified otherwise, use a specified voltage (3.0V) to perform the adjustments. Torqu Measurement Mode FWD FWD Back Tension REV REV Back Tension FF REW Torqu meter CQ-102C CQ-
14、102RC CQ-201B Meter reading 20 - 30 g cm 0.4 - 2.0 g cm 20 - 30 g cm 0.4 - 2.0 g cm More than 40 g cm PRECAUTION 1.Specified voltage : 3.0V 2.Switch position DOLBY NR switch: OFF (EX172 MODEL) AVLS switch: NORM CASSETTE SECTION Test Tape Tape Speed Adjustmnet Procedure : 1.Playback WS-48A (Tape cent
15、er part) and adjust RV601 so that the frequency counter reading becomes 3,000Hz 15Hz. 2.Playback WS-48A (Tape top and end). Check that frequency counter reading is within 1.5% of the reading of step1. Adjustment Point : MAIN BOARD CONDUCTOR SIDE Type WS-48A Signal 3kHz, 0dB Purpose Tape Speed Adjust
16、ment Test tape WS-48A (3kHz, 0dB) Set 16 PHONES jack + Frequency counter RV601: Tape speed ? ? ? ? ? ? ? ? ? ? WM-EX170/EX172 SECTION 5 DIAGRAMS 5-1. BLOCK DIAGRAM 7 8 IC301 28 L R 29 32 35 RV301 VOLUME HP901 PLAYBACK HEAD M901 REEL/CAPSTAN MOTOR 34 2418 15 23 4 11 13 5 10 19 36 1 8 4 LIMIT NORMAL P
17、RE + POWER AMP IC331 DOLBY NR IC601 MOTOR DRIVE MAIN BOARD J302 J301 DC IN 3V PHONES S305 AVLS D150 BATT S302 (POWER) 17 15 14 4U W IN+ 13S/S V VREF 5 6 21 22 3 7 RV601 TAPE SPEED S303 NORM VREF PRE OUT2 L MIX IN 2L MIX OUT L MIX OUT R PWR IN2 L PWR IN1 R HP IN 2L MIX IN 1R HP IN 1R PRE OUT1 R VREF
18、25 6 RV351 HIGH RV352 LOW S351 MEGA BASS OFF ON 14 VREFVREF S352 DOLBY NR ON OFF S351 MEGA BASS OFF ON VREF M.B ON/OFF LOW BOOST GAIN COM VCC AVLS PWR OUT 1(R) PWR OUT 2(L) MEGA BASS UNITMEGA BASS UNIT EX170 MODELEX172 MODEL 26 (TAPE SELECTOR) CrO2/METAL EX172 MODEL EX170 MODEL EX170 MODEL EX170 MOD
19、EL IN L IN R OUT L OUT R20 DRY BATTERY SIZE AA (IEC DESIGNATION R6) 2PCS, 3V ON/OFF Signal path. E: PB ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? WM-EX170/EX172 12 A B C D E F G H 3456789101112 9 10 5-2. PRINTED WIRING BOARD (EX170 MODEL) Ref. No.Location D150H-3 I
20、C301E-7 IC601E-10 Semiconductor Location Note on Printed Wiring Board: X : parts extracted from the component side. b : Pattern from the side which enables seeing. (The other layers patterns are not indicated.) Abbreviation CND: Canadian. EE: East European. FR: French. 9E: Country of origin is not s
21、hown. 16 MEGA BASS UNIT OFF ON 4 6 2 DC IN 3V BLK ORG RED WHT BLK ORG RED WHT M901 REEL/CAPSTAN MOTOR DRY BATTERY SIZE AA (IEC DESIGNATION R6) 2PCS, 3V MAIN BOARD AVLS NORM LIMIT J302 NORM CrO2/ METAL BATT RV301 VOLUME S302 (POWER) L R 4 5 3 2 16 PLAY BACK HEAD HP901 1-667-710- 11 (11) 1 5 9 10 19 1
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 索尼SONY WM-EX170电路图 索尼 SONY WM EX170 电路图