Philips-MCD-395-Service-Manual(1) 电路图 维修手册.pdf

《Philips-MCD-395-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-MCD-395-Service-Manual(1) 电路图 维修手册.pdf（42页珍藏版）》请在收音机爱好者资料库上搜索。

1、Version 1.3 MCD395/12/58 3141 785 32623 DVD Micro theatre Published by SL 1107 Service Audio Subject to modification Copyright 2011 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmi

2、tted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Block diagram .5-1 Wiring diagram .6-1 LCD & Key Board circuit diagram .7-1.7-2 layout diagram .7-3 Main Board circuit diagram .9-1.9-5 layout diagram .9-6.9-7 HP & AUX & US

3、B Jack Board circuit diagram .9-8.9-9 layout diagram .9-8.9-9 DVD MPEG Board circuit diagram. .10-1.10-8 layout diagram .10-9.10-10 Exploded view diagram .11-1 Mechanical partslist .11-2 Electrical partslist.12-1.12-2 TABLE OF CONTENTS PCBs location & Version Variations.1-1 Technical specification .

4、1-2 Service measurement setup .1-3 Service aids .1-4 Instructions on CD playability .2-1.2-2 Software version check .4-1 Rectifier Board circuit diagram .8-1 layout diagram .8-1 Power AMP Board circuit diagram .8-3.8-4 layout diagram .8-5 Revision list.13-1 RadioFans.CN 收音机爱 好者资料库 LCD & KEY BOARD RE

5、CTIFIER BOARD SERVO BOARD (DVD MPEG BOARD) TUNER MODULE MAIN BOARD POWER AMP BOARD /12 /58 xxn iRDC/n ixuA Line Out Video Out Subwoofer Out Digital Out Karaoke Features Voltage Selector ECO Power Standby (LCD Display Off) USB Direct Type /Versions: MCD395 Features in used: /05 VERSION VARIATIONS Typ

6、e /Versions: Board in used: MCD395 Service policy MAIN BOARD SERVO(MPEG) BOARD USB JACK BOARD RECTIFIER (POWER) BOARD * TIPS : C - Component Lever Repair. M - Module Lever Repair - Used C M /12 /05/55 89/16/85/ Feature diffrence C M LCD & KEY BOARD C C C C C C TUNER MODULEMM x xx xx xx xx xx xx 1 -

7、1 PCBS LOCATION POWER AMP BOARDCC RadioFans.CN 收音机爱 好者资料库 AMPLIFIER Output power . 2 x 50 W RMS Signal-to-noise ratio. 60 dBA Frequency response .63 16000 Hz, 3 dB Input sensitivity AUX . 0.5 V (max. 2 V) Impedance loudspeakers . 4 Impedance headphones .32 -1000 DVD PLAYER Laser Type. Semiconductor

8、Disc Diameter. 12cm / 8cm Video Decoding.MPEG-2 / MPEG-1 Video DAC.10 Bits Signal System . PAL / NTSC Video Format . 4:3 / 16:9 Video S/N.56 dB (minimum) Composite Video Output .1.0 Vp-p, 75 S-Video Output .Y - 1.0 Vp-p, 75 .C - 0.286 Vp-p, 75 Audio DAC . 24 Bits / 96 kHz Frequency Response.4 Hz - 2

9、0 kHz (44.1kHz) .4 Hz - 22 kHz (48kHz) .4 Hz - 44 kHz (96kHz) Digital Output. . SPDIF (Sony Philips digital interface) Coaxial Number of programmable tracks . 16 Signal-to-noise ratio. 65 dBA Channel separation. 40 dB (1 kHz) Total harmonic distortion. 0.1% (1 kHz) TUNER FM wave range .87.5 108 MHz

10、Sensitivity at 75 mono, 26 dB signal-to-noise ratio . 2.8 V stereo, 46 dB signal-to-noise ratio . 61.4 V Selectivity. 28 dB Total harmonic distortion. 5% Frequency response .63 5500 Hz (-6 dB) Signal-to-noise-ratio . 50 dBA USB PLAYER USB .V2.0/ V1.1 . support MP3/WMA/JPEG files Number of albums/ fo

11、lders.maximum 99 Number of tracks/titles.maximum 500 SPEAKERS 2-way bass reflex system GENERAL INFORMATION AC Power.220 230 V / 50 Hz Standby power consumption . 7W Eco power Standby. select DEFAULT and then select RESTORE . It can reset the region code. 2) To change the region code - open CD door a

12、t CD mode and press 5168 on RC - select REGION and select region code. 1) MCU version : at standby mode, press and hold DBB & PLAY buttons at the same time. Servo version : CD mode, open CD door and press 5168 on Remote Control. Software checking: SOFTWARE VERSION CHECKING AND REGION CODE RESET 4 -

13、1 4 - 1 SET BLOCK DIAGRAM 5 - 15 - 1 6 - 1 6 - 1 SET WIRING DIAGRAM 7 - 17 - 1 CIRCUIT DIAGRAM - LCD & KEY BOARD Part 1 7 - 27 - 2 CIRCUIT DIAGRAM - LCD & KEY BOARD Part 2 LAYOUT DIAGRAM - LCD & KEY BOARD 7 - 3 7 - 3 CIRCUIT DIAGARM - RECTIFIER BOARD 8 - 18 - 1 CIRCUIT DIAGARM - RECTIFIER BOARD LAYO

14、UT DIAGARM - RECTIFIER BOARD TOP VIEW 8 - 28 - 2 LAYOUT DIAGARM - RECTIFIER BOARD BOTTOM VIEW CIRCUIT DIAGARM - POWER AMP BOARD PART1 8 - 38 - 3 CIRCUIT DIAGARM - POWER AMP BOARD PART2 8 - 48 - 4 LAYOUT DIAGARM - POWER AMP BOARD 8 - 58 - 5 9 - 19 - 1 CIRCUIT DIAGRAM - MAIN BOARD CIRCUIT DIAGRAM - MA

15、IN BOARD 9 - 29 - 2 CIRCUIT DIAGRAM - MAIN BOARD 9 - 39 - 3 CIRCUIT DIAGRAM - MAIN BOARD 9 - 49 - 4 CIRCUIT DIAGRAM - MAIN BOARD 9 - 59 - 5 LAYOUT DIAGRAM - MAIN BOARD 9 - 69 - 6 9 - 79 - 7 LAYOUT DIAGRAM - MAIN BOARD CIRCUIT DIAGRAM - HEADPHONE BOARD 9 - 89 - 8 LAYOUT DIAGRAM - HEADPHONE BOARD CIRC

16、UIT DIAGRAM - AUX JACK BOARD LAYOUT DIAGRAM - AUX JACK BOARD CIRCUIT DIAGRAM - USB JACK BOARD 9 - 99 - 9 LAYOUT DIAGRAM - USB JACK BOARD 10 - 110 - 1 CIRCUIT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,diagram for referrence only. 10 - 210 - 2 CIRCUIT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,

17、diagram for referrence only. CIRCUIT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,diagram for referrence only. 10 - 310 - 3 CIRCUIT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,diagram for referrence only. 10 - 410 - 4 CIRCUIT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,diagram for referrence on

18、ly. 10 - 510 - 5 CIRCUIT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,diagram for referrence only. 10 - 610 - 6 CIRCUIT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,diagram for referrence only. 10 - 7 10 - 7 CIRCUIT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,diagram for referrence only. 10 - 8

19、10 - 8 LAYOUT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,diagram for referrence only. 10 - 910 - 9 LAYOUT DIAGRAM - DVD MPEG BOARD MPEG is not repaired,diagram for referrence only. 10 - 1010 - 10 333241 38 30 3528 14 39 161527 34 11 19 13 20 12 2110 SET MECHANICAL EXPLODED VIEW 11-111-1 42 31 293

20、637 40 7 9 MECHANICAL & ACCESSORIES PARTS LIST 7996510012846USB DOOR SPRING 8996510001074CD SPRING DIM:0.5MM 9996510000868CD DAMPER PINK 658F 10996510012847REAR CABINET 11996510012848CD DOOR 12996510012849TOP CABINET 13996510012850BOTTOM CABINET 14 996510012851 VOLUME KNOB 15996510012852CONTROL KNOB

21、-TOP-LEFT 16996510012853CONTROL KNOB-TOP-RIGHT 17996510012854POWER LIGHT GUIDE 18! 996510001450VDE AC CORD 1.72M 19996510001451DVD MECHANISM SONY 20 996510001452DVD TRAY LOADER WXD-8213 21996510012855FM TUNER MODULE FOR DC199A/12 22 996510001453FFC CABLE 24P 23996510010781FFC CABLE 10P L=330MM 24996

22、510001456RCA WIRE 1500MM BLACK WIRE 25996510012813REMOTE CONTROL FOR MCD395 26996510005595PIG TAIL ANTENNA WIRE BLACK 27996510012814FRONT CABINET 28996510012815CONTROL KNOB - FB 29996510012816CONTROL KNOB - FF 30996510012817 CONTROL KNOB - PRESETS(LEFT) 31996510012818CONTROL KNOB - PRESETS(RIGHT) 32

23、996510012819DISPLAY LENS 33996510012820DECORATION LENS TOP PANEL 34996510012821DECORATION LENS MIDDLE PANEL 35996510012822CONTROL KNOB - PLAY/PAUSE 36996510012823CONTROL KNOB - STOP 37996510012824 USB DOOR 38996510012825DECORATION RING 39996510012826DECORATION LENS BOTTOM PANEL 40996510012827USB LIG

24、HT GUIDE 41996510012828VOLUME KNOB LIGHT GUIDE 42996510036681 SERVO(MPEG) BOARD ASSY /58 42996510036682 SERVO(MPEG) BOARD ASSY /12 Note: Only these parts mentioned in the list are normal service parts. 11-2 SPK 996510041932 WOODEN SPEAKER BOX(LEFT+RIGHT) ELECTRICAL PARTS LIST - MAIN & H.P.ELECTRICAL

25、 PARTS LIST - LCD BOARD & AUX BOARD D405994000003223DIODE BRIDGE RECTIFIER GBU6BIC101996510001424IC SL4808DQ QFP100 D432996510010770RECTIFIER DIODE 1N5822IC102996510011311INFRA RECEIVER IC401996510001412IC LM2576TV-5.0 TO-220VL1996510000387CHOKE COIL 10UH K% 2.8X7MM IC402994000005724I.C. LD1117AL-3.

26、3V-DLCD996510010775LCD DISPLAY GS-34296+HSC-B/R IC502996500039259I.C. PT4800(L) DIP-8 PINLED1996510012841LED 3RG9SW-1-A 3MM RD/GN IC602996510010771IC 7314(ANGUS)LED2996510001423LED INDICATOR 3mm WHITE IC603996510001055IC BA4558 SOP8LED3996510001423LED INDICATOR 3mm WHITE IC604996510001055IC BA4558 S

27、OP8LED4996510001423LED INDICATOR 3mm WHITE JA301996510001410RCA JACK 8.3MM (RCA-124-012LED5996510001422LED INDICATOR BLUE JA502994000001456STEREO HEADPHONE JACKLED6996510001422LED INDICATOR BLUE JA601996510001409 RCA JACK 8.3MM 4HOLESLED7996510001422LED INDICATOR BLUE JA602996510001073EARPHONE CKX3.

28、5-19S (3PIN)Q1996510010777TRANSISTOR BC847C FREE L211996510001060FERRITE BEAN SBK160808T-601Y Q2996510010777TRANSISTOR BC847C FREE L212996510001060FERRITE BEAN SBK160808T-601Y Q3996510010776TRANSISTOR BC817-25 SOT23 L213996510001060FERRITE BEAN SBK160808T-601Y Q5996510010777TRANSISTOR BC847C FREE L2

29、14996510001060 FERRITE BEAN SBK160808T-601Y SW1996500039269TACT SWITCH L215996510001060 FERRITE BEAN SBK160808T-601Y SW10996500039269TACT SWITCH L413996510000387CHOKE COIL 10UH K% 2.8X7MMSW11996500039269TACT SWITCH L414996510010773FERRITE 100uH/1KHz/1V +/-20%SW12996500039269TACT SWITCH L503996510010

30、772FERRITE TYPE 11UH P% D4.5MM SW2996500039269 TACT SWITCH L504996510010772FERRITE TYPE 11UH P% D4.5MM SW3996500039269TACT SWITCH L605996510010772FERRITE TYPE 11UH P% D4.5MM SW4996500039269TACT SWITCH L606996510010772FERRITE TYPE 11UH P% D4.5MM SW5996500039269TACT SWITCH L607996510010772FERRITE TYPE

31、 11UH P% D4.5MM SW6996500039269TACT SWITCH L608996510010772FERRITE TYPE 11UH P% D4.5MM SW7996500039269TACT SWITCH L609996510010772FERRITE TYPE 11UH P% D4.5MM SW8996500039269TACT SWITCH L616996510010772FERRITE TYPE 11UH P% D4.5MM SW9996500039269TACT SWITCH Q416996510001414TRANSISTOR KTB772VR101996510

32、001059ENCODER EC121102X2B-HA1-082 Q422996510001413TRANSISTOR 2SD882Q ZD412996500039258ZENER DIODE 9V1 1/2W ZD413996510010769ZENER DIODE 8V2 1/2W (TC8V2)ELECTRICAL PARTS LIST - USB BOARD ZD501996510012835ZENER DIODE 5V6 1/2W (TC5V6) JA702996510001071USB JACK 4P ANGLE TYPE LED8996510001422LED INDICATO

33、R BLUE Q711996510010776TRANSISTOR BC817-25 SOT23 ELECTRICAL PARTS LIST - POWER AMP BOARD C519996510012837CBB CAP HMFS-5 0.68UF 63V C520996510012837CBB CAP HMFS-5 0.68UF 63V C585996510012836E.CAP. 3300UF 35V C586996510012836E.CAP. 3300UF 35V D505994000003223DIODE BRIDGE RECTIFIER GBU6B IC501996510012

34、838I.C TDA8920BTH SOT566-3 JA501996510000380PUSH TERMINAL JACK PST-418 L501996510012839INDUCTOR 22UH +/-10% L502996510012839INDUCTOR 22UH +/-10% 12-1 ELECTRICAL PARTS LIST - RECTIFIER BOARD 12-2 FUSE1! 994000003224FUSE 6.3A 250V FUSE2! 994000003224FUSE 6.3A 250V FUSE3! 996510000389FUSE 2.5A 250V K40

35、19940000014489V DC RELAY 10A ME-7-009-HL L401994000003226AC LINE FILTER 400UH -30% Q401996510005008TRANSISTOR SS8050D TO-92Q T401! 996510012812TRASFO EI-76 230V/50Hz T402! 996510001418TRANSFORMER STANDBY Note: Only these parts mentioned in the list are normal service parts. ELECTRICAL PARTS LISTSERV

36、O (MPEG) BOARDELECTRICAL PARTS LIST - SERVO (MPEG) BOARD (ONLY FOR REFERENCE) D305996510010756RECTIFIER DIODE SM4001S SM-2 X102996510012842XTAL 32.768KHZ 12.5PF D306996510010756RECTIFIER DIODE SM4001S SM-2 X202994000003209XTAL 4.332MHZ HC-49/S D307996510010756RECTIFIER DIODE SM4001S SM-2 X3019965100

37、10755XTAL 27MHz 20PF +/-20PPM D601996510010757SWITCHING DIODE BAV99L D602996510010757SWITCHING DIODE BAV99LD602996510010757SWITCHING DIODE BAV99L D603996510010757SWITCHING DIODE BAV99L IC103996510019969IC STK6011P9-3V PROGRAMMED IC104996510010763IC AT24C02BN-SH-T IC106996510010764IC PCF8563T SO8 IC2

38、03994000003215RDS IC SAA6581T IC301996510010762IC AM5888S HSOP28 IC302996510010761IC MPEG SPHE8281D IC303996510010760IC SDRAM 64M M12L64164A-7TG IC305996510012843IC EN29LV800AB-70TCCP PROGRAM IC307996510010763IC AT24C02BN-SH-T IC601996510001055IC BA4558 SOP8 L101996510001060FERRITE BEAN SBK160808T-6

39、01Y-S L601996510012845INDUCTOR 1uH TL201209-1R0K-LF L602996510012845INDUCTOR 1uH TL201209-1R0K-LF L603996510012845INDUCTOR 1uH TL201209-1R0K-LF Q301996510010766TRANSISTOR (MOSFET) 2SK3018 Q302996510010766TRANSISTOR (MOSFET) 2SK3018 Q304996510010765TRANSISTOR 2SB1132RQ304996510010765TRANSISTOR 2SB1132R Q305996510010765TRANSISTOR 2SB1132R Q308994000003206TRANSISTOR 8550D Q309994000003206TRANS