Roland S-MPU64 Midi Processing Unit Service Manual 电路图.pdf

《Roland S-MPU64 Midi Processing Unit Service Manual 电路图.pdf》由会员分享，可在线阅读，更多相关《Roland S-MPU64 Midi Processing Unit Service Manual 电路图.pdf（7页珍藏版）》请在收音机爱好者资料库上搜索。

1、Oct, 1998S-MPU64 TABLE OF CONTENTSPage SPECIFICATIONS1 EXPLODED VIEW2 BLOCK DIAGRAM 3 PARTS LIST 4 TEST MODE5 CIRCUIT BOARD6 CIRCUIT DIAGRAM7 Printed in Japan (AA00) (CR) 1 17059945 Issued by RJA Copyright c 1998 by ROLAND CORPORATION All rights reserved. No part of this publication may be reproduce

2、d in any form without the written permission of ROLAND CORPORATION. SPECIFICATIONS 12341234 432432 IN 1OUT 1 USB USB MIDI MIDI OUTMIDI IN MIDI INMIDI OUT 01459945 USB CONNECTOR YKF45-0002 13429273 MIDI CONNECTOR YKF51-5046 40342234 NYLON RIVET S-3055 13429615 DIN SOCKET TCS5350-01-4151 01345445 LED(

3、RED) L-1384AD/1ID 01567845 LED(GREEN) L-1384AD/1GD 01565345 FLONT PANEL 01565367 BOTTOM CHASSIS 01345445 LED(RED) L-1384AD/1ID 13429273 MIDI CONNECTOR YKF51-5046 40011312 SCREW BINDING TAPTITE P 3x8 S-MPU64 64 Channel MIDI Processing Unit S-MPU64(Super MPU64) : 64 Channel MIDI Processing Unit Connec

4、tors:MIDI Connectors (IN x 4, OUT x 4) USB Connector Power Supply:Bus-powered (Supplied from Computer or USB Hub) Current Draw:150 mA (during operation) under 0.5 mA (Suspend mode) Dimensions:8-5/8 (W) x 3-15/16 (D) x 1- 3/4 (H) inches 218 (W) x 99 (D) x 43 (H) mm Weight:1 lbs 9 oz 0.7 Kg Accessorie

5、s:Super MPU64 Driver Disk (2HD x 1):(01565334) USB Cable (2 m x 1):(01560478) Rubber Feet x 4:(01676412) Owners Manual (ENGLISH/JAPANESE): (71233934) *In the interest of product improvement, the specifications and/or appearance of this unit are subject to change without prior notice. The minimum sys

6、tem requirements for Super MPU64 and Super MPU64 driver are as follows. Please make sure that each requirement is met. Compatible OS:Microsoft Windows98 *Operation on MS-DOSand in an MS-DOSwindow is not guaranteed. Compatible PC:IBM PC/AT and compatibles equipped with USB connectors CPU/Clock:Pentiu

7、mProcessor / 166 MHz or higher Display Resolution /Colors:640 x 480 pixels / 256 color or more Memory(RAM):32 MB or more Hard Disk:1 MB or more *Although Roland has tested numerous configurations, and has determined that on average, a computer system similar to that described above will permit norma

8、l operation of the Super MPU64, Roland cannot guarantee that a given computer can be used satisfactorily with the Super MPU64 based solely on the fact that it meets the above requirements. This is because there are too many other variables that may influence the processing environment, including dif

9、ferences in motherboard design and the particular combination of other devices involved. SYSTEM REQUIREMENTS RadioFans.CN 收音机爱 好者资料库 2 EXPLODED VIEW S-MPU64 Oct, 1998 PARTS No. PART No.Part NameDescription q01565356TOP COVER w71126334MAIN BOARD ASSY(EXG) e01565345FRONT PANEL r01565367BOTTOM CHASSIS

10、t01676412FOOT SETRUBBER FOOT x4 PCS SCREW A40011056SCREW 3x6BINDING B-TIGHT ZC B40011090SCREW 3x6BINDING B-TIGHT BZC C40011312SCREW M3x8BINDING P-TITE FE BZC D40342234NYLON RIVETS-3055 BLACK RadioFans.CN 收音机爱 好者资料库 12345678910111213141516171819202122232425262728 A B C D E F G H I J K L M N O P Q R S

11、 T U 3 IC9 Photo Coupler IC8 Photo Coupler IC7 Photo Coupler RXDTXD IC6 Photo Coupler Address Bus Data Bus IC3 Static RAM IC4 Flash MEMORY RXDTXD IC1 CPU (USB Control) IC10, IC11, IC12, IC13 LED Drivers D+ D- SUB-CPU (MIDI Control) IC2 X1 12MHz S-MPU 64 Block Diagram MIDI IN2MIDI IN3MIDI IN4 MIDI OU

12、T2 MIDI OUT3 MIDI OUT4 MIDI IN1 MIDI OUT112 34 MIDI IN (RED) 1234 MIDI OUT (GREEN)USB (RED) USB BLOCK DIAGRAM S-MPU64 Oct, 1998 RadioFans.CN 收音机爱 好者资料库 PARTS LIST SAFETY PRECAUTIONS: The parts marked have safety-related characteristics. Use only listed parts for replacement. ! CONSIDERATIONS ON PART

13、S ORDERING When ordering any parts listed in the parts list, please specify the following items in the order sheet. QTY PART NUMBER DESCRIPTION MODEL NUMBER Ex. 10 22575241 Sharp Key C-20/50 15 2247017300 Knob (orange) DAC-15D Failure to completely fill the above items with correct number and descri

14、ption will result in delayed or even undelivered replacement. DIODE 01121323DA204U T106ARRAY DIODEDA1,2,3,4 01345445L-1384AD/1IDLEDD1,2,3,4,9 #01567845L-1384AD/1GDLEDD5,6,7,8 CRYSTAL #01340745MA-406 12MHZCRYSTAL RESISTOR 15399373RPC10T 101 JMTL.FILM RESISTORR31 15399381RPC10T 221 JMTL.FILM RESISTOR

15、15399393RPC10T 681 JMTL.FILM RESISTORR22,26,35,43 15399397RPC10T 102 JMTL.FILM RESISTOR 15399401RPC10T 152 JMTL.FILM RESISTORR13 15399421RPC10T 103 JMTL.FILM RESISTOR 15399469RPC10T 105 JMTL.FILM RESISTOR 01018212RR1220Q-330-DMTL.FILM RESISTORR14,15 15399917MNR34J5ABJ103R-ARRAYRA3 15399975RCE9A223JA

16、R-ARRAYRA1,5 CAPACITOR 15359206ECJ2VF1E104ZCERAMIC CAPACITOR 15359368ECUV1H330KGCERAMIC CAPACITORC43 15359384ECUV1H681KGCERAMIC CAPACITORC11 15359448ECJ2VB1H103KCERAMIC CAPACITOR 15359618ECUV1H120JCNCERAMIC CAPACITORC23,24 00907689GRM40F105Z16PTCERAMIC CAPACITORC28,33 15369152ECEV1CA100SRCHEMICAL CA

17、PACITORC1 15369212S0 50CV2R2BSCHEMICAL CAPACITORC15 INDUCTOR,COIL,FILTER 01340834EXCML20A390FERRITE-BEAD SCREWS 40011056BINDING TAPTITE B 3x6 ZCSCREW 40011090BINDING TAPTITE B 3x6 BZCSCREW 40011312BINDING TAPTITE P 3x8 BZCSCREW #40342234NYLON RIVET S-3055 BLACK PACKING CASE #01780167PACKING CASE #01

18、565278PACKING CASE (JAPANESE) #01565289PAD A #01676423PAD B ACCESSORIES #71233934OWNERS MANUAL (ENGLISH/JAPANESE) #01565334DRIVER DISK ENGLISH #01565301DRIVER DISK JAPANESE 01560478CORD USB YAF11-0684 2M 01676412FOOT SET (4P) 4 NOTE: The parts marked # are new (initial parts) CASING #01565356TOP COV

19、ER #01565345FRONT PANEL CHASSIS #01565367BOTTOM CHASSIS SWITCH 01343478TACT SWITCH SKQNAE JACK,SOCKET 13429273YKF51-5046MIDI CONNECTOR 13429615TCS5350-01-4151DIN SOCKET 01459945YKF45-0002USB CONNECTOR PWD ASSY #71126334MAIN BOARD ASSY IC #01672867CPU M38881M2-069FPSUB CPUIC2 #01789978CPU M37640E8FP(

20、DKT01-ES6)CPUIC1 01123289SRAM SRM2B256SLMX55SRAMIC3 01341167LH28F400SUT-NF60FLASH MEMORYIC4 15249116T0 TC7W00F(TE12L)CMOSIC14,17 00127490TC7W08F(TE12L)CMOSIC23 00232634TC7W74F(TE12L)CMOSIC21 15249121TC7W04F(TE12L)CMOSIC20 #15259730T0 TC74HC123AF(EL)CMOSIC10,11,12,13 15259884TC7S08F(TE85L)CMOSIC24 15

21、259885TC7S32F(TE85L)CMOSIC22 #01675023TC74VHC139FT(EL)CMOSIC16 #01675034TC74VHC138FT(EL)CMOSIC15 #01675012M62008FP-600RESET ICIC5 15289125PC-410KT 178PHOTO CUPLRIC6,7,8,9 TRANSISTOR 153091012SA1037KR T146TRANSISTORQ10,11,12,13 153191012SC2412KR T146TRANSISTORQ14,15,16,17 15329503DTA124EK T146TRANSIS

22、TORQ2,4,6,8,9 15329516 DTC114EKT146TRANSISTORQ1,3,5,7 Warning! : There is the possibility that you will burn your hands when you touch Power Supply parts soon after the power supply is turned off. Note: Consider about the natural environment carefully before through the old lithium battery away when

23、 you exchange to the new one. Oct, 1998S-MPU64 5 *Tools required G A personal computer having environment in which S- MPU64 can operate (for further information, refer to the Specification) G USB cable G A pair of tweezers (for grounding) G MIDI cable 1. Entering test mode 1.1 Using tweezers, connec

24、t the pin 5 of IC1 to ground path (hold the tweezers in this way until test 5). 1.2 Connect S-MPU64 to the PC via USB. 1.3 The unit is now in the test mode and turns on all 9 LEDs for a moment. 2. Identifying version The LEDs MID IN (red) and MIDI OUT (green) light for 1-2 seconds to identify the ve

25、rsion as described in the Version Indication table shown below. 3. Testing ICs 3.1 When all ICs are operating correctly All LEDs are lit. 3.2 Indicating failure IC(s) A blinking LED indicates that the device shown in the table below is defective and that the test mode is interrupted. The LED remains

26、 blinking until power is turned off. Turn off power, replace the IC. Re-enter the test mode by repeating step 1. 4. Testing LEDs 4.1 All LEDs turn on and off, from USB to MIDI IN1, one by one at a time. 4.2 All LEDs light. 5. Testing MIDI ports 5.1 Remove the tweezers to disconnect pin 5 of IC1 from

27、 ground reference. 5.2 Connect MIDI INs 1-4 to MIDI OUTs 1-4 in this order, one connection at a time, through a MIDI cable. Corresponding MIDI IN LED should light. MIDI IN and MIDI OUT LEDs (lighting) express the version in a binary number. : on, : off S-MPU64 Oct, 1998 TEST MODEVERSION TABLE Blinki

28、ng LEDDefective device USB (red)CPU (IC2) MIDI IN3 (red)SRAM (IC3): erase, write, read MIDI IN4 (red)Program transfer from flash memory (IC4) to SRAM (IC3) / Ver. 1.00 / Ver. 1.10 / Ver. 1.20 / Ver. 1.30 / Ver. 1.40 / Ver. 1.80 / Ver. 1.90 : : : : 12345678910111213141516171819202122232425262728 A B

29、C D E F G H I J K L M N O P Q R S T U 6 CIRCUIT BOARD MAIN BOARD ASSY (71126334) View from foil side. S-MPU64 Oct, 1998 View from component side. NOTE: There are no following parts in MAIN BOARD ASSY from Serial No. ZL62900. CAPACITOR Q10Q17 RESISTOR R56R67 123456789101112131415161718192021222324252

30、62728 A B C D E F G H I J K L M N O P Q R S T U 7 UIPC IN(1)IN(2)IN(3)IN(4)OUT(1)OUT(2)OUT(3)OUT(4) IPC USB Front SideRearSide MIDI Indicator 0000 046F 006F 7FFF FFFF 807F SFR Internal Internal Interrupt Reserved Vector ROM FFFB FFC9 RAM (Memory Expansion Mode) Reserved 3FFF Flash SRAM M37640E (32kB

31、) (16kB) IPC 07FF (14KB) NotUse 05FF 40-7Fpage (Red) (Red) (Red) (Red)(Green) (Green) (Green) (Green) 1wait 1wait 0wait Boot-SW (Red) 06,07page 08-3Fpage (SSOP) (SSOP) (SSOP) (SSOP) TX2 RESET 12MHZ A10 A9 A8 A7 D2 A1 D0 A5 A2 D1 D4 D0 A3 A2 A4 D4 D3 D2 A3 SPD A5 D3 D5 TX3 A0A6 A0 TX4 D5 D1 A6 A1 A4

32、A7 D6 D7 D7 D6 D4 D5 D1 D2 D3 D0 D6 D7 A5 A2 A7 A9 A10 A8 A4 A6 A1 A0 A3 D0.7 CWR XRD IPCCS IPCINT IPCINT SPDTX1 UDP UDN UDP UDN RAMCS A11 A12A13 A12 A14 A15 A11 A13 A0.15 XRD CWR A13 A12 A11 A10 A9 A8 A7 A6 A5 A4 A3 A2 A1 D0 D1 D2 D3 D4 D5 D6 D7 XFCS XRD A0 BA14 BA15 BA16 BA17 BA18 BA14 BA15 BA16 B

33、A17 BA18 XWR SPDSPD SPDSPD SPDSPD SPDSPD SPD RESET PSAVE RX1RX4RX3RX2 A14 A15XFCS IRST PSAVE WREQ RESET IRST CWR N213056 XWR RX1 TX1 RX2 TX2 RX3 TX3 RXTG1 RXTG2 RXTG3 RXTG4 TXTG1 TXTG2 TXTG3 TXTG4 TXTG1 TXTG2 TXTG3 TXTG4RXTG4 RXTG3 RXTG2 RXTG1 VCHK FBSY FBSY RX4 TX4 TSNS4 CWR 12MHZ D7 D6 D5 D4 D3 D2

34、 D1 D0 TSNS3 TSNS2 TSNS1 EBS WREQ XFCS ULED A15 A11 A14 A13 A12 A9 A10 A14 A15 RAMCS IPCCS TT1 TT2 TT4 TT3 TT1 TSNS1 TT2 TSNS2 TT3 TSNS3 TT4 TSNS4 RESET NSAVE VCHK RESET PUCTL PUCTL NSAVE D D +5 D +5 D D D D +5 D DDD D +5 D D +5 D D +5 D D D +5 D +5 D D D +5 D +5 D D D +5 D D +5 D +5 D D D +5 D D D

35、+5 D D D D +5 D +5 D +5 D D D +5 D D +5 D +5 D D +5 D D D D +5 D D D +5 D D D D D D D D D D D +5 D D D + D3. 3 D +5 D D D +5 D +5 D D +5 D+5 D +5 D+5 D + +5 D + +5 D D +5 D +5 D D +5 D +5 D +5 D +5 D +5 D +5 D +5 D +5 D A ADA +5 D +5 A +5 A +5 D A +5 D D D D +5 D +5 D +5 D D D +5 D D D +5 D D D + D3

36、. 3 D D +5 D D +5 D D D D +5 D D D +5 D DD +5 D +5 D +5 D D D +5 D +5 D DD +5 D +5 D DD +5 D +5 D DD +5 D D D DD D +5 D DDD + D3. 3 D +5 D DD +5 D D + D3. 3 IC6 PC410 64 1 3 5 L1L2 L3L4 L21 L22 L24 IC10C TC74HC123F VCC 16 GND 8 R23 1M R21 1k C30 0.1u R1 220 IC8 PC410 64 1 3 5 L8L9 L10L11 R3 220 IC9

37、PC410 64 1 3 5 R4 220 Q1 DTC114EK 1 23 Q2 DTA124EK 1 32 Q3 DTC114EK 1 23 L15L14 R8 220 R10 220 R9 220 L16 L17 Q4 DTA124EK 1 32 Q6 DTA124EK 1 32 Q5 DTC114EK 1 23 R6 220 IC12C TC74HC123F VCC 16 GND 8 IC11C TC74HC123F VCC 16 GND 8 IC13C TC74HC123F VCC 16 GND 8 C29 0.1u IC12B TC74HC123F A 9 B 10 Q 5 Q 1

38、2 CR 11 R/C 7 C 6 IC12A TC74HC123F A 1 B 2 Q 13 Q 4 CR 3 R/C 15 C 14 IC13B TC74HC123F A 9 B 10 Q 5 Q 12 CR 11 R/C 7 C 6 C10 0.1u C9 0.1u R37 1k X1 MA-40612.000MHz 14C24 12P IC3SRM2B256SLMX55 A14 1 A13 26 A12 2 A11 23 A10 21 A9 24 A8 25 A7 3 A6 4 A5 5 A4 6 A3 7 A2 8 A1 9 A0 10 CS 20 WE 27 OE 22 I/O8

39、19 I/O7 18 I/O6 17 I/O5 16 I/O4 15 I/O3 13 I/O2 12 I/O1 11 VCC 28 VSS 14 R32 10k IC2 M38881M2-069FP A7 49 A6 50 A5 51 A4 52 A3 53 A2 54 A1 55 A0 56 DQ7 58 DQ6 59 DQ5 60 DQ4 61 DQ3 62 DQ2 63 DQ1 64 DQ0 1 W(R/W) 2 R(E) 3 S 4 BM(BM) 5 INTR 6 P16/CTS3 13 P15/CTS2 14 P14/CTS1 15 P13/CLK 16 P11/INT 20 VCC

40、 57 VSS 24 CNVSS 18 RXD3 7 TXD3 8 RXD2 9 TXD2 10 RXD1 11 TXD1 12 P07 25 P06 26 P05 27 P04 28 P03 29 P02 30 P01 31 P00 32 PB7 33 PB6 34 PB5 35 PB4 36 PB3 37 PB2 38 PB1 39 PB0 40 PA7 41 PA6 42 PA5 43 PA4 44 PA3 45 PA2 46 PA1 47 PA0 48 P12 17 P10 21 XIN 22 XOUT 23 RESET 19 R30 10k R47 1k JK5 YKF45-0002

41、 1 2 3 4 10 20 30 40 JK4 YKF51-5046 2 4545 22 45 OUTTHRUIN 12 14 15 19 10 22 24 25 29 20 32 34 35 39 30 40 50 60 70 Q7 DTC114EK 1 23 R11 220 R12 220 Q8 DTA124EK 1 32 L5 L20 R7 220 R5 220 L13 L12 L19 L18 IC7 PC410 64 1 3 5 L6L7 R2 220 JK 3 YKF51-5046 2 4545 22 45 OUTTHRUIN 12 14 15 19 10 22 24 25 29

42、20 32 34 35 39 30 40 50 60 70 IC4 LH28F400SUT-NF60 A17 20 A16 55 A15 3 A14 4 A13 5 A12 6 A11 7 A10 8 A9 9 A8 10 A7 21 A6 22 A5 23 A4 24 A3 25 A2 26 A1 27 A0 31 NC 19 NC 28 NC 29 NC 30 NC 56 CE 32 WE 13 OE 34 BYTE 54 RY/BY 18 RP 14 */DQ15 52 DQ14 50 DQ13 48 DQ12 46 DQ11 42 DQ10 40 DQ9 38 DQ8 36 DQ7 5

43、1 DQ6 49 DQ5 47 DQ4 45 DQ3 41 DQ2 39 DQ1 37 DQ0 35 NC 1 NC 2 NC 11 NC 12 NC 15 NC 16 VPP 17 VCC 43 VCC 44 GND 33 GND 53 C11 680P R20 1k C27 0.1u C28 1.0u C16 0.1u C130.01u C23 12P IC11A TC74HC123F A 1 B 2 Q 13 Q 4 CR 3 R/C 15 C 14 IC10B TC74HC123F A 9 B 10 Q 5 Q 12 CR 11 R/C 7 C 6 IC10A TC74HC123F A

44、 1 B 2 Q 13 Q 4 CR 3 R/C 15 C 14 IC11B TC74HC123F A 9 B 10 Q 5 Q 12 CR 11 R/C 7 C 6 C12 0.1u IC13A TC74HC123F A 1 B 2 Q 13 Q 4 CR 3 R/C 15 C 14 C3 0.1u C22 0.1u R25 1k R34 1k R42 1k R22 680 R26 680 R35 680 R43 680 C31 0.1u C34 0.1u C35 0.1u R24 1M R29 1M R39 1M R45 1M R44 1M R38 1M R28 1MC170.01u C1

45、40.01u C180.01u C190.01uC200.01u C260.01uC250.01u C1 10/16 JK6 NIU 2 1 3 IC14B TC7W00F 5 6 3 IC14C TC7W00F 84 IC14A TC7W00F 1 2 7 Q9 DTA124EK 1 32 R16 1k R17 1k R18 1k R19 1k C50.1uC60.1uC70.1uC40.1u R40 10k IC17A TC7W00F 1 2 7 C32 0.1u IC17C TC7W00F 84 IC17B TC7W00F 5 6 3 R49 3.3k DA1 DA204U 21 3 D

46、A2 DA204U 21 3 DA3 DA204U 21 3 DA4 DA204U 21 3 C39 0.1u L27 L26 C40 0.1u JK1 TCS5350-01-4151 1 4 2 5 3 1 2 3 4 5 9 10 JK2 TCS5350-01-4151 1 4 2 5 3 1 2 3 4 5 9 10 C42 0.1u D2 L-1384AD/1ID 12 D3 L-1384AD/1ID 12 D4 L-1384AD/1ID 12 D1 L-1384AD/1ID 12 D6 L-1384AD/1GD 12 D7 L-1384AD/1GD 12 D8 L-1384AD/1G

47、D 12 D5 L-1384AD/1GD 12 L23 TP1 1 TP61 TP51 IC20D TC7W04F 84 IC21A TC7W74F D 2 CK 1 Q 5 Q 3 PR 7 CR 6 IC22 TC7S32F 1 2 4 53 IC21B TC7W74F VCC 8 GND 4 C46 0.1u C44 0.1u IC20B TC7W04F 35 C49 0.1u IC1 M37640E8FP P61/DQ1 1 P60/DQ0 2 P57/W(R/W) 3 P56/R(E) 4 P55/A0 5 P54/S0 6 P53/IBF0 7 P52/OBF0 8 CNVSS 9

48、 RESET 10 P51/TOUT/XCOUT 11 P50/XCIN 12 VSS 13 XIN 14 XOUT 15 VCC 16 AVCC 17 LPF 18 AVSS 19 P44/CNTR1 20 P43/CNTR0 21 P42/INT1 22 P41/INT0 23 P40/EDMA 24 P87/RTS1 25 P86/CTS1 26 P85/URXD1 27 P84/UTXD1 28 P83/STXD/RTS2 29 P82/SRXD/CTS2 30 P81/SCLK/URXD2 31 P80/SRDY/UTXD2 32 P37/RD 33 P36/WR 34 P35/SY

49、NCOUT 35 P34/PHAIOUT 36 P33/DMAOUT 37 P32 38 P31 39 P30/RDY 40 P17/AB15 41 P16/AB14 42 P15/AB13 43 P14/AB12 44 P13/AB11 45 P12/AB10 46 P11/AB9 47 P10/AB8 48 P07/AB7 49 P06/AB6 50 P05/AB5 51 P04/AB4 52 P03/AB3 53 P02/AB2 54 P01/AB1 55 P00/AB0 56 P27/DB7 57 P26/DB6 58 P25/DB5 59 P24/DB4 60 P23/DB3 61 P22/DB2 62 P21/DB1 63 P20/DB0 64 P74/OBF1 65 P73/IBF1/HLDA 66 P72/S1 67 P71