Roland Juno-D Service Manual 电路图.pdf

《Roland Juno-D Service Manual 电路图.pdf》由会员分享，可在线阅读，更多相关《Roland Juno-D Service Manual 电路图.pdf（36页珍藏版）》请在收音机爱好者资料库上搜索。

1、 Full-scale revision Second Edition There were many mistakes in the Service Note issued in September,2004. So, we correct all the mistakes and issue the Service Note as Second Edition. Please dispose of the old one and use the Second Edition. SERVICE NOTES Issued by RJA Copyright 2005 ROLAND CORPORA

2、TION All rights reserved. No part of this publication may be reproduced in any form without the written permission of ROLAND CORPORATION. Printed in Japan (0450) (TP)17058273E1 Sep.2004 (Nov.2005)JUNO-D TABLE OF CONTENTS CAUTIONNARY NOTES .2 SPECIFICATIONS.2 LOCATION OF CONTROLS.4 LOCATION OF CONTRO

3、LS PARTS LIST . 5 EXPLODED VIEW 1 . 6 EXPLODED VIEW PARTS LIST 1 . 7 EXPLODED VIEW 2 .8 EXPLODED VIEW PARTS LIST 2 .9 PARTS LIST .10 CHECKING THE VERSION NUMBER.12 USERS DATA SAVE AND LOAD.12 TEST MODE.12 FACTORY RESET INSTRUCTIONS .15 SYSTEM SOFTWARE UPDATING INSTRUCTIONS.16 BLOCK DIAGRAM 1.8 CIRCU

4、IT BOARD (MAIN) .20 CIRCUIT BOARD (MAIN) .22 CIRCUIT DIAGRAM (MAIN 1/4) .24 CIRCUIT DIAGRAM (MAIN 2/4) .26 CIRCUIT DIAGRAM (MAIN 3/4) .28 CIRCUIT DIAGRAM (MAIN 4/4) .30 CIRCUIT BOARD (PANEL R/PANEL L/PS) .32 CIRCUIT DIAGRAM (PANEL R/PANEL L/PS). 34 ERROR MESSAGES.36 SERVICE INFORMATION .36 RadioFans

5、.CN 收音机爱 好者资料库 R E V I S I O N I N F O R M A T I O N 2 0 0 6 / 1 0 / 3 0 P . 8 - 9 T y p e s o f s c r e w s w e r e r e v i s e d . 2 Sep.2004 (Nov.2005) CAUTIONNARY NOTES User data status User data status after each of the following processes is described below. Whenever carrying out procedures th

6、at involve deleting or erasing user data, always be sure to back up the user data to some form of external media (refer to Saving and Loading Data). * Executing Test Mode during Factory Reset deletes the user data. PARTS LIST Due to one or more of the following reasons, parts with parts code * canno

7、t be supplied as service parts. Part supplied only as a component in a complete assembly Copyright does not permit the part to be supplied Part is sold commercially SPECIFICATIONS JUNO-D: Synthesizer Keyboard (conforms to General MIDI 2 System) Keyboard 61 keys (with velocity) Sound Generator Maximu

8、m Polyphony 64 voices Parts 16 * Two Tones can be assigned to each part (Patch), and can be split or layered. Wave Memory 32M bytes (16-bit linear equivalent) Preset Memory Original Tones: 640 Patches: 640 (JUNO-D original: 384, General MIDI 2: 256) Rhythm Sets: 20 (JUNO-D original: 11, General MIDI

9、 2: 9) Performances: 32 User Memory Patches: 128 * Two Tones can be assigned to each Patch. Rhythm Sets: 2 Performances: 8 Effects Multi-Effects: 47 types Reverb: 8 types Chorus: 8 types Rhythm Guide Preset Patterns: 32 Tempo: 5300 BPM (with tap tempo function) Multi-Chord Memory Preset Chord Sets:

10、16 * 12 chord forms are assigned to each set. User Chord Sets: 8 * 12 chord forms can be assigned to each set. Phrase/Arpeggio Templates: 342 User Templates: 8 Styles (Variations): 473 Controllers D Beam Controller: 1 Pitch Bend/Modulation Lever: 1 Control Knobs: 5 Display 20 characters, 2 lines (Ba

11、cklit LCD) Connectors Output Jacks (L/MONO, R) Headphones Jack MIDI Connectors (IN, OUT) Hold Pedal Jack Control Pedal Jack Power Supply DC 9 V (AC Adaptor) Current draw 1000 mA Dimensions 1021 (W) x 292 (D) x 103 (H) mm 40-1/4 (W) x 11-1/2 (D) x 4-1/16 (H) inches Weight 5.0 kg/11 lbs 1 oz (excludin

12、g AC adaptor) Accessories Owners Manual English (#03675101) Owners Manual Japanese (#03675090) AC Adaptor ACI-120C (#00905767) AC Adaptor ACI-230C (#01018312) AC Adaptor PSB-1U(R) (#03017356) AC Cord 230V for PSB-1U(R) (#01903356) AC Cord 230V for PSB-1U(R) (#01903367) EURO Converter Plug ECP01-5A (

13、PLUG for 230V) (#00905234) CD-ROM (Editor program for PC/Mac) (#03672656) ProcessUser Data Backup Version Preserved Factory ResetDeleted System UpdatePreserved Test ModePreserved RadioFans.CN 收音机爱 好者资料库 3 JUNO-D Options Pedal Switch: DP-2, DP-8 Foot Switch: BOSS FS-5U Expression Pedal: EV-5 MIDI Imp

14、lementation English (#17041498) MIDI Implementation Japanese (#17041499) *In the interest of product improvement, the specifications and/or appearance of this unit are subject to change without prior notice. RadioFans.CN 收音机爱 好者资料库 4 Sep.2004 (Nov.2005) LOCATION OF CONTROLS fig.panel-r fig.panel-l f

15、ig.rear 1 2 33 4 5 4 334 7 334 334334 8 8 9 9 9 9 9 9 4 4 9 9 6 19 33 33 4 4 10 7 4 4 4 4 121212 1313 11 11 11 11 11 11 11 1515151515 16 17 18 14 5 JUNO-D LOCATION OF CONTROLS PARTS LIST NoPART CODECATEGORYPART NAMEDESCRIPTIONQTY 103126134DIODELED(INFRARED)TLN233 1 02230578MISCELLANEOUSLED SPACERLDS

16、-50R 1 201900612DIODEDIODETPS611 1 12169368MISCELLANEOUSLED SPACERLDS-40B 1 303671756KNOB, BUTTONDS-KEYTOP SX2H-B GRS BY MOONPO 7 02891789SWITCHTACT SWITCHSKRGADD010 H=5.0 14 403120890KNOB, BUTTOND S-KEYTOPSX1H-B GRS 14 02891789SWITCHTACT SWITCHSKRGADD010 H=5.0 14 502455234POTENTIOMETER12M/M ROTARY

17、POT.EVJY15F02B14 1 02452912KNOB, BUTTONJ R-KNOBSF-A BLK/LCG 1 603784489CASINGDISPLAY COVER 1 02453345MISCELLANEOUSLCD HOLDER 1 02908834MISCELLANEOUSLEAF REFLECTOR 1 701783923KNOB, BUTTONN S-KEYTOPMD1H 2 02891789SWITCHTACT SWITCHSKRGADD010 H=5.0 2 801783934KNOB, BUTTONN S-KEYTOPMD2H 1 02891789SWITCHT

18、ACT SWITCHSKRGADD010 H=5.0 2 901783956KNOB, BUTTONN S-KEYTOPMD4H 2 02891789SWITCHTACT SWITCHSKRGADD010 H=5.0 8 1003671767KNOB, BUTTONN S-KEYTOPMX1H 1 02891789SWITCHTACT SWITCHSKRGADD010 H=5.0 1 1101343090MISCELLANEOUSLED SPACER 3 1202891889POTENTIOMETER9M/M ROTARY POT.EVUFEKFK3B14 10KB CC 3 02452912

19、KNOB, BUTTONJ R-KNOBSF-A BLK/LCG 3 1301787545POTENTIOMETER9M/M ROTARY POT.EVUF2KFK3B14 10KB 2 02452912KNOB, BUTTONJ R-KNOBSF-A BLK/LCG 2 1402568867JACK, EXT TERMINALMIDI CONNECTORHDC-052A-12 1 1503347067JACK, EXT TERMINAL6.5MM JACKLGR4609-7000 5 1622365714MISCELLANEOUSCORD HOOK236-714 1 1702341634JA

20、CK, EXT TERMINALDC JACKHTJ-020-05A 1 1812499175KNOB, BUTTONBUTTONJSPUE001A 1 01676512SWITCHPUSH SWITCHSDKLA10200 1 1901343089CASINGESCUTCHEOND-BEAM CONTROLLER ESCT BLK 1 6 Sep.2004 (Nov.2005) EXPLODED VIEW 1 fig.bunkai-1 20 1 3 10 15 9 17 13 12 16 14 18 19 21 11 10 4 5 6 8 7 2 22 22 32 24 282930 26

21、e 27 23 25 31 A detailed KEYBOARD ASSY REAR INSIDE 2 INSIDE 1 BOTTOM 7 JUNO-D EXPLODED VIEW PARTS LIST 1 Parts NoPART CODEPART NAMEDESCRIPTIONQTY 103670890TOP PANEL 1 203671012SIDE PANEL L 1 303671023SIDE PANEL R 1 403234723BENDER UNITPB-H0204 1 503784923PANEL L BOARD ASSYfor SERVICE 1 603784489DISP

22、LAY COVER 1 703784934PANEL R BOARD ASSYfor SERVICE 1 803784534INSULATING SHEET 1 940122812NITTO ACETATE TAPE #5 BLACKW15MM 30M (CM) 10 1003671278METAL HOLDER SIDE PANEL 2 1103784545KEYBOARD ASSY 1 NOTE: KEYBOARD ASSY includes the following parts. 2303786378NATURAL KEY Cfor MSK-2 5 03786389NATURAL KE

23、Y Dfor MSK-2 5 03786390NATURAL KEY Efor MSK-2 5 03786401NATURAL KEY Ffor MSK-2 5 03786412NATURAL KEY Gfor MSK-2 5 03786423NATURAL KEY Afor MSK-2 5 03786434NATURAL KEY Bfor MSK-2 5 03786445NATURAL KEY Cfor MSK-2 1 2403786456SHARP KEYfor MSK-2 25 2503786312KEY FELT AMSK-2 HOOK T2.5MM L870XW5.5 1 26034

24、56967COILED SPRINGMSK-1 NATURAL KEY 36 03456978COILED SPRINGMSK-1 SHARP KEY 25 2703786301KEY FELT BMSK-2 BACK T3.0MM L840XW6.0 1 2803456856RUBBER SW KETBOARD 12Pfor MSK-1 4 03456867RUBBER SW KETBOARD 13Pfor MSK-1 1 2903786356PWB KEYBOARD HI ASSYfor MSK-2 1 03786345PWB KEYBOARD LOW ASSYfor MSK-2 1 30

25、*CHASSIS KEYBOARDfor MSK-2 1 3103786334KEY FELT CMSK-2 BOTTOM M T2.5MM L840XW10 1 3203786323KEY FELT DMSK-2 BOTTOM L T2.5MM L840XW15 1 1203671734METAL HOLDER KEY BRACKET B 1 1303671723METAL HOLDER KEY BRACKET A 2 1403784945PS BOARD ASSYfor SERVICE 1 1503784912MAIN BOARD ASSYfor SERVICE 1 1603784501M

26、ETAL CONNECT PLATEfor PS BOARD 1 1703671090METAL CONNECT PLATEfor MAIN BOARD 2 1803671290REINFORCE BAR 1 1903670901BOTTOM CASEW/FOOT 1 2012359137FOOT 4 2122365714CORD HOOK 1 2202452912J R-KNOBSF-A BLK/LCG 6 8 Sep.2004 (Nov.2005) EXPLODED VIEW 2 fig.bunkai-2 REAR BOTTOM INSIDE 1 INSIDE 2 d abc e h f

27、g g b i f j f bb b i f b f i f 8 9 kk 9 JUNO-D EXPLODED VIEW PARTS LIST 2 Screws NoPART CODEPART NAMEDESCRIPTIONQTY a40011190SCREW 3x6PAN TAPTITE P BZC 2 b40011101SCREW 3x8BINDING TAPTITE B BZC 12 c40454856SCREW M4x10BINDING NI 1 d40011490SCREW M3x6PAN MACHINE W/SW BZC 5 e40011501SCREW M3x8PAN MACHI

28、NE W/SW BZC 5 f40011312SCREW 3x8BINDING TAPTITE P BZC 32 g40567034SCREW 4x20BINDING TAPTITE P BZC 5 h40012345SCREW 4x10BINDING TAPTITE B BZC 5 i40011423SCREW M3x6PAN MACHIN W/SW ZC 6 j40011090SCREW 3x6BINDING TAPTITE B BZC 15 d 40342712 SCREW M3X6, PAN MACHINE W/SW+SMALL PW BZC 5 k 40237101 SCREW M3

29、X8, PAN MACHINE W/SW+SMALL PW BZC 2 4 10 Sep.2004 (Nov.2005) PARTS LIST fig.part1e SAFETY PRECAUTIONS: The parts marked have safety-related characteristics. Use only listed parts for replacement. NOTE: The parts marked # are new. (initial parts) Due to one or more of the following reasons, parts wit

30、h parts code * cannot be supplied as service parts. Part supplied only as a component in a complete assembly Copyright does not permit the part to be supplied Part is sold commercially The description QTY means a necessary number of the parts per one product. CASINGQTY #03670901BOTTOM CASEW/FOOT 1 #

31、03784489DISPLAY COVER 1 #03671012SIDE PANEL L 1 #03671023SIDE PANEL R 1 #03670890TOP PANEL 1 CHASSIS #03671090METAL CONNECT PLATEfor MAIN BOARD2 #03784501METAL CONNECT PLATEfor PS BOARD1 #03671723METAL HOLDERKEY BRACKET A2 #03671734METAL HOLDERKEY BRACKET B1 #03671278METAL HOLDERSIDE PANEL2 KNOB, BU

32、TTON 02452912SF-A BLK/LCGJ R-KNOB6 12499175BUTTONJSPUE001A1 SWITCH 02891789SKRGADD010TACT SWITCHSW20,SW21,SW22,SW23,SW24,SW25,SW26 ,SW27,SW28,SW29,SW30,SW31,SW32,SW3 3,SW34,SW35,SW37,SW38,SW39,SW40,SW 41,SW42,SW44,SW45,SW46,SW47,SW48,S W49,SW50 on PANEL L BOARD 29 02891789SKRGADD010TACT SWITCHSW2,SW

33、3,SW4,SW7,SW8,SW9,SW10,SW13, SW14,SW15,SW16,SW19 on PANEL R BOARD 12 01676512SDKLA10200PUSH SWITCHSW1 on PS BOARD1 JACK, EXT TERMINAL 03347067LGR4609-70006.5MM JACKJK2,JK3,JK4,JK5,JK6 on MAIN BOARD5 02568867HDC-052A-12MIDI CONNECTORJK1 on MAIN BOARD1 02341634HTJ-020-05ADC JACKJK1 on PS BOARD1 BENDER

34、 UNIT 03234723PB-H0204BENDER UNIT1 KEYBOARD ASSY #03784545KEYBOARD ASSYfor SERVICE1 PCB ASSY #03784912MAIN BOARD ASSYfor SERVICE1 NOTE: MAIN BOARD ASSY includes the following parts. 12199584GROUDING TERMINALPCB-12(M3x0.5)TER1,TER2,TER3 on MAIN BOARD3 #03784923PANEL L BOARD ASSYfor SERVICE1 NOTE: PAN

35、EL L BOARD ASSY includes the following parts. 01343089ESCUTCHEON D-BEAM CONTROLLER ESCT BLK 1 # 03671756D S-KEYTOPSX2H-B GRS BY MOONPO5 03120890D S-KEYTOPSX1H-B GRS8 01783923N S-KEYTOPMD1H1 01783934N S-KEYTOPMD2H1 01783956N S-KEYTOPMD4H2 02908834LEAF REFLECTOR1 12169368LED SPACERLDS-40B1 02230578LED

36、 SPACERLDS-50R1 02453345LCD HOLDER1 11 JUNO-D #03784934PANEL R BOARD ASSYfor SERVICE1 NOTE: PANEL R BOARD ASSY includes the following parts. # 03671756D S-KEY TOPSX2H-B GRS2 03120890D S-KEYTOPSX1H-B GRS6 01783923N S-KEY TOPMD1H1 03671767N S-KEY TOPMX1H1 01343090LED SPACER3 #03784945PS BOARD ASSYfor

37、SERVICE1 NOTE: PS BOARD ASSY includes the following parts. 40011501SCREW 3x8PAN MACHINE W/SW BZC1 12199584GROUDING TERMINALPCB-12(M3x0.5)TER1,TER2 on PS BOARD2 22465224HEATSINKfor REGULATOR IC HEATSINKHS1 on PS BOARD1 PCB ASSY DIODE 01900612TPS611DIODEQ17 on PANEL L BOARD1 03126134TLN233LED(INFRARED

38、)LED44 on PANEL L BOARD1 POTENTIOMETER 02455234EVJY15F02B14ROTARY POT.VR6 on PANEL L BOARD1 01787545EVUF2KFK3B14 10KBROTARY POT.VR1,VR5 on PANEL R BOARD2 02891889EVUFEKFK3B14 10KB CCROTARY POT.VR2,VR3,VR4 on PANEL R BOARD3 WIRING, CABLE 023420344x300-P2.0-PHR-PHR-FWIRING1 023435458x150-P2.0-PHR-PHR-

39、FWIRING1 0234381210 x150-P2.0-PHR-PHR-FWIRING1 0223178914PIN P=1.25MM L=120MMFFC1 0323607820PIN P=1.25MM L=140MMFFC1 0323608922PIN P=1.25MM L=380MMFFC1 0323605618PIN P=1.25MM L=280MM (W/SHIELDED FFC)1 SCREW 40011090SCREW 3x6BINDING TAPTITE B BZC15 40011190SCREW 3x6PAN TAPTITE P BZC2 40011490SCREW M3

40、x6PAN MACHINE W/SW BZC5 40011423SCREW M3x6PAN MACHINE W/SW ZC6 40011101SCREW 3x8BINDING TAPTITE B BZC12 40011312SCREW 3x8BINDING TAPTITE P BZC32 40011501SCREW M3x8PAN MACHINE W/SW BZC4 40012345SCREW 4x10BINDING TAPTITE P BZC5 40454856SCREW M4x10BINDING NI1 40567034SCREW 4x20BINDING TAPTITE P BZC5 PA

41、CKING #03784523PACKING CASE1 02561501PAD SIDE L1 02561512PAD SIDE R1 02561523PAD LOWER CENTER1 02561534PAD UPPER CENTER1 MISCELLANEOUS 22365714CORD HOOK1 12359137FOOT4 #03784534INSULATING SHEET1 40122812 NITTO ACETATE TAPE #5 BLACK W15MM 30M (CM)1 40122901 NITTO DUBLE-SIDE TAPE #501F W10MM 20M 20P (

42、CM)1 #03671290REINFORCE BAR1 ACCESSORIES (STANDARD) #03675090OWNERS MANUALJAPANESE1 #03675101OWNERS MANUALENGLISH1 00905756AC ADAPTORACI-100C1 00905767AC ADAPTORACI-120C1 01018312AC ADAPTORACI-230C1 03017356AC ADAPTORPSB-1U(R)1 01903356AC CORD SET 230V1.0M for PSB-1U1 01903367AC CORD SET 240V1.0M fo

43、r PSB-1U1 00905234EURO CONVERTER PLUGECP01-5A(PLUG for 230V)1 #03672656CD-ROM (EDITOR)V1.001 *REGISTRATION CARD LEAFLET USER TOUROKU ANNNAI 1 40232334WARRANTY CARD(JAPAN ONLY)1 12 Sep.2004 (Nov.2005) CHECKING THE VERSION NUMBER 1. While holding down the SYSTEM button, turn on the power. The followin

44、g screen will appear. (Continue holding down the SYSTEM button until the following screen appears.) 2. The CPU and ROM version numbers will be displayed. 3. Please turn off the power, if the version of CPU and ROM is checked. fig.version USERS DATA SAVE AND LOAD Required items A sequencer that can record and play back SMF (e.g., MC-80) MIDI cable USERS DATA SAVE Heres how to back up (save) all settings of the JUNO-D on an external MIDI sequencer. Procedure 1. Use a MIDI cable to connect the JUNO-Ds MIDI OUT to the MIDI IN of your sequencer. 2. Press the PATCH bu