Jvc-KDG-323-Service-Manual(1) 电路图 维修手册.pdf

《Jvc-KDG-323-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Jvc-KDG-323-Service-Manual(1) 电路图 维修手册.pdf（97页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL COPYRIGHT 2005 Victor Company of Japan, Limited No.MA236 2005/12 CD RECEIVER MA236200512 KD-AR270,KD-G220,KD-G227,KD-G321, KD-G322,KD-G323,KD-G324,KD-G325, KD-G326,KD-G327 Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade) TABLE OF CONTENTS 1PRECA

2、UTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-8 2SPECIFIC SERVICE INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-11 3DISAS

3、SEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12 4ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

4、. . . 1-16 5TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-17 Area suffix J - Northern America KD-AR270,KD-G220 Area suffix E - Southern Europe EX - Northern Europe EY - Eastern Europe EU - Turkey KD

5、-G321,KD-G322 Area suffix UI - India KD-G323,KD-G324 Area suffix UT - Taiwan UH - Thailand UN - Indonesia U - Other Areas KD-G325,KD-G326 Area suffix KD-G227,KD-G327 EE - Russian Federation RadioFans.CN 收音机爱 好者资料库 1-2 (No.MA236) SPECIFICATION KD-AR270/KD-G220 Design and specifications are subject to

6、 change without notice. AUDIO AMPLIFIER SECTION Power Output18 W RMS 4 Channels at 4 and or = 1% THD+N Signal to Noise Ratio80 dBA (reference: 1 W into 4 ) Load Impedance4 (4 to 8 allowance) Tone Control Range Bass10 dB at 100 Hz Treble10 dB at 10 kHz Frequency Response40 Hz to 20 000 Hz Line-Out Le

7、vel/Impedance2.5 V/20 k load (full scale) Output Impedance1 k TUNER SECTION Frequency RangeFM87.5 MHz to 107.9 MHz (with channel interval set to 100 kHz or 200 kHz) 87.5 MHz to 108.0 MHz (with channel interval set to 50 kHz) AM530 kHz to 1 710 kHz (with channel interval set to 10 kHz) 531 kHz to 1 6

8、02 kHz (with channel interval set to 9 kHz) FM TunerUsable Sensitivity11.3 dBf (1.0 V/75 ) 50 dB Quieting Sensitivity16.3 dBf (1.8 V/75 ) Alternate Channel Selectivity (400 kHz) 65 dB Frequency Response40 Hz to 15 000 Hz Stereo Separation35 dB Capture Ratio1.5 dB AM TunerSensitivity20 V Selectivity3

9、5 dB CD PLAYER SECTION TypeCompact disc player Signal Detection SystemNon-contact optical pickup (semiconductor laser) Number of channels2 channels (stereo) Frequency Response5 Hz to 20 000 Hz Dynamic Range96 dB Signal-to-Noise Ratio98 dB Wow and FlutterLess than measurable limit MP3 Decoding Format

10、MPEG1/2 Audio Layer 3 Max. Bit Rate: 320 kbps WMA (Windows Media Audio) Decoding FormatMax. Bit Rate: 192 kbps GENERAL Power Requirement Operating VoltageDC 14.4 V (11 V to 16 V allowance) Grounding SystemNegative ground Allowable Operating Temperature0C to +40C (32F to 104F) Dimensions (W H D) Inst

11、allation Size (approx.)182 mm 52 mm 150 mm (7-3/16 2-1/16 5-15/16) Panel Size (approx.)188 mm 58 mm 11 mm (7-7/16 2-5/16 7/16) Mass (approx.)1.2 kg (2.6 lbs) (excluding accessories) RadioFans.CN 收音机爱 好者资料库 (No.MA236)1-3 KD-G227 Design and specifications are subject to change without notice. AUDIO AM

12、PLIFIER SECTION Maximum Power OutputFront45 W per channel Rear45 W per channel Continuous Power Output (RMS) Front17 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total harmonic distortion. Rear17 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total harmonic distorti

13、on. Load Impedance4 (4 to 8 allowance) Tone Control RangeBass10 dB at 100 Hz Treble10 dB at 10 kHz Frequency Response40 Hz to 20 000 Hz Signal-to-Noise Ratio70 dB Line-Out Level/Impedance2.0 V/20 k load (full scale) Output Impedance1 k Frequency RangeFM87.5 MHz to 108.0 MHz AM522 kHz to 1 620 kHz FM

14、 TunerUsable Sensitivity11.3 dBf (1.0 V/75 ) 50 dB Quieting Sensitivity16.3 dBf (1.8 V/75 ) Alternate Channel Selectivity (400 kHz) 65 dB Frequency Response40 Hz to 15 000 Hz Stereo Separation30 dB Capture Ratio1.5 dB AM TunerSensitivity20 V Selectivity35 dB CD PLAYER SECTION TypeCompact disc player

15、 Signal Detection SystemNon-contact optical pickup (semiconductor laser) Number of Channels2 channels (stereo) Frequency Response5 Hz to 20 000 Hz Dynamic Range96 dB Signal-to-Noise Ratio98 dB Wow and FlutterLess than measurable limit MP3 Decoding FormatMPEG1/2 Audio Layer 3 Max. Bit Rate: 320 kbps

16、WMA (Windows Media Audio) Decoding FormatMax. Bit Rate: 192 kbps GENERAL Power RequirementOperating VoltageDC 14.4 V (11 V to 16 V allowance) Grounding SystemNegative ground Allowable Operating Temperature0C to +40C Dimensions (W H D)Installation Size (approx.)182 mm 52 mm 150 mm Panel Size (approx.

17、)188 mm 58 mm 11 mm Mass (approx.)1.2 kg (excluding accessories) RadioFans.CN 收音机爱 好者资料库 1-4 (No.MA236) KD-G321/KD-G322 Design and specifications are subject to change without notice. AUDIO AMPLIFIER SECTION Maximum Power OutputFront50 W per channel Rear50 W per channel Continuous Power Output (RMS)

18、 Front19 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total harmonic distortion. Rear19 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total harmonic distortion. Load Impedance4 (4 to 8 allowance) Tone Control RangeBass10 dB at 100 Hz Treble10 dB at 10 kHz Frequency

19、 Response40 Hz to 20 000 Hz Signal-to-Noise Ratio70 dB Line-Out Level/Impedance2.5 V/20 k load (full scale) Output Impedance1 k Other terminalsSteering wheel remote input TUNER SECTION Frequency RangeFM87.5 MHz to 108.0 MHz AM(MW) 522 kHz to 1 620 kHz (LW) 144 kHz to 279 kHz FM TunerUsable Sensitivi

20、ty11.3 dBf (1.0 V/75 ) 50 dB Quieting Sensitivity16.3 dBf (1.8 V/75 ) Alternate Channel Selectivity (400 kHz) 65 dB Frequency Response40 Hz to 15 000 Hz Stereo Separation30 dB Capture Ratio1.5 dB MW TunerSensitivity20 V Selectivity35 dB LW TunerSensitivity50 V CD PLAYER SECTION TypeCompact disc play

21、er Signal Detection SystemNon-contact optical pickup (semiconductor laser) Number of Channels2 channels (stereo) Frequency Response5 Hz to 20 000 Hz Dynamic Range96 dB Signal-to-Noise Ratio98 dB Wow and FlutterLess than measurable limit MP3 Decoding FormatMPEG1/2 Audio Layer 3 Max. Bit Rate: 320 kbp

22、s WMA (Windows Media Audio) Decoding FormatMax. Bit Rate: 192 kbps GENERAL Power RequirementOperating VoltageDC 14.4 V (11 V to 16 V allowance) Grounding SystemNegative ground Allowable Operating Temperature0C to +40C Dimensions (W H D)Installation Size (approx.)182 mm 52 mm 150 mm Panel Size (appro

23、x.)188 mm 58 mm 11 mm Mass (approx.)1.2 kg (excluding accessories) (No.MA236)1-5 KD-G323/KD-G324 Design and specifications are subject to change without notice. AUDIO AMPLIFIER SECTION Maximum Power OutputFront50 W per channel Rear50 W per channel Continuous Power Output (RMS) Front19 W per channel

24、into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total harmonic distortion. Rear19 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total harmonic distortion. Load Impedance4 (4 to 8 allowance) Tone Control RangeBass10 dB at 100 Hz Treble10 dB at 10 kHz Frequency Response40 Hz to 20 00

25、0 Hz Signal-to-Noise Ratio70 dB Line-Out Level/Impedance2.5 V/20 k load (full scale) Output Impedance1 k TUNER SECTION Frequency RangeFM87.5 MHz to 108.0 MHz AM531 kHz to 1 602 kHz FM TunerUsable Sensitivity11.3 dBf (1.0 V/75 ) 50 dB Quieting Sensitivity16.3 dBf (1.8 V/75 ) Alternate Channel Selecti

26、vity (400 kHz) 65 dB Frequency Response40 Hz to 15 000 Hz Stereo Separation30 dB Capture Ratio1.5 dB AM TunerSensitivity20 V Selectivity35 dB CD PLAYER SECTION TypeCompact disc player Signal Detection SystemNon-contact optical pickup (semiconductor laser) Number of Channels2 channels (stereo) Freque

27、ncy Response5 Hz to 20 000 Hz Dynamic Range96 dB Signal-to-Noise Ratio98 dB Wow and FlutterLess than measurable limit MP3 Decoding FormatMPEG1/2 Audio Layer 3 Max. Bit Rate: 320 kbps WMA (Windows Media Audio) Decoding FormatMax. Bit Rate: 192 kbps GENERAL Power RequirementOperating VoltageDC 14.4 V

28、(11 V to 16 V allowance) Grounding SystemNegative ground Allowable Operating Temperature0C to +40C Dimensions (W H D)Installation Size (approx.)182 mm 52 mm 150 mm Panel Size (approx.)188 mm 58 mm 11 mm Mass (approx.)1.2 kg (excluding accessories) 1-6 (No.MA236) KD-G325/KD-G326 Design and specificat

29、ions are subject to change without notice. AUDIO AMPLIFIER SECTION Maximum Power OutputFront50 W per channel Rear50 W per channel Continuous Power Output (RMS) Front19 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total harmonic distortion. Rear19 W per channel into 4 , 40 Hz to 20

30、000 Hz at no more than 0.8% total harmonic distortion. Load Impedance4 (4 to 8 allowance) Tone Control RangeBass10 dB at 100 Hz Treble10 dB at 10 kHz Frequency Response40 Hz to 20 000 Hz Signal-to-Noise Ratio70 dB Line-Out Level/Impedance2.5 V/20 k load (full scale) Output Impedance1 k TUNER SECTION

31、 Frequency RangeFM87.5 MHz to 108.0 MHz AM531 kHz to 1 602 kHz FM TunerUsable Sensitivity11.3 dBf (1.0 V/75 ) 50 dB Quieting Sensitivity16.3 dBf (1.8 V/75 ) Alternate Channel Selectivity (400 kHz) 65 dB Frequency Response40 Hz to 15 000 Hz Stereo Separation30 dB Capture Ratio1.5 dB AM TunerSensitivi

32、ty20 V Selectivity35 dB CD PLAYER SECTION TypeCompact disc player Signal Detection System Number of Channels Non-contact optical pickup (semiconductor laser) 2 channels (stereo) Frequency Response5 Hz to 20 000 Hz Dynamic Range96 dB Signal-to-Noise Ratio98 dB Wow and FlutterLess than measurable limi

33、t MP3 Decoding FormatMPEG1/2 Audio Layer 3 Max. Bit Rate: 320 kbps WMA (Windows Media Audio) Decoding FormatMax. Bit Rate: 192 kbps GENERAL Power RequirementOperating VoltageDC 14.4 V (11 V to 16 V allowance) Grounding SystemNegative ground Allowable Operating Temperature0C to +40C Dimensions (W H D

34、)Installation Size (approx.)182 mm 52 mm 150 mm Panel Size (approx.)188 mm 58 mm 11 mm Mass (approx.)1.2 kg (excluding accessories) (No.MA236)1-7 KD-G327 Design and specifications are subject to change without notice. AUDIO AMPLIFIER SECTION Maximum Power OutputFront50 W per channel Rear50 W per cha

35、nnel Continuous Power Output (RMS) Front19 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total harmonic distortion. Rear19 W per channel into 4 , 40 Hz to 20 000 Hz at no more than 0.8% total harmonic distortion. Load Impedance4 (4 to 8 allowance) Tone Control RangeBass10 dB at 100

36、Hz Treble10 dB at 10 kHz Frequency Response40 Hz to 20 000 Hz Signal-to-Noise Ratio70 dB Line-Out Level/Impedance2.5 V/20 k load (full scale) Output Impedance1 k TUNER SECTION Frequency RangeFM1/FM287.5 MHz to 108.0 MHz FM365.00 MHz to 74.00 MHz AM(MW) 522 kHz to 1 620 kHz (LW) 144 kHz to 279 kHz FM

37、 TunerUsable Sensitivity11.3 dBf (1.0 V/75 ) 50 dB Quieting Sensitivity16.3 dBf (1.8 V/75 ) Alternate Channel Selectivity (400 kHz) 65 dB Frequency Response40 Hz to 15 000 Hz Stereo Separation30 dB Capture Ratio1.5 dB MW TunerSensitivity20 V Selectivity35 dB LW TunerSensitivity50 V CD PLAYER SECTION

38、 TypeCompact disc player Signal Detection SystemNon-contact optical pickup (semiconductor laser) Number of Channels2 channels (stereo) Frequency Response5 Hz to 20 000 Hz Dynamic Range96 dB Signal-to-Noise Ratio98 dB Wow and FlutterLess than measurable limit MP3 Decoding FormatMPEG1/2 Audio Layer 3

39、Max. Bit Rate: 320 kbps WMA (Windows Media Audio) Decoding FormatMax. Bit Rate: 192 kbps GENERAL Power RequirementOperating VoltageDC 14.4 V (11 V to 16 V allowance) Grounding SystemNegative ground Allowable Operating Temperature0C to +40C Dimensions (W H D)Installation Size (approx.)182 mm 52 mm 15

40、0 mm Panel Size (approx.)188 mm 58 mm 11 mm Mass (approx.)1.2 kg (excluding accessories) 1-8 (No.MA236) SECTION 1 PRECAUTIONS 1.1Safety Precautions ! Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of

41、this system. ! Please use enough caution not to see the beam directly or touch it in case of an adjustment or operation check. (No.MA236)1-9 1.2Preventing static electricity Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destro

42、y the laser diode in the traverse unit (optical pickup). Take care to prevent this when performing repairs. 1.2.1 Grounding to prevent damage by static electricity Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as CD players. Be careful to use proper

43、 grounding in the area where repairs are being performed. (1) Ground the workbench Ground the workbench by laying conductive material (such as a conductive sheet) or an iron plate over it before placing the traverse unit (optical pickup) on it. (2) Ground yourself Use an anti-static wrist strap to r

44、elease any static electricity built up in your body. (3) Handling the optical pickup In order to maintain quality during transport and before installation, both sides of the laser diode on the replacement optical pickup are shorted. After replacement, return the shorted parts to their original condi

45、tion. (Refer to the text.) Do not use a tester to check the condition of the laser diode in the optical pickup. The testers internal power source can easily destroy the laser diode. 1.3Handling the traverse unit (optical pickup) (1) Do not subject the traverse unit (optical pickup) to strong shocks,

46、 as it is a sensitive, complex unit. (2) Cut off the shorted part of the flexible cable using nippers, etc. after replacing the optical pickup. For specific details, refer to the replacement procedure in the text. Remove the anti-static pin when replacing the traverse unit. Be careful not to take to

47、o long a time when attaching it to the connector. (3) Handle the flexible cable carefully as it may break when subjected to strong force. (4) It is not possible to adjust the semi-fixed resistor that adjusts the laser power. Do not turn it. 1.4Attention when traverse unit is decomposed *Please refer

48、 to Disassembly method in the text for the CD pickup unit. Apply solder to the short land before the flexible wire is disconnected from the connector on the CD pickup unit. (If the flexible wire is disconnected without applying solder, the CD pickup may be destroyed by static electricity.) In the as

49、sembly, be sure to remove solder from the short land after connecting the flexible wire. 1M (caption) Anti-static wrist strap Conductive material (conductive sheet) or iron plate Wires Push switch Pickup Base board Pickup Connector Flexible wire Frame CD mechanism assembly 1-10 (No.MA236) 1.5Important for laser products 1.CLASS 1 L