Kenwood-KNADV-3200-Service-Manual 电路图 维修手册.pdf

《Kenwood-KNADV-3200-Service-Manual 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Kenwood-KNADV-3200-Service-Manual 电路图 维修手册.pdf（33页珍藏版）》请在收音机爱好者资料库上搜索。

1、 2003-4 PRINTED IN JAPAN B53-0050-00 (N) 3100 DVD NAVIGATION SYSTEM KNA-DV3100 KNA-DV3200 SERVICE MANUAL KNA-DV3200 KNA-DV3100 Panel assy (A64-3105-03) Panel assy (A64-3106-03) Connecting cord assy (E30-6199-05) Electric circuit module (GPS ANT) (W02-3261-05) Mounting hardware (J21-9867-04) Bracket

2、(J19-5246-04) Screw set (N99-1713-05) DVD (W01-1618-05) : KNA-DV3100 (W01-1619-05) : KNA-DV3200 DC cord assy (E30-4964-05) The DVD mechanism infomation is not in this sarvice manual. Please, refer to sarvice manual X92-4740-00 (B53-0052-00). CAUTION (Repair of NAVI board ) You can not repair IC521 (

3、GPS Receiver) and IC701 (CORE1). If you can repair those parts please change to NAVI board assy(W02-3395-15). RadioFans.CN 收音机爱 好者资料库 KNA-DV3100/DV3200 2 BLOCK DIAGRAM SDRAM 64MB FLASH 2MB SRAM 512kB VEHICLE GPS RF SPD,REV,ILL,PKB GPS GYRO CORE1 A351 IC251,254,255 IC521 IC701 SIGNAL I/F IC752-755 IC

4、781 IC784 DVD MECHANISM RECOGNITION I/F VOICE DISPLAY COMMUNICATION RGB ENCODER OUTPUT I/F VOICE CONTROL REMOTE I/F RS-422 SW MIC an angle of eleva- tion (Elv); azimuth reading (Azm); signal level (Lev) and re- ception state (St). The display areas are secured for the maximum of 8 satel- lites. For

5、the reception state, the appropriate letter is displayed depending on the state. P : When the satellite in question is used for positioning. T : When the satellite in question is spotted but not used for positioning. : When the satellite in question is spotted yet. w Date and time information The da

6、te and time information obtained from the GPS re- ceiver is displayed in : month; day; year; hour; minute; and second. e Position information The current latitude and longitude are displayed in : sign, degree, minute, and second. As for the sign, appropriate letter is displayed according to the cond

7、itions that apply. N : When the latitude is judged to be north latitude. S : When the latitude is judged to be south latitude. W : When the longitude is judged to be west longitude. E : When the longitude is judged to be east longitude. r Positioning condition information Positioning conditions are

8、described in the following five conditions : 2D : When positioning is made on two dimensions. 3D : When positioning is made on three dimensions. NG : When positioning is not possible. error : When reception error takes place. : When conditions other than the above occur. t HDOP The HDOP value at the

9、 time of positioning (accuracy value in the horizontal direction) is displayed in numbers. LSB 01 display areas: 0.099.9 When exceeding 99.9 and when positioning is not con- ducted, is displayed. y The screen returns to the Navigation Information screen. Screen Name : Adjust position screen Function

10、s outline This is the function for adjusting the position to the default coordinate that is registered on the map disk. Screen appearance Yes Map DVD is inserted No Reset RESET POSITION Reset Please insert a map DVD to arrow vehicle position be reset to the current map DVD default. Reset Reset Posit

11、ion Map DVD is inserted RESET POSITION Please press the Reset button to reset the vehicle position to the current map DVD default. 1 1 Make the direction of the vehicle to 0 degree (for east). Adjust the current position. Return to the Navigation Information screen. Display details q The screen retu

12、rns to the Navigation Information screen. TEST MODE KNA-DV3100/DV3200 13 Screen Name : Parts information screen Functions outline Displays the conditions of the parts comprising the naviga- tion system. Displays the map software version of the navigation sys- tem. The data updates are conducted when

13、 the information changes. Screen appearance Disc Information FORMAT_VERSION_KIWI01-06-00 DATA_VERSION_01-00001 PARTS INFORMATION LODER :XXXX NAVI :XXXXGPS :Fitted Traffic system :None DVD :XX.XX 5 2 1 3 4 Display details q Displays the map software version of the software that com- prise navigation

14、system. NAVI : Displays the software version of the software that comprise navigation system. LODER : Displays the kanji ROM version. DVD : Displays the revision level of the DVD player. w Displays the conditions of the devices that comprise the navigation system. GPS: The connection condition of th

15、e GPS system is dis- played by appropriate character sets that corresponds to the condition : Fitted : GPS antenna is connected. None : Conditions other than the above. The type of traffic congestion information service is dis- played by appropriate character sets that corresponds to the condition :

16、 TMC : When a TMC tuner is connected. None : Conditions other than the above. e Format version number Displays the data stored in the “Format Version Number” item in the “Control Frame Data Volume for all data” on the disk. r Data Version Number Displays the data stored in the “Data Version Number”

17、item in the “Control Frame Data Volume for all data” on the disk. t The screen returns to the On-screen diagnostics screen. TEST MODE KNA-DV3100/DV3200 14 ABCDE 1 2 3 4 5 6 7 PC BOARD (COMPONENT SIDE VIEW) C644 C265 R260 R267 R261 C252 C759 C778 R758 R752 C754 C771 R666 R668 C666 R663 C770 1 27 54 2

18、8 1 110 43 1 85 1 1 1 14 23 1 4 1 7 14 8 8 5 1 13 2 3 1 2 4 8 5 8 2417 9 16 32 25 2 4 3 28 21 714 6 20 4 3 1 2 15 14 85 14 2 4 18 5 1 8 16 9 27 1 12 36 3748 2413 25 54 28 C752 C751 C151 R191 R181 R182 R552 R551 R977 C791 R712 R976 R981 R961 R R R R R R R558 C554 C556 RA R R773 L10 C149C150 C762 C779

19、 C761 R652 C663 C662 R331 R601 X601 C328 C330 C327 C842 R691 R690 C684 C627 C619 C846 C824 C540 R815 C804 C543 C840 C546 L523 C525 C522 C521 R817 R804 R801 C810 C814 R816 C820 C807 R525 R522 R521 C535 C534 C531 R530 C529 C528 L803 L802 L801 C955 C811 C812 C803 C819 C818 C844 C822 C835 L522 C533 R531

20、 C527 C526 C212 BAT101 C211 C217 C607 C604R602 R603 R612 C214 X701 C727 R716 R719 C681 C682 C622 C621 C620 L604 R724 R650 C725 R718 C728 C706 C709 R958 C967 R979 R978 R980 RA952 R952 R963 R953 R951 R505 R504C503 RA721 RA720 R956 R964 RA715 RA714 C231 RA951 1 15 30 16 R244 C711 C708 C713 C710 C723 C7

21、24 C721 C722 C720 X702 C731 R733 R732 C767 R737 R736 C750 13 64 R233 C664 BE R653 R654 R655 C645 C647 C641 TP515 C760 C652 R346 R611 R610 C335 R649 C701 C703 C769 C705 C707 C702 C704 R722 R726 R753 R717 C734 C823 L806 C216 C213 123 R347 C661 R664 RA765RA766 RA717 RA718 RA763 C790 RA753 R756 R755 R75

22、1 RA757RA758 R269R268 C780 C552 R557 C753 C774 RA756 RA755 C551 R187 C558 R973 R960 R714 R715 T951 T952 C719 C786 RA719 C845 C843 C542 C539 R190 C536 C537 R535 R528 R526 C532R534 L804 R503 R243 C965 C966 C964 C816 C801 C802 C839 R529 R527 C805 C815 C806 R802 R236 R235 R238R239 R234 R502 1 1 1 3 64 5

23、 131 1 1 1 1 3 3 5 5 4 4 13 5 4 13 5 4 13 5 4 13 5 4 1 13410 3 54 13 5 4 1 1 3 5 4 1 3 5 4 4 BE BE T112 BE T113 BE 4 8 8 5 5 3 5 4 232 119 220 10 C502 C956 C953 C951 C952 C501 R501 C141 L805 F801 R832 R833 R834 C841 R540R539 R541 C530 F521 C523 C524 L521 R532 R533 R542 C718 R237 R518 R517 C232C233 C

24、716 C714 C712 C717 R232 R231 R962 C152 R957 C715 R972 R974 R975 R559 R RA764 C648 C650 C649 C651 R573 R197 R646 TP518 R641 TP517 TP516 C643 R647 C332 1 1 4 8 5 1 4 8 5 3 5 4 15 R648 R651 R194 R193 R196 C646 C642 SW551 CN710 NAVI BOARD (W02-3395-15) CN340 IC256 IC641 IC754 IC751 IC254 IC752 IC952 IC9

25、55 IC501 IC231 D501 IC551 IC307 IC601 T661 IC526 D116 IC809 IC804 CN110 D103 IC410 IC106 D522 IC522 CN800 IC806 IC232 D211 IC642 IC408 IC731 IC956 D113 IC502 IC953 CN140 IC807 IC525 IC523 CN400 CN300 CN320 CN130 D502 IC801 IC954 IC521 IC211 IC606 IC255 13 5 4 KNA-DV3100/DV3200 15 JIHGF 1 2 3 4 5 6 7

26、 R3RESET EJECT R2 R4 1 3 R1 C10 15 23 154 D1 X25 B/2 SWITCH UNIT X25-9742-71 A/2 (J74-1507-22) A10 CN11 S2 CN10 S1 4 3 R181 82 R552 R551 R976 RA558 RA555 RA554 RA553 RA552 RA551 58 C554 C557 C556 RA557 RA556 R773 C555 C553 C162 1 15 1 2 1 2 31 32 31 32 5 C159 C157 C146 L105 L102 C134 R211 C119 I O G

27、 C104 C103 R322 10 6 7 1 C108 C154 L101 L104 C145 C1490 C128 C160 C135 R682 L103 C561 X101 1 15 C107 C552 C148 R557 51 R187 C558 C112 C110 C125 C153 C105 R102 R101 C260C259 C106C102 C101 3 R265 R266 R243 13 IO G 5 4 13 5 4 3 4 13 T112T113 C152 2 4 R559 RA559 R188 150 R185 R186 CN600 CN700 55 IC105 D

28、101 D252 IC107 IC551 CN350 D102 CN100 CN500 D901 CN510 10 6 IC956 D113 IC502 D251D253 NAVI BOARD ICTAddress 1056G 1067E 1075F 2542D 2552D 2562D 5025F 5216B 5226B 5236B 5255B 5265B 5514E 6412C 6423C 7315C 7513D 7523E 7543D 9524E 9546E 9555E 9565E 1124E 1134E Refer to the schematic diagram for the val

29、ues of resistors and capacitors. KNA-DV3100/DV3200 16 KLMNO 1 2 3 4 5 6 7 PC BOARD (FOIL SIDE VIEW) C908 C905C155 R904 C124 R175 R149 C143 R164 TP125 C147 R126 TP114 TP138 R184 R134 R130 C115 C117C123R137 R144 C120 R140 R143 R136R110 R112R115 R106 C258 C262C261 TP104 R179 R180 C142 R172 R171 TP105 T

30、P102 R152 C129 R150 D GS R174R173 R280 C266 C267 R251R252 C131 R154 R203 C257 R105 R108 R122 R132 R124 TP129 TP144 TP124 TP149 TP119 TP152 TP151 BE R204 R205 C161 R207 R240 R157 R209 R123 R119 R713 R168 C140 R170 R166 R167 C139 R169 R176 C144 C121 R145 R141 C122 R156 C133TP110 R139 R138 TP109 R902 8

31、5 1 5 3 1 2 2 53 41 R903 R901 RA905 C903 R120 C136 R162 TP106 R158 R159 R109 R116 R114 R113 R111 R107 R142 R129 R104 C109 C907 C906 RA904 R146 RA907 RA906 R689 R683 R685 R782 C781 R783 TP133 R669 TP135 C156 IO G R161 R160 C137 TP136 R770 C255 R272 R273 R574 C563 TP641C304 R303 C C C765 C789 RA768 C7

32、26 R711 C470 R432 R202TP143 TP146 R429 R189 R183 TP134 TP145 TP139 TP126 TP141 TP127 R206 R208 TP150 C411 C414 C403 C416 C405 C404 C413 C406 C407 C408 C412 C415 C409 C410 C158 R414 R178 TP140 R426 R407 R428 R425 R408 R418 R419 R416 R423 R427 R424 R412 R404 R420 R406 R413 R405 R409 R410 R415 R411 R41

33、7 R401 TP130 TP148 TP121 TP120 C113 C126 R360 R301 C303 RA711 RA713 C787 C794 C795 C764 C763 R778 RA754 RA751 RA759 C C301 R307 C264 R258 R262 R255 R275R274 C256 RA772 R757 R754 C755 C756 C775 C757 RA752 RA760 RA771 RA770RA769 RA761 RA762 TP142 C784 C665C782C783 C785 C127R133 C668 C667 R738 R739 R74

34、0 TP662 RA908 C132 RA903 R155 RA902 TP704 R165 RA901 TP111 TP132TP103 R263R253 R257 R241 R177 R256 R281 R254R259 R242 R192 R151 C130 R153 R147 R148 C251 C263 R264 TP113 TP107 TP101 R117R118 TP131 C111 E B TP108 TP137 R103 C902 C904 R163 R686 R693 R688 R692 R681 C562 R572 C683 R571 R687 R781 R210 R66

35、1 R670 C118R131 C116 R125 C114 R135 R127 R121 R662 R741 TP751 R277 C254 TP642 R361 TP643 C337 R354 C311 R421 R422 C418 TP703 RA716 R771 R905 TP706 TP707 R775 R776 R777 TP708 R431 R430 R516 R515 TP731 TP601 R769 R766 R767 R768 C417 R R720 TP702 TP705 R774 C R310 R311 R309 C308 C309 C307 T F402 R403 C

36、402 C401 R402 F401 Z8 C773 C744 C745 RA767 C 1 18 169 27 8 5 54 28 1 1 44 23 1 1 1 1 17 148 7 14 8 4 8 5 3 5 4 1 1 2 1 3 54 8 5 8 16 9 22 1 1 1 1 2 4 3 14 85 7 14 8 114 85 8 16 9 8 16 9 24 4825 12 13 24 48 37 3625 27 54 28 TP701 TP734 C758 C776 C R352 C C788 C766 C C336 R308 R278 R279 R306 R271 C312

37、 C310 C253 R684 R195 T111 IC902 B E B E B BE EB EB EBEB D551 IC681 IC904 D111 T110 IC901 IC905 IC104 T3 D104 IC101 D105 D108 D107 D301 T101 T103 T104 T106 T105 T102 IC401 IC411 IC109 IC682 IC781 IC661 IC702 IC402 IC403IC405 D401 D403 D114 D115 IC103 IC102 D402 IC110 T109 T114 T404 T401 T403T402 IC40

38、9 IC755 IC701 IC753 IC D781 IC108 IC783 IC784 IC951 IC406 IC251 IC310 IC309 IC301 D112 D106 IC111 IC957 IC407 IC404 D109 D110 T107 T108 IC561 IC782 13 54 13 54 3 13 1 1 4 14 8 45 31 45 31 45 31 45 31 45 31 45 31 13 5 4 13 5 4 13 5 4 45 3 1 45 3 1 45 3 1 45 3 1 45 3 1 8 5 1 4 8 5 1 4 1 7 14 8 NAVI BO

39、ARD (W02-3395-15) TP11 TP10 TP12 TP3 TP1 TP2 X25 B/2 SWITCH UNIT X25-9742-71 A/2 (J74-1507-22) KNA-DV3100/DV3200 17 TSRQP 1 2 3 4 5 6 7 R363 R460 C457 C454 R455 R451 C463 R467 C605 C451 C302 C334 R303 R332 R348 R305 C321 R330 R702 R694 C225 C601 R319 R353 C322 R456 C453 C325 C324 R335 R457 C456 R333

40、 R337 R339 R327 R329 C623 C624 C615 C464 C616 C610 C611 C613 R605 R968 R967 R965 R955 C960 C220 R959 C954 R970 R971 C958R966C961 R546 L601 C625TP661 TP213 R665 R667 C686 L731 C737 C738 C765 TP733 C743 C789 RA768 C741 C740 C742 C726 R711 RA712 TP212 C828 R729 L808 C829 R821 R523 TP522 C472 R831 R803

41、C838 R809 TP802 R836 R543 R829 C836 C834 C837 R825 C544 C541 R549 C548 C549 R550 R536 R547 R548 R304 C306 R362 C305 R302 R537 R823 C833 R820 R822 C831 C827C808 R818 C813 C470 R813 R814 R360 R301 RA711 RA713 C787 C794 C795 C320 BE C319 C736 C224 R699 C685 R336 R696 C331 R341 C329 C333 R344 R345 R466

42、C458 R461 1 TP643 C337 R354 C311 R701 C326 R359 C687 R700 R698 R477 C226 C223 R356 R325 R355 R349 R351 R323 R357 C617 R468 R469 C614 C547 C545 F802 C825 R819 C826 L807 R812 R730 R731 R749 R810 C817 C468 R421 2 731 01 R769 R766 R767 R768 C417 TP804 TP805 C963 C465R470 R793 TP732 C729 R720 702 705 R77

43、4 R721 R723 C747 R725 C748 C730 R465 C461 R835 L809 C832 R824 C221 Z601 TP211 C219 C218 C538 TP521 TP524 TP525 R524 R827 TP807 C471 R474 C469 C821 R830 R826 R828 0 311 08 9 07 R317 R315R316 C318 C316 C317 C315 C314 C313 C338 R358 R806 R807 C809 R805 R837 C848 C847 TP803 R838 TP801 2 C401 R402 F401 R

44、473 C467 R472 R476 R808 Z801 R811 R318 R321 R312 R313 R314 C830 TP808 TP806 TP523 R954 C959 R969 C957C962 R328 R326 R320 R334 R350 C222 R342 R324 C735 C773 C744 C745 RA767 C746 C466 1 27 1 4 8 5 1 4 8 5 1 4 8 5 58 41 58 41 1 4 6 3 1 7 148 34 C772 C739 R352 C732 C788 C766 C733 C336 C459 R463 R343 R33

45、8 R697 R695 R364 C339 R475 C323 R340 C312 C310 BEBE EB EB EB BE IC305 IC311 IC452 T307 T452 T451 T601T313 T311 T301 T317 T315 T302 T309 T319 T305 D552 IC306 IC213 IC303 IC451 IC603 IC527 T306 IC702 IC808 T802 IC454 02 IC803 IC805 IC453 T801 IC212 IC733 IC734 IC304 IC308 D801 IC802 IC524 D521 IC684 I

46、C683 IC455 IC732 IC309 IC302 4 5 3 1 45 3 1 45 3 1 45 31 45 31 1 2 4 3 45 3 1 45 3 1 45 31 13 54 13 54 1 3 6 4 13 64 1 3 6 4 13 64 13 64 13 64 1 1 8 5 1 14 B E 85 4 1 1 7 1 8 16 9 14 8 4 8 5 8 10 9 3 54 45 31 45 31 13 5 4 13 64 45 31 1 4 NAVI BOARD ICTAddress 1015L 1025M 1035M 1044L 1083L 1096N 1117

47、N 2124Q 2512O 3012O 3062P 3092P 3102O 5245Q 5613L 6842P 7015N 7323P 7333P 7344P 7533N 7553O 7814L 7823M 7833L 7844M 9515M 9577N 1016L 1025L 1035L 1045L 1055L 1065L 1075L 1084L 1097N 1105M 1114M 3052P 3064Q 3073Q 3092Q 3192P Refer to the schematic diagram for the values of resistors and capacitors. K

48、NA-DV3100/DV3200 18 UVWXY 1 2 3 4 5 6 7 D12 CN1 D8 Q2Q1 D10 D5 Q8 Q9 D15 J5 J4J3 J6 CN2 J2 J1 DAUGHTER UNIT X89-2622-71 (J74-1508-22) IC3 IC2 IC1 R55 C25 C57 C56 C45 R49 C2 R77 R76 R46 R58 R10 R30 C20 C16 R9 R1 C7 C3 C1 C6 C14 C31 C18 R62 C60 R22C19 R37 R63R14 R11 R6 R15 R67 CP1 W1 C59 R47 R61 C39 4

49、 11 5 5 8 148 1 7 IO G GREENBLACK 1 2 9 10 1 1 2 34 5 1 2 34 5 5 131 322 159 13 1062 3711 1284 R7 EB EB EB EB DAUGHTER UNIT X89-2622-71 (J74-1508-22) Q6 Q3 D9 D7 Q4 D11 D2 D1 D4 D3 Q5 D6 Q7 IC4 R72 R59 L4 C41 R50 R25 R27 R53 R44 C53 C23 R69 C22R68 R20 C42 C5R21 R24 R51 R39 C12 R29 R41 C21 R54 C30 R34 C13 R38 C43 L1 R42 C11 R28 R52 C37 L2 L3 R57 C9 C33 C47 R18 R19 C44 W3 R79 C55 C54 W2 R65 R3 R13 R5 C38 R2 C32 C26 C29 C35 R56 R35 R71 C58 C46 C49 R12 R70 C61 C50 R64 C17 C15 R31 R40R36 C27 R66 R4 C4 R26 C8 R48 C34 R73 R60 C10 R74 C48 R43C24 R45 R8 R75 C28 71 148 TP47 TP52 T