AN-PRC-77_RT-841_serv_user_TM11-5820-667-12_1987.pdf

《AN-PRC-77_RT-841_serv_user_TM11-5820-667-12_1987.pdf》由会员分享，可在线阅读，更多相关《AN-PRC-77_RT-841_serv_user_TM11-5820-667-12_1987.pdf（111页珍藏版）》请在收音机爱好者资料库上搜索。

1、TM 11-5820-667-12 TECHNICAL MANUAL OPERATORS AND ORGANIZATIONAL MAINTENANCE MANUAL RADIO SET AN/PRC-77 (NSN 5820-00-930-3724) (Including Receiver-Transmitter, Radio RT-841 /PRC-77) (NSN 5820-00-930-3725) This copy is a reprint which includes current pages from Changes 1 and 2. This publication is re

2、quired for official use or for administrative or operational purposes only. Dlstribution is Iimited to US Government Agencies. Other requests for this document must be referred to Commander, US Army Communications-Electronics Command and Fort Monmouth, ATTN: AMSEL-ME-P, Fort Monmouth, NJ 07703-5000.

3、 HEADQUARTERS, DEPARTMENT OF THE ARMY 1 JANUARY 1987 Change No. 2 ARMY TM 11-5820-667-12 NAVY EE150-JN-MMO-01B/E154-PRC-77 AIR FORCE TO 31R2-2PRC77-1 HEADQUARTERS DEPARTMENTS OF THE ARMY Washington, DC, 1 February 1991 OPERATORS AND ORGANIZATIONAL MAINTENANCE MANUAL RADIO SET AN/PRC-77 (NSN 5820-00-

4、930-3724) (INCLUDING RECEIVER-TRANSMITTER, RADIO RT-841/PRC-77) (NSN 5820-00-930-3725) TM 11-5820-667-12, 1 January 1989, is changed as follows: 1. The Navy and Air Force publication numbers, shown above, are added to the cover (not supplied). 2. Remove old pages and insert new pages as indicated be

5、low. New or changed material is indicated by a vertical bar in the margin of the page. Added or revised illustrations are indicated by a vertical bar adjacent to the identification number and by pointing hands on the illustration page. Remove pageInsert pages A and B . . . . . . . . . . . . . . . .

6、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A and B i and 1-0. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i and 1-0 1-1 through 14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 through 1-6 2-1

7、through 2-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1 through 2-6 3-1 and 3-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1 and 3-2 3-5 through 3-8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

8、 . . . . . . . . . .3-5 through 3-8 4-1 through 4-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1 through 4-6 5-1 and 5-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1 and 5-2 5-3 and 5-4 . . . . . . . . . . . . . . .

9、. . . . . . . . . . . . . . . . . . . . . . . . . . . .5-3, 5-3.1 /(5-3.2 blank) 5-4, 5-4.1 /(5-4.2 blank) 5-5/(5-6 blank). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-5/(5-6 blank) 6-5 and 6-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

10、 . . . . . . .6-5 and 6-6 6-11 and 6-12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-11 and 6-12 6-23 and 6-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-23 and 6-24 A-1 through A-3/(A-4 blank). . . . . . . . . . . . . . .

11、. . . . . . . . . . . . . .A-1 and A-2 B-7/(B-8 blank) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . B-7/(B-8 blank) C-1 and C-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-1 and C-2 D-1 and D-2 . . . . . . . . . . . . . .

12、. . . . . . . . . . . . . . . . . . . . . . . . . . . . D-1 and D-2 E-1 and E-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . E-1 and E-2 I-1 and I-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . I-1 and I-2 3. File th

13、is change sheet in front of the publication for reference purposes. Distribution authorized to the Department of Defense and DOD contractors only for official use or for administrative or operational purposes.This determination was made on 24 January 1991. Other requests for this document will be re

14、ferred to Commander, US Army Communications-Electronics Command and Fort Monmouth, ATTN: AMSEL-LC-LM-LT, Fort Monmouth, NJ 07703-6000. DESTRUCTION NOTICE - Destroy by any method that will prevent disclosure of contents or reconstruction of the document. C2 By Order of the Secretary of the Army CARL

15、E. VUONO General, United States Army Chief of Staff Official: PATRICIA P. HICKERSON Colonel, United States Army The Adjutant General By Order of the Secretary of the Navy: JOHN C. WEAVER Rear Admiral, United States Navy Commander, Space and Naval Warfare Systems Command By Order of the Secretary of

16、the Air Force: LARRY D. WELSH General, United States Air Force Chief of Staff Official: CHARLES C. McDONALD General, United States Air Force Commander, Air Force Logistics Command DISTRIBUTION: To be distributed in accordance with DA Form 12-51-E, block 0898, Operator and Unit Maintenance requiremen

17、ts for TM 11-5820667-12. CHANGE No.1 TM 11-5820-667-12 C1 HEADQUARTERS DEPARTMENT OF THE ARMY Washington, DC, 01 DECEMBER 1988 OPERATORS AND ORGANIZATIONAL MAINTENANCE MANUAL RADIO SET AN/PRC-77 (NSN 5820-00-930-3724) INCLUDING RECEIVER-TRANSMITTER RT-841/PRC-77 (NSN 5820-00-930-3275) TM 11-5820-667

18、-12, 1 January 1987, is changed as follows: 1. Remove old pages and insert new pages as indicated below. New or changed material is indicated by a vertical bar in the margin of the page. Added or revised illustrations are indicated by a vertical bar adjacent to the identification number. Remove page

19、sInsert pages I-3 through 1-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-3 through 1-6 2-3 and 2-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-3 through 2-4.1/(2-4.2 blank) 3-5 and 3-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5 an

20、d 3-6 5-5/(5-6 blank) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-5/(5-6 blank) 6-5 and 6-6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-5 and 6-6 D-1 and D-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . D-1 and D-2 2. File this

21、 change sheet in the front of the publication for reference purposes, DESTRUCTION NOTICDestroy by any method that will prevent disclosure of contents or reconstruction of the document. By Order of the Secretary of the Army: Official: CARL E. VUONO General, United States Army Chief of Staff R.L. DILW

22、ORTH Brigadier General, United States Army The Adjutant General DISTRIBUTION: To be distributed in accordance with DA Form 12-51 Operator and Unit requirements for AN/PRC-77. TM 11-5620-667-12 WARNING Adequate ventilation should be provided while using TRICHLOROTRIFLUOROETHANE. Avoid prolonged breat

23、hing of vapor. The solvent should not be used near heat or flame; the products of de- composition arc toxic and irritating. Since TRICHLOROTRIFLUOROETHANE diSSOlVeS natural oils, avoid prolonged contact with skin. The usc of chemical gloves (solvent resistant), chemical splash goggles and full faces

24、hield are required when using TRICHLOROTRIFLUOROETHANE. DO NOT use compressed air to dry parts when TRICHLOROTRIFLUOROETHANE has been used. TRICHLOROTRIFLUOROETHANE is an ozone-depleting substance. Lithium sulfur dioxide (Li-SO2) batteries used with this equipment contain pressurized sulfur dioxide

25、SO2 gas. Sulfur dioxide gas is toxic; do not abuse the battery in any way which might cause it to rupture. DO NOT heat, incinerate, short circuit, crush, puncture, mutilate or disassemble any battery. DO NOT use any battery which shows signs of damage, such as bulging, swelling, disfigure- ment, swo

26、llen plastic wrap, liquid in the plastic wrap, etc. IMMEDIATELY turn off the equipment if the battery compartment becomes hot to the touch. Let the battery cool at least 60 minutes before removing it. If you hear a hissing sound (battery venting) or smell irritating sulfur dioxide gas, remove the eq

27、uipment to a well- ventilated area or leave the area. DO NOT use equipment if the battery compartment shows signs of water leakage. DO NOT use water to put out a fire if a shock hazard exists (i.e., 30 or more volts). DO NOT use a HALON fire extinguisher on a lithium battery fire. Use an approved Cl

28、ass-D fire extinguisher such as Lith-X. DO NOT test lithium batteries for capacity with Test Set, AN/PSM-13 and Connector, Adapter, U-410; this equipment is inaccurate for lithium batteries and may cause the battery to vent. DO NOT recharge any primary lithium or magnesium battery. DO NOT smoke or u

29、se an open flame in battery storage areas. DO NOT dispose of lithium batteries in streams, rivers, oceans, with general refuse or trash, etc. Lithium batteries without a discharge switch shall be turned into the Defense Reutiliza- tion and Marketing Office (DRMO) for disposal. Dispose of magnesium b

30、atteries as generated; turn into DRMO only if damaged or quantity to be disposed of exceeds 500 pounds at one time. For additional information on battery disposal contact your local CECOM LAO/LAR for CECOM Safety Office Battery Disposition/Disposal Handbook dated November 1986. DO NOT seal magnesium

31、 batteries in gas-tight plastic bags, drums or any other non-vented container. Depleted magnesium batteries continue to generate hydrogen gas after use, which can cause an explosion if it accumulates in a confined area. DO NOT leave batteries in unused equipment more than 30 days. This helps insure

32、that dangerous gases do not accumulate. Accumulated gases can cause explosions which can injure personnel and damage the equipment. PREVENT personal injury when applying or removing steel strapping by wearing heavy gloves and a face shelf. DO NOT handle packing cartons by steel strapping. Change 2A

33、TM 11-5820-667-12 FIXED OPERATION WITH LONG RANGE ANTENNAS WARNING TELESCOPING ANTENNA MAST TYPICAL TOWEREXTENDED RANGE ANTENNA DOUBLET ANTENNA NEVER ERECT THESE LONG RANGE ANTENNAS DIRECTLY UNDER POWER LINES. IF YOU MUST ERECT THESE LONG RANGE ANTENNAS NEAR POWERLINES, POWERLINE POLES OR TOWERS, OR

34、 BUILDINGS WITH OVERHEAD POWERLINE CONNECTIONS, NEVER PUT THE ANTENNA CLOSER THAN TWO TIMES THE ANTENNA HEIGHT FROM THE BASE OF THE POWERLINE, POLE, TOWER OR BUILDINGS. NEVER ATTEMPT TO ERECT ANY LONG RANGE ANTENNA WITHOUT A FULL TEAM. BEFORE ERECTING ANY LONG RANGE ANTENNA, INSPECT ALL THE PARTS MA

35、KING UP THE ANTENNA KIT. DO NOT ERECT THE ANTENNA IF ANY PARTS ARE MISSING OR DAMAGED. DO AS MUCH OF THE ASSEMBLY WORK AS POSSIBLE ON THE GROUND. WHEN ERECTING THE ANTENNA, ALLOW ONLY TEAM PERSONNEL IN THE ERECTION AREA. MAKE SURE THAT THE AREA FOR THE ANCHORS IS FIRM. IF THE GROUND IS MARSHY OR SAN

36、DY, GET SPECIFIC INSTRUCTIONS FROM YOUR CREW CHIEF OR SUPERVISOR ON HOW TO REINFORCE THE ANCHORS. WHEN SELECTING LOCATIONS FOR ANCHORS, AVOID TRAVELED AREAS AND ROADS. IF YOU CANNOT AVOID THESE AREAS, GET SPECIFIC INSTRUCTIONS FROM YOUR SUPERVISOR AS TO WHAT CLEAR- ANCE YOUR GUY WIRES AND ROPES MUST

37、 HAVE OVER THE TRAVELED AREAS AND ROAD. CLEARLY MARK ALL GUY WIRES AND ROPES WITH THE WARNING FLAGS OR SIGNS SUPPLIED BY YOUR UNIT. IN AN EMERGENCY, USE STRIPS OF WHITE CLOTH AS WARNING STREAMERS. IF YOU SUSPECT THAT POWERLINES HAVE MADE ACCIDENTAL CONTACT WITH YOUR ANTENNA, STOP OPERATING, ROPE OFF

38、 THE ANTENNA AREA, AND NOTIFY YOUR SUPERIORS. IF THE WEATHER IN YOUR AREA CAN CAUSE ICE TO FORM ON YOUR LONG RANGE ANTENNA AND ITS GUY WIRES AND ROPES, ADD EXTRA GUYS TO SUPPORT THE SYSTEM. ROPE OFF THE AREA AND POST IT WITH WARNING SIGNS LIKE BEWARE OF FALLING ICE: DO NOT TRY TO ERECT ANY ANTENNA D

39、URING AN ELECTRlCAL STORM. KEEP A SHARP EYE ON YOUR ANCHORS AND GUYS. CHECK THEM DAILY AND IMMEDIATELY BEFORE AND AFTER BAD WEATHER. B TM 11-5820-667-12 SAFETY STEPS TO FOLLOW IF SOMEONE IS THE VICTIM OF ELECTRICAL SHOCK DO NOT TRY TO PULL OR GRAB THE INDIVIDUAL IF POSSIBLE, TURN OFF THE ELECTRICAL

40、POWER IF YOU CANNOT TURN OFF THE ELECTRICAL POWER, PULL, PUSH, OR LIFT THE PERSON TO SAFETY USING A WOODEN POLE OR A ROPE OR SOME OTHER INSULATING MATERIAL SEND FOR HELP AS SOON AS POSSIBLE AFTER THE INJURED PERSON IS FREE OF CONTACT WITH THE SOURCE OF ELECTRICAL SHOCK, MOVE THE PERSON A SHORT DISTA

41、NCE AWAY AND IMMEDIATELY START ARTIFICIAL RESUSCITATION C/(D blank) *TM 11-5820-667-12 EE150-JN-MMO-01B/E154-PRC-77 TO 31R2-2PRC77-1 TECHNICAL MANUAL 11-5820-667-12 HEADQUARTERS EE150-JN-MMO-01B/E154-PRC-77 DEPARTMENTS OF THE ARMY TO 31R2-2PRC77-1 Washington, DC, 1 January 1987 OPERATORS AND ORGANIZ

42、ATIONAL MAINTENANCE MANUAL RADIO SET AN/PRC-77 (NSN 5820-00-930-3724) (INCLUDING RECEIVER-TRANSMITTER, RADIO RT-841/PRC-77) (NSN 5820-00-930-3725) REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual. If you find any mistakes or if you know of a way to improve the procedur

43、es, please let us know. Mail you letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form 2028-2 located in back of this manual direct to: Commander, US Army Communications-Electronics Command and Fort Monmouth, ATTN: AMSEL-LC-LM-LT, Fort Monmouth, New Jersey 077035000.

44、 For Air Force, submit AFTO Form 22 (Technical Order System Publication Improvement Report and Reply) in accordance with paragraph 6-5, Section VI, T.O. 00-5-1. Forward direct to prime ALC/MST. For Navy, mailcomments to the Commander, Space and Naval Warfare Systems Command, ATTN: SPAWAR 8122, Washi

45、ngton, DC, 20363-5100. In either case a reply will be furnished direct to you. CHAPTER 1. Section I. II. CHAPTER 2. 3. 4. Section I. II. CHAPTER 5. Section I. II. III. CHAPTER 6. APPENDIX A. B. C. D. E. INDEX Paragraph INTRODUCTION General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

46、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1 Description and data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

47、 . . . . . . . OPERATING INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . OPERATORS MAINTENANCE INSTRUCTIONS Preventive maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

48、. . 4-1 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4 ORGANIZATIONAL MAINTENANCE General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

49、 . . . . . . . . . . . . . . . . . . 5-1 Preventive maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4 MATERIEL USED IN CONJUNCTION WITH RADIO SET AN/PRC-77 . . . . . . . . . . . . . . . . REFERENCES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . MAINTENANCE ALLOCATION . . . . . . .