Aiwa Stereo Car Cd Receiver Cdc-Z107 Parts & Service 电路图.pdf

上传人：cc518

文档编号：191485

上传时间：2025-03-06

格式：PDF

页数：36

大小：4.87MB

《Aiwa Stereo Car Cd Receiver Cdc-Z107 Parts & Service 电路图.pdf》由会员分享，可在线阅读，更多相关《Aiwa Stereo Car Cd Receiver Cdc-Z107 Parts & Service 电路图.pdf（36页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL DATA STEREO CAR CD RECEIVER CDC-Z107YU S/M Code No. 09-002-422-4R1 REVISION This Service Manual is the “Revision Publishing” and replaces “Simple Manual” of CDC-Z107, (S/M Code No. 09-99B-422-4T1). BASIC CD MECHANISM : TN-CCD1001-113J RadioFans.CN 收音机爱好者资料库 SPECIFICATIONS RADIO SECTI

2、ON (FM) Frequency Range87.5 MHz 108 MHz (100-kHz steps) 87.5 MHz 108 MHz (50-kHz steps) Usable Sensitivity12.7 dBf 50 dB Quieting Sensitivity 17.2 dBf IF Rejection80 dB Frequency Response30 Hz 15,000 Hz S/N Ratio63 dB Stereo Separation35 dB at 1 kHz Alternate Channel Selectivity 70 dB Capture Ratio3

3、 dB (AM) Frequency Range530 kHz 1,710 kHz (10-kHz steps) 531 kHz 1,602 kHz (9-kHz steps) Usable Sensitivity30 V (30 dB) Set the frequency increment for your area using the switch on the bottom of the unit. (The switch is set at the factory to the 10k position for the U.S.A.) CD SECTION Frequency Res

4、ponse17 Hz 20 kHz +0/3 dB Dynamic RangeMore than 80 dB Channel SeparationMore than 65 dB S/N RatioMore than 85 dB Wow/FlutterUnmeasurable AUDIO SECTION Max. Power Output45 W x 4 channels TAPE/MD IN input Input Sensitivity (load impedance) TAPE/MD IN500 mV (10 k) GENERAL Power Supply Voltage14.4 V (1

5、1 to 16 V allowable), DC, negative ground Load Impedance4 Tone ControlBass 10 dB at 100 Hz Treble 10 dB at 10 kHz Preamp Output Voltage (load impedance) 2.2 V (10 k) Installation Size182 (W) x 53 (H) x 155 (D) mm (71/4 (W) x 21/8 (H) x 61/8 (D) inches) Design and specifications are subject to change

6、 without notice. ACCESSORIES / PACKAGE LIST KANRIREF. NO.DESCRIPTIONPART NO. 1 8A-KC7-902-010 IB,INST,YU,YL (3L,P) 1 8A-KCH-901-010 IB,YU(3L) 107 2 87-B10-141-010 NUT,5 TYPE-2 3 87-B10-143-010 UT1+5-15 W/O SLOT 4 87-B10-144-010 W,5.2-10-0.5 5 87-B10-145-010 W-SPR,5.3-8.5-1.5 6 8Z-KC1-231-110 HLDR,HA

7、LF -C 7 8Z-KC1-232-010 KEY,REMOVE -C 8 8Z-KC1-235-010 HLDR,REAR MTG 9 8Z-KC1-244-010 S-SCREW,5*6 TH+ TAPPING ST 10 8Z-KC1-250-010 S-SCREW,HEXAGON 11 8Z-KT1-616-010 CONN ASSY,16P B52 - 2 - RadioFans.CN 收音机爱好者资料库 Precaution to replace Optical block (OPTIMA-720AIE) Body or clothes electrostatic potent

8、ial could ruin laser diode in the optical block. Be sure ground body and workbench, and use care the clothes do not touch the diode. 1) After the connection, remove solder shown in right figure. - 3 - CLASS 1LASER PRODUCT KLASSE 1LASER PRODUKT LUOKAN 1LASER LAITE KLASS 1LASER APPARAT This set employ

9、s laser. Therefore, be sure to follow carefully the instructions below when servicing. WARNING! WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION. BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 30cm FROM THE SURFACE OF TH

10、E OBJEC- TIVE LENS ON THE OPTICAL PICK-UP BLOCK. sCaution: Invisible laser radiation when open and interlocks defeated avoid exposure to beam. sAdvarsel: Usynlig laserstling ved bning, nr sikkerhedsafbrydere er ude af funktion. Undg udsttelse for strling. VAROITUS! Laiteen Kyttminen muulla kuin tss

11、kyttohjeessa mainitulla tavalla saataa altistaa kyt-tjn turvallisuusluokan 1 ylittvlle nkymttmlle lasersteilylle. VARNING! Om apparaten anvnds p annat stt n vad som specificeras i denna bruksanvising, kan anvndaren utsttas fr osynling laserstrlning, som verskrider grnsen fr laserklass 1. PROTECTION

12、OF EYES FROM LASER BEAM DURING SERVICING CAUTION Use of controls or adjustments or performance of proce- dures other than those specified herin may result in hazardous radiation exposure. ATTENTION Lutillisation de commandes, rglages ou procdures autres que ceux spcifis peut entraner une dangereuse

13、exposition aux radiations. ADVARSEL Usynlig laserstling ved bning, nr sikkerhedsafbrydereer ude af funktion. Undg udsttelse for strling. This Compact Disc player is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the rear exterior. PICK-UP ASSY P.C.B RadioFans.CN

14、收音机爱好者资料库 KANRI NO. REF. NO.DESCRIPTIONPART NO.KANRI NO. REF. NO.DESCRIPTIONPART NO. - 4 - IC 87-A20-446-010 C-IC,LA9241ML 87-A21-319-010 C-IC,LC78622NE 87-A21-488-040 C-IC,LA6556 8Z-KT1-622-010 C-IC,LC75374E 87-A21-562-010 IC,LA4743B 88-KT1-606-080 IC,PST994D 87-A21-535-030 C-IC,LC72358N-9910 87-

15、A21-489-030 C-IC,LC75853NW TRANSISTOR 89-324-122-080 TR,2SC2412K 87-A30-289-040 C-TR,2SA1037AK(R) 87-A30-288-040 C-TR,DTC114YKA 87-A30-287-040 C-TR,DTC114TKA 87-026-235-080 CHIP-TR,DTC114EK 87-026-210-080 CHIP-TR,DTC144EK 87-A30-299-080 TR,2SB1326 87-A30-282-040 C-TR,DTA114TKA 87-A30-168-010 TR,2SB1

16、566F 89-211-821-080 CHIP-TR 2SB1182Q 89-423-953-010 TR,2SD2395F 87-A30-301-080 TR,2SD1862 87-A30-449-040 C-TR,DTA123YKA DIODE 87-A40-250-080 CHIP-DIODE,DAN217 87-001-783-080 DIODE,1N4002 87-020-331-080 C-DIODE,DAN202K 87-A40-624-080 ZENER,MTZJ10A 87-A40-523-080 ZENER,MTZJ9.1B 87-070-136-080 ZENER,MT

17、ZJ5.1B 87-017-932-080 ZENER,MTJ6.2B 87-A40-798-010 DIODE,1N5402 (3A/200V) MAIN C.B C101 87-010-178-080 CHIP CAP 1000P C102 87-010-197-080 CAP, CHIP 0.01 DM C103 87-010-495-040 CAP,E 2.2-50 GAS C106 87-010-322-080 C-CAP,S 100P-50 CH C107 87-010-552-040 CAP,E 22-16 GAS C108 87-010-322-080 C-CAP,S 100P

18、-50 CH C109 87-010-553-040 CAP,E 47-16 GAS C110 87-010-198-080 CAP, CHIP 0.022 C111 87-010-553-040 CAP,E 47-16 GAS C112 87-010-185-080 C-CAP,S 3900P-50 B C113 87-010-197-080 CAP, CHIP 0.01 DM C114 87-010-197-080 CAP, CHIP 0.01 DM C115 87-010-196-080 CHIP CAPACITOR,0.1-25 C116 87-010-196-080 CHIP CAP

19、ACITOR,0.1-25 C131 87-012-365-080 C-CAP,S 0.027-25VBK C132 87-012-365-080 C-CAP,S 0.027-25VBK C133 87-012-358-080 C-CAP,S 0.47-10 F Z C134 87-012-358-080 C-CAP,S 0.47-10 F Z C161 87-010-196-080 CHIP CAPACITOR,0.1-25 C171 87-010-197-080 CAP, CHIP 0.01 DM C173 87-010-322-080 C-CAP,S 100P-50 J CH GRM C

20、201 87-010-553-040 CAP,E 47-16 GAS C202 87-010-553-040 CAP,E 47-16 GAS C203 87-010-178-080 CHIP CAP 1000P C204 87-016-669-080 C-CAP,S 0.1-25 K B C205 87-A11-606-080 C-CAP,S 0.22-25 K B C206 87-010-492-040 CAP,E 0.33-50 GAS C207 87-010-195-080 C-CAP,S 0.068-25 Z F C2012 C208 87-010-176-080 C-CAP,S 68

21、0P-50 J SL C209 87-010-992-080 C-CAP,S 0.047-25 K B MK212 C210 87-016-669-080 C-CAP,S 0.1-25 K B C211 87-010-498-040 CAP,E 10-16 M 5L SRE C212 87-010-180-080 C-CER 1500P C213 87-010-992-080 CAP, CHIP 0.047 C214 87-016-669-080 CHIP CAPACITOR,0.1-25 C215 87-010-178-080 CHIP CAP 1000P C216 87-A11-606-0

22、80 C-CAP,S 0.22-25 K B C217 87-016-669-080 CAP, CHIP 0.01 DM C218 87-010-198-080 CAP, CHIP 0.022 C219 87-012-157-080 C-CAP,S 330P-50 CH C220 87-010-184-080 CHIP CAPACITOR 3300P(K) C221 87-010-322-080 C-CAP,S 100P-50 CH C222 87-010-492-040 CAP,E 0.33-50 GAS C223 87-010-067-040 CAP,E 0.1-50 5L C224 87

23、-010-553-040 CAP,E 47-16 GAS C225 87-010-805-080 C-CAP,S 1-16 Z F C226 87-010-497-040 CAP,E 4.7-35 GAS C227 87-010-555-040 CAP,E 100-10 GAS C228 87-016-669-080 CHIP CAPACITOR,0.1-25 C229 87-010-498-040 CAP,E 10-16 GAS C230 87-016-669-080 CHIP CAPACITOR,0.1-25 C231 87-010-555-040 CAP,E 100-10 GAS C23

24、2 87-016-669-080 CHIP CAPACITOR,0.1-25 C233 87-010-555-040 CAP,E 100-10 GAS C234 87-010-193-080 CHIP CAPACITOR,0.033 C235 87-010-992-080 CAP, CHIP 0.047 C236 87-010-067-040 CAP,E 0.1-50 5L C237 87-010-553-040 CAP,E 47-16 GAS C238 87-010-197-080 CAP, CHIP 0.01 DM C240 87-016-669-080 C-CAP,S 0.1-25 K

25、B C250 87-016-669-080 CHIP CAPACITOR,0.1-25 C251 87-010-555-040 CAP,E 100-10 GAS C252 87-016-669-080 CHIP CAPACITOR,0.1-25 C253 87-016-669-080 CHIP CAPACITOR,0.1-25 C254 87-016-669-080 CHIP CAPACITOR,0.1-25 C256 87-010-186-080 CAP,CHIP 4700P C258 87-010-150-080 C-CAP,S 6P-50 D CH C259 87-010-316-080

26、 C-CAP,S 33P-50 CH C261 87-012-156-080 C-CAP,S 220P-50 CH C262 87-016-669-080 CHIP CAPACITOR,0.1-25 C263 87-010-555-040 CAP,E 100-10 GAS C264 87-010-555-040 CAP,E 100-10 GAS C265 87-016-669-080 CHIP CAPACITOR,0.1-25 C266 87-016-669-080 CHIP CAPACITOR,0.1-25 C267 87-010-498-040 CAP,E 10-16 GAS C268 8

27、7-010-498-040 CAP,E 10-16 GAS C269 87-010-180-080 C-CER 1500P C270 87-010-180-080 C-CER 1500P C271 87-010-154-080 CAP CHIP 10P C272 87-010-154-080 CAP CHIP 10P C273 87-010-494-040 CAP,E 1-50 GAS C274 87-010-494-040 CAP,E 1-50 GAS C280 87-A10-189-040 CAP,E 220-10 C281 87-010-555-040 CAP,E 100-10 GAS

28、C282 87-016-669-080 CHIP CAPACITOR,0.1-25 C301 87-010-498-040 CAP,E 10-16 GAS C302 87-010-498-040 CAP,E 10-16 GAS C303 87-010-494-040 CAP,E 1-50 GAS C304 87-010-494-040 CAP,E 1-50 GAS C305 87-010-184-080 CHIP CAPACITOR 3300P(K) C306 87-010-184-080 CHIP CAPACITOR 3300P(K) C307 87-010-198-080 CAP, CHI

29、P 0.022 C308 87-010-198-080 CAP, CHIP 0.022 C309 87-010-498-040 CAP,E 10-16 GAS C310 87-010-498-040 CAP,E 10-16 GAS C311 87-A11-177-080 C-CAP,S 0.15-16 K B C312 87-A11-177-080 C-CAP,S 0.15-16 K B C313 87-A11-177-080 C-CAP,S 0.15-16 K B C314 87-A11-177-080 C-CAP,S 0.15-16 K B C315 87-010-498-040 CAP,

30、E 10-16 GAS ELETRICAL MAIN PARTS LIST KANRI NO. REF. NO.DESCRIPTIONPART NO.KANRI NO. REF. NO.DESCRIPTIONPART NO. - 5 - C316 87-010-498-040 CAP,E 10-16 GAS C321 87-010-196-080 CHIP CAPACITOR,0.1-25 C322 87-010-555-040 CAP,E 100-10 M 5L SRE C323 87-010-196-080 CHIP CAPACITOR,0.1-25 C324 87-010-498-040

31、 CAP,E 10-16 GAS C351 87-010-494-040 CAP,E 1-50 GAS C352 87-010-494-040 CAP,E 1-50 GAS C353 87-010-494-040 CAP,E 1-50 GAS C354 87-010-494-040 CAP,E 1-50 GAS C361 87-012-358-080 C-CAP,S 0.47-10 F Z C362 87-012-358-080 C-CAP,S 0.47-10 F Z C363 87-012-358-080 C-CAP,S 0.47-10 F Z C364 87-012-358-080 C-C

32、AP,S 0.47-10 F Z C365 87-010-175-080 CAP 560P C366 87-010-175-080 CAP 560P C367 87-010-175-080 CAP 560P C368 87-010-175-080 CAP 560P C453 87-010-498-040 CAP,E 10-16 GAS C454 87-010-498-040 CAP,E 10-16 GAS C457 87-012-140-080 CAP 470P C458 87-012-140-080 CAP 470P C461 87-005-902-080 C-COIL,S 4.7UH K

33、LK2125 C511 8A-KC7-623-000 CAP,E 2200U-16 BT(125C) C512 87-010-196-080 CHIP CAPACITOR,0.1-25 C513 87-010-196-080 CHIP CAPACITOR,0.1-25 C514 87-010-553-040 CAP,E 47-16 M 5L SRE C515 87-010-494-040 CAP,E 1-50 GAS C516 87-010-178-080 CHIP CAP 1000P C517 87-010-178-080 CHIP CAP 1000P C519 87-010-494-040

34、 CAP,E 1-50 M 5L SRE C551 87-010-553-040 CAP,E 47-16 GAS C590 87-010-178-080 CHIP CAP 1000P C611 87-010-553-040 CAP,E 47-16 GAS C612 87-010-198-080 CAP, CHIP 0.022 C613 87-016-044-040 CAP,E 100-16 GAS C621 87-010-553-040 CAP,E 47-16 GAS C622 87-010-553-040 CAP,E 47-16 GAS C641 87-010-196-080 CHIP CA

35、PACITOR,0.1-25 C642 87-010-196-080 CHIP CAPACITOR,0.1-25 C671 87-010-198-080 CAP, CHIP 0.022 C672 87-010-555-040 CAP,E 100-10 GAS C673 87-010-553-040 CAP,E 47-16 GAS C674 87-010-198-080 CAP, CHIP 0.022 C681 87-010-553-040 CAP,E 47-16 GAS C682 87-010-198-080 CAP, CHIP 0.022 C701 87-010-315-080 C-CAP,

36、S 27P-50 CH C702 87-010-314-080 C-CAP,S 22P-50V C706 87-010-497-040 CAP,E 4.7-35 GAS C711 87-010-322-080 C-CAP,S 100P-50 CH C712 87-010-322-080 C-CAP,S 100P-50 CH C761 87-010-555-040 CAP,E 100-10 GAS C763 87-010-196-080 CHIP CAPACITOR,0.1-25 C771 87-012-156-080 C-CAP,S 220P-50 J CH GRM C831 87-010-4

37、94-040 CAP,E 1-50 GAS C832 87-010-494-040 CAP,E 1-50 GAS C835 87-010-182-010 C-CAP,S 2200P-50 K B C2012 C836 87-010-182-010 C-CAP,S 2200P-50 K B C2012 C881 87-010-182-080 C-CAP,S 2200P-50 B C882 87-010-182-080 C-CAP,S 2200P-50 B C883 87-010-182-080 C-CAP,S 2200P-50 B C884 87-010-182-080 C-CAP,S 2200

38、P-50 B CON201 87-A60-859-010 CONN,12P TKC-F12X-K1 CON202 87-A60-860-010 CONN,14P TKC-F14X-K1 CON881 8Z-KT1-611-010 CONN,16P CAM-B51 F881 8Z-KC1-621-010 FUSE,15A 32V J101 8Z-KT1-614-010 ANT,AW-002 J451 87-A61-225-010 JACK,PIN 2P XR-401 L101 87-003-143-080 COIL 4.7 UH L102 8Z-KT1-619-010 COIL,68MH K7-

39、D L671 87-003-149-080 COIL,47UH L831 87-003-143-080 COIL,4.7UH K LAL02 L881 8Z-KT1-615-010 FLTR,AMORPHOUS -CHOKE R241 87-022-371-080 C-RES,S 330K-1/10W F R242 87-022-371-080 C-RES,S 330K-1/10W F SW702 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A TU101 8A-KC8-621-010 TU UNIT, FAE347-A12 X201 81-592-641-01

40、0 VIB,CER 16.93MHZ X701 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49 FRONT C.B C901 87-010-805-080 CAP, S 1-16 C902 87-010-194-080 CAP, CHIP 0.047 C903 87-010-194-080 CAP, CHIP 0.047 C904 87-010-177-080 C-CAP,S 820P-50 SL C905 87-010-196-080 CHIP CAPACITOR,0.1-25 LCD901 8A-KCG-610-010 LCD,AKC-16-17 LED951 8

41、7-A91-052-080 LED,SEL6227S RED LED952 87-A91-052-080 LED,SEL6227S RED LED953 87-A91-052-080 LED,SEL6227S RED LED961 87-A40-813-040 C-LED,SEC1E01C BLUE LED962 87-A40-813-040 C-LED,SEC1E01C BLUE LED963 87-A40-813-040 C-LED,SEC1E01C BLUE PL901 8Z-KT1-641-010 LAMP,T-3 PL902 8Z-KT1-641-010 LAMP,T-3 SW901

42、 87-036-251-080 SW,T CT 6X3.5 160 SW902 87-036-251-080 SW,T CT 6X3.5 160 SW903 87-036-251-080 SW,T CT 6X3.5 160 SW904 87-036-251-080 SW,T CT 6X3.5 160 SW905 87-036-251-080 SW,T CT 6X3.5 160 SW906 87-036-251-080 SW,T CT 6X3.5 160 SW907 87-036-251-080 SW,T CT 6X3.5 160 SW908 87-036-251-080 SW,T CT 6X3

43、.5 160 SW910 87-036-251-080 SW,T CT 6X3.5 160 SW911 87-036-251-080 SW,T CT 6X3.5 160 SW913 87-036-251-080 SW,T CT 6X3.5 160 SW914 87-036-251-080 SW,T CT 6X3.5 160 SW915 87-036-251-080 SW,T CT 6X3.5 160 SW916 87-036-251-080 SW,T CT 6X3.5 160 SW917 87-036-251-080 SW,T CT 6X3.5 160 SW918 87-036-251-080

44、 SW,T CT 6X3.5 160 SW921 87-A91-597-010 SW,RTRY SIM-026MT SW971 87-036-251-080 SW,T CT 6X3.5 160 AUX C.B CON831 87-A60-912-010 CONN,3P V 1MSA-9202B-1 J831 85-HRL-623-010 JACK,3.5 ST BLK ! 8 8 A Resistor Code Chip Resistor Part Coding Figure Value of resistor Chip resistor WattageTypeTolerance 1/16W

45、1/10W 1/8W 1608 2125 3216 5% 5% 5% CJ CJ CJ FormLWt 1.60.80.45 21.250.45 3.21.6 108 118 128 : A : A CHIP RESISTOR PART CODE 0.55 Resistor Code Dimensions (mm) Symbol 1/16W10055%CJ1.00.50.35104 L t W TRANSISTOR ILLUSTRATION B C EB C E B C EE C B 2SB1566 E C B 2SA1037 2SC2412 DTA114TKA DTA123YKA DTC11

46、4EK DTC114YKA DTC114TKA DTC144EK 2SD23952SB11822SB1326 2SD1862 - 6 - WIRING - 1 (MAIN: 1 / 2) - 7 - 181920212223242526272829303132 A B C D E F G H I J K L M N O P Q R S T U 1716151413121110987654321 - 8 - WIRING - 1 (MAIN: 1 / 2) 151413121110987654321 A B C D E F G H I J K L M N O P Q R S T U 1617181920212223242526272829303132 SCHEMATIC DIAGRAM - 1 (MAIN: 1 / 2) - 9 - SCHEMATIC DIAGRAM - 2 (MAIN: 2 / 2) - 10 - WIRING - 2 (FRONT) - 11 - 101112131415161718192021222324 A B C D E F G H I J K L M N O P Q R S T U 1234567892526272829303132 SCHEMATIC DIAGRAM - 3 (FRONT) - 12 - IC BLOCK DIAGRAM IC,L