Aiwa Stereo Car Cd Receiver Cdc-R307-Rv407 Parts & Service 电路图.pdf

《Aiwa Stereo Car Cd Receiver Cdc-R307-Rv407 Parts & Service 电路图.pdf》由会员分享，可在线阅读，更多相关《Aiwa Stereo Car Cd Receiver Cdc-R307-Rv407 Parts & Service 电路图.pdf（33页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL DATA STEREO CAR CD RECEIVERBASIC CD MECHANISM : CDC02AW1 CDC-R307 CDC-RV407 YZ YZ S/M Code No. 09-004-429-0R1 REVISION This Service Manual is the Revision Publishing and replaces Simple Manual (S/M Code No. 09-002-429-0T1). RadioFans.CN 收音机爱 好者资料库 2 RADIO SECTION (FM) Frequency Range8

2、7.5 MHz 108 MHz (50 kHz steps) Usable Sensitivity12.7 dBf 50 dB Quieting Sensitivity17.2 dBf IF Rejection80 dB Frequency Response30 Hz 15,000 Hz S/N Ratio63 dB Stereo Separation35 dB at 1 kHz Alternate Channel Selectivity70 dB Capture Ratio3 dB (MW) Frequency Range531 kHz 1,602 kHz (9 kHz steps) Usa

3、ble Sensitivity30 V (30 dB) (LW) Frequency Range144 kHz 288 kHz (1 -kHz/9 -kHz steps) Usable Sensitivity30 V (30 dB) CD SECTION Frequency Response17 Hz 20 kHz +0/3 dB Dynamic RangeMore than 80 dB Channel SeparationMore than 65 dB S/N RatioMore than 85 dB Wow/FlutterUnmeasurable AUDIO SECTION Max. Po

4、wer Output45 W x 4 channels AUX IN input Input Sensitivity (load impedance) AUX IN300 mV (10 k) GENERAL Power Supply Voltage14.4 V (11 to 16 V allowable), DC, negative ground Load Impedance4 Tone ControlBass 10 dB at 100 Hz Treble 10 dB at 10 kHz Preamp Output Voltage (load impedance) 2.2 V (10 k) I

5、nstallation Size182 (W) x 53 (H) x 155 (D) mm (71/4 (W) x 21/8 (H) x 61/8 (D) inches) STEERING-WHEEL-MOUNTED REMOTE CONTROL UNIT DimensionsApprox. 67 (W) x 26 (H) x 27 (D) mm (23/4 (W) x 11/16 (H) x 11/8 (D) inches) (excluding holder) WeightApprox. 38 g (1.33 oz.) (including holder, battery) SPECIFI

6、CATIONS Design and specifications are subject to change without notice. ACCESSORIES / PACKAGE LIST DESCRIPTIONREF. NO.KANRI NO. PART NO. 1 8A-KCG-905-010 IB,INST YZ(9L)-I 1 8A-KC4-901-010 IB,YZ(9L) R307,RV407 2 8Z-KC1-030-010 CASE,DFP-C 3 8Z-KC1-231-110 HLDR,HALF-C 4 8Z-KC1-235-010 HLDR,REAR MTG 5 8

7、Z-KC1-232-010 KEY,REMOVE-C 6 87-B10-141-010 NUT,5 TYPE-2 7 87-B10-144-010 W,5.2-10-0.5 8 87-B10-145-010 W-SPR,5.3-8.5-1.5 9 87-B10-143-010 UT1+5-15 W/O SLOT 10 87-B10-216-010 U+2.6-4.0 ZINC BLK(BH M2.6) 11 8Z-KC1-244-010 S-SCREW,5*6 TH+TAPPING ST 12 8Z-KC1-250-010 S-SCREW,HEXAGON *13 R8-AZR-190-040

8、AZR-1 RCKCGNF * NOTE: This remote controller is not an accessory part. It is an individual model. RadioFans.CN 收音机爱 好者资料库 3 This set employs laser. Therefore, be sure to follow carefully the instructions below when servicing. WARNING! WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO C

9、LOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION. BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 30cm FROM THE SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL PICK-UP BLOCK. Caution: Invisible laser radiation when open and interlocks defeated avoid exposure to beam. Advarsel: Usynlig las

10、erstling ved bning, nr sikkerhedsafbrydere er ude af funktion. Undg udsttelse for strling. VAROITUS! Laiteen Kyttminen muulla kuin tss kyttohjeessa mainitulla tavalla saataa altistaa kyt-tjn turvallisuusluokan 1 ylittvlle nkymttmlle lasersteilylle. VARNING! Om apparaten anvnds p annat stt n vad som

11、specificeras i denna bruksanvising, kan anvndaren utsttas fr osynling laserstrlning, som verskrider grnsen fr laserklass 1. PROTECTION OF EYES FROM LASER BEAM DURING SERVICING CAUTION Use of controls or adjustments or performance of proce- dures other than those specified herin may result in hazardo

12、us radiation exposure. ATTENTION Lutillisation de commandes, rglages ou procdures autres que ceux spcifis peut entraner une dangereuse exposition aux radiations. ADVARSEL Usynlig laserstling ved bning, nr sikkerhedsafbrydereer ude af funktion. Undg udsttelse for strling. This Compact Disc player is

13、classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the rear exterior. CLASS 1LASER PRODUCT KLASSE 1LASER PRODUKT LUOKAN 1LASER LAITE KLASS 1LASER APPARAT Precaution to replace Optical block (KSS 710A) Body or clothes electrostatic potential could ruin laser diode in

14、 the optical block. Be sure ground body and workbench, and use care the clothes do not touch the diode. 1) After the connection, remove solder shown in right figure. Solder RadioFans.CN 收音机爱 好者资料库 CAUTION WHEN SERVICING 2. Servicing Position Put the DFP onto the CD case to fix it. (Fig. 2) 1. Disass

15、embly Instruction 1) Remove the COVER TOP and COVER BOTTOM. 2) Remove the DFP. 3) Remove the four screws (indicated by arrows) from CD mechanism. (Fig. 1) Screw (a) 2: VTT 2.6-6 Screw (b) 2: VTT 2.6-3B Fig. 1 Fig. 2 4 5 ELECTRICAL MAIN PARTS LIST DESCRIPTIONREF. NO.KANRI NO. PART NO.DESCRIPTIONREF.

16、NO.KANRI NO. PART NO. IC 88-KT1-606-080 IC,PST994D 8Z-KT1-622-010 C-IC,LC75374E 87-A21-562-010 IC,LA4743B 87-A21-528-030 C-IC,UPD178018AGC-554-3B9 87-020-784-080 IC,TC4053BF 88-KT1-608-010 C-IC,LC75854W 87-A90-951-010 RCR UNIT,SBX1971-52 87-A21-467-010 C-IC,CXA2581N 87-A21-533-030 C-IC,CXD2587Q 87-0

17、17-888-080 IC,NJM4558MD 87-A21-534-030 C-IC,UPD78012FGC-656-AB8 87-A21-161-040 C-IC,BA6392FP 87-A20-712-040 C-IC,BA6417F 88-KT1-607-080 C-IC,SAA6579T TRANSISTOR 87-A30-287-040 C-TR,DTC114TKA 87-A30-289-040 C-TR,2SA1037AK(R) 89-324-122-080 C-TR,2SC2412KR 87-A30-290-010 TR,KTA1658(Y) 87-A30-291-010 TR

18、,KTC4369(Y) 89-418-580-080 TR,2SD1858-TV2 89-423-953-010 TR,2SD2395F 89-113-625-080 C-TR,2SA1362GR 87-A30-283-040 C-TR,DTA114YKA 87-A30-248-040 C-TR,2SB1197KQ 87-A30-011-080 C-TR,DTB113ZK 87-A30-273-040 C-TR,DTC124EKA 87-026-210-040 C-TR,DTC144EK DIODE 87-A40-250-080 C-DIODE,DAN217 87-A40-649-080 ZE

19、NER,MTZJ11A 87-A40-509-080 ZENER,MTZJ6.8C 87-020-330-080 DIODE,DAP202K 87-A40-620-080 ZENER,MTZJ6.2A 87-A40-650-080 ZENER,MTZJ6.8A 87-017-932-080 ZENER,MTZJ6.2B 87-070-136-080 ZENER,MTZJ5.1B 87-A40-798-010 DIODE,1N5402(3A/200V) 87-020-465-080 DIODE,1SS133 87-020-331-080 C-DIODE,DAN202K 87-A40-523-08

20、0 ZENER,MTZJ9.1B 87-A40-337-080 ZENER,MTZJ6.8B 87-001-783-080 DIODE,1N4002 87-020-331-080 C-DIODE,DAN202K MAIN C.B ANT101 8Z-KT1-614-010 ANT,AW-002 C101 87-010-178-080 CHIP CAP,1000P C102 87-010-197-080 CAP,CHIP 0.01 DM C103 87-010-186-080 C-CAP,S 4700P-50 KB C104 87-010-186-080 C-CAP,S 4700P-50 KB

21、C105 87-010-490-040 CAP,E 0.1-50 M 5L C106 87-010-198-080 CAP,CHIP 0.022 C107 87-010-198-080 CAP,CHIP 0.022 C108 87-018-131-080 CAP,TC U 1000P-50 KB C109 87-010-197-080 CAP,CHIP 0.01 DM C111 87-010-196-080 CHIP CAPACITOR,0.1-25 C112 87-010-197-080 CAP,CHIP 0.01 DM C113 87-010-197-080 CAP,CHIP 0.01 D

22、M C115 87-010-178-080 CHIP CAP,1000P C116 87-010-197-080 CAP,CHIP 0.01 DM C117 87-010-197-080 CAP,CHIP 0.01 DM C118 87-010-197-080 CAP,CHIP 0.01 DM C119 87-010-495-040 CAP,E 2.2-50 GAS C120 87-010-185-080 C-CAP,S 3900P-50 B C121 87-010-220-080 C-CAP,S 0.018-25BK C122 87-010-220-080 C-CAP,S 0.018-25B

23、K C123 87-012-358-080 C-CAP,S 0.47-10 FZ C124 87-012-358-080 C-CAP,S 0.47-10 FZ C131 87-010-182-080 C-CAP,S 2200P-50 KB C132 87-010-182-080 C-CAP,S 2200P-50 KB C151 87-012-149-080 C-CAP,S 30P-50 J CH C152 87-010-315-080 C-CAP,S 27P-50 J CH C153 87-010-495-040 CAP,E 2.2-50 M 5L C154 87-012-157-080 C-

24、CAP,S 330P-50 J CH C155 87-010-175-080 CHIP CAP,560P-50 J SL C156 87-010-196-080 CHIP CAPACITOR,0.1-25 C157 87-010-553-040 CAP,E 47-16 M 5L C202 87-012-358-080 C-CAP,S 0.47-10 FZ C203 87-010-196-080 CHIP CAPACITOR,0.1-25 C205 87-010-553-040 CAP,E 47-16 GAS C206 87-010-198-080 CAP,CHIP 0.022 C207 87-

25、010-196-080 CHIP CAPACITOR,0.1-25 C208 87-010-196-080 CHIP CAPACITOR,0.1-25 C209 87-010-196-080 CHIP CAPACITOR,0.1-25 C211 87-010-198-080 CAP,CHIP 0.022 C212 87-010-196-080 CHIP CAPACITOR,0.1-25 C214 87-010-196-080 CHIP CAPACITOR,0.1-25 C216 87-010-198-080 CAP,CHIP 0.022 C217 87-010-196-080 CHIP CAP

26、ACITOR,0.1-25 C218 87-010-196-080 CHIP CAPACITOR,0.1-25 C219 87-010-182-080 C-CAP,S 2200P-50 B C220 87-010-553-040 CAP,E 47-16 GAS C251 87-012-368-080 C-CAP,S 0.1-50 ZF C252 87-010-182-080 C-CAP,S 2200P-50 B C301 87-012-358-080 C-CAP,S 0.47-10 FZ C302 87-012-358-080 C-CAP,S 0.47-10 FZ C303 87-010-80

27、5-080 CAP,S 1-16 C304 87-010-805-080 CAP,S 1-16 C305 87-010-184-080 CHIP CAPACITOR,3300P(K) C306 87-010-184-080 CHIP CAPACITOR,3300P(K) C307 87-010-198-080 CAP,CHIP 0.022 C308 87-010-198-080 CAP,CHIP 0.022 C309 87-010-805-080 C-CAP,S 1-16 ZF C310 87-010-805-080 C-CAP,S 1-16 ZF C311 87-A11-177-080 C-

28、CAP,S 0.15-16 KB C312 87-A11-177-080 C-CAP,S 0.15-16 KB C313 87-A11-177-080 C-CAP,S 0.15-16 KB C314 87-A11-177-080 C-CAP,S 0.15-16 KB C315 87-010-805-080 C-CAP,S 1-16 ZF C316 87-010-805-080 C-CAP,S 1-16 ZF C317 87-010-196-080 CHIP CAPACITOR,0.1-25 C318 87-010-498-040 CAP,E 10-16 GAS C321 87-010-555-

29、040 CAP,E 100-10 GAS C322 87-010-198-080 CAP,CHIP 0.022 C331 87-A11-062-080 C-CAP,S 2.2-16 ZF C332 87-A11-062-080 C-CAP,S 2.2-16 ZF C333 87-A11-062-080 C-CAP,S 2.2-16 ZF C334 87-A11-062-080 C-CAP,S 2.2-16 ZF C335 87-010-491-040 CAP,E 0.22-50 GAS C336 87-010-491-040 CAP,E 0.22-50 GAS C339 87-010-805-

30、080 CAP,S 1-16 C340 87-010-805-080 CAP,S 1-16 C342 87-012-140-080 CAP,470P C344 87-012-140-080 CAP,470P C401 87-010-494-040 CAP,E 1-50 M 5L SRE C405 87-010-196-080 CHIP CAPACITOR,0.1-25 C406 87-010-196-080 CHIP CAPACITOR,0.1-25 C407 87-012-358-080 C-CAP,S 0.47-10 FZ C408 87-012-358-080 C-CAP,S 0.47-

31、10 FZ C409 87-010-805-080 C-CAP,S 1-16 ZF C410 87-010-805-080 C-CAP,S 1-16 ZF C451 87-012-358-080 C-CAP,S 0.47-10 FZ C452 87-012-358-080 C-CAP,S 0.47-10 FZ 6 DESCRIPTIONREF. NO.KANRI NO. PART NO.DESCRIPTIONREF. NO.KANRI NO. PART NO. C453 87-012-358-080 C-CAP,S 0.47-10 FZ C454 87-010-197-080 CAP,CHIP

32、 0.01 DM C501 87-012-358-080 C-CAP,S 0.47-10 FZ C502 87-012-358-080 C-CAP,S 0.47-10 FZ C503 87-012-358-080 C-CAP,S 0.47-10 FZ C504 87-012-358-080 C-CAP,S 0.47-10 FZ C505 87-010-178-080 CHIP CAP,1000P C506 87-010-178-080 CHIP CAP,1000P C507 87-010-178-080 CHIP CAP,1000P C508 87-010-178-080 CHIP CAP,1

33、000P C509 87-010-805-080 CAP,S 1-16 C510 87-010-498-040 CAP,E 10-16 GAS C511 87-012-368-080 C-CAP,S 0.1-50 ZF C512 87-012-368-080 C-CAP,S 0.1-50 ZF C513 87-012-368-080 C-CAP,S 0.1-50 ZF C514 87-012-368-080 C-CAP,S 0.1-50 ZF C519 87-010-805-080 C-CAP,S 1-16 ZF C801 8A-KC7-623-000 CAP,E 2200U-16 BT(12

34、5C) C901 87-016-039-090 CAP,DL 0.022F-5.5 Z 70 FM C902 87-012-358-080 C-CAP,S 0.47-10 FZ C903 87-010-196-080 CHIP CAPACITOR,0.1-25 C904 87-010-315-080 C-CAP,S 27P-50 CH C905 87-010-314-080 C-CAP,S 22P-50V C906 87-010-196-080 CHIP CAPACITOR,0.1-25 C907 87-010-178-080 CHIP CAP,1000P C908 87-010-178-08

35、0 CHIP CAP,1000P C909 87-010-198-080 CAP,CHIP 0.022 C910 87-010-322-080 C-CAP,S 100P-50 CH C911 87-010-322-080 C-CAP,S 100P-50 CH C912 87-010-198-080 CAP,CHIP 0.022 C914 87-010-198-080 CAP,CHIP 0.022 C916 87-010-198-080 CAP,CHIP 0.022 CON401 87-A61-219-010 CONN,20P H 52089-2020 CON402 88-KTA-603-010

36、 CONN,15P CAM-B68 CON851 8A-KT1-632-010 CONN,ASSY 8P ISO WHITE A CON852 8A-KT1-631-010 CONN,ASSY 8P ISO BLACK A D909 87-027-262-010 LED,TLR-124(RED) F251 8Z-KC1-621-010 FUSE,15A 32V FFC401 88-KC4-641-010 FF-CABLE,20P 1.0 90MM J401 87-A61-225-010 JACK,PIN 2P XR-401 L101 87-003-143-080 COIL,4.7UH L102

37、 8Z-KT1-619-010 COIL,68MH K7-D L201 87-003-149-080 COIL,47UH L202 87-003-102-080 COIL,10UH L301 87-003-102-080 COIL,10UH L401 87-003-102-080 COIL,10UH L402 87-003-102-080 COIL,10UH L851 8Z-KT1-615-010 FLTR,AMORPHOUS-CHOKE S901 87-A91-070-010 SW,TACT SKHHLV SFR101 87-024-437-080 SFR,100K H RH063MC TU

38、101 8A-KC8-620-010 TU UNIT,FAE347-A11 X501 87-A70-091-010 VIB,XTAL 4.332MHZ CSA-309 X901 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49 FRONT C.B C951 87-012-358-080 C-CAP,S 0.47-10 FZ C952 87-012-358-080 C-CAP,S 0.47-10 FZ C953 87-010-176-080 C-CAP,S 680P-50 SL C954 87-010-194-080 CAP,CHIP 0.047 C955 87-010-

39、194-080 CAP,CHIP 0.047 C956 87-010-194-080 CAP,CHIP 0.047 C957 87-012-358-080 C-CAP,S 0.47-10 FZ C958 87-010-197-080 CAP,CHIP 0.01 DM C959 87-010-197-080 CAP,CHIP 0.01 DM C960 87-010-194-080 CAP,CHIP 0.047 CON951 88-KTA-602-010 CONN,15P CAM-B67 L951 87-005-906-080 C-COIL,S 10.0UHK L952 87-005-906-08

40、0 C-COIL,S 10.0UHK L953 87-005-906-080 C-COIL,S 10.0UHK LCD951 8A-KC3-610-010 LCD,AKC-3/4(2 COLOR) LCD951 8A-KC3-611-010 LCD,AKC-3/4(NO COLOR) LED951 87-017-827-070 C-LED,SEC1201C RED LED952 87-017-827-070 C-LED,SEC1201C RED LED953 87-017-827-070 C-LED,SEC1201C RED LED954 87-A40-813-040 C-LED,SEC1E0

41、1C BLUE LED955 87-A40-813-040 C-LED,SEC1E01C BLUE LED956 87-A40-813-040 C-LED,SEC1E01C BLUE PL951 8Z-KT1-641-010 LAMP,T-3 PL952 8Z-KT1-641-010 LAMP,T-3 S951 87-036-251-080 SW,TACT SKQCAE S952 87-036-251-080 SW,TACT SKQCAE S953 87-036-251-080 SW,TACT SKQCAE S954 87-A90-001-080 C-SW,TACT SKQMAL S955 8

42、7-036-251-080 SW,TACT SKQCAE S956 87-036-251-080 SW,TACT SKQCAE S957 87-036-251-080 SW,TACT SKQCAE S958 87-A90-001-080 C-SW,TACT SKQMAL S959 87-A90-001-080 C-SW,TACT SKQMAL S960 87-A90-001-080 C-SW,TACT SKQMAL S961 87-036-251-080 SW,TACT SKQCAE S962 87-036-251-080 SW,TACT SKQCAE S963 87-036-251-080

43、SW,TACT SKQCAE S964 87-036-251-080 SW,TACT SKQCAE S965 87-036-251-080 SW,TACT SKQCAE S966 87-036-251-080 SW,TACT SKQCAE S967 87-A91-597-010 SW,RTRY SIM-026MT JACK AUX C.B FC951 8A-KC7-611-010 F-CABLE,3P(AUX) J951 85-HRL-623-010 JACK,3.5 ST BLK CD C.B C803 87-A10-711-080 C-CAP,E 100-6.3 M MF C804 87-

44、010-178-080 CHIP CAP,1000P C805 87-016-669-080 C-CAP,S 0.1-25 K B C806 87-010-184-080 CHIP CAPACITOR,3300P(K) C808 87-016-669-080 C-CAP,S 0.1-25 K B C809 87-010-880-080 C-CAP,E 47-6.3 MF C811 87-016-669-080 C-CAP,S 0.1-25 K B C813 87-016-669-080 C-CAP,S 0.1-25 K B C816 87-010-880-080 C-CAP,E 47-6.3

45、MF C831 87-012-156-080 C-CAP,S 220P-50 CH C832 87-010-194-080 CAP,CHIP 0.047 C833 87-012-156-080 C-CAP,S 220P-50 CH C834 87-012-156-080 C-CAP,S 220P-50 CH C835 87-016-669-080 C-CAP,S 0.1-25 K B C836 87-012-156-080 C-CAP,S 220P-50 CH C837 87-010-186-080 CHIP CAPACITOR,4700P(K) C838 87-010-194-080 CAP

46、,CHIP 0.047 C839 87-010-880-080 C-CAP,E 47-6.3 MF C840 87-016-669-080 C-CAP,S 0.1-25 K B C841 87-016-669-080 C-CAP,S 0.1-25 K B C842 87-016-526-080 C-CAP,S 0.47-16 BK C843 87-012-155-080 C-CAP,180P-50CH C844 87-012-155-080 C-CAP,180P-50CH C845 87-010-177-080 C-CAP,S 820P-50 SL C846 87-010-177-080 C-CAP,S 820P-50 SL C847 87-010-885-080 C-CAP,E 22-10 MF C848 87-010-885-080 C-CAP,E 22-10 MF C849 87-010-318-080 C-CAP,S 47P-50 CH C850 87-010-318-080 C-CAP,S 47P-50 CH C851 87-A12-034-080 C-CAP,E