Teac-PL-S3500-Service-Manual(1) 电路图 维修手册.pdf

《Teac-PL-S3500-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Teac-PL-S3500-Service-Manual(1) 电路图 维修手册.pdf（24页珍藏版）》请在收音机爱好者资料库上搜索。

1、NOTESCONTENTS PL-S3500 Home Theater System PC board shown are viewed from parts side. The parts with no reference number or no parts number in the exploded views are not supplied. As regards the resistors and capacitors, refer to the circuit diagrams contained in this manual. Parts marked with this

2、sign are safety critical components. they must be replaced with identical ensure exact replacement. ! components - refer to the appropriate parts list and 2 EXPLODED VIEW AND PARTS LIST 3 PC BOARDS AND PARTS LIST 5 INCLUDED ACCESSORIES 2 3 7 17 DIGITAL OUT DOLBY D I G I T A L 4 WIRING DIAGRAM 15 1 S

3、PECIFICATIONS MASTER VOLUME MUTINGSURROUND MODE INPUT SELECTOR HOME THEATER SYSTEM PL-S3500 STANDUP PHONESPOWER TEAC Parts of mark can be used only with the version designated. E: EUROPE J: JAPAN HK: HONG KONG UK: U.K. RadioFans.CN 收音机爱 好者资料库 PL-S3500 1 SPECIFICATIONS 2 Surround Output Power(0.9% TH

4、D, 1kHz, 8ohms): 30 + 30 watts (Front) 30 watts (Center) Amplifier Section Digital Audio Section BASS : +/- 10 dB at 100 Hz Power Requirements : Standard Accessories : General Power Consumption : 200W Dimensions (W x H x D ): (17-1/8 x 2-3/4 x 14-3/8) inches Remote Control Unit (RC-881) x1 Signal-to

5、-Noise Ratio : Audio Input Sensitivity/Impedance : Frequency Response : Digital Input Level/Impedance: Digital 1, 2 (OPTICAL): - 15 dBm -21 dBm Sampling Frequency : 32 kHz, 44.1 kHz, 48kHz, 96 kHz 230 V AC, 50 Hz (EUR/UK/HKG) Unit : Impedance : Satellite Speakers 90 x 130 x 81mm Power Handling Capac

6、ity : Improvements may result in specifications are features change without notice. Illustrations may differ slightly from production model. Weight and dimensions are approximate. Weight : Dimensions (W x H x D) : (3-3/5 x 5-5/16 x 3-3/16) inches 30W 0.8 kg (1.76 lb) - front 65 mm x 2 Unit : 8 ohms

7、Unit : 30 W 200 x 77 x 81 mm 165mm 30 + 30 watts (Rear) * Line: 250 mV/47k ohms * Line: 20 Hz - 20 kHz, +1/ -3 dB * Line: 65dB (IHF-A) Tone Control : TREBLE : +/- 10 dB at 10 kHz Digital 3 (COAXIAL): 0.5 Vp-p/75 ohms 435 x 70 x 365mm Weight(net) : 4.2 kg (9.24)lb Front/Center/Speaker Cable (5m x 3)

8、Surround Speaker Cable (10 m x 2) Sub-woofer RCA pin cord (1.8m) Batteries (AA, R6,SUM-3) x 2 75 mm 8 ohms 0.6 kg (1.32 lb) -rear Center Speaker Impedance : Power Handling Capacity : Dimensions (W x H x D) : Weight : 1.0 kg (2.2 lb) Subwoofer 4 ohms Impedance : Output Power: 50 W Signal-to-Noise Rat

9、io : 60 dB (80 Hz, 400 mV, STO) Power Requirements : 230V AC , 50Hz (EUR/UK/HKG) 200 x 315 x 353 mm Dimensions (W x H x D) : Weight : 8.2 kg (18.04 lb) (7-7/8 x 12-7/16 x 13-7/8) inches * LINE means CD/DVD, AUX and TV/VCR (7-7/8 x 3-1/16 x 3-3/16) inches 100 V AC, 60 Hz (DM) 100V AC , 60Hz (DM) Radi

10、oFans.CN 收音机爱 好者资料库 PL-S3500 1 1 2 2 3 3 4 4 6 6 6 6 7 7 8 8 9 9 5 5 11 11 11 11 12 12 13 13 14 14 15 15 15 15 16 16 17 17 17 17 19 19 20 20 18 18 21 21 22 22 23 23 25 25 24 24 26 26 27 27 29 29 30 30 28 28 31 31 32 32 33 33 34 34 35 35 39 39 36 36 38 38 37 37 42 42 4242 43 43 4040 1010 1010 4040 41

11、41 3 2 EXPLODED VIEWS AND PARTS LIST EXPLODED VIEW - 1 34 34 33 33 29 29 30 30 1 1 1 1 1 1 1 1 RadioFans.CN 收音机爱 好者资料库 REF. NO EXPLODED VIEW - 1 PARTS NO.DESCRIPTION 1-1SATELLITE SPEAKER 5x30W REMARKS PL-S3500 4 ESB20A501-0602 1-3 1-4 1-5 1-6 1-7 1-8 1-9 1-10 1-11 1-12 1-13 1-14 1-16 1-17 1-19 1-20

12、1-21 1-22 1-23 1-24 1-25 1-26 1-27 1-28 1-29 1-30 1-31 1-2SPEAKER SPONGE 165x145x2mm SPEAKERFSB52A065-6401 APE100180-0008MAIN PCB ASSY SUBWOOFER REAR COVERBPC000021-0001 HWF11C035-6160WASHER FIB 12x3.5x1.6mm COVER SPON L34xW4.5xT3mmIVE000096-0002 IVE000095-0001COVER SPON L55xW36xT2MM APE100180-0024I

13、/P PCB ASSY SUBWOOFER SPONGE L174xW10 xT2mmIVE000093-0001 IVE000094-0001SPONGE L94.5xW10 xT2mm BACK PANEL 230V E, UK, HKGSP100062-0006 TTI110011-0010PWR TRANS I/P 100V/60HZ EI-76 J TRANSFORMER BRACKETGSE000110-0004 BPL010014-0007LOGO PLATE RINGBPH100076-0001 BPK106037-0001POWER KEY SW+LED PCB ASSYAP

14、E200220-0001 LED LENSBPN100106-0001 APE200222-4001LED PCB ASSY SUBWOOFER PAPER TUBE 65x56.5x120mmDPP216556-2001 IVN000005-0001CLOTH 130 x130mm BLACK WOOD CAB BOXEVM200003-0001 BRF100026-0001RUBBER PAD 20 xT4 PLAS. FOOT 32xT8.5BPE100019-0001 DSS100004-0003SPACER 6.7x3.1x9.9mm POWER PCB ASSY -SUBWOOFE

15、R E, UK, HKAPE200250-5001 HNT140700-1300NUT M4 HWS11A047-3030WASHER 10 x4.7x0.3mm BPF105041-0001 1-32 1-33 1-34 ! HSP143053-3060SCREW M2x6mm HST143084-3080SCREW 3xx8mm SCREW T3x8mmHST140054-3080 HST140054-3100SCREW T3x10mm HSD143103-3250SCREW M4x25mm HST140044-3080SCREW T2.5x8mm HST140051-3140SCREW

16、T3x14mm 1-36 1-37 1-38 1-39 1-35 1-40 1-41 IVE000097-0001 GSP100062-0004BACK PANEL 110V J VPE003252-0010LINE CORD 2P VDE E LINE CORD 3P BS UK, HK VPE006252-0020 VPA002254-0020LINE CORD 3P T-MARK J DBU001002-0011AC LINE BUSHING! 1-15BRB100028-0002RUBBER PAD 50 x25xT2mm TTI123011-0010PWR TRANS 230V/50

17、Hz EI-76 E, UK, HK! 1-18BPG001046-0001GRILLE FRONT PANEL HST140071-3140SCREW T3.5x14mm1-42 HST140051-3220SCREW T3x22mm1-43 POWER PCB ASSY - SUBWOOFER JAPE200250-5002 ! ! ! PL-S3500 EXPLODED VIEW - 2 1 1 2 2 3 3 4 4 4 4 4 4 4 4 4 4 4 4 4 4 6 6 7 7 8 8 9 9 5 5 11 11 11 12 12 13 13 13 14 14 15 15 16 16

18、 17 17 19 19 20 20 18 18 21 21 22 22 23 23 23 23 26 26 25 25 26 26 25 25 24 24 24 24 27 27 27 27 27 27 27 27 28 28 28 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 33 33 33 33 33 33 33 33 33 33 33 29 29 31 31 32 32 32 32 1010 5 REF. NO EXPLODED VIEW - 2 PARTS NO.DESCRIPTION 2-1 2-3 2-4 2-5 2-2 2-6

19、 2-8 2-9 2-10 2-7 2-11 2-12 2-13 2-14 2-15 2-16 2-17 2-18 2-19 2-20 2-21 2-22 2-23 2-24 2-25 2-26 2-27 2-28 2-29 2-30 2-31 2-32 2-33 REMARKS ! 6 PL-S3500 MSW003019-0010POWER SW BPC000042-0002SW COVER - POWER SW PROTECTOR GSE200025-0001TOP COVER APE200290-5001POWER PCB ASSY 230V E, UK, HK APE200290-5

20、004POWER PCB ASSY 100V J APE200110-5001MAIN PCB ASSY BPH00067-0001PLASTIC BRACKET DBU001005-0010AC LINE BUSHING VPE003252-0010LINE CORD 2P VDE E VPE006250-0020LINE CORD 3P BS UK, HK VPA002254-0020LINE CORD 3P T-MARK J BPL010014-0007LOGO PLATE BPN100105-0001REMOTE LENS APE200123-4001SENSOR PCB ASSY B

21、PK208004-0001POWER KEY APE200122-4001EARPHONE PCB ASSY GSE200024-0001 GSE200036-0001 BRACKET SECC T=0.8mm HEADPHONE BRACKET BPN100102-0001 BFT211000-0001 DISPLAY LENS LCD FILTER PVC BPK238004-0001 BPK228004-0001 VOLUME KNOB DISPLAY LENS BRACKET BPF104022-0001FRONT PANEL ASW100002-0001FUNCTION KEY AP

22、E200121-5001CONTROL CHASSIS PCB ASSY DSS100022-0002 DSS100022-0001 SPACER A=12.7 B=1.2-1.6mm SPACER A=10 B=1.2-1.6mm BPE100018-0001FOOT HIPS BPE100018-0002 FOOT CHROME BRB200002-0001 RUBBER GSE100195-0001BOTTOM CAB GSE100194-0001BACK CAB E, UK, HK GSE100194-0002BACK CAB J HST143084-1060SCREW M3x6mm

23、HST143084-1080SCREW M3x8mm HST143084-1160SCREW M3x16mm HSP140054-1080SCREW T3x8mm ! ! ! PL-S3500 REF. NO MAIN PCB ASSY - TOP PARTS NO.DESCRIPTION APE200110-5001MAIN PCB ASSY MAIN PCBLFM200110-0001 REMARKS 3 PC BOARDS AND PART LISTS 7 SCB008050-1010FB17,18,502,503CHIP BEAD 100OHM RCI916433-0001IC904,

24、905IC - RT9164-33CLR IC111RCI049326-0001IC - CS49326 IC406RCI043043-0001IC - CS43L43 IC403RCI008415-0001IC - CS8415A IC503,504,505RCI000505-0001IC - STA505 IC906IC - B1117NRCI011170-0001 IC402IC - CS5333RCI005333-0001 IC106,108RCI740574-0002IC - TC74LCX574FT IC107,109,110RCI740245-0001IC - TC74LCX24

25、5FT IC - STA304ARCI000304-0001IC501,502 IC - W27C020PRCI270020-0002IC112 IC104IC - TC74HC04AFNRCI740004-0001 IC400IC - TC4052BFNRCI004052-0001 INDUCTOR 150UHSAN001600-1510 ZENER DIODE 6.9-7.2VRAZ005007-0020 DIODE 1N4148RAD114148-0010 ZD400,401, D101,102,400,401,403, L510,513,514 D701-703,706,707 C52

26、6,527,583PDE039570-1020CE - 1000UF-50V L500-504,L2032,2034,SIL106002-2000CHOKE COIL 20UH 2A FB704-706,708,709,BEAD FERIT 100OHMSFB001001-0030 L700,701INDUCTOR 47UHSAN001600-4700 JK401,404OPTICAL RECEIVER DLR1111CJT200001-0005 RB100CONNECTOR 6PIN P=2MMCCN20000-0106 XL500CRYSTAL 6.144MHZJQC013100-6151

27、 XT400OSCILLATOR 12.288MHZJQC223100-1261 RAM207000-1001 CCN396020-0104 PVE039570-2220 TR - 2N7000 CONNECTOR 4PIN P=3.96MM CE - 2200UF-50V Q704,705 CN904 C2200 JK500SPEAKER JACK 10PIN CN100CONNECTOR B4B-XH-A 4PIN P=2.5MM CJS010101-0020 CCN250000-0104 C916CE - 1000UF-16VPVE039540-1020 Q5002TR - 2SA733

28、RAP200733-0001 CCN200000-0104CN400CONNECTOR 4PIN P=2MM CON100 IC903RHI007912-0001IC - 7912 Q100-102,401,700-703 RAN200945-0001TR - 2SC945 JK405CJR006101-0010RCA JACK 6PIN CCN200000-0111CONNECTOR 11PIN P=2MM IC902RHI007805-0001IC - MC7805ACT XL100JQC213100-2461CRYSTAL 24MHZ IC101RHI780516-0001IC - W7

29、8E516B IC900IC - BA05TRHI007805-0005 L2036-2038 RCI740125-0005IC103,105 IC - RC4558DRCI004558-0003IC401,405 IC - MC74LCX125DTR2 FB700,701,711-713,715 CN900CCN250000-0108CONNECTOR B8B-XH-A 8PIN P=2.5MM ! ! ! L507-509,515,2045SCB000001-0001CHIP BEAD - 4PIN FB710,714,716 MAIN PCB - TOP 8 PL-S3500 JK500

30、 MAIN PCB - BOTTOM REF. NOPARTS NO.DESCRIPTION C929,931 POWER PCBLCP200290-0001 POWER PCB ASSY POWER PCB ASSY E, UK, HKAPE200290-5001 REMARKS BR901RHD208080-0010BRIDGE KBU808 C932,939,940PME039540-1020CE 1000UF/16V C947,948,952CE 1000UF/50VPVE039570-1020 CE 1000UF/16V - 10 x16mmPVE039540-1020 ! ! !

31、! POWER TRANS 230V EI-35 E, UK, HK 9 PL-S3500 POWER PCB ASSY JAPE200290-5004 T901JFT006008-0020AC FILTER D901 D907,908 D902,904,909,910 D903 F901KSA020315-0120FUSE 3.15A/250V E, UK, HK MRL012004-0011RL901RELAY GJSH-112DM DIODE 1N4148RAD114148-0010 DIODE 1N4001RAD114001-0010 DIODE BYV26DRAD100026-001

32、0 DIODE HER204RAD100204-0010 D906RHD115822-0010DIODE 1N5822 SN901RHO615003-3001OPT SENSOR SFH615A-3 IC903RHI000249-0001IC - TOP249 IC904RHI004310-0001IC - TL431 RAN202222-0001Q903TR - PN2222A Q904RHN000120-0001TR - TIP120 RAN202001-0001Q913TR - 2SC2001L D905RHD208020-0010BRIDGE MUR1620CT ZD902DIODE

33、ZENER 5.6-5.9VRAZ005006-0020 ZD901DIODE P6KE200ARAD160200-0010 ZD903DIODE ZENER 6.9-7.2VRAZ005007-0020 SIL106001-6090L901INDUCTOR 6UH 10.5TS SIL106002-6090L902,903INDUCTOR 6UH 13.5TS T903TSC023001-0040PWR TRAN 230V E, UK, HK ! ! ! RNT005130-5090RT901NTC- 5 OHM ZD904DIODE ZENER 4.1-4.3VRAZ005004-0030

34、 CN902,903CCN396021-0104CONNECTOR 4PIN P=3.96MM TTB123011-0020T902 TTB110011-0020POWER TRANS 100V EI-35 J ! ! KSA020315-0011FUSE 3.15A/250V J! TTI110011-0010PWR TRAN 100V J! C905,906,909, C963,964,968 PVY1705K0-2220!COND.SAFTY 0.0022UF 400V C901,902COND SAFTY 0.22UF 275VPVX2705G0-2240! C914PME039550

35、-4710CE 470UF/25V ! QAF025000-5640R901,902RESISTOR - 560K 1/2W QAF025000-1050R903,904RESISTOR - 1M 1/2W QAF045000-4790R907RESISTOR - 4.7 OHM 1/4W ! ! ! ! ! ! ! ! ! ! ! C903,904CE 220UF/200VPJE0995E0-2210 ! POWER PCB 10 PL-S3500 REF. NO CONTROL PCB ASSY PARTS NO.DESCRIPTION CONTROL PCB ASSYAPE200121-

36、5001APE200121-5001 CONTROL PCBLVC200121-0301 IC303IC - PT6311RCI006311-0001 D301,302RAD114148-0010DIODE -1N4148 LD201LED RED - D3MM TA301-303,305 ZD201,202DIODE ZENER 15.3V-15.9VRAZ005016-0010 REMARKS PL-S3500 TACT SW SKHVBE3520MAW060001-0010 REF. NO SENSOR PCB ASSY PARTS NO.DESCRIPTION IRT SENSOR R

37、IM B38FRHO200038-0001SN201 SENSOR PCB SENSOR PCB PCB ASSYAPE200123-4001 REF. NO EAR PHONE PCB ASSY PARTS NO.DESCRIPTION EAR PHONE PCB ASSYAPE200122-4001 JK301 RB302CCN200000-0103CONNECTOR 3PIN P=2MM REMARKS REMARKS EAR PHONE PCB LVC200123-0301 PHONE JACK 9PIN LVC200122-0301 CJM064001-1010 Q301TR - 2

38、SC945RAN200945-0001 KED200003-0010 DP301KLV000016-0010VFD VA84x9PA VR301MSW005002-0010ROTARY L20 xF7MM 11 12 CONTROL PCB EARPHONE PCBSENSOR PCB PL-S3500 REF. NO MAIN PCB ASSY SUBWOOFER PARTS NO.DESCRIPTIONREMARKS MAIN PCB ASSY - SUBWOOFERAPE100180-0018 MAIN PCB - SUBWOOFERLVM100180-0011 IC401IC - TL

39、074CN C905,906CE 6800UF/50VPVE039570-6820 IC502IC -LM3886T PL-S3500 IC351RHI004558-0001IC - JRC4558D RHI003886-0001 RHI000740-0001 ! DB901RHD204010-0011BRIDGE RS402L! D504DIODE 1N4001RAD114001-0010 D351,352DIODE 1N4148RAD114148-0010 ZD502DIODE ZENER 9.1V-9.5VRAZ005009-0020 F902,903KSA020400-0121FUSE

40、 4A/250V TR - 2SC945RAN200945-0001Q351-353 CN301 CN401 CONNECTOR 4PIN P=2MMCCN200000-0104 CCN250000-0102CONNECTOR B2B-XH 2PIN 13 ! CN351CONNECTOR 3PIN P=2MMCCN200000-0103 CN906CCN396010-0103CONNECTOR 3PIN P=3.96MM REF. NOPARTS NO.DESCRIPTION I/P PCB ASSY SUBWOOFER REMARKS I/P PCB I/P PCB ASSYAPE1001

41、80-0024 LVM100180-0021 JK301RCA JACK 1PINCJR001101-0010 SW SLIDE K22F24MSW004020-0010SW301 ZD501,901,902DIODE ZENER 14.5-15.1VRAZ005015-0020 REF. NOPARTS NO.DESCRIPTION LED PCB ASSY SUBWOOFER REMARKS LED PCB ASSYAPE200222-4001 LD401LED D3MM ORANGE/GREENKED350003-0030 LVA200222-0601LED PCB REF. NO PO

42、WER PCB ASSY SUBWOOFER PARTS NO.DESCRIPTION POWER PCB ASSY -SUBWOOFER APE200250-5001 D353DIODE - 1N4148 REMARKS RAD114148-0010 ! T902 D354-356DIODE 1N4001RAD114001-0010 RL901RELAY GJ-SH-112DM CN901,902CONNECTOR 4PIN P=3.96MMCCN396021-0104 LVM100180-001 TTA123011-0010PWR TRANS 230V-50HZ EI-28 E,UK,HK

43、 MRL012004-0011 SUBWOOFER POWER PCB ZD350ZENER DIODE 11.1-11.6VRAZ005011-0030 Q354,355,357TR - 2SC945RAN200945-0001 F901FUSE 3.15A/250V E, UK, HKKSA020315-0120 E, UK, HK APE200250-5002 TTA110011-0010PWR TRANS 100V-50HZ EI-28 J) SUBWOOFER POWER PCB ASSY J ! ! KSA020315-0011FUSE 3.15A/250V J! ! ! PL-S

44、3500 MAIN PCB SUBWOOFER POWER PCB SUBWOOFERI/P PCB SUBWOOFER LED PCB SUBWOOFER MAIN PCB - TOP 15 PL-S3500 CN904 CN900 CN100 CN400 CON100 TO POWER PCB RB904 TO CONTROL PCB CON301 TO POWER PCB RB906TO CONTROL PCB CN302TO POWER PCB RB905 PL-S3500 MAIN PCB SUBWOOFER 16 POWER PCB SUBWOOFER CN301 CN503 CN

45、401 CN351 CN905 CN901CN902 TO I/P PCB TO SPEAKER TO LED PCB TO POWER PCB SUBWOOFER RB351 TO POWER PCB SUBWOOFER RB906 TO TRANSFORMERTO TRANSFORMER CN903 CN902 POWER PCB TO AC LINE CORD TO POWER SWITCH SUBWOOFER RB401 SUBWOOFER RB301 5 INCLUDED ACCESSORIES PL-S3500 REF. NOPARTS NO.DESCRIPTION INCLUDE

46、D ACCESSORIES REMOTE CONTROLHT996 E, UK, HK RCA CABLE BATTERY (AA, R6, UM-3) INSTRUCTION BOOK JYOM200005-0002 FBY006315-0003 AIR123015-3301 VRC101003-0010 YOM200005-0001INSTRUCTION BOOK E, UK, HK AIR123015-3304REMOTE CONTROLHT996 J REMARKS 17 PL-S3500 TEAC AUSTRALIA PTY., LTD. A.B.N. 80 005 408 462

47、280 William Street, Melbourne, VIC 3000, Australia Phone:(03)9672-2400 TEAC ITALIANA S.p.A. TEAC BELGIUM NV/SA. Via C, Cantu 11, 20092 Cinisello Balsamo, Milano, Italy Phone:02-66010550 c/o TEAC NEDERLAND BV, Oeverkruid 15, NL-4941 W Raamsdonksveer, Nederland Phone:+31-162-510860 TEAC CORPORATION 3-

48、7-3 Nakacho, Musashino-shi, Tokyo 180-8550, Japan Phone:(0422)52-5081 TEAC AMERICA, INC. TEAC CANADA LTD. TEAC MEXICO, S.A.De C.V. TEAC UK LIMITED TEAC DEUTSCHLAND GmbH TEAC FRANCE S.A. TEAC NEDERLAND BV 7733 Telegraph Road, Montebello, California 90640 Phone: (323)726-0303 5939 Wallace Street, Mississauga, Ontario L4Z 1Z8, Canada Phone: (905)-890-8008 Campesinos 184,Col. Granjas Esmeraida, 09810, Mexico Phone: (525)-