ID-1_serv_2009.pdf

《ID-1_serv_2009.pdf》由会员分享，可在线阅读，更多相关《ID-1_serv_2009.pdf（72页珍藏版）》请在收音机爱好者资料库上搜索。

1、Jan. 2009 SERVICE MANUAL ADDENDUM CONTENTS REPLACEMENT PAGE . . . . . . . . . . . . . . . . . . . . . . . 5-5 PARTS LIST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 BOARD LAYOUTS. . . . . . . . . . . . . . . . . . . . . . . . . . . 11 VOLTAGE DIAGRAM . . . . . . . . . . . . . .

2、. . . . . . . . . . . 13 Jan. 2009 5 - 5 5-3 TRANSMITTER ADJUSTMENT ADJUSTMENTADJUSTMENT CONDITION MEASUREMENT VALUE ADJUSTMENT UNITLOCATIONUNITADJUST YGR CURRENT FPGA D.C. voltage ad- justment /DV I 1 Preset R1086 and R1087 maxi- mum counterclockwise. Preset IQ Direct-current output ON. Operating f

3、req. : 1300.00 MHz Mode : DV mode Connect an RF power meter or 50 dummy load to the antenna connector. Transmitting Rear panel Connect an ammeter between the DC power supply and ID-1. 100 mA higher from the pre- set position. MAIN unit R1087 2100 mA higher from step 1. MAIN unit R1086 REFERENCE FREQ

4、UENCY REF Crystal adjustment 1 Operating freq. : 1300.00 MHz Mode : FM mode Connect an RF power meter or 50 dummy load to the antenna connector. Transmitting Rear panel Loosely couple a fre- quency counter to the antenna connector. 1300.0000 MHzPC screen REF Crystal adjust- ment FM CARRIER FPGA D.C.

5、 voltage ad- justment /FM I 1 Operating freq. : 1300.00 MHz Mode : FM mode Connect an RF power meter or 50 dummy load to the antenna connector. Transmitting MAIN unit C o n n e c t a d i g i t a l multimeter or an oscillo- scope to the check point CP30. T h e s a m e voltage that during in DV m o d

6、e ( T X ) at the check point CP30. PC screen FPGA D.C. voltage adjust- ment /FM I FPGA D.C. voltage ad- justment /FM Q 2 TransmittingT h e s a m e adjustment as step 1, if need. PC screen FPGA D.C. voltage adjust- ment /FM Q OUTPUT POWER TX output adjustment 1 Operating freq. : 1300.00 MHz Mode : FM

7、 mode TX power : High Transmitting Rear panel Connect an RF power meter to the antenna connector. 11 WMAIN unit R1251 FM DEVIATION FM modulation adjustment 1 Operating freq. : 1270.00 MHz Mode : FM mode Connect an audio generator to the MIC connector and set as : 1.0 kHz/20 mVrms Set a Modulation an

8、alyzer as: HPF : OFF LPF : 20 kHz De-emphasis : OFF Detector : (PP)/2 Transmitting Rear panel Connect a modulation analyzer to the antenna connector through an attenuator. 4.35 kHz MAIN unit R1704 DSP INPUT LEVEL DSP input level adjust- ment 1 Operating freq. : 1270.00 MHz Connect an audio generator

9、 to the MIC connector and set as : 1.0 kHz/20 mVrms Connect an RF power meter or 50 dummy load to the antenna connector. Transmitting LOGIC-1 unit Connect an oscillo- scope to the check point CP207. IC1 (LOGIC-1) is; uPD9930 -750 mVp-p AD73311 -2.1 Vp-p MAIN unit R1707 (Replacement page) Jan. 2009 J

10、an. 2009 1 SECTION 6SECTION 6. PARTS LIST M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) LOGIC-1 UNIT REF PARTS DESCRIPTION M. H/V NO. NO. LOCATION IC1 1130011631 S.IC AD73311ARSZ T 9.6/31.9 IC2 1130010920 S.IC AMBE-2020 T 31.8/51 IC3 1130006891 S.IC TC7S04FU(TE85R,F) B

11、30.7/46.1 IC4 1180002371 S.REG R1111N321B-TR-F T 33.2/38.7 IC50 1140010091 S.IC UPD70F3102AGJ-33-8EU-A T 61.6/54 IC51 1130007281 S.IC TC7S32FU(TE85R,F) T 45.3/65.2 IC52 1110005731 S.IC S-80928CNMC-G8Y-G B 54.3/42.2 IC53 1130007111 S.IC TC7W04FU(TE12L,F) T 44.6/62.1 IC54 1140008650 S.IC HN58X2464TI T

12、 45.2/56.4 IC55 1130010630 S.IC SN74AHCT541PWR B 43/36.3 IC56 1190001340 S.IC M62334FP 600C T 59.8/37.1 IC57 1190001340 S.IC M62334FP 600C T 68.2/37 IC58 1110002861 S.IC TA75S393F(TE85R,F) B 4/48.1 IC100 1130010620 S.IC SN74AHC541PWR B 109.6/49.6 IC101 1130007111 S.IC TC7W04FU(TE12L,F) T 106.1/56.2

13、IC102 1130008711 S.IC TC7SET04FU(T5L,JF) T 110.9/55.3 IC103 1130010630 S.IC SN74AHCT541PWR T 108.9/49.3 IC104 1120002840 S.IC RTL8019AS-LF T 87.7/39.1 IC105 1130010581 S.IC UPD43256BGW-70LL-9JL-A T 108.7/37.2 IC150 1110005430 S.IC CMX589AD5 T 98.2/11.4 IC151 1130008711 S.IC TC7SET04FU(T5L,JF) T 89.1

14、/16.9 IC152 1130004201 S.IC TC4S66F(TE85R,F) B 103.9/7.5 IC153 1130004201 S.IC TC4S66F(TE85R,F) B 100.9/13 IC200 1120002871 S.IC XCS20XL-4TQG144I T 32.1/18.9 IC201 1130006891 S.IC TC7S04FU(TE85R,F) B 36.5/54.2 IC202 1130008361 S.IC TC7SHU04FU(TE85L,JF) T 25.6/32.9 IC203 1130006891 S.IC TC7S04FU(TE85

15、R,F) B 35.4/31.1 IC300 1110005290 S.IC NJM2115V-TE1-#ZZZB T 58.6/19.4 IC301 1110005290 S.IC NJM2115V-TE1-#ZZZB T 57.2/30.5 IC302 1110005290 S.IC NJM2115V-TE1-#ZZZB T 68.4/20.7 IC350 1130006221 S.IC TC4W53FU(TE12L,F) T 84.4/19.1 IC351 1110003780 S.IC NJM2902V-TE1-#ZZZB T 90.6/23.1 IC352 1130006221 S.

16、IC TC4W53FU(TE12L,F) T 81.2/23.6 IC353 1130008561 S.IC TC75S51F(TE85L,F) T 100.8/23.8 IC354 1130006221 S.IC TC4W53FU(TE12L,F) T 104.8/18.8 IC355 1110002751 S.IC TA75S01F(TE85R,F) B 87.5/17.5 IC500 1180001071 S.IC TA7805F(TE16L,Q) T 86.3/73.9 IC502 1180002391 S.REG S-812C33AMC-C2N-G T 92.8/66 IC503 1

17、110005440 S.IC NJM2374AM-TE1 T 110.5/70.6 IC504 1180002391 S.REG S-812C33AMC-C2N-G T 64.3/74.8 IC550 1130012051 S.IC FT232BL T 11.8/61.4 IC551 1130009570 S.IC BR93LC46F-WE2 T 12.8/52.2 IC553 1130007281 S.IC TC7S32FU(TE85R,F) B 10.4/49 Q50 1530002280 S.TRA 2SC4081 T106 S B 8.3/43.6 Q51 1510000771 S.T

18、RA 2SA1586-GR(TE85L,F) B 5.7/43.9 Q52 1590000430 S.TRA DTC144EUA T106 B 7.9/47.6 Q100 1590000430 S.TRA DTC144EUA T106 T 79/26.4 Q101 1590001980 S.TRA XP4315(TX) B 42/7.9 Q102 1590001980 S.TRA XP4315(TX) B 39.5/7.9 Q103 1590000430 S.TRA DTC144EUA T106 B 67.7/6.4 Q150 1590001400 S.TRA XP1214(TX) T 91.

19、3/12.8 Q151 1590001400 S.TRA XP1214(TX) B 97.2/6.4 Q153 1590000430 S.TRA DTC144EUA T106 B 76.3/24.3 Q154 1590000430 S.TRA DTC144EUA T106 B 106.3/12.5 Q155 1590000430 S.TRA DTC144EUA T106 B 74.5/20.6 Q156 1590000430 S.TRA DTC144EUA T106 B 72/22.4 Q400 1590000430 S.TRA DTC144EUA T106 B 73.3/14.4 Q500

20、1520000201 S.TRA 2SB798-T2-AZ DK T 80.3/63.6 Q501 1590000430 S.TRA DTC144EUA T106 T 76.6/66.1 Q502 1530002280 S.TRA 2SC4081 T106 S T 67.9/72.3 Q503 1520000201 S.TRA 2SB798-T2-AZ DK B 74.3/68.5 Q504 1530002280 S.TRA 2SC4081 T106 S B 70/74.5 Q550 1590000430 S.TRA DTC144EUA T106 B 15.5/49.9 D50 1790001

21、240 S.DIO MA2S728-(TX) T 59.3/66.6 D51 1750000550 S.DIO 1SS355 TE-17 B 1.4/48.1 D52 1750000550 S.DIO 1SS355 TE-17 B 50.1/60.5 D53 1750000550 S.DIO 1SS355 TE-17 T 46.6/59.5 D54 1750000550 S.DIO 1SS355 TE-17 B 48.1/66.7 D55 1730002280 S.ZEN MA8091-M(TX) T 12.7/43.9 D201 1790001240 S.DIO MA2S728-(TX) B

22、 39.6/51.1 D350 1720000361 S.DIO HSU88TRF-E T 85.3/24.3 D351 1720000361 S.DIO HSU88TRF-E T 87.7/19.4 D501 1790000671 S.DIO SB07-03C-TB-E T 72.2/69.6 D502 1750000550 S.DIO 1SS355 TE-17 T 71.2/72.3 D503 1790000671 S.DIO SB07-03C-TB-E T 99.4/65.9 D504 1790000671 S.DIO SB07-03C-TB-E B 110.2/74.1 X50 605

23、0011290 S.XTA CR-715 SX-1302 6 MHz T 44.4/47.2 X100 6050011300 S.XTA CR-716 SX-1302 20 MHz T 99.1/55.5 X200 6050011240 S.XTA CR-708 DSX631S 16.384 MHz T 19/34.3 X201 6050011700 S.XTA CR-760 DSX531S 9.8304 MHz T 37.2/33.3 X550 6050011290 S.XTA CR-715 SX-1302 6 MHz T 3.4/55.5 L50 6200005741 S.COI ELJR

24、E 47NGFA T 65.2/67.6 L51 6200005741 S.COI ELJRE 47NGFA T 48.4/46 L100 6200005741 S.COI ELJRE 47NGFA B 111.3/56 L101 6200005741 S.COI ELJRE 47NGFA B 111.3/57.3 L102 6200005741 S.COI ELJRE 47NGFA T 87/52.4 L103 6200005741 S.COI ELJRE 47NGFA B 108.5/27.6 L114 6200006991 S.COI ELJRE 56NGFA B 11.9/70.6 L

25、115 6200006991 S.COI ELJRE 56NGFA B 13.4/70.6 L116 6200006991 S.COI ELJRE 56NGFA B 14.9/70.6 S.=Surface mount LOGIC-1 UNIT REF PARTS DESCRIPTION M. H/V NO. NO. LOCATION L117 6200006991 S.COI ELJRE 56NGFA B 16.2/70.6 L119 6200006991 S.COI ELJRE 56NGFA B 19.5/70.6 L120 6200006991 S.COI ELJRE 56NGFA B

26、20.9/70.6 L121 6200006991 S.COI ELJRE 56NGFA B 22.7/70.6 L150 6200002041 S.COI NLV25T-101J T 99.7/17 L210 6200005741 S.COI ELJRE 47NGFA T 70.6/67.4 L211 6200005741 S.COI ELJRE 47NGFA B 47.7/53.7 L214 6200005741 S.COI ELJRE 47NGFA B 49/56.4 L420 6200003590 S.COI EXCCL3225U1 B 30.9/74 L421 6200003590

27、S.COI EXCCL3225U1 B 38.8/73.9 L500 6190001561 S.COI CDRH5D18NP-101NC T 104.3/74 L501 6190001561 S.COI CDRH5D18NP-101NC T 104.3/66.8 L510 6200003590 S.COI EXCCL3225U1 B 108.8/70.7 L550 6200005521 S.COI NLV25T-470J T 12.5/70.5 L551 6200005741 S.COI ELJRE 47NGFA T 15.6/71.3 L552 6200006991 S.COI ELJRE

28、56NGFA B 14.6/55.8 R1 7030003320 S.RES ERJ3GEYJ 101 V (100) T 2.2/21.5 R2 7030003560 S.RES ERJ3GEYJ 103 V (10K) T 2.9/23.5 R12 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 37.4/57.5 R13 7030003640 S.RES ERJ3GEYJ 473 V (47K) T 37.1/61.8 R14 7030003640 S.RES ERJ3GEYJ 473 V (47K) T 35.8/61.8 R15 7030003640

29、S.RES ERJ3GEYJ 473 V (47K) T 34.5/61.8 R17 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 35.3/57.5 R18 7030003640 S.RES ERJ3GEYJ 473 V (47K) T 35.5/40.5 R25 7030003450 S.RES ERJ3GEYJ 122 V (1.2K) T 14.3/19.4 R26 7030003420 S.RES ERJ3GEYJ 681 V (680) T 13.5/22.6 R27 7030003640 S.RES ERJ3GEYJ 473 V (47K) T

30、15.3/35.5 R50 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 44.4/69.8 R51 7030003620 S.RES ERJ3GEYJ 333 V (33K) T 47.2/65 R53 7030003640 S.RES ERJ3GEYJ 473 V (47K) T 48.5/62.4 R54 7030003560 S.RES ERJ3GEYJ 103 V (10K) T 15.5/44.4 R55 7030003640 S.RES ERJ3GEYJ 473 V (47K) T 15.5/43 R57 7030003520 S.RES ERJ

31、3GEYJ 472 V (4.7K) B 3.7/43.9 R58 7030003680 S.RES ERJ3GEYJ 104 V (100K) T 15.4/46.2 R59 7030003500 S.RES ERJ3GEYJ 332 V (3.3K) B 2.4/43.9 R60 7030003570 S.RES ERJ3GEYJ 123 V (12K) B 47.7/56.4 R61 7030003570 S.RES ERJ3GEYJ 123 V (12K) B 45.8/56.4 R62 7030003620 S.RES ERJ3GEYJ 333 V (33K) B 49.3/45.1

32、 R63 7030003520 S.RES ERJ3GEYJ 472 V (4.7K) B 53.9/44.5 R64 7030003320 S.RES ERJ3GEYJ 101 V (100) B 61.5/39.7 R65 7030003320 S.RES ERJ3GEYJ 101 V (100) B 62.8/39.7 R66 7030003320 S.RES ERJ3GEYJ 101 V (100) T 72.5/35.1 R67 7030003320 S.RES ERJ3GEYJ 101 V (100) T 72.5/37.7 R68 7030003600 S.RES ERJ3GEY

33、J 223 V (22K) B 9.1/45.6 R69 7030003490 S.RES ERJ3GEYJ 272 V (2.7K) T 8.2/46.7 R70 7030003620 S.RES ERJ3GEYJ 333 V (33K) B 4.4/45.8 R71 7030003620 S.RES ERJ3GEYJ 333 V (33K) B 4/50.5 R72 7030003620 S.RES ERJ3GEYJ 333 V (33K) B 6.3/51.4 R73 7030003530 S.RES ERJ3GEYJ 562 V (5.6K) B 7.1/49.6 R74 703000

34、3640 S.RES ERJ3GEYJ 473 V (47K) B 46.3/68.7 R75 7030003570 S.RES ERJ3GEYJ 123 V (12K) B 48.1/69 R76 7030003510 S.RES ERJ3GEYJ 392 V (3.9K) B 67.9/38.3 R78 7030003360 S.RES ERJ3GEYJ 221 V (220) T 50.9/43.3 R79 7030003340 S.RES ERJ3GEYJ 151 V (150) T 48.6/50.2 R100 7030003640 S.RES ERJ3GEYJ 473 V (47K

35、) T 76.5/26.2 R101 7030003560 S.RES ERJ3GEYJ 103 V (10K) T 88/27.8 R102 7030003560 S.RES ERJ3GEYJ 103 V (10K) T 88/26.5 R105 7030003380 S.RES ERJ3GEYJ 331 V (330) T 95.8/55.9 R106 7030003800 S.RES ERJ3GEYJ 105 V (1M) T 95.8/53.1 R107 7030003360 S.RES ERJ3GEYJ 221 V (220) T 81.7/53.1 R108 7030003560

36、S.RES ERJ3GEYJ 103 V (10K) T 87.5/50.6 R110 7030003370 S.RES ERJ3GEYJ 271 V (270) B 52.3/8 R111 7030003410 S.RES ERJ3GEYJ 561 V (560) B 90.3/44.5 R112 7030003410 S.RES ERJ3GEYJ 561 V (560) B 89/44.5 R113 7030003370 S.RES ERJ3GEYJ 271 V (270) B 42.1/5.9 R114 7030003420 S.RES ERJ3GEYJ 681 V (680) B 39

37、.5/5.9 R115 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 110.9/54.7 R116 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 106.3/57.8 R146 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 79.1/23.5 R148 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 105.5/9.9 R149 7030003320 S.RES ERJ3GEYJ 101 V (100) T 88.4/14.2 R150 7030003640

38、S.RES ERJ3GEYJ 473 V (47K) B 97.9/11 R151 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 97.9/9.7 R152 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 97.9/12.3 R153 7030003440 S.RES ERJ3GEYJ 102 V (1K) B 97.9/14.9 R154 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 97.9/13.6 R155 7030003800 S.RES ERJ3GEYJ 105 V (1M) T 9

39、2.4/15.3 R156 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 90.7/8.2 R157 7030003640 S.RES ERJ3GEYJ 473 V (47K) B 95.3/8.8 R158 7030003750 S.RES ERJ3GEYJ 394 V (390K) B 100.8/7.5 R159 7030009340 S.RES ERJ3GEYJ 275V (2.7M) B 99.7/10.1 R199 7030003320 S.RES ERJ3GEYJ 101 V (100) B 32.7/53.4 R200 7030003320 S

40、.RES ERJ3GEYJ 101 V (100) T 28.1/32 R201 7030003800 S.RES ERJ3GEYJ 105 V (1M) T 22.4/32.8 R202 7030003520 S.RES ERJ3GEYJ 472 V (4.7K) T 45.2/9.4 R203 7030003520 S.RES ERJ3GEYJ 472 V (4.7K) T 31.6/5.8 R204 7030003640 S.RES ERJ3GEYJ 473 V (47K) T 39/5.8 R205 7030003440 S.RES ERJ3GEYJ 102 V (1K) B 24.3

41、/23.2 R206 7030003440 S.RES ERJ3GEYJ 102 V (1K) T 18.9/24.7 R207 7030003440 S.RES ERJ3GEYJ 102 V (1K) T 18.9/26.1 R208 7030003320 S.RES ERJ3GEYJ 101 V (100) B 34.8/34.8 R209 7030003800 S.RES ERJ3GEYJ 105 V (1M) B 35.6/33 R210 7030003440 S.RES ERJ3GEYJ 102 V (1K) T 41.5/33.3 R211 7030003400 S.RES ERJ

42、3GEYJ 471 V (470) B 37.8/52 R212 7030003360 S.RES ERJ3GEYJ 221 V (220) T 15.5/28.1 R250 7030005661 S.RES ERA3YED 203V (20K) T 52.9/5.8 Jan. 2009 2 M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) LOGIC-1 UNIT REF PARTS DESCRIPTION M. H/V NO. NO. LOCATION R251 7030005661 S.

43、RES ERA3YED 203V (20K) T 48.9/5.8 R252 7030005321 S.RES ERA3YED 103V (10K) T 50.8/6.6 R253 7030005661 S.RES ERA3YED 203V (20K) T 48.9/7.1 R254 7030005321 S.RES ERA3YED 103V (10K) T 52.5/7.9 R255 7030005661 S.RES ERA3YED 203V (20K) T 48.9/8.4 R256 7030005321 S.RES ERA3YED 103V (10K) T 50.8/9.2 R257 7

44、030005661 S.RES ERA3YED 203V (20K) T 48.9/9.7 R258 7030005321 S.RES ERA3YED 103V (10K) T 52.5/10.5 R259 7030005661 S.RES ERA3YED 203V (20K) T 48.9/11 R260 7030005321 S.RES ERA3YED 103V (10K) T 50.8/11.8 R261 7030005661 S.RES ERA3YED 203V (20K) T 48.9/12.3 R262 7030005321 S.RES ERA3YED 103V (10K) T 5

45、2.5/13.1 R263 7030005661 S.RES ERA3YED 203V (20K) T 48.9/13.6 R264 7030005321 S.RES ERA3YED 103V (10K) T 50.8/14.4 R265 7030005661 S.RES ERA3YED 203V (20K) T 48.9/14.9 R266 7030005321 S.RES ERA3YED 103V (10K) T 52.5/15.7 R267 7030005661 S.RES ERA3YED 203V (20K) T 48.9/16.2 R268 7030005321 S.RES ERA3

46、YED 103V (10K) T 50.8/17 R269 7030005661 S.RES ERA3YED 203V (20K) T 48.9/17.5 R270 7030005321 S.RES ERA3YED 103V (10K) T 52.5/18.3 R271 7030005661 S.RES ERA3YED 203V (20K) T 48.9/18.8 R272 7030005661 S.RES ERA3YED 203V (20K) T 52.7/20.2 R273 7030005661 S.RES ERA3YED 203V (20K) T 48.9/20.2 R274 70300

47、05321 S.RES ERA3YED 103V (10K) T 50.8/20.7 R275 7030005661 S.RES ERA3YED 203V (20K) T 48.9/21.5 R276 7030005321 S.RES ERA3YED 103V (10K) T 52.1/22.1 R277 7030005661 S.RES ERA3YED 203V (20K) T 48.9/22.8 R278 7030005321 S.RES ERA3YED 103V (10K) T 50.8/23.3 R279 7030005661 S.RES ERA3YED 203V (20K) T 48

48、.9/24.1 R280 7030005321 S.RES ERA3YED 103V (10K) T 52.1/24.7 R281 7030005661 S.RES ERA3YED 203V (20K) T 48.9/25.4 R282 7030005321 S.RES ERA3YED 103V (10K) T 50.8/25.9 R283 7030005661 S.RES ERA3YED 203V (20K) T 48.9/26.7 R284 7030005321 S.RES ERA3YED 103V (10K) T 52.1/27.3 R285 7030005661 S.RES ERA3Y

49、ED 203V (20K) T 48.9/28 R286 7030005321 S.RES ERA3YED 103V (10K) T 50.8/28.5 R287 7030005661 S.RES ERA3YED 203V (20K) T 48.9/29.3 R288 7030005321 S.RES ERA3YED 103V (10K) T 52.1/29.9 R289 7030005661 S.RES ERA3YED 203V (20K) T 48.9/30.6 R290 7030005321 S.RES ERA3YED 103V (10K) T 50.8/31.1 R291 7030005661 S.RES ERA3YED 203V (20K) T 48.9/31.9 R292 7030005321 S.RES ERA3YED 103V (10K) T 52.1/32.7 R293 7030005661 S.RES ERA3YED 203V (20K) T 48.9/33.2 R300 7030003320 S.RES ERJ3GEYJ 101 V (100) T 60.7/14.9 R301 7030003520 S.RES ER