Roland DJ-2000 Mixer Service Manual 电路图.pdf

《Roland DJ-2000 Mixer Service Manual 电路图.pdf》由会员分享，可在线阅读，更多相关《Roland DJ-2000 Mixer Service Manual 电路图.pdf（22页珍藏版）》请在收音机爱好者资料库上搜索。

1、DJ-2000 May, 1998DJ-2000 TABLE OF CONTENTSPage SPECIFICATIONS / INPUT AND OUTPUT STANDARD1, 2 PANEL LAYOUT 3 EXPLODED VIEW4 PARTS LIST5, 6 IDENTIFYING THE VERSION NUMBER7 TEST MODE 7, 8 BLOCK DIAGRAM 9 CIRCUIT BOARD DSP BOARD ASSY (71018267) 10 MIXER BOARD ASSY (71017901) / PHONES BOARD (71017990) J

2、ACK BOARD A (71017934) / JACK BOARD B (71017967)11 SW BOARD A ASSY (71018278) / SW BOARD B ASSY (71120867)12 PS BOARD 1 ASSY (71019190) / PS BOARD 2 ASSY (71017890) / MIDI BOARD ASSY (71120889) / TRANS BOARD ASSY (*)13 CIRCUIT DIAGRAM DSP BOARD ASSY14 MIXER BOARD ASSY 1/315 MIXER BOARD ASSY 2/316 MI

3、XER BOARD ASSY 3/3+PHONES17 JACK BOARD A+JACK BOARD B 18 PS1+PS2+TRANS BOARD ASSY19 SW BOARD A ASSY 20 SW BOARD B ASSY 21 MIDI BOARD ASSY 22 Printed in Japan (CR) ACE0 1 17059928 Issued by RJA Copyright c 1998 by ROLAND CORPORATION All rights reserved. No part of this publication may be reproduced i

4、n any form without the written permission of ROLAND CORPORATION. MAIN SPECIFICATIONS/INPUT AND OUTPUT STANDARDS Specifications GFrequency Response 20Hz20kHz +1dB(GAIN = min) GTotal Harmonic Distortion 0.05% or less(20Hz to 20kHz rated output) GSN Ratio 80dB(Input terminated with 150W, IHF-A,Typ.) GC

5、rosstalk -70dB or less(1kHz between channels) -70dB or less(1kHz between L and R) GEqualizer HIGH: +16dB(12kHz shelving type) MID: +16dB(2kHz peaking type) LOW: +16dB(40Hz shelving type) GIsorator HIGH:-+12dB MID:-+12dB LOW:-+12dB GPower AC100V(50/60Hz), AC117V,AC230V,AC240V GPower Consumption 35W G

6、Dimensions 482.0(W)x310.4(D)x111.9(H)mm (7U) 19(W)x12-1/4(D)x4-7/16(H) inches GWeight 6.8kg / 16lbs GAccessories Owners Manual English(#71018723) AC Cord100V : (#13499219) 117V : (#13499220) 230V : (#13499221) 240VA : (#13499222) Euro Converter Plug (#00905234) 230VE only GOptions Cross Fader for re

7、placing : CFX-1 * In the interest of product improvement, the specifications and /or appearance of this unit are subject to change without prior notice. Input Standard Output Standard _ _ _ _ Input SocketRated Input LevelNon-Clip Max, InputInput ImpedanceType of Connectors MIC1 MIC2 LINE1-5 PHONO1-3

8、 RETURN -50dBm(2.45mV) -50dBm(2.45mV) -20dBm(77.5mV) (GAIN = max) +4dBm(1.23V) (GAIN = min) -55dBm(1.38mV) (GAIN = max) -31dBm(22mV) (GAIN = min) -10dBm(245mV) -10dBm(245mV) -10dBm(245mV) 0dBm(775mV) (GAIN = max) +24dBm(12.3V) (GAIN = min) -35dBm(13.8mV) (GAIN = max) -5dBm(138mV) (GAIN = min) +10dBm

9、(2.45V) 2.2k 2.2k 22k 50k 100k XLR-3-31 TYPE(UNBAL) 1/4TRS PHONE(UNBAL) 1/4TRS PHONE(UNBAL) RCA RCA 1/4 PHONE Output SocketRated Output Level - Non-Clip Max, OutputOutput ImpedanceType of Connectors MASTER OUT SEND OUT SAMPLER OUT PHONES * 0dBm=0.775 Vrms*1: Both Channels 33 Loaded +4dBm (1.23V) 0 d

10、Bm (0.775V) -10dBm (245mV) -10dBm (245mV) +20dBm (7.75V) +16dBm (4.89V) +10dBm (2.45V) +10dBm (2.45V) 1W+1W *1 300 2.2k 2.2k 2.2k 10 1/4 PHONE RCA 1/4 PHONE RCA 1/4 STEREO PHONE RadioFans.CN 收音机爱 好者资料库 2 May, 1998DJ-2000 PANEL LAYOUT PARTS LIST No.PART No.PART NAME q01451045LED(GREEN) LN31GPH-(TA5)

11、w01451089LED(RED) LNJ801RFDAE e01451056LED(GREEN) LNJ309GKGAH r01451090LED(RED) LNJ809RKDAH t01451078LED(YELLOW) LNJ409YKXAH y01451067LED(YELLOW) LN41YPH-(TA5) u0145111212M/M ROTARY POT. EVJY96FB6B24 01341267J R-KNOB SF(BLK/RED) i0145110112M/M ROTARY POT. EVJY95FB6A15 01341267J R-KNOB SF(BLK/RED) o0

12、145112312M/M ROTARY POT. EVJY95FB6B54 01341267J R-KNOB SF(BLK/RED) !00145115612M/M ROTARY POT. EVJY15FB6A24 01341267J R-KNOB SF(BLK/RED) !1014511679M/M ROTARY POT. EVUF2KFK3C15 01341267J R-KNOB SF(BLK/RED) !2014511789M/M ROTARY POT. EVUF3KFK3B24 01341267J R-KNOB SF(BLK/RED) !30145113414M/M ROTARY PO

13、T.RK14K12D (TKO05 A-3) 01452423J R-KNOB MF BLK RED !40145477811M/M ROTARY POT.RK11K114 (TKO10 A-1) 01452423J R-KNOB MF BLK RED !50145478911M/M ROTARY POT.RK11K114 (TKO10 A-2) 01341267J R-KNOB SF(BLK/RED) !601454767ROTARY SWITCH SRBV16-F0020-11 01341267J R-KNOB SF(BLK/RED) !715029350LED(GREEN/RED) LN

14、11WP23 !801454745LED(RED) LNJ808RKDAG !901454734LED(GREEN) LN38GPX-(TA7) 001457167LED(RED) LNJ208R8ARA 01455489SW HOLDER 01455490RUBBER SWITCH 101454712LED(SEGMENT) LN534RAMR 01455501DISPLAY COVER 20145118960M/M SLIDE POT. EWAQ36D20A14 01455423POT DUST COVER L 01452412J S-KNOB L BLK RED 30145119060M

15、/M SLIDE POT. EWAQ1GD20A14 01455423POT DUST COVER L 01452412J S-KNOB L BLK RED 40145120145M/M SLIDE POT. EWAP36D20A14 01455412POT DUST COVER S 01452412SLIDER KNOB(BLK/RED) J S-KNOB L BLK RED 50145420145M/M SLIDE POT. EWAP37D15G54 01455412POT DUST COVER S 01452412SLIDER KNOB(BLK/RED) J S-KNOB L BLK R

16、ED 601348978LEVER SWITCH LS001-D22BAB-LFA15B 01455401DUST COVER 701348990LEVER SWITCH LS001-C23OAB-LFA15B 01455401DUST COVER 801348989LEVER SWITCH LS001-D42BBB-LFA15B 01455401DUST COVER 901452812PUSH SW/KEY TOP PS009-PSH022BBT-PA5.5W #013129375PUSH SW SPEA12 22495521BUTTON #101451301PUSH SW SPEA52-*

17、 (TKO05 A-5) 22495521BUTTON #201454723PUSH SW SWITCH ESB64620 22495572F S-BUTTON BX MCG #3005692786.5MM JACK LGR4609-7000 22150756JACK NUT 2 #401455223FRONT PANEL #501455278CROSSFADER PANEL #601455290EFFECT PANEL #701347734SEESAW SWITCH MSR5-2#1 6A/250V #823425740AC INLET INL-8 10A/125V 2P PO #90145

18、5245BOTTOM COVER 22355160FOOT D25 (BASE) $0134492836.5MM JACK HLJ7101-01-3010 $113449645RCA PIN JACK YKC21-3049 $2005692786.5MM JACK LGR4609-7000 $301239890XLR CONNECTOR CANNON NC3FAH2-0 $413429672MIDI JACK YKF51-5047 $501348889GROUNDING TERMINAL MT-903C $601455234BOTTOM CHASSIS RadioFans.CN 收音机爱 好者

19、资料库 3 LOCATION OF CONTROLS DJ-2000 May, 1998 RadioFans.CN 收音机爱 好者资料库 4 May, 1998DJ-2000 EXPLODED VIEW PARTS LIST SAFETY PRECAUTIONS: The parts marked have safety-related characteristics. Use only listed parts for replacement. ! CONSIDERATIONS ON PARTS ORDERING When ordering any parts listed in the p

20、arts list, please specify the following items in the order sheet. QTY PART NUMBER DESCRIPTION MODEL NUMBER Ex. 10 22575241 Sharp Key C-20/50 15 2247017300 Knob (orange) DAC-15D Failure to completely fill the above items with correct number and description will result in delayed or even undelivered r

21、eplacement. 5 NOTE:The parts marked # are new (initial parts) CASING #01455223FRONT PANEL #01455234BOTTOM CHASSIS #01455245BOTTOM COVER 22355160FOOTD25 #01455278FADER PANELCROSS FADER #01455290EFFECT PANEL #01455501DISPLAY COVER CHASSIS #01455256TRANS HOLDERPS ASSY #01455489SW HOLDEREFFECT ASSY 0078

22、2734IC HOLDERPS ASSY KNOB, BUTTON 01341267J R-KNOB SF BLK/RED GAIN, EQ, MIC2, RETURN, MONITOR, CH SELECT, EFFECT BAL 01452423J R-KNOB MF BLK REDISOLATOR, RATE, PITCH, FORMANT #01452412J S-KNOB L BLK REDFADER 22495521BUTTONCUE SELECT, METER SELECT 22495572F S-BUTTON BX MCGFREQ RANGE, SYNC TYPE, BPM S

23、YNC #01455490RUBBER SWITCHEFFECT SWITCH #01347734MSR5-2#1 6A/250VSeesaw SWITCH(POWER) #01348978LS001-D22BAB-LFA15BLever SWITCHSW101,SW103,SW201,SW203,SW301,SW303,SW401, SW403 on MX (INPUT, ASSIGN) #01348990LS001-C23OAB-LFA15BLever SWITCHSW701 on MX(ISOLATOR) #01348989LS001-D42BBB-LFA15BLever SWITCHS

24、W702 on MX(SEND SELECT) 13129375SPEA12 2 CIRCUITPush SWITCHSW704 on MX(METER) #01451301SPEA52-* (TKO05 A-5)Push SWITCHSW705 on MX(CUE) #01452812PS009-PSH022BBT-PA5.5WPush SWITCHSW1001-1002 on MX(TRANSFORMER) #01454723ESB64620 Push SWITCHSW1-3 on SWA(FREQ RANGE,SYNC TYPE,BPM SYNC) #01454767SRBV16-F00

25、20-11Rotary SWITCHSW4 on SWB(CH SELECT) JACK, SOCKET 01239890NC3FAH2-0XLR JACKJK6 on JKA(MIC1) 13449645YKC21-3049PIN JACKJK1-2,JK4,JK7 on JKA, JK8 on JKB 13429672YKF51-5047MIDI JACKJK2 on MIDI 00569278LGR4609-7000PHONE JACKJK3,JK5 on JKA, JK1001 on PH(MIC1, MIC2, PHONES) 13449283HLJ7101-01-3010PHONE

26、 JACKJK9-14 on JKB(MASTER, SEND, RETURN) PCB ASSY 71018267DSP BOARD ASSY 71017901MIXER BOARD ASSY 71017934JACK BOARD A ASSY 71017967JACK BOARD B ASSY 71017990PHONES BOARD ASSY 71019190PS-1 BOARD ASSY HI NOTE:Replacement PS BOARD 1 ASSY HI is 230V/240V version exclusive use. When using PS BOARD 1 ASS

27、Y for 100V/117V veision, be sure to make the following modifications. 1. Replace fuse to specific one. When necessary, please order it separatery from PS BOARD 1 ASSY. See TABLE A. TABLE A 100V/117V#12559435SB500 5x20mm 500mA/250V 230V/240V#12559540S504 5x20mm T160mA/250 2. Replace fuse seal to spec

28、ific one. When necessary, please order it separatery from PS BOARD 1 ASSY. See TABLE B. TABLE B 100V/117V#40014389FUSE SEAL UL 500MA 250V 230V240V#40013589FUSE SEAL T160MAL250V 3. Change the check mark on the PWB as shown in fig.1. fig.1 230V/240V 100/11771018478 G 230/24071019190 100V/117V G 100/11

29、771018478 230/24071019190 71017890PS-2 BOARD ASSY ! DJ-2000 May, 1998 EXPLODED VIEW PARTS LIST No.PART NUMBERPART NAME q01455290EFFECT PANEL w01455489SW HOLDER e01455490RUBBER SWITCH r71018278SW BOARD A ASSY t71120867SW BOARD B ASSY y71018267DSP BOARD ASSY u01455256TRANS HOLDER i71017890PS BOARD 2 A

30、SSY o01455645POWER TRANSFORMER UNIVERSAL !071019190PS BOARD 1 ASSY HI NOTE: Replacement PS BOARD 1 ASSY HI is 230V/240V version exclusive use. When using PS BOARD 1 ASSY for 100V/117V veision, be sure to make the following modifications. 1. Replace fuse to specific one. When necessary, please order

31、it separatery from PS BOARD 1 ASSY. See TABLE A. TABLE A 100V/117V#12559435SB500 5x20mm 500mA/250V 230V/240V#12559540S504 5x20mm T160mA/250 2. Replace fuse seal to specific one. When necessary, please order it separatery from PS BOARD 1 ASSY. See TABLE B. TABLE B 100V/117V#40014389FUSE SEAL UL 500MA

32、 250V 230V240V#40013589FUSE SEAL T160MAL250V 3. Change the check mark on the PWB as shown in fig.1. fig.1 230V/240V100V/117V 100/117 71018478G 100/117 71018478 G 230/240 71019190230/240 71019190 !1*CROSSFADER UNIT CFX-1 NOTE: CROSS FADER UNIT CFX-1 is consumable goods. When necessary,please replace

33、with the Cross Fader for replacing the DJ-2000(CFX-1;Optionally available. !201455223FRONT PANEL !301455234BOTTOM CHASSIS !401347734SEESAW SWITCH MSR5-2#1 6A/250V !571017990PHONES BOARD ASSY !671017901MIXER BOARD ASSY !771120889MIDI BOARD ASSY !871017934JACK BOARD ASSY A !971017967JACK BOARD ASSY B

34、001455245BOTTOM COVER 122355160FOOT D25 212159799EDGE HOLDER No.PART NUMBERPART NAME 40239889TRUSS BUTTON HEAD SCREW S-TITE M3*6 BZC 40239890TRUSS BUTTON HEAD SCREW S-TITE M4*8 BZC 22150756JACK NUT 2 40015967FLAT TAPTITE S 3*6 BZC 40011312BINDING TAPTITE P 3*8 BZC 40011934INTERNAL TOOTH WASHER M9 ZC

35、 40016756JACK NUT HLJ0999-01-360 HEX M1240016712 40016712JACK WASHER 12*18*0.6 BZC 40011490PAN MACHINE SCREW W/SW M3*6 BZC 40011101BINDING TAPTITE B 3*8 BZC 40011090BINDING TAPTITE B 3*6 BZC 40013056PAN MACHINE SCREW W/SW+SMALL PW M3*6 ZC 22150524BOSS NUT M3/M3 L8 40017934PAN MACHINE SCREW W/SW+PW M

36、3*6 ZC 40011056BINDING TAPTITE B 3*6 ZC 40012289BINDING TAPTITE B 3*16 ZC 40012867PAN MACHINE SCREW W/SW+PW M3*8 ZC 01458590BOSS NUT M3/M3 L8.5 22153526BOSS NUT M3/M3 L12 MB=MAIN BOARDIB=IF BOARDSCB=SCSI BOARD SB=SW BOARDEB= ENC BOARD G 6 FUSE, FUSE HOLDER 12559435SB 500 500MA/250VFUSE 5x20 500mA/25

37、0Vfor 100V/117V 12559540S504 160MA T160MAL250VFUSE 5x20 T160mA/250Vfor 230V/240V 12189823CNT47-0003AFUSE HOLDERon PS1 CONNECTOR 1336992553253-0310 CONNECTORCN3 on PS2, CN6 on JKA, CN1002 on PH 1336992653253-0410 CONNECTORCN5 on PS2 1336992953253-0710CONNECTORCN704 on MX, CN2 on PS2 1336993253253-101

38、0CONNECTORCN4 on PS2 1336993453253-1210CONNECTORCN701 on MX, CN3 on JKB 1336993953254-0310CONNECTORCN9 on DSP 1336994053254-0410CONNECTORCN1 on DSP, CN11 on SWA 1336994253254-0610CONNECTORCN8 on DSP 1336994353254-0710 CONNECTORCN10 on SWB #1336994653254-1010CONNECTORCN4 on DSP 1342930151048-1200CONN

39、ECTORCN1 on PS2, CN6 on TR 13369669S9B-PH-K-SCONNECTORCN1001 on CF #01456567IL-FPC-10SL-NCONNECTORCN7 on DSP, CN7 on SWB 13379157IL-FPC-16SL-NCONNECTORCN2 on DSP, CN13 on SWA #01120345IL-FPC-28SL-NCONNECTORCN7 on JKA #01120356IL-FPC-28ST-NCONNECTORCN712 on MX WIRING, CABLE #0145499012X180-P2.0-51065

40、-51065-FWIRING(MX to JKB) #0145501210X200-P2.0-51065-51065-FWIRING(PS2 to DSP) #014550677X180-P2.0-51065-51065-FWIRING(PS2 to MX) #014550783X180-P2.0-51065-51065-FWIRING(PS2 to JKA) #015609904X200-P2.0-51065-51065-FWIRING(PS2 to SWA) #015657673*270-P2.0-51065-51015-RWIRINGon MX (to PH) #014550349X15

41、0-P2.0-PH-51015-FWIRINGon MX (to CF) #0156094510X50-A5.0 BBR-P1.25-HBL8FUJI CARD(DSP to SWB) #0156096716X50-A5.0 BBR-1.25-HBL8FUJI CARD(DSP to SWA) #0156097828X200-A6.0 BBR-P1.25-HBL10FUJI CARD(MX to JKA) #01455089W7WIRINGon MX (to DSP and SWB) #01455101W8WIRINGon PS1 (to Power SW), Black #01455134W

42、9WIRINGon PS1 (to Power SW), Brown #01561012W11WIRINGon PS1 (to Power Trans), Brown #01561023W12WIRINGon PS1 (to Power Trans), White #01672734W13WIRINGon MIDI (to DSP) 0089073412X100-P2.0RIBON CABLEon PS2 and TR TRANSFORMER #0145564501455645U0 UNIVERSALPOWER TRANSFORMER AC INLET 23425740INL-8 10A/12

43、5V 2P POAC INLETJK1 on PS1 SCREW 40011090Binding Taptite B 3x6 BZC 40011101Binding Taptite B 3x8 BZC 40012289Binding Taptite B 3x16 ZC 40011056Binding Taptite B 3x6 ZC 40011312Binding Taptite P 3x8 BZCfor XLR, Pin Jack, MIDI Jack, AC INLET #40239889Button-Trus Taptite S M3x6 BZC #40239890Button-Trus

44、 Taptite S M4x8 BZC 40015967Flat Taptite S 3x6 BZCfor Crossfader Unit 40011490Sems Screw M3x6 BZC 40013056Pan Machine Screw W/SW+Small PW M3*6 ZC 40017934W Sems Screw M3x6 ZC 40012867W Sems Screw M3x8 ZC 22150756JACK NUT 2for Headphones Jack #22150524BOSS NUT M3/M3 L8 #22153526BOSS NUT M3/M3 L12EFFE

45、CT ASSY #01458590BOSS NUT M3/M3 L8.5EFFECT ASSY 40011789Hex Nut M3 ZCfor Phono Earth 40016712Jack Washer 12x18x0.6 BZC 40016756Jack Nut HLJ0999-01-0360 M12 40011878External Tooth Washer M3 ZCfor Phono Earth 40011934Internal Tooth Washer M3 BZCfor XLR Gnd PACKING #01455456PACKING CASEfor Packing #015

46、61534UPPER PAD #01561545SUB PAD #01561556BOTTOM PAD #01561567SIDE PAD #40123401VINYL BAG 0.05*600*460 MISCELLANEOUS #01455267HEATSINKPS ASSY 12159799EHS-11UEDGE HOLDERPS ASSY #01348889MT-903CGROUNDING TERMINALPhono Earth 12199584M1698 GROUNDING TERMINALTER1-2 on MIDI 01569934VR SPACEREFFECT ASSY #01

47、455401DUST COVER SWSW MASK #01455412POT DUST COVER SMASTER/CROSS FADER MASK #01455423POT DUST COVER LCH FADER MASK 40016523Inshlock Tie 100mm T-18R #40014389FUSE SEAL UL 500MA 250Von PS1 for 100V/117V #40013589FUSE SEAL T160MAL250V #397on PS1 for 230V/240V ACCESSORIES(Standard) #71018234OWNERS MANUA

48、L SET Japanese #71018723OWNERS MANUAL SET English 13499219DC-382-J01 VFF2PAC CORD SET 100V 13499220UC-713-J01 SJT2P18AWG60AC CORD SET 120V 13499221EC-511-E07 H03VVH2-F 2PAC CORD SET 230V 13499222SC-078-J02 ES206-75HMAAC CORD SET 240VA 00905234ECP01-5AEURO CONVERTER PLUGfor 230V E ! DJ-2000 May, 1998

49、 NOTE:PS-2 BOARD ASSY includes TRANS BOARD ASSY. 71120889MIDI BOARD ASSY 71018278SW BOARD A ASSY 71120867SW BOARD B ASSY *CROSS FADER UNIT CFX-1 NOTE: CROSS FADER UNIT CFX-1 is consumable goods. When necessary,please replace with the Cross Fader for replacing the DJ-2000. (CFX-1;Optionally available) IC #01340078HD6433040SA00FIC CPUIC2 on DSP 01236401TMS57070FFTIC DSPIC3 on DSP 01126767UDA1309H IC AD