Rotel-RC1082-pre-sm 电路图 维修手册.pdf

《Rotel-RC1082-pre-sm 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Rotel-RC1082-pre-sm 电路图 维修手册.pdf（13页珍藏版）》请在收音机爱好者资料库上搜索。

1、T echnical Manual STEREO CONTROL AMPLIFIER RC-1082 Table of Contents Specification. 1 Parts List. 27 Case Outlines. 8 Safety Caution. 8 PCB Assembly. 910 Schematic Diagram . 1113 SHINSEN-BLD. 4F 10-10 SHINSEN-CHO, SHIBUYA-KU, TOKYO 150-0045, JAPAN Serial. NO. Beginning Y-402A-0707/pdf Specifications

2、 Total Harmonic Distortion (20Hz-20kHz) 0.004% Intermodulation Distortion (60 Hz : 7 kHz, 4:1) 0.004% at 1V output Input Sensitivity / Impedance Phono - MC 250 V / 100 ohms Phono - MM 2.5 mV / 47 kOhms Line Level 150 mV / 220 kOhms Phono Overload (MC/MM) 16 mV / 160 mV Output Sensitivity / Impedance

3、 1 V/ 100 Ohms Frequency Response Phono Input 20Hz-20kHz, 0.2dB Line Level Input 4Hz-100kHz, 0.5dB Signal to Noise Ratio (IHF “A” weighted) Phono - MC/MM 70 dB/75 dB Line Level 100 dB Power Requirements USA Version 120 Volts, 60 Hz European Version 230 Volt, 50 Hz Power Consumption 15 Watts Standby

4、Power Consumption 2.5 Watts Dimensions (W x H x D) 432 x 92 x 344 mm 17 x 3 5/8 x 13 9/16” Weight (net)7.5 kg, 16.53 lbs. RadioFans.CN 收音机爱 好者资料库 RECORDING LISTENING TUNER TUNERAUX 1 TAPE 1TAPE 2AUX 3PHONOCD PHONOCDTAPE 1AUX 3AUX 2 AUX 1AUX 2 OFF STAND BY STEREO CONTROL AMPLIFIER RC-1082 BALANCETONE

5、TREBLEBASS ON PHONES MEDIA PLAYER Apearance RC-1082 RadioFans.CN 收音机爱 好者资料库 Parts List 1/4 RC-1082 SYMBOLPARTS NO.DESCRIPTION 501 X-1463PCB ASSY H1,H2,H3,H4017 C-4401A01 SUB HEAT SINKER H=25 Q501/503,502/504,505/507,506/508019 C-4334A04TRANSISTOR CAP HI,H2,H3,H4019 TO-126MICA SHEET TBM-51W-15 #9524

6、X701023 CSTLS8M00G53BOCERAMIC RESONATOR IC401,402031 AD797ANZIC (OPE AMP) IC702031 HIN232CPIC (RS232) HIN232CPZ IC704031 LB1641IC (MOTOR DRIVE) IC542031 LC4966IC (LOGIC SWITCH) IC701031 M37544G2AGP-C82IC SMD (CPU) OTP IC504031 NJM2114DIC (OPE DUAL) IC601031 NJM4556ADIC (OPE DUAL) IC901031 NJM7805FAI

7、C (REG. +5VDC) KIA7805API IC902031 NJM7815FAIC (REG. +15VDC) KIA7815API IC903031 NJM7915FAIC (REG. -15VDC) KIA7915PI IC403,404,IC301,302031 OPA277PIC (OPE AMP) IC904031 PC817X2IC (PHOTO COUPLER) PC817X2J000F IC705031 RPM7138H9IC (REMOTE RECEIVER) IC703,706031 TC74HC595APIC (8BIT SHIFT REGISTELATCH)

8、IC451031 TC9163ANIC (SWITCH ALLEY) TC9193ANG Q401-404032 D786-RS TRANSISTOR 2SD786-RS Q451-458,468032 TA1345TRANSISTOR 2SA1345AC Q527,528032 TA608-FGTRANSISTOR 2SA608KAA-FG Q460-467,470032 TC3399TRANSISTOR 2SC3399AC Q525,526,529,530,701,903,907032 TC536-FGTRANSISTOR 2SC536KAA-FG Q904032 TD863-EFTRAN

9、SISTOR 2SD863AE-EF Q519,520033 A1209-STTRANSISTOR 2SA1209-ST Q409,410,521,522033 B631-EFTRANSISTOR 2SB631K-EF Q517,518033 C2911-STTRANSISTOR 2SC2911-ST Q407,408,523,524033 D600-EFTRANSISTOR 2SD600K-EF Q505-512,902033 TA1016-FGTRANSISTOR 2SA1016KAA-FG Q905033 TA1450-STTRANSISTOR 2SA1450AA-ST Q405,406

10、,501-504,513-516033 TC2362-FGTRANSISTOR 2SC2362KAA-FG Q901,906033 TC3708-STTRANSISTOR 2SC3708AA-ST D901,902034 BR84 POWER DIODE 400V8A D511-514034 E-562CURRENT REGULATIVE DIODE 5.6mA D509,510034 MA27W-AVARISTOR DIODE (MA2B027WA) D715-730034 SELK1E12WLED 2F (BLUE) D903,905034 T1N4004-TBDIODE 1N4004-F

11、 D401-404,441-448,501-508,515,516,541034 T1N4148-86DIODE 1N4148TAP-50 D601,602,701-708,714,904,907,914034 T1N4148-86DIODE 1N4148TAP-50 D709-712,911034 TRD12JST1ZENER DIODE 12V (AB2) D407,408034 TRD15JST1ZENER DIODE 15V (AB2) D405,406,908,912034 TRD18JST1ZENER DIODE 18V (AB2) D906034 TRD4.7JST1ZENER

12、DIODE 4.7V (AB2) D713034 TRD5.6JST1ZENER DIODE 5.6V (AB2) F901036 5ST2.5-R FUSE 250V2.5A C507,508041 25ZA47MTZ ELECTROLYTIC CAPACITOR 25V47uF C501,502041 35ZA4R7MTZ ELECTROLYTIC CAPACITOR 35V4.7uF C901-904041 ALN20S1078DD ELECTROLYTIC CAPACITOR 63V 4700uF C708041 FYD0H224ZSUPER CAPACITOR 5.5V0.22F 0

13、16 X-1463C01-10 PCB ASSY RadioFans.CN 收音机爱 好者资料库 Parts List 2/4 RC-1082 SYMBOLPARTS NO.DESCRIPTION C607,608041 TEEUFC1E101SB ELECTROLYTIC CAPACITOR 25V100uF C413-420,451,452,529,530,C303-306041 TEEUFC1E221B ELECTROLYTIC CAPACITOR 25V220uF C421-424,918,919041 TEEUFC1E471B ELECTROLYTIC CAPACITOR 25V47

14、0uF C409,410,425,426,527,528,531,532041 TEEUFC1H100LB ELECTROLYTIC CAPACITOR 50V10uF C505,506041 TEEUFC1H1R0B ELECTROLYTIC CAPACITOR 50V1uF C601,602041 TEEUFC1H4R7B ELECTROLYTIC CAPACITOR 50V4.7uF C509-512,908,909041 TEEUFC1V101BELECTROLYTIC CAPACITOR 35V100uF C513-516041 TEEUFC1V471BELECTROLYTIC CA

15、PACITOR 35V470uF C701,722,912041 TUTES1A101-7TFELECTROLYTIC CAPACITOR 10V100uF C916,917,C720041 TUTES1E101-7TFELECTROLYTIC CAPACITOR 25V100uF C707041 TUTES1E470-7TFELECTROLYTIC CAPACITOR 25V47uF C713-717,910041 TUTES1H010-7TFELECTROLYTIC CAPACITOR 50V1uF C461-468,718041 TUTES1H100-7TFELECTROLYTIC CA

16、PACITOR 50V10uF C719041 TUTES1H2R2-7TFELECTROLYTIC CAPACITOR 50V2.2uF C911041 TUTES1V101-7TFELECTROLYTIC CAPACITOR 35V100uF C915041 TUTES1V102-7TSELECTROLYTIC CAPACITOR 35V1000uF C605,606042 TP50V103JEMYLAR CAPACITOR 0.01uF C525,526042 TP50V152JEMYLAR CAPACITOR 0.0015uF C523,524042 TP50V472JEMYLAR C

17、APACITOR 0.0047uF C905-907,914,923-930043 TC500V103 CERAMIC CAPACITOR 500V0.01uF C703-705,723043 TC50V103 CERAMIC CAPACITOR 0.01uF C427043 TC50V473 CERAMIC CAPACITOR 0.047uF C517-522044 50MSAN104JESTACKED FILM CAPACITOR 0.1uF C706044 KT18-2A104KM.P CAPACITOR MKT1818-410/015 C411,412044 PP160V6800PFP

18、OLYPROPYLENE CAPACITOR 160V6800pF C407,408044 PP400V1000PFPOLYPROPYLENE CAPACITOR 400V1000pF C401,402,405,406,503,504,C301,302044 PP630V100PFPOLYPROPYLENE CAPACITOR 630V100pF C403,404044 PP630V330PFPOLYPROPYLENE CAPACITOR 630V330pF C603,604044 PP630V47PFPOLYPROPYLENE CAPACITOR 630V47pF C533,534044 S

19、50V220PJ STYROL CAPACITOR 50V220pF(J) VR513,514051 4TR-2774#1 VARIABLE RESISTOR 20KBX2 VR511051 4TR-2776# 1VARIABLE RESISTOR 100KMN VR502051 C-4170A33 VARIABLE RESISTOR 50KAX2 with MOTOR R919054 1WS100JFMOF RESISTOR 1W 100 R902054 1WS180JFMOF RESISTOR 1W 180 R560,561,611054 1WS470JFMOF RESISTOR 1W 4

20、70 R917054 1WS68JFMOF RESISTOR 1W 68 R905,906054 2WS100JFMOF RESISTOR 2W 100 R901054 ERQ1CJP2R2SFUSIBLE RESISTOR 1W 2.2 R529-532054 TGP14-010RMETAL RESISTOR GP1/4T-TC50-10R R701,702,926054 TMF16-1000METAL FILM RESISTOR 1/6W 100 R451-470,922,923054 TMF16-1001METAL FILM RESISTOR 1/6W 1K R721,915054 TM

21、F16-1002METAL FILM RESISTOR 1/6W 10K R474,539,540,555-557,708-711054 TMF16-1003METAL FILM RESISTOR 1/6W 100K R715,717,916,R706054 TMF16-1003METAL FILM RESISTOR 1/6W 100K R562054 TMF16-1004METAL FILM RESISTOR 1/6W 1M R716,924,925,927054 TMF16-10R0METAL FILM RESISTOR 1/6W 10 R541,542054 TMF16-1201META

22、L FILM RESISTOR 1/6W 1.2K R549-552,722,723054 TMF16-1501METAL FILM RESISTOR 1/6W 1.5K R553,554054 TMF16-1502METAL FILM RESISTOR 1/6W 15K R537,538,545,546054 TMF16-2001METAL FILM RESISTOR 1/6W 2K R543,544054 TMF16-2201METAL FILM RESISTOR 1/6W 2.2K R547,548,911-913054 TMF16-2202METAL FILM RESISTOR 1/6

23、W 22K Parts List 3/4 RC-1082 SYMBOLPARTS NO.DESCRIPTION R914054 TMF16-3301METAL FILM RESISTOR 1/6W 3.3K R558,559054 TMF16-4700METAL FILM RESISTOR 1/6W 470 R714054 TMF16-4701METAL FILM RESISTOR 1/6W 4.7K R704,705054 TMF16-4702METAL FILM RESISTOR 1/6W 47K R476054 TMF16-4703METAL FILM RESISTOR 1/6W 470

24、K R707054 TMF16-5600METAL FILM RESISTOR 1/6W 560 R907054 TMF1502METAL FILM RESISTOR 1/4W 15K R918054 TMF2701METAL FILM RESISTOR 1/4W 2.7K R612054 TMF4700METAL FILM RESISTOR 1/4W 470 R908054 TMF4701METAL FILM RESISTOR 1/4W 4.7K R910054 TMF4702METAL FILM RESISTOR 1/4W 47K R477054 TMF5600METAL FILM RES

25、ISTOR 1/4W 560 R909054 TMF8201METAL FILM RESISTOR 1/4W 8.2K R507,508,511,512054 TMFR401K2STANDARD METAL FILM RESISTOR 1/4W 1.2K R435,436,920,921054 TMFR401K5STANDARD METAL FILM RESISTOR 1/4W 1.5K R417,418,517,518054 TMFR4022KSTANDARD METAL FILM RESISTOR 1/4W 22K R421,422054 TMFR402K7STANDARD METAL F

26、ILM RESISTOR 1/4W 2.7K R605,606054 TMFR4033KSTANDARD METAL FILM RESISTOR 1/4W 33K R433,434.535,536,609,610054 TMFR4047KSTANDARD METAL FILM RESISTOR 1/4W 47K R409,410054 TMFR4047RSTANDARD METAL FILM RESISTOR 1/4W 47 R425,426054 TMFR404K7STANDARD METAL FILM RESISTOR 1/4W 4.7K R431,432,601,602054 TMFR4

27、100KSTANDARD METAL FILM RESISTOR 1/4W 100K R429,430054 TMFR4100RSTANDARD METAL FILM RESISTOR 1/4W 100 R607,608054 TMFR4150RSTANDARD METAL FILM RESISTOR 1/4W 150 R303,304054 TMFR4220KSTANDARD METAL FILM RESISTOR 1/4W 220K R419,420,513-516054 TMFR4270RSTANDARD METAL FILM RESISTOR 1/4W 270 R603,604054

28、TMFR4330KSTANDARD METAL FILM RESISTOR 1/4W 330K R427,428054 TMFR4470KSTANDARD METAL FILM RESISTOR 1/4W 470K R471,472,519-522,R415,416054 TMFR4470RSTANDARD METAL FILM RESISTOR 1/4W 470 R407,408054 TMFR4560RSTANDARD METAL FILM RESISTOR 1/4W 560 R405,406054 TPR9372-010RMETAL RESISTOR 10 R527,528054 TPR

29、9372-018KMETAL RESISTOR 18K R401,402054 TPR9372-047KMETAL RESISTOR 47K R503,504054 TPR9372-100KMETAL RESISTOR 100K R403,404,501,502054 TPR9372-100RMETAL RESISTOR 100 R301,302054 TPR9372-560RMETAL RESISTOR 560 R533,534,R305,306054 TRC55C1000FMETAL RESISTOR 100R R505,506,509,510054 TRC55C1201F METAL R

30、ESISTOR 1.2K R523,524054 TRC55C2200F METAL RESISTOR 220R R525,526054 TRC55C3301F METAL RESISTOR 3.3K R411-414054 TRC55C5601F METAL RESISTOR 5.6K R423,424054 TRC55C7502F METAL RESISTOR 75K S901061 4TR-2947PUSH SWITCH SPUN12K007 S401061 4TR-3301PUSH SWITCH SPUJ19A605 S701-708,711-718061 C-4679A04TACT

31、SWITCH 9.5mm DARK GRAY HV061095GS S501061 C-4946A01PUSH SWITCH PS005-PA022BCbK-M RY901063 DH2U-24 RELAY DH24D2-O(M) RY451-458,501,502,601,602063 EA2-24NURELAY MP1065 C-4939A01 3.5 MINI JACK PJ-315 HJ1065 C-4939A02 3.5 MINI JACK PJ317-01 HJ901-905065 YKB21-5103A3.5 JACK (ST) PJ1-PJ6066 4TR-2672#3 4P

32、PIN JACK (WHT.RED) SKT1066 SY010-8P/KRJ45 TERMINAL (8P) Parts List 4/4 RC-1082 SYMBOLPARTS NO.DESCRIPTION D001,D002068 B2B-EHCONNECTOR WAFER 2P JP9B,JP14B,JP18B068 B2B-PH-KSCONNECTOR WAFER 2P JP1B,JP2B,JP13B068 B3B-PH-KSCONNECTOR WAFER 3P JP12B,JP15B068 B4B-PH-KSCONNECTOR WAFER 4P JP0B068 B5B-EHCONN

33、ECTOR WAFER 5P JP4B,JP11B068 B5B-PH-KSCONNECTOR WAFER 5P JP16B,JP17B068 B9B-PH-KSCONNECTOR WAFER 9P CON4,5068 C-3683#2 PCB TERMINAL 3P CON3068 C-3683#3 PCB TERMINAL 4P CON2068 C-4422A01 PCB TERMINAL 2P V11,V13,V14068 S6B-PH-KSCONNECTOR WAFER 6P 011 FP-617A-BBLACK SUB PANEL 011 FP-617A-SSILVER SUB PA

34、NEL 011 TF3-01B00H/S PANEL 012 C-4711A01KNOB 43 W/LED (BLACK) 012 C-4711A01SKNOB 43 W/LED (SILVER) 012 C-4953A01KNOB 13 (BLACK) 012 C-4953A01SKNOB 13 (SILVER) 012 RV4-09A00PUSH BUTTON 14 (BLACK) 012 RV4-09A01PUSH BUTTON 14 (SILVER) 012 VR4-06B00PUSH BUTTON 7 (SILVER) 012 VR4-06B01PUSH BUTTON 7 (BLAC

35、K) 012 WP3-04A00TACT BUTTON 16KEY (BLACK) 012 WP3-04A01TACT BUTTON 16KEY (SILVER) 019 C-4714A00POWER KNOB RING 14 (BLACK) 019 C-4714A01POWER KNOB RING 14 (SILVER) 019 C-670#18FELT 56 019 PK4-07A00TMETAL FOOT 60 019 PR4-12B00KNOB RING 46 (RED) 019 PR4-12B01KNOB RING 46 (BLU) 019 VR4-04A00BUTTON RING

36、7 (SILVER) 019 VR4-04A01BUTTON RING 7 (BLACK) 022 T-1106T01POWER TRANSFORMER 034 SEL1124RLED (RED) 1X5 034 SEL1E24WLED (BLU) 1X5 069 C-4629A01AC 2P INLET 6102.3100 (WIRING) 072 4TR-2875PIN PLUG OFC CORD 072 C-4621A03AC CORD SET SJT AWG16 for U.S.A. 072 C-4622A02AC CORD SET for AUSTRALIA 072 C-4623A0

37、3AC CORD SET for U.K. 072 C-4624A03AC CORD SET for EUROPE 081 WP3-05A00INSIDE CARTON 081 WP3-06A00SHIPPING CARTON 081 ZE-204ETHAFOAM MOULDING 082 OMRC-1082-11OWNERS MANUAL 092 RR-AT97REMOTE CONTROL UNIT O T H E R S RC1082 SYMBOLPARTSDESCRIPTION 011 FP-617A-BBLACK PANEL ASSY 011 FP-617A-SSILVER PANEL

38、 ASSY 011 TH3-01B00H/S PANEL H109 012 C-4711A01KNOB 43F (BLK) 012 C-4711A01SKNOB 43F (SLV) 012 RV4-09A00PUSH BUTTON 14F (BLK) 012 RV4-09A01PUSH BUTTON 14F (SLV) 012 WP3-04A00TACT BUTTON 16 KEY (BLK) 012 WP3-04A01TACT BUTTON 16 KEY (SLV) 034 SEL1124RLED (RED) 1X5 034 SEL1E24WLED (BLU) 1X5 Addendum Li

39、st for Black and Silver Panel Assy is included: Panel Window Side Cap Knob Ring Tact buttons LED Case Outlines LB1641 NJM78XXFANJM79XXFAPC817X2 Safety Caution Cautions during Inspection and Repair 1. Keep in mind the safety warnings The safety instructions are shown as the labels or printings on the

40、 exterior, the inside chassis or the parts, etc. Refer to the instructions when proceeding with inspection or repair. 2. Use only the specified parts for replacement The selected parts are used at critical area to reduce fire hazard or electrical shock. So when replacing these parts where designaged

41、 with marks or marks on the schmatic diagram or the parts list, ensure to use only the same parts. 3. Ensure to dress back the AC (Mains) cord to the original position If for some reason, the AC cord is moved or partially disassembled, ensure to re- route or assemble back to the original position. T

42、he AC cord area is protected and secured by tubing and insulation materials for the sake of safety, so that no loose wire will touch and cause fire hazard and electrical shock. 4. Check for safety aspects after inspection or repair Ensure all parts, such as screws or wires, removed during inspection

43、 or repair are secured back to the original positions, and check visually for any anomaly. Also check for any electrical leakage or resistance to maintain the safety. NJM4556AD LC4966 HIN232CP TC74HC595AP TC9163AN RPM7138H9 AD797ANZ M37544G2AGP-C82 NJM2114D OPA277P NJM2444D 12345678 91011 12 13 14 1

44、516 1718192021222324 2526272829303132 2SA608K 2SA1016K 2SA1450 2SC536K 2SC2362K 2SC3708 2SD863 2SA1345 2SC3399 2SD786 2SB631K 2SA1209 2SD600K 2SC2911 RC-1082 1 2 3 PCB Assembly 1/2 MAIN PCB (1/2) 016 X-1463C0109 RC-1082 Bottom Pattern PCB Assembly 2/2 RC-1082 MAIN PCB (2/2) 016 X-1463C0109 Top Pattern Schematic Diagram 1/3 MAIN PCB (1/3) 016 X-1463C0109 RC-1082 Schematic Diagram 2/3 MAIN PCB (2/3) 016 X-1463C0109 RC-1082 Schematic Diagram 3/3 MAIN PCB (3/3) 016 X-1463C0109 RC-1082