Yamaha-PM5D mix 电路图.pdf

《Yamaha-PM5D mix 电路图.pdf》由会员分享，可在线阅读，更多相关《Yamaha-PM5D mix 电路图.pdf（646页珍藏版）》请在收音机爱好者资料库上搜索。

1、PM5D/PM5D-RH 1 SERVICE MANUAL PA 011740 Copyright (c) Yamaha Corporation. All rights reserved. PDF-K75301 04.09 HAMAMATSU, JAPAN DIGITAL MIXING CONSOLE CONTENTS SPECIFICATIONS.4 CONNECTOR PIN ASSIGNMENTS .13 PANEL LAYOUT.15 DIMENSIONS.29 CIRCUIT BOARD LAYOUT .30 DISASSEMBLY PROCEDURE.36 LSI PIN DESC

2、RIPTION.71 IC BLOCK DIAGRAM.84 CIRCUIT BOARDS.92 INSPECTIONS. 191/203 SERVICE CHECK PROGRAM . 215/225 PANEL TEST. 235/240 UPDATING THE PROGRAM . 245/246 INSTALLING an OPTION CARD . 247/248 PM5D/PM5D-RH SAVING FILE to a MEMORY CARD . 249/251 INITIALIZING THE PM5Ds INTERNAL MEMORY .253 WARNING MESSAGE

3、S . 254/256 ERROR MESSAGES. 255/257 MIDI IMPLEMENTATION CHART .258 MIDI DATA FORMAT .259 PARTS LIST BLOCK DIAGRAM OVERALL CONNECTOR CIRCUIT DIAGRAM CIRCUIT DIAGRAM PW800W SERVICE MANUAL PSL120 PARTS LIST PM5D:200408- PM5D-RH: 200408- PW800W: 200408- PSL120:200408- DIGITAL MIXING CONSOLE PM5D POWER S

4、UPPLY PW800W POWER SUPPLY LINK CABLE PSL120 OPTION （目次） （総合仕様） （表） （） （寸法図） （） （分解手順） （LSI端子機能表） （IC図） （基板図） （検査） （検査） （） （） （取付） （任意） （PM5D内蔵初期化） （） （） （MIDI） （MIDI） （） （総接続回路図） （回路図） （） RadioFans.CN 收音机爱 好者资料库 PM5D/PM5D-RH 2 LITHIUM BATTERY HANDLING This product uses a lithium battery for memory b

5、ack-up. WARNING :Lithium batteries are dangerous because they can be exploded by improper handling. Observe the following precautions when handling or replacing lithium batteries. Leave lithium battery replacement to qualified service personnel. Always replace with batteries of the same type. When i

6、nstalling on the PC board by soldering, solder using the connection terminals provided on the battery cells. Never solder directly to the cells. Perform the soldering as quickly as possible. Never reverse the battery polarities when installing. Do not short the batteries. Do not attempt to recharge

7、these batteries. Do not disasemble the batteries. Never heat batteries or throw them into fire. ADVARSEL! Lithiumbatteri-Eksplosionsfare ved fejlagtig hndtering. Udskiftning m kun ske med batteri af samme fabrikat og type. levr det brugte batteri tilbage til leverandren. VARNING Explosionsfara vid f

8、elaktigt batteribyte. Anvnd samma batterityp eller en ekvivalent typ som rekommenderas av apparattillverkaren. Kassera anvnt batteri enligt fabrikantens instruktion. VAROITUS Paristo voi rjht, jos se on virheellisesti asennettu. Vaihda paristo ainoastaan laitevalmistajan suosittelemaan tyyppiiin. Hv

9、it kytetty paristo valmistajan ohjeiden mukaisesti. The following information complies with Dutch official Gazette 1995. 45; ESSENTIALS OF ORDER ON THE COLLECTION OF BATTERIES. Please refer to the diassembly procedure for the removal of Back-up Battery. Leest u voor het verwijderen van de backup bat

10、terij deze beschrijving. 電池取扱 注意 電池誤交換爆発危険。交換場合、指定部品使用 。 IMPORTANT NOTICE This manual has been provided for the use of authorized Yamaha Retailers and their service personnel. It has been assumed that basic service procedures inherent to the industry, and more specifically Yamaha Products, are alrea

11、dy known and understood by the users, and have therefore not been restated. WARNING :Failure to follow appropriate service and safety procedures when servicing this product may result in personal injury, destruction of expensive components and failure of the product to perform as specified. For thes

12、e reasons, we advise all Yamaha product owners that all service required should be performed by an authorized Yamaha Retailer or the appointed service representative. IMPORTANT :This presentation or sale of this manual to any individual or firm does not constitute authorization certification, recogn

13、ition of any applicable technical capabilities, or establish a principal-agent relationship of any form. The data provided is belived to be accurate and applicable to the unit(s) indicated on the cover. The research engineering, and service departments of Yamaha are continually striving to improve Y

14、amaha products. Modifications are, therefore, inevitable and changes in specification are subject to change without notice or obligation to retrofit. Should any discrepancy appear to exist, please contact the distributors Service Division. WARNING :Static discharges can destroy expensive components.

15、 Discharge any static electricity your body may have accumulated by grounding yourself to the ground bus in the unit (heavy gauge black wires connect to this bus.) IMPORTANT :Turn the unit OFF during disassembly and parts replacement. Recheck all work before you apply power to the unit. WARNING: CHE

16、MICAL CONTENT NOTICE! The solder used in the production of this product contains LEAD. In addition, other electrical/electronic and/or plastic (Where applicable) components may also contain traces of chemicals found by the California Health and Welfare Agency (and possibly other entities) to cause c

17、ancer and/or birth defects or other reproductive harm. DO NOT PLACE SOLDER, ELECTRICAL/ELECTRONIC OR PLASTIC COMPONENTS IN YOUR MOUTH FOR ANY REASON WHAT SO EVER! Avoid prolonged, unprotected contact between solder and your skin! When soldering, do not inhale solder fumes or expose eyes to solder/ f

18、lux vapor! If you come in contact with solder or components located inside the enclosure of this product, wash your hands before handling food. WARNING Components having special characteristics are marked and must be replaced with parts having specification equal to those originally installed. 印商品、安

19、全維持重要部品。交換場合、安全必指定部品使用。 RadioFans.CN 收音机爱 好者资料库 PM5D/PM5D-RH 3 Take care not to trap your fingers. PM5D PM5D-RH PW800W PSL120 PW800W PW800W （作業中指挟様注意。 ） RadioFans.CN 收音机爱 好者资料库 PM5D/PM5D-RH 4 SPECIFICATIONS 1. General Specifications Sampling Frequency Internal:44.1 kHz, 48 kHz, 88.2 kHz, 96 kHz Exte

20、rnal:44.1 kHz (-10%) to 48 kHz (+6%) 88.2 kHz (-10%) to 96 kHz (+6%) Signal Delay PM5D:Less than 2.3 ms INPUT to STEREO A,B (Fs = 48 kHz) Less than 1.15 ms INPUT to STEREO A,B (Fs = 96 kHz) PM5D-RH:Less than 2.5 ms INPUT to STEREO A,B (Fs = 48 kHz) Less than 1.25 ms INPUT to STEREO A,B (Fs = 96 kHz)

21、 Fader100mm motorized x38 Fader Resolution+10 to -138, - dB (1024 steps/100 mm) Maximum Voltage Gain PM5D:84 dB INPUT1-48 to Each Output PM5D-RH:86 dB INPUT1-48 to Each Output Crosstalk (1kHz)-80 dB Adjacent Input Channels (INPUT1-48) Dimensions1551 x 950 x 283 mm (W x D x H) Net Weight PM5D:98 kg P

22、M5D-RH:97 kg Power Requirements PM5D:480W, DC 24V, 20A (Use PW800W Only) PM5D-RH:528W, DC 24V, 22A (Use PW800W Only) Operation free-air Temperature Range+10C to + 35C Storage Temperature Range-20C to + 60C Included Accessories Owners Manual Gooseneck Lamps x 3 Power Supply PW800W Connection Cable St

23、udio Manager CD-ROM Studio Manager Installation Guide Optional Accessories mini YGDAI cards Power Supply PW800W Power Supply Link Cable PSL120 Connector Analog Input (1-48) Analog Input (ST IN1-4 L,R) XLR-3-31 Type (Balanced) x48 Phantom Power PM5D:+48V DC is supplied to Input by individual mechanic

24、al switch PM5D-RH:+48V DC is supplied to Input by individual software control Pad SwitchPM5D:0/26 dB attenuation Gain Control PM5D:44 dB detented 60 dB to 16 dB (PAD=OFF), 34 to +10 dB (PAD=ON) PM5D-RH:72 dB by software control 62 dB to 10 dB (1 dB step) Peak IndicatorRed LED is lit when post HA lev

25、el reaches 3 dB below clipping Signal IndicatorGreen LED is lit when post HA level reaches 14 dB below nominal Insert (Pre AD converter)PM5D:Out, In (TRS Balanced) Insert SwitchPM5D:On/Off AD Converter24bit linear, 128 times oversampling ConnectorXLR-3-31 Type (Balanced) x8 Phantom PowerPM5D-RH:+48V

26、 DC is supplied to Input by individual software control Gain Control PM5D:44 dB detented 34 dB to +10 dB PM5D-RH:72 dB by software control 62 dB to +10 dB (1 dB step) Peak IndicatorRed LED is lit when post HA level reaches 3 dB below clipping Signal IndicatorGreen LED is lit when post HA level reach

27、es 14 dB below nominal AD Converter24bit linear, 128 times oversampling （総合仕様） （一般仕様） PM5D/PM5D-RH 5 Analog Input (2TR IN ANALOG1,2 L,R) Digital Input (2TR IN DIGITAL1-3) Talkback Input Oscillator STEREO A,B L,R MIX1-24 MATRIX1-8 MONITOR OUT L,C,R, CUE OUT PHONES (x2) Digital Output (2TR OUT DIGITAL

28、1-3) ConnectorXLR-3-31 Type (Balanced) x4 Gain Switch+24 dBu (default) / +18 dBu AD Converter24bit linear, 128 times oversampling Connector AES/EBU XLR-3-31 Type (Balanced) x2 (DIGITAL IN 1,2) SPDIF RCA PIN (DIGITAL IN 3) Sampling Rate Converter On/Off by software control (1:3 and 3:1 maxi- mum inpu

29、t to output sample rate ratio) ConnectorXLR-3-31 Type (Balanced) Phantom Power+48V DC is supplied by software control Gain 50 dB fi xed (pre level control) AD Converter24bit linear, 128 times oversampling Talkback Select TALKBACK IN and selected INPUT1-48 can be used simultaneously Level0 to 96dB (1

30、dB step) On/OffDedicated switch and software control Waveform MODE: Sine Wave 1ch, Sine Wave 2ch, Pink Noise, Burst Noise Sine Waveform: 100Hz, 1kHz, 10kHz RoutingMIX1-24, MATRIX1-8, STEREO A,B (L,R) ConnectorXLR-3-32 Type (Balanced) DA Converter24bit linear, 128 times oversampling ConnectorXLR-3-32

31、 Type (Balanced) DA Converter24bit linear, 128 times oversampling Level ControlAnalog potentiometer ConnectorTRS Level ControlAnalog potentiometer Connector AES/EBU XLR-3-32 Type (Balanced) x2 (DIGITAL OUT 1,2) SPDIF RCA PIN (DIGITAL OUT 3) Sampling Rate Converter On/Off by software control (1:3 and

32、 3:1 maxi- mum input to output sample rate ratio) PM5D/PM5D-RH 6 2. Inputs/Outputs Characteristics Analog Input Characteristics (PM5D) Analog Input Characteristics (PM5D-RH) *1.Sensitivity is the lowest level that will produce an output of +4 dBu (1.23 V) or the nominal output level when the unit is

33、 set to maximum gain. (All faders and level controls are maximum position.) *2.XLR-3-31 type connectors are balanced. (1=GND, 2=HOT, 3=COLD) *3.Phone jacks are balanced. (Tip=HOT, Ring=COLD, Sleeve=GND ) *4.There are switches inside the body to preset the maximum input level. *In these speci cations

34、, 0 dBu = 0.775 Vrms. *All input AD converters are 24bit linear, 128 times (48 kHz) oversampling. *PM5D: +48V DC (phantom power) is supplied to INPUT (1-48) XLR type connectors via each individual switch, and TALKBACK XLR type connectors via software switch. PM5D-RH: +48V DC (phantom power) is suppl

35、ied to INPUT (1-48) and TALKBACK XLR type connectors via master mechanical switch and each individ- ual software switch. Input TerminalsPADGAIN Actual Load Impedance For Use With Nominal GAIN SW *4 Input Level Connector Sensitivity *1 Nominal Max. Before Clip INPUT 1-48 0 -60dB 3k 50-600 Mics equiva

36、lent to a 20 kHz filter with infinite dB/octave attenuation. *Dynamic range is measured with a 6 dB/octave filter 12.7 kHz; equivalent to a 20 kHz filter with infinite dB/octave attenuation. PM5D/PM5D-RH 12 4. Other Functions NameNumberTotal Scene MemoryPreset 1 + User 500501 Input Patch LibraryPres

37、et 1 + User 99 100 Output Patch LibraryPreset 1 + User 99 100 Input Channel LibraryPreset 1 + User 199200 Output Channel LibraryPreset 1 + User 199200 Input EQ LibraryPreset 40 + User 159199 Output EQ LibraryPreset 3 + User 196199 GATE LibraryPreset 4 + User 195199 COMP LibraryPreset 36 + User 16319

38、9 Effect LibraryPreset 54 + User 145 199 GEQ LibraryPreset 1 + User 199200 HA LibraryPreset 1 + User 199200 FunctionParameter PhaseNormal/Reverse MS DecodeOn, S-Gain Attenuator96 to +24 dB HPF Slope= 12 dB/Oct Frequency= 20 Hz to 600 Hz 4Band Equalizer Frequency= 20 Hz to 20 kHz Gain= 18 dB to +18 d

39、B Q= 0.10 to 10.0 Low Shelving (Low Band) High Shelving, LPF (High Band) Type I/Type II InsertInsert Point: Pre EQ/Post EQ/Pre Delay/Post Fader Direct Out Direct Out Point:Pre HPF/Pre EQ/Pre Fader/Post On Noise Gate Type: Gate/Ducking Threshold= 54 dB to 0 dB Attack= 0 msec to 120 msec Hold= 0.02 ms

40、ec to 1.96 sec Decay= 5 msec to 42.3 sec Range= 70 dB to 0 dB Key In:Self Pre EQ/Self Post EQ/Mix21-24/ Ch1-STIN4R (8ch block) Key In Filter: HPF/LPF/BPF Compressor Type:Comp/Expander/Compander H/ Compander S Threshold= 54 dB to 0 dB Ratio= 1:1 to :1 Attack= 0 msec to 120 msec Release= 5 msec to 42.

41、3 sec Gain= 0 dB to +18 dB Knee= Hard to 5 (soft) Input DelayTime= 0.0 msec to 1000 msec FaderLevel: 1024 steps, , 138 dB to +10 dB OnOn/Off DCA Group8 Groups Mute Group8 Groups Mix Send 24 sends Fix/Variable can be set each two mixes Mix Send Point:Pre EQ/Pre Fader/Post On/Post TO ST Level: 1024 st

42、eps, , 138 dB to +10 dB LCR PanCSR= 0% to 100% Surround Pan3-1, 5.1, 6.1 panning support FunctionParameter 8Band Equalizer (Matrix: 4band) Frequency= 20 Hz to 20 kHz Gain= 18 dB to +18 dB Q= 0.10 to 10.0 Low Shelving (Low Band) High Shelving, LPF (High Band) Type I/Type II InsertInsert Point: Pre EQ

43、/Post EQ/Pre Fader/Post On Compressor Type: Comp/Expander/Compander H/Com- pander S Threshold= 54 dB to 0 dB Ratio= 1:1 to :1 Attack= 0 msec to 120 msec Release= 5 msec to 42.3 sec Gain= 0 dB to +18 dB Knee= Hard to 5 (soft) Input DelayTime = 0.0 msec to 1000 msec FaderLevel: 1024 steps, , 138 dB to

44、 +10 dB OnOn/Off DCA Group2 Groups Mute Group8 Groups Mix to Matrix Stereo to Matrix Matrix Send Point: Pre Fader/Post Fader/Post On Level: 1024 steps, , 138 dB to +10 dB Output Port Att0 dB to 9 dB FunctionParameter GEQ31 bands x 12 systems EffectsStereo In/Stereo Out multi effector x 8 systems Lib

45、raries Input Function Output Function Processor （他機能） PM5D/PM5D-RH 13 CONNECTOR PIN ASSIGNMENTS 21334 683537 36 PinSignalPinSignal 1GND35GND 2Input 1-2(+)36Input 1-2() 3Input 3-4(+)37Input 3-4() 4Input 5-6(+)38Input 5-6() 5Input 7-8(+)39Input 7-8() 6Input 9-10(+)40Input 9-10() 7Input 11-12(+)41Input

46、 11-12() 8Input 13-14(+)42Input 13-14() 9Input 15-16(+)43Input 15-16() 10DTR In(+)44DTR In() 11RTS Out(+)45RTS Out() 12GND46GND 13Word Clock In(+)47Word Clock In() 14Word Clock Out(+)48Word Clock Out() 15Control In(+)49Control In() 16Control Out(+)50Control Out() 17GND51ID6 In 18GND52ID6 Out 19Input

47、 17-18(+)53Input 17-18() 20Input 19-20(+)54Input 19-20() 21Input 21-22(+)55Input 21-22() 22Input 23-24(+)56Input 23-24() 23Input 25-26(+)57Input 25-26() 24Input 27-28(+)58Input 27-28() 25Input 29-30(+)59Input 29-30() 26Input 31-32(+)60Input 31-32() 27ID0 In61ID1 In 28ID2 In62ID3 In 29ID4 In63ID5 In

48、30ID0 Out64ID1 Out 31ID2 Out65ID3 Out 32ID4 Out66ID5 Out 33MSB In672Ch/Line In 34FG68FG PinSignalPinSignal 1GND35GND 2Output 1-2(+)36Output 1-2() 3Output 3-4(+)37Output 3-4() 4Output 5-6(+)38Output 5-6() 5Output 7-8(+)39Output 7-8() 6Output 9-10(+)40Output 9-10() 7Output 11-12(+)41Output 11-12() 8Output 13-14(+)42Output 13-14() 9Output 15-16(+)43Output 15-16() 10DTR Out(+)44DTR Out() 11RTS In(+)45RTS In() 12GND46GND 13Word Clock Out(+)