AN-GRC-106A_user_TM11-5820-520-10_1984.pdf

《AN-GRC-106A_user_TM11-5820-520-10_1984.pdf》由会员分享，可在线阅读，更多相关《AN-GRC-106A_user_TM11-5820-520-10_1984.pdf（104页珍藏版）》请在收音机爱好者资料库上搜索。

1、PAGE 1-3 PAGE 2-1 PAGE 2-16 PAGE 2-21 PAGE 3-2 TM 11-5820-520-10 O P E R A T O R S M A N U A L This copy is a reprint which includes current pages from Change 1. R A D I O S E T SA N / G R C - 1 0 6 ( N S N 5 8 2 0 - 0 0 - 4 0 2 - 2 2 6 3 ) A N / G R C - 1 0 6 A ( N S N 5 8 2 0 - 0 0 2 2 3 - 7 5 4 8

2、 ) H E A D Q U A R T E R S , D E P A R T M E N T O F T H E A R M Y 2 8 M A Y 1 9 8 4 T M 1 1 - 5 8 2 0 - 5 2 0 - 1 0 DANGEROUS VOLTAGES EXIST IN THIS EQUIPMENT Voltages as high as 128 volts ac, 3,000 volts dc, and 10,000 volts RF are used in the operation of Amplifier, Radio Frequency AM-3349/GRC-10

3、6. DANGEROUS VOLTAGES EXIST AT THE AM-3349/GRC-106 50-OHM LINE AND WHIP ANTENNA CONNECTORS Be careful when working around the antenna or antenna connectors. Radio- frequency voltages as high as 10,000 volts exist at these points. Operator and maintenance personnel should be familiar with the require

4、ments of TB SIG 291 before attempting installation or operation of Radio Set AN/GRC-106(*). DEATH ON CONTACT May result if operating personnel fail to observe safety precautions and fail to follow requirements of TB SIG 291. DONT TAKE CHANCES WARNING Adequate ventilation should be provided while usi

5、ng TRICHLOROTRIFLUORO- ETHANE. Prolonged breathing of vapor should be avoided. The solvent should not be used near heat or open flame; the products of decomposition are toxic and irritating. Since TRICHLOROTRIFLUOROETHANE dissolves natural oils, pro- longed contact with skin should be avoided. When

6、necessary, use gloves which the solvent cannot penetrate. If the solvent is taken internally, consult a physician immediately. TM 11-5820-529-10 C 1 Change No. 1 HEADQUARTERS DEPARTMENT OF THE ARMY Washington, DC, 15 May 1989 OPERATORS MANUAL RADIO SETS AN/GRC-106 (NSN 5820-00-402-2263) AN/GRC-106A

7、(NSN 5820-00-223-7548) TM 11-5820-520-10, 28 May 1984 is changed as follows: 1. Remove old pages and insert new pages as indicated below. New or changed material is indicated by a vertical bar in the margin of the page. Revised illustrations are indicated by a miniature pointing hand adjacent to the

8、 changed area. Remove pagesInsert pages a and c . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . a through d band d . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .None i and ii . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i and ii 1-1 through 1-4 . . .

9、 . . . . . . . . . . . . . . . . . . . . . .1-1 through 1-4 1-7 and 1-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7 and 1-8 2-9 and 2-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-9 and 2-10 2-15 through 2-20 . . . . . . . . . . . . . . . . . . . . . . . 2-15 through 2-2

10、0 2-23 through 2-26 . . . . . . . . . . . . . . . . . . . . . . . 2-23 through 2-26 2-29 and 2-30 . . . . . . . . . . . . . . . . . . . . . . . . . . 2-29 and 2-30 2-33 through 2-40 . . . . . . . . . . . . . . . . . . . . . . . 2-33 through 2-40 2-45 and 2-46 . . . . . . . . . . . . . . . . . . . .

11、. . . . . . 2-45 and 2-46 3-3 and 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3 and 3-4 A-1 and A-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . A-1 and A-2 B-5 through B-7/(B-8 blank) . . . . . . . . . . . . . B-5 through B-7/(B-8 blank) 2. File this change sheet in front

12、 of the publication for reference purposes. Distribution authorized to the Department of Defense and DOD contractors only for official use or for administration or operational purposes. This determination was made on 9 February 1989. Other requests for this document will be referred to Commander, US

13、 Army Communications-Electronics Command and Fort Monmouth, ATTN: AMSEL-LC-ME-P, Fort Monmouth, NJ 07703-5000. DESTRUCTION NOTICE Destroy by any method that will prevent disclosure of contents or reconstruction of the document. TM11-5820-520-10 WARNING RADIOACTIVE MATERIAL CONTROLLED DISPOSAL REQUIR

14、ED ACCOUNTABILITY NOT REQUIRED STD RW-2 Meter, electrical indicating . . . . Ra226 . . . . . . 1.0uCi . . . . 6625-01-226-5681 Meter, electrical indicating . . . . Ra226 . . . . . . 1.0uCi . . . . 6625-00-226-5679 Meter, signal level . . . . . . . . . .Ra226 . . . . . . 0.6uCi . . . . 6625-00-226-56

15、80 Radiation Information:The following radiation information must be read and understood by all personnel before operating or repairing Radio Sets AN/GRC-106 and AN/GRC-106A. Radioactive materials are present in the above listed components of the AM-3349/GRC-106 and the RT-662/GRC. The components ar

16、e potentially hazardous when broken. See qualified medical personnel and the local Radiological Protection Officer (RPO) immediately, if you are exposed to or cut by broken components. First aid instructions are contained in TB 43-0116 and TB 43-0122. NEVER place radioactive components in your pocke

17、t. Use extreme care NOT to break radioactive components while handling them. NEVER remove radioactive components from cartons until you are ready to use them. If any of these components are broken, notify the local RPO immediately. The RPO will survey the immediate area for radiological contaminatio

18、n and will supervise the removal of broken components. The above listed radioactive components will NOT be repaired or disassembled. a TM11-5820-520-10 FIXED OPERATION WITH LONG RANGE ANTENNAS WARNING NEVER ERECT THESE LONG RANGE ANTENNAS DIRECTLY UNDER POWER LINES. IF YOU MUST ERECT THESE LONG RANG

19、E ANTENNAS NEAR POWER LINES, POWERLINE POLES OR TOWERS, OR BUILDINGS WITH OVERHEAD POWERLINE CONNECTIONS, NEVER PUT THE ANTENNA CLOSER THAN TWO TIMES THE ANTENNA HEIGHT FROM THE BASE OF THE POWER LINE, POLE, TOWER OR BUILDINGS, 100 FEET AWAY IS A GOOD SAFE ROUND NUMBER TO REMEMBER. NEVER ATTEMPT TO

20、ERECT ANY LONG RANGE ANTENNA WITHOUT A FULL TEAM. BEFORE ERECTING ANY LONG RANGE ANTENNA, INSPECT ALL THE PARTS MAKING UP THE ANTENNA KIT. DO NOT ERECT THE ANTENNA IF ANY PARTS ARE MISSING OR DAMAGED. DO AS MUCH OF THE ASSEMBLY WORK AS POSSIBLE ON THE GROUND. WHEN ERECTING THE ANTENNA, ALLOW ONLY TE

21、AM PERSONNEL IN THE ERECTION AREA. MAKE SURE THAT THE AREA FOR THE ANCHORS IS FIRM. IF THE GROUND IS MARSHY OR SANDY, GET SPECIFIC INSTRUCTIONS FROM YOUR CREW CHIEF OR SUPERVISOR ON HOW TO REINFORCE THE ANCHORS. WHEN SELECTING LOCATIONS FOR ANCHORS, AVOID TRAVELED AREAS AND ROADS. IF YOU CANNOT AVOI

22、D THESE AREAS, GET SPECIFIC INSTRUCTIONS FROM YOUR SUPERVISOR AS TO WHAT CLEAR- ANCE YOUR GUY WlRES AND ROPES MUST HAVE OVER THE TRAVELED AREAS AND ROAD. CLEARLY MARK ALL GUY WIRES AND ROPES WITH THE WARNING FLAGS OR SIGNS SUPPLIED BY YOUR UNIT. IN AN EMERGENCY, USE STRIPS OF WHITE CLOTH AS WARNING

23、STREAMERS. IF YOU SUSPECT THAT POWERLINES HAVE MADE ACCIDENTAL CONTACT WITH YOUR ANTENNA, STOP OPERATING, ROPE OFF THE ANTENNA AREA, AND NOTIFY YOUR SUPERIORS. IF THE WEATHER IN YOUR AREA CAN CAUSE ICE TO FORM ON YOUR LONG RANGE ANTENNA AND ITS GUY WIRES AND ROPES, ADD EXTRA GUYS TO SUPPORT THE SYST

24、EM. ROPE OFF THE AREA AND POST IT WITH WARNING SIGNS LIKE BEWARE OF FALLING ICE. DO NOT TRY TO ERECT ANY ANTENNA DURING AN ELECTRICAL STORM. KEEP A SHARP EYE ON YOUR ANCHORS AND GUYS. CHECK THEM DAILY AND lMMEDIATELY BEFORE AND AFTER BAD WEATHER. bChange 1 TM 11-5820-520-10 WARNING SERIOUS INJURY OR

25、 EVEN DEATH CAN HAPPEN IF THE FOLLOWING ARE NOT CAREFULLY OBSERVED WHEN INSTALLING AND USING THE ANTENNAS USED WITH YOUR RADIO SETS. 1. ARE THERE ANY 2. HOW HIGH ARE 3. HOW TALL ARE POWERLINES IN YOUR AREA OF OPERATION ? THESE POWERLINES ? THE POLES OR TOWERS CARRYING POWERLINES ? MOBILE OPERATION W

26、ITH WHIP ANTENNAS DO NOT STOP YOUR VEHICLE UNDER POWER LINES. G G G G IF POSSIBLE, TRY TO MAINTAIN MOBILE COMMUNICATIONS WITH YOUR ANTENNA(S) TIED DOWN. MAKE SURE AN ANTENNA TIP CAP IS SECURELY TAPED ON THE END OF EACH WHIP ANTENNA. DO NOT LEAN AGAINST OR TOUCH A WHIP ANTENNA WHILE THE TRANSMITTER I

27、S ON. DURING CROSS-COUNTRY OPERATION, DO NOT ALLOW ANYONE TO STICK AN ARM, LEG OR WEAPON OVER THE SIDES OF THE VEHICLE.IF YOUR ANTENNA ACCIDENTALLY TOUCHES A POWERLINE AND A LEG, ARM OR WEAPON CONTACTS A DAMP BUSH OR THE GROUND, A SERIOUS OR FATAL ACCIDENT CAN HAPPEN. G IF YOU ARE NOT SURE THAT AN A

28、NTENNA ON YOUR VEHICLE WILL CLEAR A POWERLINE, STOP BEFORE YOU GET CLOSE TO THE POWERLINE AND EITHER CAREFULLY TIE DOWN THE ANTENNA OR REMOVE ANTENNA SECTIONS TO MAKE SURE THAT YOU CAN SAFELY DRIVE UNDER THE POWERLINE. Change 1c TM11-5820-520-10 SAFETY STEPS TO FOLLOW IF SOMEONE IS THE VICTIM OF ELE

29、CTRICAL SHOCK DO NOT TRY TO PULL OR GRAB THE INDIVIDUAL IF POSSIBLE, TURN OFF THE ELECTRICAL POWER IF YOU CANNOT TURN OFF THE ELECTRICAL POWER, PULL, PUSH, OR LIFT THE PERSON TO SAFETY USING A DRY WOODEN POLE OR A DRY ROPE OR SOME OTHER INSULATING MATERIAL SEND FOR HELP AS SOON AS POSSIBLE AFTER THE

30、 INJURED PERSON IS FREE OF CONTACT WITH THE SOURCE OF ELECTRICAL SHOCK, MOVE THE PERSON A SHORT DISTANCE AWAY AND IMMEDIATELY START ARTIFICIAL RESUSCITATION dChange 1 Technical Manual *TM11-5820-520-10 No. 11-5820-520-10 HEADQUARTERS DEPARTMENT OF THE ARMY Washington, DC, 28 May 1984 OPERATORS MANUA

31、L RADIO SETS AN/GRC-106 (NSN 5820-00-402-2263) AND AN/GRC-106A (NSN 5820-00-223-7548) REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter or DA Form 2028 (Rec

32、ommended Changes to Publications and Blank Forms) direct to: Commander,US Army Communications-Electronics Command and Fort Monmouth, ATTN: AMSEL-LC-ME-PS, Fort Monmouth, New Jersey 07703-5000. In either case, a reply will be furnished direct to you. SUBJECTPAGE CHAPTER 1INTRODUCTION . . . . . . . .

33、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Section IGeneral Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Scope . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1

34、Consolidated Index of Army Publications and Blank Forms . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Maintenance Forms, Records and Reports . . . . . . . . . . . . . . . . . . 1-1 Administrative Storage . . . . . . . . . . . . . . . . . . . . . . . .

35、. . . . . . . . .1-1 Destruction of Army Electronics Materiel . . . . . . . . . . . . . . . . . 1-1 Reporting Equipment Improvement Recommendations (EIR) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Nomenclature Cross Reference List . . . . . . . . . . . . . . . . . . . . .

36、1-2 List of Abbreviations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2 Hand Receipt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2 Section IIEquipment Description . . . . . . . . . . . . . . . . . . . .

37、 . . . . . . 1-3 Section Ill Equipment Purpose, Capabilities and Features . . . . . . . . . . . . 1-3 Description of Major Components . . . . . . . . . . . . . . . . . . . . . . . 1-3 Antenna Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-4 Differences Bet

38、ween Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-5 Performance Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 -7 Technical Principles of Operation . . . . . . . . . . . . . . . . . . . . 1-9 *This manual supersedes TM 11-5

39、820-520-10, 23 November 1982. i TM11-5820-520-10 SUBJECT CHAPTER 2 Section I PAGE 2-0OPERATING INSTRUCTIONS . . . . . . . . . . Description and Use of Operators Control and Indicators . . . . . . . . . . . . . Preventive Maintenance Checks and 2-1 Section II Services (PMCS) . . . . . . . . . . . . .

40、 . . . .2-16 2-20 2-20 2-21 2-21 2-40 2-45 PMCS Procedures . . . . . . . . . . . . . . . . . . . . PMCS Chart . . . . . . . . . . . . . . . . . . . . . . . . . Section IllOperation Under Usual Conditions . . . . . Assembly and Preparation for Use . . . . . . Operating Procedures . . . . . . . . . .

41、. . . . . . . Preparation for Movement . . . . . . . . . . . . . Operation Under Unusual Conditions . . . .Section IV 2-46 2-46 2-46 2-47 Operation in Unusual Weather . . . . . . . . . . Jamming and ECM Procedures . . . . . . . . . Anti-Jamming Procedures . . . . . . . . . . . . . Destruction to Pre

42、vent Enemy Use . . . . . . 2-48 3-0 CHAPTER 3MAINTENANCE INSTRUCTIONS . . . . . . . 3-2 Troubleshooting Procedures . . . . . . . . . . REFERENCES . . . . . . . . . . . . . . . . . . . .APPENDIX A APPENDIX B APPENDIX C APPENDIX D A-1 COMPONENTS OF END ITEM LIST . . . . .B-1 ADDITIONAL AUTHORIZATION L

43、IST (NOT APPLICABLE) EXPENDABLE SUPPLIES AND MATERIALS LIST (NOT APPLICABLE) Glossary Index-1 GLOSSARY INDEX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ii TM 11-5820-520-10 RADIO SET AN/GRC-106 iii b

44、lank/1-0 TM 11-5820-520-10 CHAPTER 1 INTRODUCTION Section 1. GENERAL 1-1.SCOPE This manual is for your use in operating Radio Sets AN/GRC-106 and AN/GRC-106A. It gives detailed operating instructions, and will tell you how to set up and maintain the equipment. AN GRC-106(*) will designate both the A

45、N/GRC-106 and AN-GRC-106A. 1-2. CONSOLIDATED INDEX OF ARMY PUBLICATIONS AND BLANK FORMS Refer to the latest issue of DA Pam 25-30 to determine whether there are new editions, changes or additional publications pertaining to the equipment. 1-3.MAINTENANCE FORMS, RECORDS, AND REPORTS a . R e p o r t s

46、 o f M u i n t e n a n c e a n d U n s a t i s f a c t o r y E q u i p m e n t . D e p a r t m e n t o f t h e Army forms and procedures used for equipment maintenance will be those prescribed by DA Pam 738-750 as contained in Maintenance Management Update. h. Reporting of Item and Packaging Discrep

47、ancies. Fill out and forward SF 364 (Report of Discrepancy (ROD) as prescribed in AR 735-11-2/DLAR 4140.55/SECNAVINST 4355.18 AFR 400-54/MCO 4430.3J. c . T r a n s p o r t a t i o n D i s c r e p a n c y R e p o r t ( T D R ) ( S F 3 6 1 ) . F i l l o u t a n d f o r w a r d Transportation Discrepan

48、cy Report (TDR) (SF 361) as prescribed in AR 55-38/ NAVSUPINST 4610.33C/AFR 75-18/MCO P4610.19D/DLAR 4500.15. 1-4.A D M I N I S T R A T I V E S T O R A G E Administrative storage of equipment issued to and used by Army activities will have preventive maintenance performed in accordance with the PMCS

49、 charts before storing. When removing the equipment from administrative storage the PMCS should be performed to assure operational readiness. 1-5.DESTRUCTION OF ARMY ELECTRONICS MATERIEL Destruction of Army electronics materiel to prevent enemy use shall be in accordance with TM 750-244-2. 1-6. REPORTING EQUIPMENT IMPROVEMENT RECOMMENDATIONS (EIR) If your AN/GRC-106 needs improvement, let US know. Send us an EIR. You, the user, are the only one who can tell us what you dont like about your equipment. Let US k n o w why you dont like the design or performance. Put it on an S