Pioneer-XVVS600-cs-sm1 电路图 维修手册.pdf

《Pioneer-XVVS600-cs-sm1 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Pioneer-XVVS600-cs-sm1 电路图 维修手册.pdf（23页珍藏版）》请在收音机爱好者资料库上搜索。

1、ORDER NO. PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-

2、01, Singapore 159936 PIONEER CORPORATION 2001 RRV2505 T ZZK JULY 2001 Printed in Japan THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). Model No.Order No.Remarks XR-A9800D/KUCXJRRV2329 This service manual should be used together with the following manual(s): STEREO DVD CASSETTE DECK

3、RECEIVER XV-VS800 XV-VS600 CONTENTS 1. SAFETY INFORMATION.2 2. CONTRAST OF MISCELLANEOUS PARTS.3 3. SCHEMATIC DIAGRAM.12 4. PCB CONNECTION DIAGRAM.22 Type Model Power Requirement RegionThe voltage can be converted by XV-VS800XV-VS600No.the following method. DBDXJAC110-127V/220-230V/240V3With the vol

4、tage selector DDXJRAAC110-127V/220-230V/240V1With the voltage selector DDXJ/RBAC110-127V/220-230V/240V2With the voltage selector DDXJ/ARAC110-127V/220-230V/240V4With the voltage selector DLXJ/NCAC110-120V/220-230V/240V3With the voltage selector RadioFans.CN 收音机爱 好者资料库 XV-VS800, XV-VS600 2 1. SAFETY

5、INFORMATION Printed on the Rear Panel (DLXJ/NC Type only) LABEL CHECK LASER DIODE CHARACTERISTICS FOR DVD :MAXIMUM OUTPUT POWER : 5 mW WAVELENGTH : 655 nm FOR CD :MAXIMUM OUTPUT POWER : 5mW WAVELENGTH : 785 nm Additional Laser Caution 1. Inside detection switch (S201 on the SMEB assy) and loading- s

6、tatus detection switch (S9503 on the MOTOR assy) are detected by the microprocessor (IC11 in the DVDM assy). To permit the laser diode to oscillate, it is required to set the inside detection switch for the inside position (S201 : ON) and to set the loading-status detection switch for the clamp posi

7、tion (the center terminal of S9503 is shorted to +5V). The 655 nm laser diode for DVD oscillation will continue if pin 19 of IC1 is shorted to +5V (fault condition) in the DVDM assy. The 785 nm laser diode for CD oscillates if pin 20 of IC1 is shorted to +5V in the DVDM assy. In the test mode , the

8、laser diode oscillates when microproces- sor detects a PLAY signal, or when the PLAY key is pressed (S5931 ON in the DISPLAY assy), with the above requirements satisfied. 2. When the cover is open, close viewing through the objective lens with the naked eye will cause exposure to the laser beam. : R

9、efer to page 82 on the service manual RRV2329. WARNING ! THE AEL (ACCESSIBLE EMISSION LEVEL) OF THE LASER POWER OUTPUT IS LESS THAN CLASS 1 BUT THE LASER COMPONENT IS CAPABLE OF EMITTING RADIATION EXCEEDING THE LIMIT FOR CLASS 1. A SPECIALLY INSTRUCTED PERSON SHOULD DO SERVICING OPERATION OF THE APP

10、ARATUS. This service manual is intended for qualified service technicians ; it is not meant for the casual do-it- yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual.

11、Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. Radio

12、Fans.CN 收音机爱 好者资料库 XV-VS800, XV-VS600 3 2. CONTRAST OF MISCELLANEOUS PARTS Parts marked by NSP are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, b

13、e sure to use parts of identical designation. Screws adjacent to mark on product are used for disassembly. Reference Nos. indicate the pages and Nos. in the service manual for the base model. NOTES: When ordering resistors, first convert resistance values into code form as shown in the following exa

14、mples. Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%, and K=10%). Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5 6 1 4 7 3 R 5 0 1 R 0 5 6 2 1 560 47k 0.5 1 RD1/4PU J RD1/4PU J RN2H

15、 K RS1P K 56 x 101 47 x 103 R50 1R0 561 473 5.62kRN1/4PC F562 x 1015621 CONTRAST TABLE for XV-VS800 XV-VS800/DBDXJ, DDXJRA, DDXJ/RB, DDXJ/AR, DLXJ/NC and XR-A9800D/KUCXJ are constructed the same except for the following : Part No. Ref. No.MarkSymbol and DescriptionXR-A9800D XV-VS800XV-VS800XV-VS800X

16、V-VS800XV-VS800Remarks /KUCXJ/DBDXJ/DDXJRA /DDXJ/RB /DDXJ/AR /DLXJ/NC PCB ASSEMBLIES MAIN ASSYXWM3174 XWM3172 XWM3172 XWM3172 XWM3172 XWM3172 P5- 1 AF ASSYXWZ3330XWZ3322XWZ3322XWZ3322XWZ3322XWZ3322 COMPLEX ASSYXWM3178 AWM7618 AWM7618 AWM7618 AWM7618 AWM7618 P5- 4 PRIMARY ASSYXWZ3332XWZ3326XWZ3326XWZ

17、3326XWZ3326XWZ3326 P7- 1 DISPLAY ASSYXWZ3331AWU7801AWU7801 AWU7801AWU7801AWU7801 PACKING SECTION P3- 1Power CordADG7022ADG1158ADG1158ADG1154ADG1158ADG1154 P3- 5Remote Control UnitXZN3109XZN3110XZN3110XZN3110XZN3110XZN3110 P3- 9Front PadXHA3020XHA3030XHA3030XHA3030XHA3030XHA3030 P3-10Rear PadXHA3021X

18、HA3031XHA3031XHA3031XHA3031XHA3031 P3-11Packing CaseXHD3144XHD3280XHD3280XHD3280XHD3291XHD3281 P3-12NSPWarranty CardARY7045Not usedNot usedNot usedNot usedNot used P3-14Operating InstructionsXRE3036Not usedNot usedNot usedNot usedNot used (English/French) Operating InstructionsNot usedXRE3052Not use

19、dNot usedNot usedXRE3052 (English/Chinese) Operating InstructionsNot usedNot usedXRB3010XRB3010Not usedNot used (English) Operating InstructionsNot usedNot usedNot usedNot usedXRE3053Not used (English/Spanish) Power CordNot usedNot usedNot usedNot usedXDG3009Not used Power-cord Plug Conversion Adapt

20、er Not usedXKM3002Not usedNot usedXKM3002Not usedAccessories Caution SheetXRH3004Not usedNot usedNot usedXRH3002Not used Region LabelNot usedNot usedVRW1708 VRW1701Not usedNot usedFor Packing Case Caution Sheet ARNot usedNot usedNot usedNot usedXRH3002Not usedAccessories EXTERIOR SECTION P5-12 Power

21、 Transformer (T1) (AC120V) XTS3042Not usedNot usedNot usedNot usedNot used P5-12 Power Transformer (T1)Not usedXTS3055XTS3055XTS3055XTS3055XTS3055 (AC110-127V/220-230V/240V) P5-13 Fuse (FU1 : 6.3A)REK1085Not usedNot usedNot usedNot usedNot used P5-13 Fuse (FU1 : T5A)Not usedAEK1061AEK1061AEK1061AEK1

22、061AEK1061 P5-25Rear PanelXNC3065XNC3131XNC3131XNC3131XNC3131XNC3132 P5-38Tray CapXAK3157XAK3236XAK3236XAK3236XAK3236XAK3236 Tray Panel DVDNot usedXAK3251XAK3251XAK3251XAK3251XAK3251For Tray Cap P5-41NSPFuse CardAAX2374Not usedNot usedNot usedNot usedNot used P5-42NSPGetterXAX3175XAX3271XAX3271XAX32

23、71XAX3271XAX3271 P5-4365 LabelARW7050Not usedNot usedNot usedNot usedNot used Fuse (FU2, FU3 : T3.15A)Not usedAEK1059AEK1059AEK1059AEK1059AEK1059*1 NSPName LabelNot usedNot usedXAL3101XAL3101XAL3101Not used*2 NSPRegion LabelNot usedNot usedXAX3183XAX3184XAX3185Not usedFor Rear Panel Caution LabelNot

24、 usedXRW3003 XRW3003 XRW3003XRW3003 XRW3003 *3 RadioFans.CN 收音机爱 好者资料库 XV-VS800, XV-VS600 4 Notes : For PCB ASSEMBLIES, Refer to “CONTRAST OF PCB ASSEMBLIES” and “3. SCHEMATIC DIAGRAM”. The numbers in the remarks column correspond to the numbers on the “ FRONT PANEL ASSY ”. *1 Refer to “3. SCHEMATIC

25、 DIAGRAM”. *2 Stick Name Label on the Rear Panel. *3 Refer to “LABEL CHECK”. Part No. Ref. No.MarkSymbol and DescriptionXR-A9800D XV-VS800XV-VS800XV-VS800XV-VS800XV-VS800Remarks /KUCXJ/DBDXJ/DDXJRA /DDXJ/RB /DDXJ/AR /DLXJ/NC NSPSISIR LabelNot usedNot usedNot usedNot usedNot usedXAX3280For Rear Panel

26、 Rear SheetAED7037Not usedNot usedNot usedNot usedNot used FRONT PANEL SECTION P7-8GND Plate CXNG3047Not usedNot usedNot usedNot usedNot used P7-8GND Plate ANot usedXNG3030XNG3030XNG3030XNG3030XNG3030 P7-18Volume KnobXAA3013XAA3022XAA3022XAA3022XAA3022XAA3022 P7-21FUNC Button LXAD3061XAD3118XAD3118X

27、AD3118XAD3118XAD3118No.8 FUNC Cap LNot usedXAK3247XAK3247XAK3247XAK3247XAK3247No.7 P7-22FUNC Button RXAD3051XAD3112XAD3112XAD3112XAD3112XAD3112No.10 FUNC Cap RNot usedXAK3248XAK3248XAK3248XAK3248XAK3248No.9 P7-23FUNC Frame LXAD3052Not usedNot usedNot usedNot usedNot used P7-24FUNC Frame RXAD3053Not

28、usedNot usedNot usedNot usedNot used P7-25DVD ENT ButtonXAD3056XAD3110XAD3110XAD3110XAD3110XAD3110No.12 P7-26Display PanelXAK3135XAK3259XAK3259XAK3259XAK3259XAK3259 P7-27EQ PanelXAK3150Not usedNot usedNot usedNot usedNot used SC PanelNot usedXAK3268XAK3268XAK3268XAK3268XAK3268No.26 SC Panel AssyNot

29、usedXXG3090XXG3090XXG3090XXG3090XXG3090No.13 P7-28JOG LensXAK3152XAK3243XAK3243XAK3243XAK3243XAK3243No.23 P7-29V LensXAK3153XAK3237XAK3237XAK3237XAK3237XAK3237 P7-33FL CoverXAK3164XAK3239XAK3239XAK3239XAK3239XAK3239 P7-34Cover Sheet LXAK3184Not usedNot usedNot usedNot usedNot used P7-35Cover Sheet R

30、XAK3185Not usedNot usedNot usedNot usedNot used LED BarrierNot usedXEC3022XEC3022XEC3022XEC3022XEC3022No.24 P7-36Power ButtonXAD3044XAD3102XAD3102XAD3102XAD3102XAD3102No.17 P7-37CD ButtonXAD3045XAD3104XAD3104XAD3104XAD3104XAD3104No.19 P7-38SC ButtonXAD3060Not usedNot usedNot usedNot usedNot used SC

31、Button LNot usedXAD3105XAD3105XAD3105XAD3105XAD3105No.29 SC Cap LNot usedXAK3241XAK3241XAK3241XAK3241XAK3241No.27 SC Button RNot usedXAD3106XAD3106XAD3106XAD3106XAD3106No.30 SC Cap RNot usedXAK3267XAK3267XAK3267XAK3267XAK3267No.28 ASES ButtonNot usedXAD3114XAD3114XAD3114XAD3114XAD3114No.20 Timer But

32、tonNot usedXAD3115XAD3115XAD3115XAD3115XAD3115No.21 P7-39SC Button LXAD3047Not usedNot usedNot usedNot usedNot used Audio ButtonNot usedXAD3107XAD3107XAD3107XAD3107XAD3107No.14 P7-40SC Button RXAD3049Not usedNot usedNot usedNot usedNot used Visual ButtonNot usedXAD3108XAD3108XAD3108XAD3108XAD3108No.

33、15 P7-41DOLBY ButtonXAD3054XAD3121XAD3121XAD3121XAD3121XAD3121No.11 P7-42Sub PanelXAK3203XAK3271XAK3271XAK3271XAK3271XAK3271No.6 P7-43Standby LensXAK3151XAK3240XAK3240XAK3240XAK3240XAK3240No.18 P7-44Deck Lens LXAK3159XAK3249XAK3249XAK3249XAK3249XAK3249No.3 P7-45Deck Lens RXAK3160XAK3250XAK3250XAK325

34、0XAK3250XAK3250No.5 P7-46JOG ConductorXAK3165XAK3244XAK3244XAK3244XAK3244XAK3244No.22 P7-47Deck Door_LXAN3022XAN3037XAN3037XAN3037XAN3037XAN3037No.2 P7-48Deck Door_RXAN3026XAN3038XAN3038XAN3038XAN3038XAN3038No.4 P7-49Front PanelXMB3027XMB3058XMB3058XMB3058XMB3058XMB3058No.1 P7-50DV Button LXAD3057No

35、t usedNot usedNot usedNot usedNot used P7-51DV Button RXAD3059Not usedNot usedNot usedNot usedNot used P7-52NSPFront Panel ASSYXXG3066XXG3086XXG3086XXG3086XXG3086XXG3086 O/C ButtonNot usedXAD3103XAD3103XAD3103XAD3103XAD3103No.16 SpacerXEB3012Not usedNot usedNot usedNot usedNot used SpacerXEB3013Not

36、usedNot usedNot usedNot usedNot used Cushion SpacerXEB3015Not usedNot usedNot usedNot usedNot used Cushion SpacerXEB3016Not usedNot usedNot usedNot usedNot used Cushion SpacerXEB3017Not usedNot usedNot usedNot usedNot used SpacerXEC3014Not usedNot usedNot usedNot usedNot used SpacerXEC3019Not usedNo

37、t usedNot usedNot usedNot used XV-VS800, XV-VS600 5 XV-VS600/DBDXJ, DDXJ/RB, DLXJ/NC and XR-A9800D/KUCXJ are constructed the same except for the following : CONTRAST TABLE for XV-VS600 Part No. Ref. No.MarkSymbol and DescriptionXR-A9800DXV-VS600XV-VS600XV-VS600Remarks /KUCXJ/DBDXJ/DDXJ/RB/DLXJ/NC PC

38、B ASSEMBLIES MAIN ASSYXWM3174AWM7605AWM7605AWM7605 P5- 1 AF ASSYXWZ3330AWU7789AWU7789AWU7789 P5- 2 SECONDARY ASSYXWZ3323XWZ3317XWZ3317XWZ3317 COMPLEX ASSYXWM3178AWM7617AWM7617AWM7617 P5- 3 REAR AMP ASSYXWZ3325XWZ3319XWZ3319XWZ3319 P5- 4 PRIMARY ASSYXWZ3332XWZ3320XWZ3320XWZ3320 P7- 1 DISPLAY ASSYXWZ3

39、331AWU7800AWU7800AWU7800 PACKING SECTION P3- 1Power CordADG7022ADG1158ADG1158ADG1154 P3- 5Remote Control UnitXZN3109XZN3108XZN3108XZN3108 P3- 9Front PadXHA3020XHA3030XHA3030XHA3030 P3-10Rear PadXHA3021XHA3031XHA3031XHA3031 P3-11Packing CaseXHD3144XHD3277XHD3277XHD3278 P3-12NSPWarranty CardARY7045Not

40、 usedNot usedNot used P3-14Operating Instructions (English/French)XRE3036Not usedNot usedNot used Operating Instructions (English/Chinese)Not usedXRE3052Not usedXRE3052 Operating Instructions (English)Not usedNot usedXRB3010Not used Power-cord Plug Conversion AdapterNot usedXKM3002Not usedNot used R

41、egion LabelNot usedNot usedVRW1701Not usedFor Packing Case Caution SheetXRH3004Not usedNot usedNot usedAccessories EXTERIOR SECTION P5-12 Power Transformer (T1) (AC120V)XTS3042Not usedNot usedNot used P5-12 Power Transformer (T1)Not usedXTS3039XTS3039XTS3039 (AC110-127V/220-230V/240V) P5-13 Fuse (FU

42、1 : 6.3A)REK1085Not usedNot usedNot used P5-13 Fuse (FU1 : T5A)Not usedAEK1061AEK1061AEK1061 P5-15Power BracketXNG3033Not usedNot usedNot used P5-25Rear PanelXNC3065XNC3128XNC3128XNC3129 P5-26SEC HolderXMR3013XMR3014XMR3014XMR3014 P5-38Tray CapXAK3157XAK3236XAK3236XAK3236 Tray Panel DVDNot usedXAK32

43、51XAK3251XAK3251 P5-41NSPFuse CardAAX2374Not usedNot usedNot used P5-42NSPGetterXAX3175XAX3269XAX3269XAX3269 P5-4365 LabelARW7050Not usedNot usedNot used P5-44NSP$M Mecha. DVD (5ch)XXA3019Not usedNot usedNot used P5-44NSP$M Mecha. DVD (2ch)Not usedXXA3018XXA3018XXA3018 Fuse (FU2, FU3 : T3.15A)Not us

44、edAEK1059AEK1059AEK1059*1 NSPName LabelNot usedNot usedXAL3099Not used*2 NSPRegion LabelNot usedNot usedXAX3184Not usedFor Rear Panel Caution LabelNot usedXRW3003XRW3003XRW3003*3 NSPSISIR LabelNot usedNot usedNot usedXAX3279For Rear Panel Rear SheetAED7037Not usedNot usedNot used FRONT PANEL SECTION

45、 P7-8GND Plate CXNG3047Not usedNot usedNot used P7-8GND Plate ANot usedXNG3030XNG3030XNG3030 P7-18Volume KnobXAA3013XAA3022XAA3022XAA3022 P7-21FUNC Button LXAD3061XAD3118XAD3118XAD3118No.8 FUNC Cap LNot usedXAK3247XAK3247XAK3247No.7 P7-22FUNC Button RXAD3051XAD3112XAD3112XAD3112No.10 FUNC Cap RNot u

46、sedXAK3248XAK3248XAK3248No.9 P7-23FUNC Frame LXAD3052Not usedNot usedNot used P7-24FUNC Frame RXAD3053Not usedNot usedNot used P7-25DVD ENT ButtonXAD3056XAD3110XAD3110No.12 P7-26Display PanelXAK3135XAK3238XAK3238XAK3238 P7-27EQ PanelXAK3150Not usedNot usedNot used SC PanelNot usedXAK3268XAK3268XAK32

47、68No.26 SC Panel AssyNot usedXXG3090XXG3090XXG3090No.13 P7-28JOG LensXAK3152XAK3243XAK3243XAK3243No.23 XV-VS800, XV-VS600 6 Notes :For PCB ASSEMBLIES, Refer to “PCB PARTS LIST”, “3. SCHEMATIC DIAGRAM” and “4. PCB CONNECTION DIAGRAM”. Part No. Ref. No.MarkSymbol and DescriptionXXA3019XXA3018Remarks (

48、XR-A9800D)(XV-VS600) P5-10CONNECT ASSY (6CH)XWX3023Not used P5-10CONNECT ASSY (2CH)Not usedXWX3019 P5-1425P Flexible CableXDD3046Not used P5-1415P Flexible CableNot usedXDD3049 P5-1830P Flexible CableXDD3044Not used P5-1816P Flexible CableNot usedXDD3043 P5-217P Flexible Cable/30VXDD3053ADD7197 P5-2

49、3DVD BaseXNG3034ANG7262 P5-24DVD ShieldXNK3006ANK7066 P5-5521P Flexible CableXDD3052Not used P5-557P Flexible CableNot usedXDD3045 XXA3018 and XXA3019 are constructed the same except for the following : CONTRAST OF $M MECHA. DVD Part No. Ref. No.MarkSymbol and DescriptionXR-A9800DXV-VS600XV-VS600XV-VS600Remarks /KUCXJ/DBDXJ/DDXJ/RB/DLXJ/NC P7-29V LensXAK3153XAK3237XAK3237XAK3237 P7-33FL CoverXAK3164XAK