Sony_ICF-SW100E_ICF-SW100S_serv_2005.pdf

《Sony_ICF-SW100E_ICF-SW100S_serv_2005.pdf》由会员分享，可在线阅读，更多相关《Sony_ICF-SW100E_ICF-SW100S_serv_2005.pdf（52页珍藏版）》请在收音机爱好者资料库上搜索。

1、Ver. 1.1 2005.11 SERVICE MANUAL ICF-SW100E/SW100S AN-100 US Model Canadian Model Tourist Model ICF-SW100S AEP Model E Model ICF-SW100E/SW100S UK Model Australian Model ICF-SW100E FM STEREO/SW/MW/LW PLL SUNTHESIZED RECEIVER 9-959-320-12 2005K02-1 2005.11 Sony Corporation Personal Audio Division Publi

2、shed by Sony Engineering Corporation ICF-SW100E/SW100S 4-9. PRINTED WIRING BOARD CONTROL Section 38 37 Ver. 1.1 Note: X : parts extracted from the component side. Y : parts extracted from the conductor side. z: Through hole. : Pattern on the side which is seen. : Pattern of the rear side. D: Chip co

3、mponents extracted from the rear side. ICF-SW100E/SW100S 45 8 12 11 19 44(Including No.8) (Included in No. 44) not supplied not supplied ANT2 40 40 39 SECTION 5 EXPLODED VIEWS NOTE: -XX and -X mean standardized parts, so they may have some difference from the original one. Abbreviation EA : Saudi Ar

4、abia Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 5-1.MAIN SECTION 5-2.ACTIVE ANTENNA (AN-100) SECTION (ICF-SW100S) 63 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 13-909-832-01CABINET (REAR) (LID) 23-911-703-01COPPER LEAF 33-913-417-01SPRING 43-911-702-01

5、PLATE, CLICK 53-384-797-01SCREW *6A-3661-961-A MICROCOMPUTER BOARD, COMPLETE 73-565-241-01CLOTH (B) 1 UNWEAVED 8X-3371-472-2CABINET (FRONT) (LID) ASSY (included in No.44) 93-909-839-01BUTTON (LIGHT) 103-909-851-01GRILLE, SP 113-909-857-02SCREW, SHAFT 123-913-419-01CUSHION 133-911-701-01SPRING (B), L

6、EAF 143-909-842-01CLAW (LOCK) 153-909-838-01BUTTON (MEMORY) 163-909-837-01BUTTON (10 KEY) 173-909-840-01BUTTON (KEY PROTECT) *18A-3661-960-A KEY BOARD, COMPLETE 191-651-256-12PC BOARD, FLEXIBLE (KEY) 203-909-847-01PANEL, SIDE 213-909-846-01KNOB (SENS) 223-909-853-01SPRING, BATTERY COIL 234-017-441-0

7、1CUSHION (B) 243-892-318-00SCREW, SMALL 253-909-836-01KNOB (VOL) 263-909-835-01KNOB (TONE) *273-355-447-01SPACER (OPEN) 281-651-257-12PC BOARD, FLEXIBLE (SIGNAL) *29A-3679-561-A SIGNAL BOARD, COMPLETE *31A-3638-005-A TERMINAL (+) ASSY, BATTERY 323-909-841-01LID, BATTERY CASE 333-909-831-01CABINET (R

8、EAR) (MAIN) 343-910-063-01SCREW (1.7X10) 353-910-062-01FOOT, RUBBER 363-719-381-01SCREW (M2X4) 373-909-834-01KNOB (POWER) 383-909-492-01PLATE (ANT), CONTACT 39X-3368-534-2CABINET (FRONT) (MAIN) ASSY (EXCEPT EA) 39X-3368-535-2CABINET (FRONT) (MAIN) ASSY (EA) 40X-3368-536-2CHASSIS ASSY *414-023-575-01

9、CUSHION, LID 423-355-482-11SHEET (KT), ADHESIVE 44X-3372-340-4CHASSIS ASSY, FLEXIBLE (including No.8) 453-019-248-01PLATE, BLIND ANT11-501-658-21ANTENNA, TELESCOPIC ANT21-501-657-31ANTENNA, FERRITE-ROD (LW.MW) SP6011-505-165-12SPEAKER (4cm) Items marked “*” are not stocked since they are seldom requ

10、ired for routine service. Some delay should be anticipated when ordering these items. The mechanical parts with no reference number in the exploded views are not supplied. 513-895-517-11SCREW (2), TAPPING, STEP 523-719-381-01SCREW (M2X4) 533-910-063-01SCREW (1.7X10) 543-909-492-01PLATE (ANT), CONTAC

11、T 553-909-491-01PLATE (B), CONTACT 563-909-490-01PLATE (A), CONTACT 573-909-488-01REEL 581-559-706-11CORD (WITH PLUG) 593-909-489-01KNOB (ANTENNA) 603-909-486-02CASE (UPPER) *61A-3661-962-A ACTIVE ANTENNA BOARD, COMPLETE 623-909-487-01CASE (LOWER) *63A-3638-008-A ANTENNA ASSY, ACTIVE ANT31-501-658-2

12、1ANTENNA, TELESCOPIC Ver. 1.1 41 SECTION 6 ELECTRICAL PARTS LIST NOTE: Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX and -X mean standardized parts, so they may have some difference from the ori

13、ginal one. RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable Abbreviation AUS : Australian modeIT : Itlian model CND : Canadian modelJE : Tourist model EA : Saudi Arabia model Items marked “*” are not stocked since they are seldo

14、m required for routine service. Some delay should be anticipated when ordering these items. SEMICONDUCTORS In each case, u: , for example: uA.: A.uPA. : PA. uPB. : PB.uPC. : PC. uPD. : PD. CAPACITORS uF: F COILS uH: H Les composants identifis par une marque 0 sont critiques pour la scurit. Ne les re

15、mplacer que par une pice portant le numro spcifi. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board. ACTIVE ANTENNA Ref. No.Part No.DescriptionRemarksRef

16、. No.Part No.DescriptionRemarks Ver. 1.1 45 SIGNAL Ver. 1.1 48 SIGNAL Ver. 1.1 49 Ref. No.Part No.DescriptionRemarks MISCELLANEOUS * 191-651-256-12PC BOARD, FLEXIBLE (KEY) 281-651-257-12PC BOARD, FLEXIBLE (SIGNAL) 581-559-706-11CORD (WITH PLUG) ANT11-501-658-21ANTENNA, TELESCOPIC ANT21-501-657-31ANT

17、ENNA, FERRITE-ROD (LW.MW) ANT31-501-658-21ANTENNA, TELESCOPIC SP6011-505-165-12SPEAKER (4cm) * ACCESSORIES * 01-467-543-41ADAPTOR, AC (AC-E314) (CND) 01-476-124-11ADAPTOR, AC (AC-E321) (SW100S: EA) 01-476-124-12ADAPTOR, AC (AC-E321) (SW100S: AEP, IT, E) 01-476-125-13ADAPTOR, AC (AC-E322) (US) 01-476

18、-126-13ADAPTOR, AC (AC-E323) (JE) 01-569-007-11ADAPTOR, CONVERSION 2P (JE) 01-569-008-12ADAPTOR, CONVERSION 2P (SW100S: AEP, IT, E) 01-569-008-21ADAPTOR, CONVERSION 2P (SW100S: EA) 01-573-856-11ADAPTOR, CHANGE (CND) X-3329-657-1ATTACHMENT 3-757-853-08MANUAL, INSTRICTION (ENGLISH, ARABIC, KORIAN, JAP

19、ANESE) (EA, JE) 3-757-853-22MANUAL, INSTRICTION (ENGLISH, FRENCH, SPANISH, PORTUGUESE, SWEDISH) (AEP, E, US) 3-757-853-32MANUAL, INSTRICTION (ENGLISH, FRENCH, GERMAN, ITALIAN, DUTCH) (SW100E: AEP/SW100S: AEP, IT) 3-757-853-58MANUAL, INSTRUCTION (ENGLISH, FRENCH, GERMAN, ITALIAN, DUTCH) (SW100S: CND/

20、SW100E: UK, IT, AUS) 3-893-802-18BOOK, GUIDE, WAVE (SW100E: IT/SW100S: CND, JE) 3-893-802-32BOOK, GUIDE, WAVE (SW100E: AEP, E/SW100S: AEP, IT, E, US) 3-899-567-02PLATE (ASSY), ABSORPTION 3-910-057-03CASE, CARRYING 3-912-505-01LIST, FREQUENCY 8-954-008-93RECEIVER, EAR MDR-E808LP/C1 SET *A-3638-036-A

21、AN-71.2 (SW100E) Ver. 1.1 Les composants identifis par une marque 0 sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 50 ICF-SW100E

22、/SW100S MEMO ICF-SW100E/SW100S KEY BOARD SUPPLEMENT - 4 Subject : zSUFFIX CHANGE OF KEY, MICROCOMPUTER AND SIGNAL BOARD. zCHANGE OF THE MICROCOMPUTER (IC102). SERVICE MANUAL Ver. 1.1 AN-100 US Model Canadian Model Tourist Model ICF-SW100S AEP Model E Model ICF-SW100E/SW100S UK Model Australian Model

23、 ICF-SW100E CHANGE OF BOARD SUFFIX The KEY board, MICROCOMPUTER board and SIGNAL board changed to new type. The schematic diagram, the printed wiring board and the electrical parts list of a new type are described in this SUPPLEMENT-4. Refer to original service manual (9-959-320-12) for other inform

24、ations. KEY BOARD (SIDE A) before 1-651-255-12 : former type after 1-651-255-13 : new type 2 ICF-SW100E/SW100S MICROCOMPUTER BOARD MICROCOMPUTER BOARD (SIDE A) before 1-651-254-16 : former type after 1-651-254-17 : new type SIGNAL BOARD SIGNAL BOARD (SIDE A) before 1-651-253-16 : former type after 1

25、-651-253-17 : new type CHANGE OF THE MICROCOMPUTER (IC102) At the same time as changing the board, a microcomputer (SIGNAL board IC102) and a ceramic filter (SIGNAL board CF204) were changed. Therefor, please synchronize the exchange of these parts with the board suffix. BEFOR BOARD SUFFIX-16AFTER B

26、OARD SUFFIX-17 CF2041-577-065-31 FILTER, CERAMIC1-767-414-71 FILTER, CERAMIC IC1028-759-254-73 uPD1724GB-599-1A78-806-218-01 uPD17072GB-575-1A7-A SECTION 1 DIAGRAMS 3 5 4 ICF-SW100E/SW100S 1-1. SCHEMATIC DIAGRAM TUNER Section Abbreviation JE :Tourist model 6 8 7 ICF-SW100E/SW100S 1-2. SCHEMATIC DIAG

27、RAM CONTROL Section ICF-SW100E/SW100S 9 10 1-3. PRINTED WIRING BOARD SIGNAL BOARD (SIDE A) ANT2 LW/MW FERRITE-BAR ANTENNA ANT1 FM/SW TELESCOPIC ANTENNA R47 R6 R4 R34 R35 R31 R32 R26 R21 R40 R39 R38R37 R25 R29 R20 R30 R101 R114 R103 R109 R161 R115 R157 R148 R146 R145 R133 R132 R144 R151 R153R163 R158

28、 R122 R149 R123 R124 R116 R117 R119 R120 R165 R208 R121 R207 R219 R218 R304 R305 R303 R302 Q303 R211 R201 R308 R301 R204 R309 R312 R314 R334 R327 R318 R326 R325 R333 R315 R311 R323 R322 (EXCEPT JE) R321 R452 R350 R316 R320 R324 R213 R214 R107 R127 R159 R5 R8 C1 C4 C5 C10 C9 C36 C11 C37 C101 C140 C10

29、8 C150 C111 C115 C116 C138 C136 C151 C250 C224 C223 C229 C215 C213 C338 C305 C323 C312 C311 C306 C302 C301 C341 C307 C313 C340 C331 C303 C316 C317 C318 C339 C332 C333 C334 C330 C324 C325 C326 C335 C410 C118 C139 C222 C204 C205 C202 C207 C208 C452 C29 C146 C133 R147 C135 C12 C451 C6 C25 C26 C23 C24 R

30、13 R7 R41 R23R24 R19 R33 R451 R10 R17 R18 R16 R113R104 R14 R15 R108 R160R162 R106 R118 R125 DGS R164 R135 R215 R209 R205 R216 R217 R221 R306 R330 R310 R313 R307 R317 R45 R206 R210 R202 R203 R42 R105 R406R102 R28 R43 R11 R12 R9 R22 C8 C13 C15 C102 C103 C104 C409 C109 C147 C144 C145 C137 C121 C110 C12

31、4 C134 C125 C127 C126 C408 C14 C7 C18 C19 C22 C220 C21 C219 C329 C206 C232 C209 C212 C214 C210 C31 C30 C32 C201 C230 C304 C322 C309 C310 C314 C320 C321 C319 C315 C454 C225 C226 C227 C218 C233 C34 C28 C33 C17 C16 C2 L4L3 L1 L7 L9 L8 L101 L6 L102 L204 L202 L201 L303 L301 (JE) L302 D2 D7 JC1 S302 D104

32、D202 Q108 D203 D403 D103 D102 Q105 D1 D405 D101 Q307 Q310 Q451 Q308 Q301 Q302 Q304 Q305 Q208 Q210 Q203 Q204 C216 Q206 Q201 Q7 Q11 Q10 Q205 Q202 Q107 Q4 Q110 Q112 Q109 Q101 Q102 Q103 Q106 Q113 Q104 D3 Q1 Q3 Q2 Q5 Q8 Q6 D201 D6 D5 Q306 Q311 Q9 17 (17) 1-651-253- SIGNAL BOARD (SIDE A) DRY BATTERY SIZE

33、AA (IEC DESIGNATION R6) 2PCS. 3V RESET E GSD SGD SGD ECB SGD BCE BCE BCE BCE ECBECB ECB BCE BCE ECB ECB BCE ECB ECB ECB BCE BCE DSG DSG GSD ECB ECB BCE BCE ECB ECB ECB GSD 234567 A 1 B C D E Note on Printed Wiring Boards: X : parts extracted from the component side. x : parts extracted from the cond

34、uctor side. z: Through hole. : Pattern from the side which enables seeing. (The other layers Patterns are not indicated.) Caution: Pattern face side:Parts on the pattern face side seen from the (Side A)pattern face are indicated. Parts face side:Parts on the parts face side seen from the (Side B)par

35、ts face are indicated. Abbreviation JE: Tourist model Ref. No.Location Semiconductor Location D1C-1 D2B-2 D3A-2 D5A-3 D6B-4 D7B-1 D101C-2 D102C-3 D103C-3 D104C-4 D201B-4 D202B-5 D203C-4 D403D-2 D405C-1 Q1B-2 Q2B-2 Q3B-2 Q4B-3 Q5B-2 Q6B-2 Q7A-3 Q8B-3 Q9B-1 Q10A-4 Q11A-3 Q101C-1 Q102C-2 Q103C-2 Q104C-

36、2 Q105D-2 Q106C-3 Q107C-3 Q108D-3 Q109D-3 Q110D-3 Q112D-3 Q113D-2 Q201C-4 Q202C-4 Q203B-5 Q204B-5 Q205C-4 Q206C-4 Q208C-5 Q210B-5 Q301A-5 Q302B-5 Q303B-5 Q304B-5 Q305C-5 Q306B-7 Q307C-7 Q308A-7 Q310C-6 Q311B-7 Q451A-7 ICF-SW100E/SW100S 11 12 1-4. PRINTED WIRING BOARD SIGNAL BOARD (SIDE B) 1 1 IC201

37、1 IC101 1 IC302 1 IC301 1 IC102 1 IC303 R332 R152 R150 R155 R154 R156 Q403 Q111 Q309 C327 C328 Q404Q402 BCE CF204 CN401 CF203 CF201 CF202 X201 X101 X202 L401 RV301 RV302 RV202 RV201 L402 D401 D402 S301 S301 J301 i J302 LINE OUT N VOLD4 L10 L5 Q450 Q401 Q12 ECB CT1 CT2 R126 C143 R112 R134 R410 R411 R

38、130 R139 R140 R141 R142 R328 R329 R319 R131 R407 R408 R409 R222 R212 R404 R403 R27 R453 R111 R110 R44 R454 C131 C128C129 C308 C337 C211 C336 C404 C402 C403 C406 C453C27 C35 C450 C112 C107 R138 R143 R136 R137 R129 R128 R412 R401 R402 R36 C113 C122 C123 C132 C407 C401 C405 S1 S1 J303 J1 ACTIVE ANT DC

39、IN 3V SENS LOCAL DX t T1 T2 T101 T4 T3 T203 T5 T6 T202 T204 T201 T401 XF1 BCE SIGNAL BOARD (SIDE B) 17 (17) 1-651-253- 1615 1630 18 14 15 28 29 42 4363 6 3 4 5 5 8 8 9 10 MICROCOMPUTER BOARD (SUPPLEMENT-4:Page 15) A AM TONE/FM MODE MUSIC/STEREO NEWS/MONO t ECB 2345678 A 1 B C D E Note on Printed Wir

40、ing Boards: X : parts extracted from the component side. x : parts extracted from the conductor side. z: Through hole. : Pattern from the side which enables seeing. (The other layers Patterns are not indicated.) Caution: Pattern face side:Parts on the pattern face side seen from the (Side A)pattern

41、face are indicated. Parts face side:Parts on the parts face side seen from the (Side B)parts face are indicated. Ref. No.Location Semiconductor Location D4A-7 D401B-3 D402B-2 IC101C-6 IC102D-6 IC201B-4 IC301B-3 IC302C-3 IC303D-5 Q12A-7 Q111C-7 Q309D-6 Q401B-3 Q402D-3 Q403D-6 Q404D-3 Q450A-6 ICF-SW10

42、0E/SW100S 13 14 1-5. PRINTED WIRING BOARD MICROCOMPUTER BOARD (SIDE A) MICROCOMPUTER BOARD (SIDE A) 17 (17) 1-651-254- R605 R604 D604 D605 BT601 S601 LIGHT LIGHT LIGHT 2345 A 1 B C Note on Printed Wiring Boards: X : parts extracted from the component side. x : parts extracted from the conductor side

43、. z: Through hole. : Pattern from the side which enables seeing. (The other layers Patterns are not indicated.) Caution: Pattern face side:Parts on the pattern face side seen from the (Side A)pattern face are indicated. Parts face side:Parts on the parts face side seen from the (Side B)parts face ar

44、e indicated. Ref. No.Location Semiconductor Location D604B-1 D605C-1 ICF-SW100E/SW100S 15 16 1-6. PRINTED WIRING BOARD MICROCOMPUTER BOARD (SIDE B) RB628 RB626 RB627 RB625 RB624 RB603 RB619 RB618 RB610 RB617 RB616 RB604 RB631 RB605 RB606 RB614RB613RB612 RB615 RB607 RB608 RB609 RB629RB630 RB611 RB620

45、 RB621 RB622 RB623 RB601 RB602 1 1 1CN60218 1CN60116 IC604 IC603 41 41 40 40 21 21 20 20 80 80 61 61 60 60 AB SIGNAL BOARD (SUPPLEMENT-4:Page 11) KEY BOARD (SUPPLEMENT-4:Page 17) SP601 SPEAKER 13 IC602 IC601 13 D602 D603 D601 IC607 13 IC60513 IC606 1 4 5 8 C629 C616 Q603 Q601 Q602 ECB BCE BCE D606 D

46、607 R614 R620 R601 R603 R607 R611 R621 C602 C603 C604 C605 C606 C607 C608 R602 R612 R606 R609 R610 R616 C631 C614 C601 R622 R619 R624 R613 C622 C621 C620 C632 C623 C618 C617 C613 R617 R608 R618 R623 R615 C619 C628 C630 C627 C626 C625 C624 C611 C610 C609 C612 MICROCOMPUTER BOARD (SIDE B) 17 (17) 1-65

47、1-254- X601 2345 A 1 B C D Note on Printed Wiring Boards: X : parts extracted from the component side. x : parts extracted from the conductor side. z: Through hole. : Pattern from the side which enables seeing. (The other layers Patterns are not indicated.) Caution: Pattern face side:Parts on the pa

48、ttern face side seen from the (Side A)pattern face are indicated. Parts face side:Parts on the parts face side seen from the (Side B)parts face are indicated. Ref. No.Location Semiconductor Location D601B-1 D602C-1 D603C-1 D606B-4 D607C-4 IC601A-1 IC602A-1 IC603B-2 IC604B-3 IC605B-4 IC606C-3 IC607C-

49、4 Q601B-1 Q602C-1 Q603B-1 ICF-SW100E/SW100S 17 18 1-7. PRINTED WIRING BOARD KEY BOARD (SIDE A) KEY BOARD (SIDE A) 13 (13)1-651-255- CN701 B MICROCOMPUTER BOARD (SUPPLEMENT-4:Page 15) 234567 A 1 B C D Note on Printed Wiring Boards: X : parts extracted from the component side. x : parts extracted from the conductor side. z: Through