Roland BR-1180, BR-1180CD Recorder Service Manual 电路图.pdf

《Roland BR-1180, BR-1180CD Recorder Service Manual 电路图.pdf》由会员分享，可在线阅读，更多相关《Roland BR-1180, BR-1180CD Recorder Service Manual 电路图.pdf（35页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE NOTES Issued by RJA Copyright 2002 ROLAND CORPORATION All rights reserved. No part of this publication may be reproduced in any form without the written permission of ROLAND CORPORATION. Printed in Japan (0800) (NB)17058069E0 MAY.2002BR-1180 TABLE OF CONTENTS SPECIFICATIONS.2 LOCATION OF CON

2、TROLS .4 LOCATION OF CONTROLS PARTS LIST.5 EXPLODED VIEW 1.6 EXPLODED VIEW 2.7 EXPLODED VIEW 3.8 EXPLODED VIEW PARTS LIST.9 PARTS LIST.10 CHECKING THE VERSION NUMBER.15 USERS DATA SAVE AND LOAD.15 RESTORING THE FACTORY SETTINGS.16 SYSTEM SOFTWARE UPDATE PROCEDURE .17 TEST MODE.17 BLOCK DIAGRAM.20 CI

3、RCUIT BOARD(MAIN) .22 CIRCUIT DIAGRAM(MAIN 1/4) .24 CIRCUIT DIAGRAM(MAIN 2/4) .26 CIRCUIT DIAGRAM(MAIN 3/4) .28 CIRCUIT DIAGRAM(MAIN 4/4) .30 CIRCUIT BOARD(SW SHEET ASSY).32 CIRCUIT BOARD(ANALOG).34 CIRCUIT DIAGRAM(+5V BOARD).36 CIRCUIT DIAGRAM(SW).38 ERROR MESSAGES.40 CDI-BR-1.41 SPECIFICATIONS.41

4、PARTS LIST.42 INSTALLING THE CDI-BR-1.43 The wiring exchange method.44 RadioFans.CN 收音机爱 好者资料库 2 MAY.2002 SPECIFICATIONS BR-1180: Digital Recording Studio BR-1180CD: Digital Recording Studio (built-in CD-R/RW drive) Tracks Track: 10V-Track: 80 (8 V-Tracks per each Track) *Up to 2 tracks can be recor

5、ded simultaneously, and up to 10 tracks can be played back simultaneously. Maximum Useful Capacity/Recording Time Internal Hard Disk: 20 G bytes (conversion in 1 track, times approximate) *The above-listed recording times are approximate. Times may be slightly shorter depending on the number of song

6、s and size of imported loop phrase that were created. *The above number is the total for all the tracks that are used. If each of the ten tracks contain an equal amount of data, the length of the resulting song will be approximately 1/10 of the above. Signal Processing AD Conversion: 24 bit, AF Meth

7、od (Guitar/Bass) 24 bit, AF Method (Mic) 24 bit, Modulation (Line) 24 bit, Modulation (Simul) DA Conversion: 24 bit, Modulation Internal Processing: 24 bit (digital mixer section) Recording Data: 16 bit linear (data type: LIN) Sample Rate 44.1 kHz Frequency Response 20 Hz-20 kHz (+1/-3 dB) Total Dis

8、tortion 0.15 % or less (INPUT SENS : CENTER, 1 kHz at nominal output level, data type: LIN) Nominal Input Level (Variable) GUITAR/BASS jack: -10 dBu MIC 1, 2 jack: -40 dBu LINE jack: -10 dBu Input Impedance GUITAR/BASS jack: 1 M ohms MIC 1, 2 jack (TRS): 2.2 k ohms (HOT-COLD) 1.1 k ohms (HOT-GND, CO

9、LD-GND) MIC 1, 2 jack (XLR): 2.2 k ohms (HOT-COLD) 1.1 k ohms (HOT-GND, COLD-GND) LINE IN jack: 50 k ohms Nominal Output Level LINE OUT jack: -10 dBu Output Impedance LINE OUT jack: 2 k ohms PHONES jack: 100 ohms Recommended Load Impedance LINE OUT jack: 20 k ohms or greater PHONES jack: 8-50 ohms R

10、esidual Noise Level LINE OUT jack: -87dBu or less (INPUT SELECT: GUITAR/BASS, input terminated with 1 k?, INPUT SENS: CENTER, IHF-A, typ.) Interface DIGITAL OUT: S/PDIF (Optical type) Display 64 x 40mm (Backlit LCD) Connectors MIDI IN connector MIDI OUT connector DIGITAL OUT connector (optical type)

11、 FOOT SW jack (1/4 inch phone type) EXP PEDAL jack (1/4 inch phone type) PHONES jack (Stereo 1/4 inch phone type) LINE OUT jack L/R (RCA Phono type) LINE IN jack L/R (RCA Phono type) MIC 1, 2 jack (TRS balanced, 1/4 inch phone type) MIC 1, 2 connector (XLR balanced) GUITAR/BASS jack (1/4 inch phone

12、type) Power Supply DC 12 V; Supply AC Adaptor (Roland PSB-3U) Power Consumption 3 A Dimensions 460 (W) x 273 (D) x 87 (H) mm 18-1/8 (W) x 10/3/4 (D) x 3-7/16 (H) mm Weight BR-1180CD: 3.85 kg/8 lbs 8 oz BR-1180: 3.50 kg/7 lbs 12 oz (Excluding AC Adaptor) Accessories AC Adaptor: PSB-3U (#02900423) AC

13、CORD 100V(#00894367) 120V(#00894378) 230V(#00894389) 240VE(#00907001) 240VA(#23495124) Owners Manual Japanese(#72018489) English(#72018367) Roland Service (information sheet)(#*) DISCRETE DRUMS (CD-ROM(#*); BR-1180CD only) Options CD-R/RW drive (for BR-1180): CDI-BR-1 Expression Pedal: EV-5 (Roland)

14、 Foot Switch: FS-5U Pedal Switch: DP-2 (Roland) *0dBu = 0.775V rms *In the interest of product improvement, the specifications and/or appearance of this unit are subject to change without prior notice. Data typeRecording time LIN60 hours MT1120 hours MT2160 hours LV1190 hours LV2240 hours RadioFans.

15、CN 收音机爱 好者资料库 3 BR-1180 RadioFans.CN 收音机爱 好者资料库 4 MAY.2002 LOCATION OF CONTROLS fig.panel_top-rear.eps TOP REAR blnzakwq r g c s a p p h y jyiuxuo 9;8761 t e 1 v f s p d 524 3 5 BR-1180 LOCATION OF CONTROLS PARTS LIST No.PART CODEPART NAMEDESCRIPTIONQTY 1005692786.5MM JACKLGR4609-71004 201239890XLR

16、JACKNC3FAH2-02 3134492586.5MM JACKHLJ4306-01-30802 402900478RCA(PIN JACK)YKC21-32821 501340412P R-KNOBSF-A BLK/LCG1 029004679M/M ROTARY POTENTIOMETEREVJC25FB6A54 50KAX21 602568778IC (OPTICAL CONNECTOR)GP1FA350TZ1 713429825MIDI CONNECTORYKF51-5054 2PZ1 802900312DC JACKHEC0470-01-6401 922365714CORD HO

17、OK236-7141 1002896767BOTTOM COVER1 1102896756TOP CASE1 1202011456Y S-KEYTOPSX1H BLK1 01340290TACT SWITCHEVQ11A H=5.01 1322485303D R-KNOB(ALPHA-DIAL)L BLK 248-3031 01905467ROTARY ENCODEREVE GC1 F20 24B1 1400900190D S-KEYTOPSX2H BLK2 01340290TACT SWITCHEVQ11A H=5.02 1501234090D T-KEYTOPMX4B BLK1 01340

18、290TACT SWITCHEVQ11A H=5.04 1602013090F C-KEYTOPMX1H CLR12 01340290TACT SWITCHEVQ11A H=5.012 01904178LED (CLR)SPR-505MVWT3112 1701670512F C-KEYTOPSX1H BLK2 01340290TACT SWITCHEVQ11A H=5.02 1802123467F C-KEYTOPMX1H BLK1 01340290TACT SWITCHEVQ11A H=5.01 1901783945N S-KEYTOPMD3H1 01340290TACT SWITCHEVQ

19、11A H=5.03 15029348LED (GREEN) SLR-342MCT32 (PLAY)1 01904112LEDSLR-342VCT32 .NP.Q RANK (REC) 2000900145D S-KEYTOPSD1H BLK6 01340290TACT SWITCHEVQ11A H=5.06 01904112LEDSLR-342VCT32 N.P.Q RANK6 2100900156D S-KEYTOPSD2H BLK2 01340290TACT SWITCHEVQ11A H=5.04 01904112LEDSLR-342VCT32 N.P.Q RANK4 220090018

20、9D S-KEYTOPSX1H BLK1 01340290TACT SWITCHEVQ11A H=5.01 2300904245D S-KEYTOPSX3H BLK1 01340290TACT SWITCHEVQ11A H=5.03 2400904256D S-KEYTOPSX4H BLK1 01340290TACT SWITCHEVQ11A H=5.04 2502457512J R-KNOBSFA BLK/LCG2 028967019M/M ROTARY POTENTIOMETEREVUF2K4A15 100KA2 2622495277D S-KEYTOPMD1H BLK 249-277(W

21、/WINDOW)1 01340290TACT SWITCHEVQ11A H=5.01 01904112LEDSLR-342VCT32 N.P.Q RANK1 2701902289U S-KNOBM BLK LCG11 01677312POTENTIOMERTER (SLIDE)EWAP1AC10 B54 50KB11 2800900167D S-KEYTOPSD3H BLK1 01340290TACT SWITCHEVQ11A H=5.03 01904112LEDSLR-342VCT32 N.P.Q RANK3 2922495271DS-KEYTOPMX4H BLK 249-2711 0134

22、0290TACT SWITCHEVQ11A H=5.04 3022355334FOOT MKS235-3344 3102896789DISPLAY COVER1 17041159LCDF-51320GNY-LY-AA W/TAPE1 3202896790PANEL SHEET1 3302457512J R-KNOBSFA BLK/LCG1 028967129M/M ROTARY POTENTIOMETEREVUF2KFK4B54 50KB1 3401904189LEDSEL2210R D RANK3 3515039237LEDSLR-342MC3F (GREEN)1 3615029347LED

23、 (RED)SLR-342VC3F1 6 MAY.2002 EXPLODED VIEW 1 fig.bunkai-1 A A d p o W i 2 4 3 6 5 8 s y r u a w e 9 w q 7 0 5 7 3 9 BA 1 E t 3 7 BR-1180 EXPLODED VIEW 2 fig.bunkai-2 f C E F G J I D G C D H C G D P8 CDRW P8 HDD h g % l l ; k j . n , ! m # / M L M 9 BR-1180 EXPLODED VIEW PARTS LIST Parts Screws No.P

24、arts CodeParts Name 117041159LCD F-51320GNY-LY-AA W/TAPE 202896756TOP CASE 300900145D S-KEYTOP SD1H BLK 422495277D S-KEYTOP MD1H BLK 500900189D S-KEYTOP SX1H BLK 600904256D S-KEYTOP SX4H BLK 700900156D S-KEYTOP SD2H BLK 800904245D S-KEYTOP SX3H BLK 901670512F C-KEYTOP SX1H BLK 1022495271D S-KEYTOP M

25、X4H BLK 1100900167D S-KEYTOP SD3H BLK 1200900190D S-KEYTOP SX2H BLK 1301234090D T-KEYTOP MX4B BLK 1402123467F C-KEYTOP MX1H BLK 1502013090F C-KEYTOP MX1H CLR 1601783945N S-KEYTOP MD3H 1702011456Y S-KEYTOP SX1H BLK 18*SW BOARD ASSY (on 72015312 SW SHEET ASSY) 1902121456BNCD-P=1.25-K-14-220 2002673245

26、BNCD-P=1.25-K-16-220 2102673223BNCD-P=1.25-K-18-90 2202124845BNCD-P=1.25-K-18-150 2302896778CHASSIS 2422355334FOOT MKS 2502896767BOTTOM COVER 2602896801CDRW COVER 2702904778HDD SIDE CUSHION 2802904745HDD BUSH VB-1209-55 2902904756HDD COLLAR 3002904767HDD FRONT CUSHION 3102896823HDD HOLDER R 32028968

27、12HDD HOLDER L 3302897167HDD MAXTOR 541DX 2B 020HI 3402904623WIRING HDD IDE 3502900412WIRING HDD POWER 3602899445INSULATING SHEET CDRW 3772017823CDI-BR-1 PCB ASSY 3802899434DD HOLDER CDRW STOP 3902902156WIRING IDE 4002899401DD HOLDER CDRW L 4102899412DD HOLDER CDRW R 4201016223FOOT 01016223 43027829

28、90ATAPI CD-RW DRIVE UJDA340 4472015301MAIN BOARD ASSY 45*ANALOG BOARD ASSY (on 72015312 SW SHEET ASSY) 4602124845BNCD-P=1.25-K-18-150 4701340412P R-KNOB SF-A BLK/LCG 48*+5V POWER BOARD ASSY (on 72015312 SW SHEET ASSY) 4922365714CORD HOOK 5002896834INSULATING SHEET MAIN 5102896956WIRING 5V POWER 5202

29、903223RIBBON CABLE JWFV 2X70-P2.0 5302896978WIRING 2 LCD No.Parts CodeParts Name A40011278SCREW 3x8 BINDING TAPTITE P ZC B40457245WASHER M3x12x1 ZC C40012534SCREW 3x6 BINDING TAPTITE S BZC D40011312SCREW 3x8 BINDING TAPTITE P BZC E40011490SCREW M3x6 PAN HEAD W/SW+PW BZC F40015956SCREW 3x12 BINDING T

30、APTITE S BZC G40012512SCREW 3x6 BINDING TAPTITE S ZC H40233012SCREW 2.6x8 BINDING TAPTITE P BZC I40019134SCREW M4x8 BINDING TAPTITE S W/INTERNAL TOOTH WASHER BZC J40019123SCREW 3x8 BINDING TAPTITE S BZC K40450367SCREW 6-32UNC 1008SR/KM003 L40233978SCREW M2x8 PAN HEAD W/SW+PW ZC M40455867SCREW 2x2.5

31、BINDING MACHINE ZC 10 MAY.2002 PARTS LIST fig.part1e SAFETY PRECAUTIONS: The parts marked have safety-related characteristics. Use only listed parts for replacement. CONSIDERATION ON PARTS ORDRING When ordering any parts listed in the parts list, please specify the following items in the order sheet

32、. QTYPART NUMBERDESCRIPTIONMODEL NUMBER Ex.1022575241Sharp KeyC-20/50 152247017300Knob (orange)DAC-15D Failure to completely fill the above items with correct number and description will result in delayed or even undelivered replacement. NOTE: The parts marked # are new. (initial parts) CASING Qty #

33、02896756TOP CASE1 #02896801CDRW COVER1 #02896767BOTTOM COVER1 #02896789DISPLAY COVER1 CHASSIS #02896778CHASSIS1 #02896812HDD HOLDER L1 #02896823HDD HOLDER R1 #02899401DD HOLDER CDRW LBR-1180CD ONLY1 #02899412DD HOLDER CDRW RBR-1180CD ONLY1 #02899434DD HOLDER CDRW STOPBR-1180CD ONLY1 KNOB, BUTTON 020

34、13090F C-KEYTOPMX1H CLR12 00900145D S-KEYTOPSD1H BLK6 00900156D S-KEYTOPSD2H BLK2 00900167D S-KEYTOPSD3H BLK1 00900189D S-KEYTOPSX1H BLK2 00900190D S-KEYTOPSX2H BLK2 00904245D S-KEYTOPSX3H BLK1 00904256D S-KEYTOPSX4H BLK1 01234090D T-KEYTOPMX4B BLK1 01670512F C-KEYTOPSX1H BLK2 01783945N S-KEYTOPMD3H

35、1 02011456Y S-KEYTOPSX1H BLK1 02123467F C-KEYTOPMX1H BLK1 22495271DS-KEYTOPMX4H BLK 249-2711 22495277D S-KEYTOPMD1H BLK 249-277(W/WINDOW)1 02457512J R-KNOBSFA BLK/LCG3 01340412P R-KNOBSF-A BLK/LCG1 22485303D R-KNOB(ALPHA-DIAL)L BLK 248-3031 01902289U S-KNOBM BLK LCG11 SWITCH 01340290EVQ11A H=5.0TACT

36、 SWITCHSW1,SW2,SW3,SW4,SW5,SW6,SW7,SW8,SW9,S W10,SW11,SW12,SW13,SW14,SW15,SW16,SW17, SW18,SW19,SW20,SW21,SW22,SW23,SW24,SW2 5,SW26,SW27,SW28,SW29,SW30,SW31,SW32,SW 33,SW34,SW35,SW36,SW37,SW38,SW39,SW40,S W41,SW42,SW43,SW44,SW45,SW46,SW47,SW48, SW49,SW50,SW51,SW52,SW53,SW54 on SWB 54 JACK, EXT TERMIN

37、AL 13429825YKF51-5054 2PZMIDI CONNECTORJK9 on MB1 00569278LGR4609-71006.5MM JACKJK1 on ANB. JK7,10,11 on MB4 #02900312HEC0470-01-640DC JACKJK8 on MB1 01239890NC3FAH2-0XLR JACKJK2,JK4 on ANB2 #02900478YKC21-3282RCA(PIN JACK)JK5 on ANB1 13449258HLJ4306-01-30806.5MM JACKJK3,JK6 on ANB.2 DISPLAY UNIT 17

38、041159F-51320GNY-LY-AA W/TAPELCD1 NOTE: Replacement F-51320GNY-LY-AA should be made on a unit base. 11 BR-1180 DISK DRIVE UNIT #02897167MAXTOR 541DX 2B 020HIHDD1 NOTE: Replacement MAXTOR 541DX 2B 020HI should be made on a unit base. 02782990UJDA340ATAPI CD-RW DRIVEBR-1180CD ONLY1 NOTE: Replacement U

39、JDA340 should be made on a unit base. PCB ASSY #72015301MAIN BOARD ASSY1 #72015312SW SHEET ASSY1 NOTE: SW SHEET ASSY includes the following parts. *BR-1180 ANALOG BOARD ASSYAssy(Unit)1 *BR-1180 +5V POWER BOARD ASSYAssy(Unit)1 *BR-1180 SW BOARD ASSYAssy(Unit)1 NOTE: BR-1180 SW BOARD ASSY includes the

40、 following parts. # 02903223RIBBON CABLEJWFV 2X70-P2.01 40013334SPACER PLASTIC PIPE3.2X5X10 CLARYTY2 40344367LED SPACERPOLYCARBONATE-PIPE 3X6X10.55 #72017823PCB ASSYBR-1180CD ONLY1 IC #02900434UPD7031060A058-UENIC (CPU 16BIT)IC28 on MB.1 02231767RA0A-101 (TC223C080AF-101)IC (DSP)IC27 on MB1 #0289674

41、5S1L50753F27B000IC (I/F)IC36 on MB1 02568489GM71V18163CT-6IC (DRAM)IC47 on MB1 02457634MBM29LV160BE70TN-KIC (FLASH MEMORY)IC24 on MB1 02451434AK4552VTIC (AD/DA)IC5 on MB1 02892334TC74LCX245FT(EL)IC (CMOS)IC35,IC39 on MB2 #02900267TC7S66F(TE85R)IC (CMOS)IC46 on MB1 02458090TC4066BFT(EL)IC (CMOS)IC2,I

42、C6,IC13 on MB3 01672623TC74HC4053AFT(EL)IC (TTL)IC29,IC32 on MB2 01121845TC7W04FU TE12LIC (CMOS)IC23 on MB1 01348912TC7SH08FU(TE85L)IC (CMOS)IC40 on MB1 02124934TC74VHC541FTELIC (CMOS)IC37,IC42 on MB2 00458034TC75S51F TE85RIC (OP AMP)IC33 on MB1 00346445NJM2100M(TE3)IC (BIPOLAR OP AMP)IC3 on MB1 151

43、89261M5218AFP-600EIC (BIPOLAR OP AMP)IC7,IC8 on MB2 01458445UPC29M33T-T1IC (REGULATOR)IC49 on MB1 #02903734TA78M09F(TE16L)IC (REGULATOR)IC48 on MB1 01899790UPC29L33T-E2IC (REGULATOR)IC1 on MB1 02563467NJM2374AM-TE1IC (SWITCHING REGULATOR)IC9 on MB1 #02900201M62270GP-C60JDC-DC IC(REGULATOR)IC22 on MB

44、1 01785178TC9271FSIC (DIGITAL OUT IF)IC25 on MB1 #02903745S-80930CNMC-G80IC (RESET)IC34 on MB1 02568778GP1FA350TZIC (OPTICAL CONNECTOR)CN1 on MB1 15289124PC-4007IC (PHOTO COUPLER)IC26 on MB1 15189250M5218ALIC (BIPOLAR OP AMP)IC20 on SWB. IC4,IC11,IC12 on ANB4 15189190M5216L-600YIC (BIPOLAR OP AMP)IC

45、10 on ANB1 #02898412NJM2374ADIC (SWITCHING REGULATOR)IC21 on +5PB1 02673812HY57V641620HGT-PIC (DRAM)IC30 on MB1 TRANSISTOR 02780423POWER MOSFET CPH6302-TLTRANSISTORQ29 on MB1 153091042SA1586-GR(TE85R)TRANSISTORQ7 on MB1 #02900301TPC8303(TE12L)TRANSISTORQ21,Q22,Q31 on MB3 15329501DTA143EK T146TRANSISTORQ38 on MB1 00239812DTC114EUT106TRANSISTORQ2,Q3,Q4,Q5,Q6,8,12,14,23,24,27,30,33,34,36 on MB15 02340645RN1441-A(TE85L)TRANSISTORQ11,Q13 on MB2 #02900212M54563FP-200DTRANSISTORIC38 on MB1 #02900234M54585KP-200DTRANSIST