Aiwa-CDC-X307-X407-Service-Manual 电路图 维修手册.pdf

《Aiwa-CDC-X307-X407-Service-Manual 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Aiwa-CDC-X307-X407-Service-Manual 电路图 维修手册.pdf（32页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL DATA STEREO CAR CD RECEIVER CDC-X207 CDC-X307 CDC-X407 CDC-X2070 CDC-X3070 CDC-X4010 YU YU YU YL YL YL S/M Code No. 09-002-422-3R1 REVISION BASIC CD MECHANISM: TN-CCD1001-113J This Service Manual is the “Revision Publishing” and replaces “Simple Manual” of CDC-X207/ X307/ X407, (S/M C

2、ode No. 09-99B-422-3T1) and CDC-X2070/ X3070/ X4010, (S/M Code No. 09-99C-422-3T2). RadioFans.CN 收音机爱 好者资料库 SPECIFICATIONS RADIO SECTION (FM) Frequency Range87.5 MHz 108 MHz (100-kHz steps) 87.5 MHz 108 MHz (50-kHz steps) Usable Sensitivity12.7 dBf 50 dB Quieting Sensitivity 17.2 dBf IF Rejection80

3、dB Frequency Response30 Hz 15,000 Hz S/N Ratio63 dB Stereo Separation35 dB at 1 kHz Alternate Channel Selectivity 70 dB Capture Ratio3 dB (AM) Frequency Range530 kHz 1,710 kHz (10-kHz steps) 531 kHz 1,602 kHz (9-kHz steps) Usable Sensitivity30 V (30 dB) Set the frequency increment for your area usin

4、g the switch on the bottom of the unit. (The switch is set at the factory to the 10k position for the U.S.A.) CD SECTION Frequency Response17 Hz 20 kHz +0/3 dB Dynamic RangeMore than 80 dB Channel SeparationMore than 65 dB S/N RatioMore than 85 dB Wow/FlutterUnmeasurable AUDIO SECTION Max. Power Out

5、put45 W x 4 channels 35 W x 4 channels TAPE/MD IN input Input Sensitivity (load impedance) TAPE/MD IN500 mV (10 k) 300 mV (10 k) GENERAL Power Supply Voltage14.4 V (11 to 16 V allowable), DC, negative ground Load Impedance4 Tone ControlBass 10 dB at 100 Hz Treble 10 dB at 10 kHz Preamp Output Voltag

6、e (load impedance) 2.2 V (10 k) Installation Size182 (W) x 53 (H) x 155 (D) mm (71/4 (W) x 21/8 (H) x 61/8 (D) inches) STEERING-WHEEL-MOUNTED REMOTE CONTROL UNIT Dimensionsapprox. 67 (W) x 26 (H) x 27 (D) mm (23/4 (W) x 11/16 (H) x 11/8 (D) inches) (excluding holder) Weightapprox. 38g (1.33 oz.) (in

7、cluding holder, battery) Design and specifications are subject to change without notice. 1 8A-KC7-902-010 IB,INST,YU,YL (3L,P) 1 8A-KCG-902-010 IB,YU(3L) 207 1 8A-KCG-901-010 IB,YU(3L) 307,407 1 8A-KCG-903-010 IB,YL(3L) 4010, 3070, 2070 2 87-B10-141-010 NUT,5 TYPE-2 3 87-B10-143-010 UT1+5-15 W/O SLO

8、T 4 87-B10-144-010 W,5.2-10-0.5 5 87-B10-145-010 W-SPR,5.3-8.5-1.5 6 87-B10-216-010 U+2.6-4.0 ZINC BLK (BH M2.6) 7 8Z-KC1-030-010 CASE,DFP -C 8 8Z-KC1-231-110 HLDR,HALF -C 9 8Z-KC1-232-010 KEY,REMOVE -C 10 8Z-KC1-235-010 HLDR,REAR MTG 11 8Z-KC1-244-010 S-SCREW,5*6 TH+ TAPPING ST 12 8Z-KC1-250-010 S-

9、SCREW,HEXAGON 13 8Z-KT1-616-010 CONN ASSY,16P B52 ACCESSORIES / PACKAGE LIST KANRIREF. NO.DESCRIPTIONPART NO. -2- RadioFans.CN 收音机爱 好者资料库 Precaution to replace Optical block (OPTIMA-720AIE) Body or clothes electrostatic potential could ruin laser diode in the optical block. Be sure ground body and w

10、orkbench, and use care the clothes do not touch the diode. 1) After the connection, remove solder shown in right figure. -3- CLASS 1LASER PRODUCT KLASSE 1LASER PRODUKT LUOKAN 1LASER LAITE KLASS 1LASER APPARAT This set employs laser. Therefore, be sure to follow carefully the instructions below when

11、servicing. WARNING! WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION. BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 30cm FROM THE SURFACE OF THE OBJEC- TIVE LENS ON THE OPTICAL PICK-UP BLOCK. sCaution: Invisible laser r

12、adiation when open and interlocks defeated avoid exposure to beam. sAdvarsel: Usynlig laserstling ved bning, nr sikkerhedsafbrydere er ude af funktion. Undg udsttelse for strling. VAROITUS! Laiteen Kyttminen muulla kuin tss kyttohjeessa mainitulla tavalla saataa altistaa kyt-tjn turvallisuusluokan 1

13、 ylittvlle nkymttmlle lasersteilylle. VARNING! Om apparaten anvnds p annat stt n vad som specificeras i denna bruksanvising, kan anvndaren utsttas fr osynling laserstrlning, som verskrider grnsen fr laserklass 1. PROTECTION OF EYES FROM LASER BEAM DURING SERVICING CAUTION Use of controls or adjustme

14、nts or performance of proce- dures other than those specified herin may result in hazardous radiation exposure. ATTENTION Lutillisation de commandes, rglages ou procdures autres que ceux spcifis peut entraner une dangereuse exposition aux radiations. ADVARSEL Usynlig laserstling ved bning, nr sikker

15、hedsafbrydereer ude af funktion. Undg udsttelse for strling. This Compact Disc player is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the rear exterior. PICK-UP ASSY P.C.B RadioFans.CN 收音机爱 好者资料库 KANRI NO. REF. NO.DESCRIPTIONPART NO.KANRI NO. REF. NO.DESCRIPTI

16、ONPART NO. IC 87-A20-446-010 C-IC,LA9241ML 87-A21-319-010 C-IC,LC78622NE 87-A21-488-040 C-IC,LA6556 8Z-KT1-622-010 C-IC,LC75374E 87-A21-562-010 IC,LA4743B 88-KT1-606-080 IC,PST994D 87-A21-535-030 C-IC,LC72358N-9910 87-A21-489-030 C-IC,LC75853NW 87-A90-951-010 RCR UNIT,SBX1971-52 TRANSISTOR 89-324-12

17、2-080 TR,2SC2412K 87-A30-289-040 C-TR,2SA1037AK(R) 87-A30-288-040 C-TR,DTC114YKA 87-A30-287-040 C-TR,DTC114TKA 87-026-235-080 CHIP-TR,DTC114EK 87-026-210-080 CHIP-TR,DTC144EK 87-A30-299-080 TR,2SB1326 87-A30-282-040 C-TR,DTA114TKA 87-A30-168-010 TR,2SB1566F 89-211-821-080 CHIP-TR 2SB1182Q 89-423-953

18、-010 TR,2SD2395F 87-A30-301-080 TR,2SD1862 87-A30-449-040 C-TR,DTA123YKA DIODE 87-A40-250-080 CHIP-DIODE,DAN202K 87-001-783-080 DIODE,1N4002 87-020-331-080 CHIP-DIODE,DAN202K 87-A40-624-080 ZENER,MTZJ10A 87-A40-523-080 ZENER,MTZJ9.1B 87-070-136-080 ZENER,MTZJ5.1B 87-017-932-080 ZENER,MTJ6.2B 87-A40-

19、798-010 DIODE,1N5402 (3A/200V) 87-A40-817-040 C-ZENER,STZ6.8N MAIN C.B C101 87-010-178-080 CHIP CAP 1000P C102 87-010-197-080 CAP, CHIP 0.01 DM C103 87-010-495-040 CAP,E 2.2-50 GAS C106 87-010-322-080 C-CAP,S 100P-50 CH C107 87-010-552-040 CAP,E 22-16 GAS C108 87-010-322-080 C-CAP,S 100P-50 CH C109

20、87-010-553-040 CAP,E 47-16 GAS C110 87-010-198-080 CAP, CHIP 0.022 C111 87-010-553-040 CAP,E 47-16 GAS C112 87-010-185-080 C-CAP,S 3900P-50 B C113 87-010-197-080 CAP, CHIP 0.01 DM C114 87-010-197-080 CAP, CHIP 0.01 DM C115 87-010-196-080 CHIP CAPACITOR,0.1-25 C116 87-010-196-080 CHIP CAPACITOR,0.1-2

21、5 C131 87-012-365-080 C-CAP,S 0.027-25VBK C131 87-010-220-080 C-CAP,S 0.018-25 K B C132 87-012-365-080 C-CAP,S 0.027-25VBK C132 87-010-220-080 C-CAP,S 0.018-25 K B C133 87-012-358-080 C-CAP,S 0.47-10 F Z C134 87-012-358-080 C-CAP,S 0.47-10 F Z C161 87-010-196-080 CHIP CAPACITOR,0.1-25 C171 87-010-19

22、7-080 CAP, CHIP 0.01 DM C173 87-010-322-080 C-CAP,S 100P-50 J CH GRM C176 87-010-197-080 C-CAP,S 0.01-25 K B C201 87-010-553-040 CAP,E 47-16 GAS C202 87-010-553-040 CAP,E 47-16 GAS C203 87-010-178-080 CHIP CAP 1000P C204 87-016-669-080 C-CAP,S 0.1-25 K B C205 87-A11-606-080 C-CAP,S 0.22-25 K B C206

23、87-010-492-040 CAP,E 0.33-50 GAS C207 87-010-195-080 C-CAP,S 0.068-25 Z F C2012 C208 87-010-176-080 C-CAP,S 680P-50 J SL C209 87-010-992-080 CAP, CHIP 0.047 C210 87-016-669-080 C-CAP,S 0.1-25 K B C211 87-010-498-040 CAP,E 10-16 M 5L SRE C212 87-010-180-080 C-CER 1500P C213 87-010-992-080 CAP, CHIP 0

24、.047 C214 87-016-669-080 C-CAP,S 0.1-25 K B C215 87-010-178-080 C-CAP,S 1000P-50 K B C2012 C215 87-010-182-080 C-CAP,S 2200P-50 K B C2012 C216 87-A11-606-080 C-CAP,S 0.22-25 K B C217 87-016-669-080 C-CAP,S 0.1-25 K B C218 87-010-198-080 CAP, CHIP 0.022 C219 87-012-157-080 C-CAP,S 330P-50 CH C220 87-

25、010-184-080 CHIP CAPACITOR 3300P(K) C221 87-010-322-080 C-CAP,S 100P-50 CH C222 87-010-492-040 CAP,E 0.33-50 GAS C223 87-010-067-040 CAP,E 0.1-50 5L C224 87-010-553-040 CAP,E 47-16 GAS C225 87-010-805-080 C-CAP,S 1-16 Z F C225 87-010-184-080 C-CAP,S 3300P-50 K B C2012 C226 87-010-497-040 CAP,E 4.7-3

26、5 GAS C227 87-010-555-040 CAP,E 100-10 GAS C228 87-016-669-080 CHIP CAPACITOR,0.1-25 C229 87-010-498-040 CAP,E 10-16 GAS C230 87-016-669-080 CHIP CAPACITOR,0.1-25 C231 87-010-555-040 CAP,E 100-10 GAS C232 87-016-669-080 CHIP CAPACITOR,0.1-25 C233 87-010-555-040 CAP,E 100-10 GAS C234 87-010-193-080 C

27、HIP CAPACITOR,0.033 C235 87-010-992-080 CAP, CHIP 0.047 C236 87-010-067-040 CAP,E 0.1-50 5L C237 87-010-553-040 CAP,E 47-16 GAS C238 87-010-197-080 CAP, CHIP 0.01 DM C240 87-016-669-080 C-CAP,S 0.1-25 K B C250 87-016-669-080 CHIP CAPACITOR,0.1-25 C250 87-010-805-080 C-CAP,S 1-16 Z F C251 87-010-555-

28、040 CAP,E 100-10 GAS C256 87-010-186-080 CAP,CHIP 4700P C258 87-010-150-080 C-CAP,S 6P-50 D CH C259 87-010-316-080 C-CAP,S 33P-50 CH C261 87-012-156-080 C-CAP,S 220P-50 J CH GRM C262 87-016-669-080 C-CAP,S 0.1-25 K B C263 87-010-555-040 CAP,E 100-10 GAS C264 87-010-555-040 CAP,E 100-10 GAS C265 87-0

29、16-669-080 C-CAP,S 0.1-25 K B C266 87-016-669-080 C-CAP,S 0.1-25 K B C267 87-010-498-040 CAP,E 10-16 GAS C268 87-010-498-040 CAP,E 10-16 GAS C269 87-010-180-080 C-CER 1500P C270 87-010-180-080 C-CER 1500P C271 87-010-154-080 CAP CHIP 10P C272 87-010-154-080 CAP CHIP 10P C273 87-010-494-040 CAP,E 1-5

30、0 M 5L SRE C274 87-010-494-040 CAP,E 1-50 M 5L SRE C280 87-A10-189-040 CAP,E 220-10 C281 87-010-555-040 CAP,E 100-10 GAS C282 87-016-669-080 C-CAP,S 0.1-25 K B C301 87-010-498-040 CAP,E 10-16 GAS C302 87-010-498-040 CAP,E 10-16 GAS C303 87-010-494-040 CAP,E 1-50 GAS C304 87-010-494-040 CAP,E 1-50 GA

31、S C305 87-010-184-080 CHIP CAPACITOR 3300P(K) C306 87-010-184-080 CHIP CAPACITOR 3300P(K) C307 87-010-198-080 CAP, CHIP 0.022 C308 87-010-198-080 CAP, CHIP 0.022 C309 87-010-498-040 CAP,E 10-16 GAS C310 87-010-498-040 CAP,E 10-16 GAS -4- ELETRICAL MAIN PARTS LIST KANRI NO. REF. NO.DESCRIPTIONPART NO

32、.KANRI NO. REF. NO.DESCRIPTIONPART NO. C311 87-A11-177-080 C-CAP,S 0.15-16 K B C312 87-A11-177-080 C-CAP,S 0.15-16 K B C313 87-A11-177-080 C-CAP,S 0.15-16 K B C314 87-A11-177-080 C-CAP,S 0.15-16 K B C315 87-010-498-040 CAP,E 10-16 GAS C316 87-010-498-040 CAP,E 10-16 GAS C321 87-010-196-080 CHIP CAPA

33、CITOR,0.1-25 C322 87-010-555-040 CAP,E 100-10 GAS C323 87-010-196-080 CHIP CAPACITOR,0.1-25 C324 87-010-498-040 CAP,E 10-16 GAS C331 87-012-358-080 C-CAP,S 0.47-10 F Z C332 87-012-358-080 C-CAP,S 0.47-10 F Z C333 87-010-196-080 C-CAP,S 0.1-25 Z F C2012 C334 87-010-196-080 CHIP CAPACITOR,0.1-25 C351

34、87-010-494-040 CAP,E 1-50 GAS C352 87-010-494-040 CAP,E 1-50 GAS C353 87-010-494-040 CAP,E 1-50 GAS C354 87-010-494-040 CAP,E 1-50 GAS C361 87-012-358-080 C-CAP,S 0.47-10 F Z C362 87-012-358-080 C-CAP,S 0.47-10 F Z C363 87-012-358-080 C-CAP,S 0.47-10 F Z C364 87-012-358-080 C-CAP,S 0.47-10 F Z C365

35、87-010-175-080 CAP 560P C366 87-010-175-080 CAP 560P C367 87-010-175-080 CAP 560P C368 87-010-175-080 CAP 560P C451 87-010-498-040 CAP,E 10-16 GAS C452 87-010-498-040 CAP,E 10-16 GAS C453 87-010-498-040 CAP,E 10-16 GAS C454 87-010-498-040 CAP,E 10-16 GAS C455 87-012-140-080 CAP 470P C456 87-012-140-

36、080 CAP 470P C457 87-012-140-080 CAP 470P C458 87-012-140-080 CAP 470P C511 8A-KC7-623-000 CAP,E 2200U-16 BT(125C) C512 87-010-196-080 CHIP CAPACITOR,0.1-25 C513 87-010-196-080 CHIP CAPACITOR,0.1-25 C514 87-010-498-040 CAP,E 10-16 GAS C515 87-010-494-040 CAP,E 1-50 GAS C516 87-010-178-080 CHIP CAP 1

37、000P C517 87-010-178-080 CHIP CAP 1000P C519 87-010-494-040 CAP,E 1-50 M 5L SRE C519 87-010-494-040 CAP,E 1-50 M 5L SRE C531 87-012-368-080 C-CAP,S 0.1-50 Z F C532 87-012-368-080 C-CAP,S 0.1-50 Z F C533 87-012-368-080 C-CAP,S 0.1-50 Z F C534 87-012-368-080 C-CAP,S 0.1-50 Z F C590 87-010-178-080 CHIP

38、 CAP 1000P C611 87-010-553-040 CAP,E 47-16 GAS C612 87-010-198-080 CAP, CHIP 0.022 C613 87-016-044-040 CAP,E 100-16 GAS C621 87-010-553-040 CAP,E 47-16 GAS C622 87-010-553-040 CAP,E 47-16 GAS C641 87-010-196-080 CHIP CAPACITOR,0.1-25 C642 87-010-196-080 CHIP CAPACITOR,0.1-25 C671 87-010-198-080 CAP,

39、 CHIP 0.022 C672 87-010-555-040 CAP,E 100-10 GAS C673 87-010-553-040 CAP,E 47-16 GAS C674 87-010-198-080 CAP, CHIP 0.022 C681 87-010-553-040 CAP,E 47-16 GAS C682 87-010-198-080 CAP, CHIP 0.022 C701 87-010-315-080 C-CAP,S 27P-50 CH C702 87-010-314-080 C-CAP,S 22P-50V C706 87-010-497-040 CAP,E 4.7-35

40、GAS C711 87-010-322-080 C-CAP,S 100P-50 CH C712 87-010-322-080 C-CAP,S 100P-50 CH C761 87-010-555-040 CAP,E 100-10 GAS C763 87-010-196-080 CHIP CAPACITOR,0.1-25 C771 87-012-156-080 C-CAP,S 220P-50 J CH GRM C831 87-010-494-040 CAP,E 1-50 M 5L SRE C832 87-010-494-040 CAP,E 1-50 M 5L SRE C835 87-010-18

41、2-080 C-CAP,S 2200P-50 K B C2012 C836 87-010-182-080 C-CAP,S 2200P-50 K B C2012 C881 87-010-182-080 C-CAP,S 2200P-50 B C882 87-010-182-080 C-CAP,S 2200P-50 B C883 87-010-182-080 C-CAP,S 2200P-50 B C884 87-010-182-080 C-CAP,S 2200P-50 B CON201 87-A60-859-010 CONN,12P TKC-F12X-K1 CON202 87-A60-860-010

42、 CONN,14P TKC-F14X-K1 CON851 88-KTA-603-010 CONN,15P CAM-B68 CON881 8Z-KT1-611-010 CONN,16P CAM-B51 F881 8Z-KC1-621-010 FUSE,15A 32V J101 8Z-KT1-614-010 ANT,AW-002 J451 87-A61-225-010 JACK,PIN 2P J451 87-A61-224-010 JACK,PIN 4P XR-401 L101 87-003-143-080 COIL 4.7 UH L102 8Z-KT1-619-010 COIL,68MH K7-

43、D L465 87-003-143-080 COIL,4.7UH K LAL02 L671 87-003-149-080 COIL,47UH L831 87-003-143-080 COIL,4.7UH K LAL02 L881 8Z-KT1-615-010 FLTR,AMORPHOUS -CHOKE LED702 87-027-262-010 LEDE,TLR124(RED) R241 87-022-371-080 C-RES,S 330K-1/10W F R242 87-022-371-080 C-RES,S 330K-1/10W F SW701 87-A91-070-010 SW,TAC

44、T SKHHLV SW702 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A TU101 8A-KC8-621-010 TU UNIT, FAE347-A12 X201 81-592-641-010 VIB,CER 16.93MHZ X701 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49 FRONT C.B C901 87-010-805-080 CAP, S 1-16 C902 87-010-194-080 CAP, CHIP 0.047 C903 87-010-194-080 CAP, CHIP 0.047 C904 87-010

45、-177-080 C-CAP,S 820P-50 SL C905 87-010-196-080 CHIP CAPACITOR,0.1-25 C971 87-010-196-080 CHIP CAPACITOR,0.1-25 CON901 88-KTA-602-010 CONN,15P CAM-B67 LCD901 8A-KCG-610-010 LCD,AKC-16-17 LED951 87-017-827-070 C-LED,SEC1201 RED LED952 87-017-827-070 C-LED,SEC1201 RED LED953 87-017-827-070 C-LED,SEC12

46、01 RED LED961 87-A40-813-040 C-LED,SEC1E01C BLUE LED962 87-A40-813-040 C-LED,SEC1E01C BLUE LED963 87-A40-813-040 C-LED,SEC1E01C BLUE PL901 8Z-KT1-641-010 LAMP,T-3 PL902 8Z-KT1-641-010 LAMP,T-3 SW901 87-036-251-080 SW,T CT 6X3.5 160 SW902 87-036-251-080 SW,T CT 6X3.5 160 SW903 87-036-251-080 SW,T CT 6X3.5 160 SW904 87-A90-001-080 C-SW,TACT SKQMAL SW905 87-A90-001-080 C-SW,TACT SKQMAL SW906 87-A90-001-080 C-SW,TACT SKQMAL SW907 87-036-251-080 SW,T CT 6X3.5 160 SW908 87-036-251-080 SW,T CT 6X3.5 160 SW910 87-A90-001-080 C-SW,TACT SKQM