Pioneer-XRVS300D-cs-sm1 电路图 维修手册.pdf

《Pioneer-XRVS300D-cs-sm1 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Pioneer-XRVS300D-cs-sm1 电路图 维修手册.pdf（163页珍藏版）》请在收音机爱好者资料库上搜索。

1、ORDER NO. PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-

2、01, Singapore 159936 ? ? ? ? ? ? PIONEER CORPORATION 2000 RRV2340 T ZZK AUG. 2000 Printed in Japan THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). Model No.Order No.Remarks XR-A9800D/KUCXJRRV2329 This service manual should be used together with the following manual(s): STEREO DVD CA

3、SSETTE DECK RECEIVER XR-VS500D XR-VS300D CONTENTS 1. SAFETY INFORMATION.2 2. CONTRAST OF MISCELLANEOUS PARTS.3 3. SCHEMATIC DIAGRAM.10 4. PCB CONNECTION DIAGRAM.20 5. GENERAL INFORMATION.22 Type Model Power Requirement RegionThe voltage can be converted by XR-VS500DXR-VS300DNo.the following method.

4、DBXJAC110-127V/220-230V/240V3With the voltage selector DDXJ/RAAC110-127V/220-230V/240V1With the voltage selector DDXJ/RBAC110-127V/220-230V/240V2With the voltage selector DDXJ/RDAC110-127V/220-230V/240V4With the voltage selector DLXJ/NCAC110-127V/220-230V/240V3With the voltage selector RadioFans.CN

5、收音机爱 好者资料库 XR-VS500D, XR-VS300D 2 1. SAFETY INFORMATION Printed on the Rear Panel LABEL CHECK (For DLXJ/NC Type) LASER DIODE CHARACTERISTICS FOR DVD :MAXIMUM OUTPUT POWER : 5 mW WAVELENGTH : 655 nm FOR CD :MAXIMUM OUTPUT POWER : 5mW WAVELENGTH : 785 nm Additional Laser Caution 1. Inside detection sw

6、itch (S201 on the SMEB assy) and loading- status detection switch (S9503 on the MOTOR assy) are detected by the microprocessor (IC11 in the DVDM assy). To permit the laser diode to oscillate, it is required to set the inside detection switch for the inside position (S201 : ON) and to set the loading

7、-status detection switch for the clamp position (the center terminal of S9503 is shorted to +5V). The 655 nm laser diode for DVD oscillation will continue if pin 19 of IC1 is shorted to +5V (fault condition) in the DVDM assy. The 785 nm laser diode for CD oscillates if pin 20 of IC1 is shorted to +5

8、V in the DVDM assy. In the test mode , the laser diode oscillates when microproces- sor detects a PLAY signal, or when the PLAY key is pressed (S5931 ON in the DISPLAY assy), with the above requirements satisfied. 2. When the cover is open, close viewing through the objective lens with the naked eye

9、 will cause exposure to the laser beam. : Refer to page 82 on the service manual RRV2329. WARNING ! THE AEL (ACCESSIBLE EMISSION LEVEL) OF THE LASER POWER OUTPUT IS LESS THAN CLASS 1 BUT THE LASER COMPONENT IS CAPABLE OF EMITTING RADIATION EXCEEDING THE LIMIT FOR CLASS 1. A SPECIALLY INSTRUCTED PERS

10、ON SHOULD DO SERVICING OPERATION OF THE APPARATUS. This service manual is intended for qualified service technicians ; it is not meant for the casual do-it- yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex prod

11、ucts such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repa

12、ir to a qualified service technician. RadioFans.CN 收音机爱 好者资料库 XR-VS500D, XR-VS300D 3 2. CONTRAST OF MISCELLANEOUS PARTS Parts marked by NSP are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety fac

13、tor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screws adjacent to mark on product are used for disassembly. Reference Nos. indicate the pages and Nos. in the service manual for the base model. NOTES: When ordering resistors, first convert resistance values

14、 into code form as shown in the following examples. Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%, and K=10%). Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5 6 1 4 7 3 R 5 0 1 R 0 5

15、 6 2 1 560 47k 0.5 1 RD1/4PU J RD1/4PU J RN2H K RS1P K 56 x 101 47 x 103 R50 1R0 561 473 5.62kRN1/4PC F562 x 1015621 CONTRAST TABLE for XR-VS500D XR-VS500D/DBXJ, DDXJ/RA, DDXJ/RB, DDXJ/RD, DLXJ/NC and XR-A9800D/KUCXJ are constructed the same except for the following : Part No. Ref. No.MarkSymbol and

16、 DescriptionXR-A9800DXR-VS500DXR-VS500DXR-VS500DXR-VS500DXR-VS500DRemarks /KUCXJ/DBXJ/DDXJ/RA /DDXJ/RB /DDXJ/RD /DLXJ/NC PCB ASSEMBLIES MAIN ASSYXWM3174 XWM3172 XWM3172 XWM3172 XWM3172 XWM3172 P5- 1 AF ASSYXWZ3330XWZ3322XWZ3322XWZ3322XWZ3322XWZ3322 COMPLEX ASSYXWM3178 XWM3176 XWM3176 XWM3176 XWM3176

17、 XWM3176 P5- 4 PRIMARY ASSYXWZ3332XWZ3326XWZ3326XWZ3326XWZ3326XWZ3326 P7- 1 DISPLAY ASSYXWZ3331XWZ3324XWZ3324XWZ3324XWZ3324XWZ3324 PACKING SECTION P3- 1Power CordADG7022ADG1158ADG1158ADG1158ADG1158ADG1154 P3- 5Remote Control UnitXZN3109XZN3110XZN3110XZN3110XZN3110XZN3110 P3-11Packing CaseXHD3144XHD3

18、138XHD3138XHD3138XHD3138XHD3139 P3-12NSPWarranty CardARY7045Not usedNot usedNot usedNot usedNot used P3-14Operating InstructionsXRE3036Not usedNot usedNot usedNot usedNot used (English/French) Operating InstructionsNot usedXRE3035XRE3035XRE3035XRE3035XRE3035 (English/Chinese) Operating InstructionsN

19、ot usedNot usedXRC3022XRC3022XRC3022Not used (Spanish/Arabian) Region LabelNot usedNot usedVRW1708 VRW1701VRW1705Not usedFor Packing Case Caution SheetNot usedNot usedXRH3001Not usedXRH3001Not usedAccessories EXTERIOR SECTION P5-12 Power Transformer (T1) (AC120V) XTS3042Not usedNot usedNot usedNot u

20、sedNot used P5-12 Power Transformer (T1)Not usedXTS3038XTS3038XTS3038XTS3038XTS3038 (AC110-127V/220-230V/240V) P5-13 Fuse (FU1 : 6.3A)REK1085Not usedNot usedNot usedNot usedNot used P5-13 Fuse (FU1 : T5A)Not usedAEK1061AEK1061AEK1061AEK1061AEK1061 P5-25Rear PanelXNC3065XNC3066XNC3066XNC3066XNC3066XN

21、C3067 P5-41NSPFuse CardAAX2374Not usedNot usedNot usedNot usedNot used P5-42NSPGetterXAX3175XAX3176XAX3176XAX3176XAX3176XAX3176 P5-4365 LabelARW7050Not usedNot usedNot usedNot usedNot used Fuse (FU2, FU3 : T3.15A)Not usedAEK1059AEK1059AEK1059AEK1059AEK1059*1 NSPName LabelNot usedNot usedXAL3051XAL30

22、51XAL3051Not used*2 NSPRegion LabelNot usedNot usedXAX3183XAX3184XAX3185Not usedFor Rear Panel Caution LabelNot usedNot usedNot usedNot usedNot usedPRW1018 *3 NSPSISIR LabelNot usedNot usedNot usedNot usedNot usedXAX3181For Rear Panel FRONT PANEL SECTION P7-26Display PanelXAK3135XAK3136XAK3136XAK313

23、6XAK3136XAK3136 P7-33FL CoverXAK3164XAK3163XAK3163XAK3163XAK3163XAK3163 P7-42Sub Panel SXAK3203XAK3202XAK3202XAK3202XAK3202XAK3202 Mic KnobNot usedXAB3007XAB3007XAB3007XAB3007XAB3007No. 1 Notes : For PCB ASSEMBLIES, Refer to “CONTRAST OF PCB ASSEMBLIES” and “3. SCHEMATIC DIAGRAM”. The numbers in the

24、 remarks column correspond to the numbers on the “ EXPLODED VIEWS ”. *1 Refer to “3. SCHEMATIC DIAGRAM”. *2 Stick Name Label on the Rear Panel. *3 Refer to “LABEL CHECK”. RadioFans.CN 收音机爱 好者资料库 XR-VS500D, XR-VS300D 4 XR-VS300D/DBXJ, DDXJ/RA, DDXJ/RB, DLXJ/NC and XR-A9800D/KUCXJ are constructed the

25、same except for the following : CONTRAST TABLE for XR-VS300D Part No. Ref. No.MarkSymbol and DescriptionXR-A9800DXR-VS300DXR-VS300DXR-VS300DXR-VS300DRemarks /KUCXJ/DBXJ/DDXJ/RA /DDXJ/RB /DLXJ/NC PCB ASSEMBLIES MAIN ASSYXWM3174 XWM3171 XWM3171 XWM3171 XWM3171 P5- 1 AF ASSYXWZ3330XWZ3316XWZ3316XWZ3316

26、XWZ3316 P5- 2 SECONDARY ASSYXWZ3323XWZ3317XWZ3317XWZ3317XWZ3317 COMPLEX ASSYXWM3178 XWM3175 XWM3175 XWM3175 XWM3175 P5- 3 REAR AMP ASSYXWZ3325XWZ3319XWZ3319XWZ3319XWZ3319 P5- 4 PRIMARY ASSYXWZ3332XWZ3320XWZ3320XWZ3320XWZ3320 P7- 1 DISPLAY ASSYXWZ3331XWZ3318XWZ3318XWZ3318XWZ3318 PACKING SECTION P3- 1

27、Power CordADG7022ADG1158ADG1158ADG1158ADG1154 P3- 5Remote Control UnitXZN3109XZN3108XZN3108XZN3108XZN3108 P3-11Packing CaseXHD3144XHD3135XHD3135XHD3135XHD3136 P3-12NSPWarranty CardARY7045Not usedNot usedNot usedNot used P3-14Operating InstructionsXRE3036Not usedNot usedNot usedNot used (English/Fren

28、ch) Operating InstructionsNot usedXRE3035XRE3035XRE3035XRE3035 (English/Chinese) Operating InstructionsNot usedNot usedXRC3022XRC3022Not used (Spanish/Arabian) Region LabelNot usedNot usedVRW1708 VRW1701Not usedFor Packing Case Caution SheetNot usedNot usedXRH3001Not usedNot usedAccessories EXTERIOR

29、 SECTION P5-12 Power Transformer (T1) (AC120V) XTS3042Not usedNot usedNot usedNot used P5-12 Power Transformer (T1)Not usedXTS3039XTS3039XTS3039XTS3039 (AC110-127V/220-230V/240V) P5-13 Fuse (FU1 : 6.3A)REK1085Not usedNot usedNot usedNot used P5-13 Fuse (FU1 : T5A)Not usedAEK1061AEK1061AEK1061AEK1061

30、 P5-15Power BracketXNG3033Not usedNot usedNot usedNot used P5-25Rear PanelXNC3065XNC3063XNC3063XNC3063XNC3064 P5-26SEC HolderXMR3032XMR3033XMR3033XMR3033XMR3033 P5-41NSPFuse CardAAX2374Not usedNot usedNot usedNot used P5-42NSPGetterXAX3175XAX3174XAX3174XAX3174XAX3174 P5-4365 LabelARW7050Not usedNot

31、usedNot usedNot used P5-44NSP$M Mecha. DVD (5p)XXA3019Not usedNot usedNot usedNot used P5-44NSP$M Mecha. DVD (2p)Not usedXXA3018XXA3018XXA3018XXA3018 Fuse (FU2, FU3 : T3.15A)Not usedAEK1059AEK1059AEK1059AEK1059*1 NSPName LabelNot usedNot usedXAL3049XAL3049Not used*2 NSPRegion LabelNot usedNot usedXA

32、X3183XAX3184Not usedFor Rear Panel Caution LabelNot usedNot usedNot usedNot usedPRW1018*3 NSPSISIR LabelNot usedNot usedNot usedNot usedXAX3181For Rear Panel FRONT PANEL SECTION P7-26Display PanelXAK3135XAK3134XAK3134XAK3134XAK3134 P7-33FL CoverXAK3164XAK3163XAK3163XAK3163XAK3163 P7-42Sub Panel SXAK

33、3203XAK3202XAK3202XAK3202XAK3202 P7-50DV Button LXAD3057XAD3058XAD3058XAD3058XAD3058 Mic KnobNot usedXAB3007XAB3007XAB3007XAB3007No. 1 Notes : For PCB ASSEMBLIES, Refer to “CONTRAST OF PCB ASSEMBLIES” and “3. SCHEMATIC DIAGRAM”. The numbers in the remarks column correspond to the numbers on the “ EX

34、PLODED VIEWS ”. *1 Refer to “3. SCHEMATIC DIAGRAM”. *2 Stick Name Label on the Rear Panel. *3 Refer to “LABEL CHECK”. XR-VS500D, XR-VS300D 5 Notes :For PCB ASSEMBLIES, Refer to “PCB PARTS LIST”, “3. SCHEMATIC DIAGRAM” and “4. PCB CONNECTION DIAGRAM”. EXPLODED VIEWS Part No. Ref. No.MarkSymbol and De

35、scriptionXXA3019XXA3018Remarks (XR-A9800D)(XR-VS300D) P5-10CONNECT ASSY (6CH)XWX3023Not used P5-10CONNECT ASSY (2CH)Not usedXWX3019 P5-1425P Flexible CableXDD3046Not used P5-1415P Flexible CableNot usedXDD3049 P5-1830P Flexible CableXDD3044Not used P5-1816P Flexible CableNot usedXDD3043 P5-217P Flex

36、ible Cable/30VXDD3053ADD7197 P5-23DVD BaseXNG3034ANG7262 P5-24DVD ShieldXNK3006ANK7066 P5-5521P Flexible CableXDD3052Not used P5-557P Flexible CableNot usedXDD3045 XXA3018 and XXA3019 are constructed the same except for the following : CONTRAST OF $M MECHA. DVD Front Panel 1 CONTRAST OF PCB ASSEMBLI

37、ES SECONDARY ASSYFJ XWZ3317 and XWZ3323 are constructed the same except for the following : MarkSymbol and Description Part No. Remarks XWZ3323XWZ3317 C33, C34 (4700F/80V)ACH7071Not used C33, C34 (4700F/71V)Not usedXCH3001 XR-VS500D, XR-VS300D 6 AF ASSYFI XWZ3322, XWZ3316 and XWZ3330 are constructed

38、 the same except for the following : MarkSymbol and Description Part No. Remarks XWZ3330XWZ3322XWZ3316 IC3301STK407-070BSTK407-070BSTK407-090B IC3305, IC3306 (5A)AEK7019AEK7019Not used IC3305, IC3306 (7A)Not usedNot usedAEK7021 IC3835Not usedM65847AFPM65847AFP Q3351IRFI9Z34GIRFI9Z34GIRF9540A Q3352IR

39、FIZ34GIRFIZ34GIRF540A Q3803Not used2SD1858X2SD1858X D30021SS1331SS133Not used D3803Not usedMTZJ5.6BMTZJ5.6B F2201, F2202RTF1209XTF3002XTF3002 L3065 CHIP BEADVTL1081VTL1081Not used L3065Not usedNot usedLCTB4R7K1608 C3011, C3012Not usedNot usedCEAT100M50 C3042, C3991CKSRYB103K50CKSRYB103K50Not used C3

40、623, C3624CKSRYB471K50CKSRYB471K50Not used C3625CEAT330M16CEAT330M16Not used C3815Not usedCEAT100M50CEAT100M50 C3816, C3819Not usedCEAT470M16CEAT470M16 C3817Not usedCCSRYB473K16CCSRYB473K16 C3818Not usedCCSRCH101J50CCSRCH101J50 C3828C3830Not usedCKSRYB683K16CKSRYB683K16 C3831Not usedCKSRYB102K50CKSR

41、YB102K50 C3832Not usedCKSRYB122K50CKSRYB122K50 C3833C3836Not usedCKSRYB103K50CKSRYB103K50 C3837Not usedCCSRCH471J50CCSRCH471J50 C3838Not usedCKSRYB472K50CKSRYB472K50 C3839, C3840Not usedCKSRYB224K10CKSRYB224K10 C3842, C3843Not usedCEAT2R2M50CEAT2R2M50 C3858CEAT100M50Not usedNot used C3890Not usedCKS

42、RYB822K50CKSRYB822K50 R3010RS1/16S822JRS1/16S822JRS1/16S472J R3026RD1/4PU822JRS1/4PU822JRD1/4PU472J R3627RS1/16S471JRS1/16S471JNot used R3831Not usedRS1/4PU102JRD1/4PU102J R3832R3834Not usedRS1/16S102JRS1/16S102J R3835, R3839Not usedRS1/16S682JRS1/16S682J R3836, R3837Not usedRS1/16S472JRS1/16S472J R

43、3838, R3846Not usedRS1/16S153JRS1/16S153J R3840R3842, R3844, R3845Not usedRS1/16S103JRS1/16S103J R3843Not usedRS1/16S562JRS1/16S562J R3855Not usedRS1/16S680JRS1/16S680J CN3601 4P SPEAKER TERMINALAKE7018XKE3004XKE3004 CN3603 9P JUMPER CONNECTORKPE9KPE9Not used CN5104 30P FFC CONNECTORHLEM30R-1HLEM30R

44、-1Not used CN5104 16P FFC CONNECTORNot usedNot usedHLEM16R-1 JA3441 2P PIN JACKNot usedNot usedVKB1060 JA3991 HEADPHONE JACKXKN3007XKN3007XKN3004 SCREWNot usedNot usedBBZ30P140FMC MICA SHEETNot usedNot usedXEE3003 FET BRACKETNot usedNot usedXNG3016 XR-VS500D, XR-VS300D 7 REAR AMP ASSYFK XWZ3319 and

45、XWZ3325 are constructed the same except for the following : MarkSymbol and Description Part No. Remarks XWZ3325XWZ3319 IC3401STK402-230Not used Q3401Q34042SD2114KNot used Q3405, Q3410DTA124EKNot used Q3406Q3409, Q3411Q3413, Q34152SC2412KNot used Q3414, Q3471, Q34722SA1037KNot used D50, D3425, D3426,

46、 D3471, D34721SS355Not used D61, D62, D3403D3408, D3427, D34281SS133Not used D3409MTZJ12CNot used D3429MTZJ4.7BNot used L3401L3403 AF CHOKE COILATH-133Not used L3404 CHIP BEADVTL1081Not used RY3401, RY3402ASR7017Not used C3401C3403CEANP2R2M50Not used C3404C3406CKSRYB222K50Not used C3407C3409CCSRCH22

47、1J50Not used C3410C3412CEANP100M35Not used C3413C3415CCSRCJ3R0C50Not used C3416, C3417, C3431CEAT101M50Not used C3419CEATR47M50Not used C3420CEAT101M10Not used C3421CEAT100M50Not used C3422, C3471, C3472CCSRCH100D50Not used C3423, C3424, C3429CKSRYB103K50Not used C3425C3428CKSRYF104Z25Not used C3432

48、CEAT221M16Not used R3401R3404RS1/16S332JNot used R3405R3408RS1/16S102JNot used R3409R3411RS1/10S273JNot used R3412RS1/10S104JNot used R3413R3415RS1/16S563JNot used R3416R3418RS1/10S561JNot used R3419R3421RD1/4PU563JNot used R3422RS1/10S223JNot used R3424RS1/16S102JNot used R3425R3428RS1/10S823JNot u

49、sed R3429, R3430, R3432RS1/10S153JNot used R3433RS1/16S273JNot used R3434, R3475, R3476RS1/10S392JNot used R3435RS1/16S104JNot used R3436R3437, R3439, R3440RS1/16S223JNot used R3438RS1/16S103JNot used R3441RS1/16S224JNot used R3442R3444RD1/4LMF100JNot used R3445R3447RS1/16S100JNot used R3448RS3LMF102JNot used R3449RD1/4PU681