Philips-AZ-3830-Service-Manual(1) 电路图 维修手册.pdf

《Philips-AZ-3830-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-AZ-3830-Service-Manual(1) 电路图 维修手册.pdf（18页珍藏版）》请在收音机爱好者资料库上搜索。

1、Version 1.0 AZ3830/55 3141 785 31540 MP3 CD Soundmachine Published by LX 0702 Service Audio Subject to modification Copyright 2006 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmit

2、ted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. CONTENTS Circuit diagram - AMP Board Key Board LCD Board WMA Board PCB Layout diagram - AMP Board Key Board LCD Board WMA Board Service parts list RadioFans.CN 收音机爱 好者资料库 CIR

3、CUIT DIAGRAM - AMP BOARD RadioFans.CN 收音机爱 好者资料库 LAYOUT DIAGRAM - AMP BOARD RadioFans.CN 收音机爱 好者资料库 LAYOUT DIAGRAM - AMP BOARD CIRCUIT DIAGRAM - KEY BOARD LAYOUT DIAGRAM - KEY BOARD CIRCUIT DIAGRAM - LCD BOARD LAYOUT DIAGRAM - LCD BOARD 52pin changed from power_key to standby KEY VOLUME:680R 1K1 2K2

4、 3K6 5K 1 8K2 20K KEY0and KEY1 VOLUME RESISTOR VALUE AS BELOW IS RECOMMENDED A20 Pull down :audio clock taken form crin. Note:Tn= test point (pad 0.8mm) Serial LCD interface Print point select:Europe/America A23 pull down : boot from on-chip boot ROM, A23 pull up : boot from external flash ROM. Prin

5、t port: Package 0603 to AMP Mute SE=Servo FB=Ferrite Bead 84pin changed to Power_key with serial 100K resistor . A10 D23 A1 KEY4 A9 A17 D18 D26 A15 A8 A14 A23 A20 A2 D22 I/OVDD D30 A11 A16 A21 A4 A6 D21 D31:16 A18 A23 A7 D28 A3 /TA D16 D25 D17 A12 A23:1 D24 KEY2 A22 A19 D27 D19 D29 D31 A20 A13 A5 D2

6、0 SD_CS DSI SD_CKE A23:1 KEY2 DAC_BLCK SE_BLCK ROTARY1 SE_EF KEY1 SD_CLK SE_CFLG 5250_IDE_W SDA1 POWER_KEY AMP_Mute Tray_open LCD_CLK AC_DETECT Tray_close TXD TUNER_ST_MO CD_CTRL SD_CAS Serial LCD_CS0 D1 TUNER_RW ROTARY2 RXD SE_SCL SD_LDQM /RESET PSTCLK DAC_LRCK 5250_IDE_R USB_/RESET R/W TXD USB_CS

7、Tray_in SE_RESET LOW_BATT POWER_AMP_Mute LCD_DATA SD_RAS DSCLK SE_CLK REMOTE_INT KEY0 SD_UDQM POWER_AMP_Mute open/close SD_WE D2 BATT_LOW TUNER_DATA SE_SDA SE_DATA TUNER_CLK LCD_Backlight STATUS /BKPT Tray_out CS0 DAC_DATA SCL1 /TA USB_INT OEB D31:16 USB_H_WAKEUP SE_LRCK STANDBY DSO 1.2V I/OVDD MAIN

8、_VCC I/OVDD MAIN_VCC I/OVDD I/OVDD MAIN_VCC C17 4.7uF C5 0.1uF R224K7 R9100K FB1 2K5100MHz C7210nF R1147R R1347R C2010nF C11 1nF R1247R R02100R C18 1nF R547R R19 10K R747R C4 0.1uFC10 0.1uF T2 C13 0.1uF C19 680pF FB2 2K5100MHz R447R C7 0.1uF R254K7 C16 1uF R80100R C22 22pF R81K R082 10K C1 4.7uF R10

9、R T11 R2084K7 Y18.4672Mhz C21 22pF C6 0.1uF T10 C3 0.1uF R1810K FB3 2K5100MHz R241M R02447R C9 47uF/6.3V R08110K C12 680pF C15 680pF IC1 Amadeus_Plus ( SCF5250LAG100 ) 82 31 5 4 2 17 20 21 8 10 126 125 83 136 124 67 134 133 132 39 131 130 128 127 14 13 12 11 7 6 92 139 46 135 141 38 115 122 121 119

10、118 123 97 1 144 143 142 140 138 137 51 59 66 53 129 50 49 120 88 106 108 41 91 112 107 61 45 64 63 62 79 47 65 52 40 37 42 34 44 43 113 57 68 54 105 58 89 32 56 104 90 103 9 95 100 98 3 96 99 102 117 114 87 85 86 84 101 69 60 80 93 81 94 55 19 30 29 28 36 27 24 25 22 23 18 16 116 33 35 48 70 71 72

11、73 74 75 76 77 78 110 109 111 15 26 SCL0/SDATA1_BS1/GPIO41 CS0/CS4 A21 A22 A23/GPIO54 A11 A10 A9 A18 A17 BCLK/GPIO40 BCLKE/GPIO63 SDA0/SDATA3/GPIO42 DATA_24 SDUDQM/GPO53 EF/GPIO6 DATA_25 DATA_26 DATA_27 PLLCORE2GND DATA_28 DATA_29 DATA_30 DATA_31 A13 A14 A15 A16 A19 A20/A24 VDD-3 DATA_21 BUFENB1_GPI

12、O29 VDD-1 GND-1 PLLCORE2VDD TEST2 SDRAM_CS0/GPIO60 SDRAS/GPIO59 SDCAS/GPIO39 SDWE/GPIO38 SDLDQM/GPO52 GND-3 DATA_16 DATA_17 DATA_18 DATA_19 DATA_20 DATA_22 DATA_23 VDD-4 EBUOUT2/QSPI_CS1/GPIO16 CFLG/GPIO5 EBUOUT1/GPIO37 GND-2 EBUIN3/CMD_SDIO2/GPIO14 EBUIN2/SCLK_OUT/GPIO13 VDD-2 SCL1/TXD1/GPIO10 RSTI

13、# LRCK2/GPIO23 OE SDA1/RXD1/GPIO44 SDATAO2/GPIO34 SCLK2/GPIO22 GND-4 BUFENB2_GPIO30 SDATAO1/TOUT1/GPIO18 LRCK1/GPIO19 SCLK1/GPIO20 ADOUT/SCLK4/GPIO58 TA_GPIO12 SDATAI1/GPIO17 EBUIN1/GPIO36 PLLCORE1GND PLLCORE1VDD IDEDIOW_GPIO32 CRIN IDEDIOR_GPIO31 IDEIORDY_GPIO33 MCLK1/GPIO11 SUBR/QSPI_CLK/GPIO25 MC

14、LK2/QSPI_CS2/GPIO24 XTRIM/GPIO0 TRST/DSCLK SFSY/QSPI_DOUT/GPIO27 CORE-VDD-2 RW RCK/QSPI_DIN/QSPI_DOUT/GPIO26 TMS/BKPT CORE-GND-2 TCK GND-6 PST3/INTMON1/GPIO47 PSTCLK/GPIO51 PST1/GPIO49 VDD-6 PST2/INTMON2/GPIO48 PST0/GPIO50 TDI/DSI TEST0 HI-Z DDATA3/RTS0_B/GPIO4 DDATA1/RTS1_B/SDATA2 DDATA2/CTS0_B/GPI

15、O3 DDATA0/CTS1_B/SDATA0 TDO/DSO SDATAI3/GPIO8 EBUIN4/QSPI_CS0/GPI015 LRCK3/GPIO43/AudioClock TXD0/GPIO45 SCLK3/GPIO35 RXD0/GPI046 CS1/QSPI_CS3/GPIO28 CORE-GND-1 A1 A2 A3 OSCPAD-GND A4 A6 A5 A8 A7 CORE-VDD-1 A12 TEST1 OSCPAD-VDD CROUT WAKEUP#/GPIO21 ADIN0/GPI52 ADIN1/GPI53 ADIN2/GPI54 ADVDD ADGND ADI

16、N3/GPI55 ADIN4/GPI56 ADIN5/GPI57 ADREF LIN LINOUT LINGND VDD-5 GND-5 C8 0.1uF R10100K C14 1nF FB4 2K5100MHz C2 1nF R647R R234K7 R2094K7 CIRCUIT DIAGRAM - WMA BOARD VDD_SDRAM D31 D25 D24 D29 A10 A11 A1 A15 A6 OEB D19 A19 D20 A2 D28 D27 D16 A12 A13 A19 D20 A3 D30 A17 D18 A8 D23 A9 D26 D21 A18 A16 CS0

17、A14 A16 D21 D22 D28 D17 D19 A13 R/W A20 D18 A14 D29 VDD_FLASH A5 D23 D17 D16 A15 D30 A10 A7 A18 D24 A4 D22 A9 D26 VDD_SDRAM VDD_FLASH A12D27 D31 D25 A11 A17 CS0 SD_CLK D16:31 SD_CS OEBSD_CKE SD_RAS D16:31A1:20A1:20 SD_WE SD_CAS SD_UDQM R/W SD_LDQM MAIN_VCC MAIN_VCC C25 47uF/6.3V IC2 KH29LV800CTTC-70

18、G(OPT41) 25 24 23 22 21 20 19 18 8 7 6 5 4 3 2 1 48 17 16 29 31 33 35 38 40 42 44 30 32 34 36 39 41 43 45 12 47 26 28 11 15 13 37 27 46 9 10 14 A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18 IO0 IO1 IO2 IO3 IO4 IO5 IO6 IO7 IO8 IO9 IO10 IO11 IO12 IO13 IO14 IO15/A1 RESET BYTE CE OE

19、WE RDY/BUSY VPP VCC GND GND NC NC NC C66 0.1uF FB112K5100MHz C67 0.1uF T20 C62 0.1uF C23 10nF FB52K5100MHz C61 0.1uFC76 100uF C24 0.1uF C74 0.1uF IC8 16M SDRAM 2 3 5 6 8 9 11 12 39 40 42 43 45 46 48 49 21 22 23 24 27 28 29 30 31 32 20 1 25 7 13 38 44 26 50 4 41 10 47 14 15 16 17 18 19 33 34 35 36 37

20、 I/O0 I/O1 I/O2 I/O3 I/O4 I/O5 I/O6 I/O7 I/O8 I/O9 I/O10 I/O11 I/O12 I/O13 I/O14 I/O15 A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 VCC VCC VCCQ VCCQ VCCQ VCCQ GND GND GNDQ GNDQ GNDQ GNDQ LDQM WE CAS RAS CS A11 NC CKE CLK UDQM NC C73 0.1uF CIRCUIT DIAGRAM - WMA BOARD changed from 5k1to 12K changed from 8K2 to

21、5k6 changed form 0R to 6k8 * V1,V2 is input,v2,v3,v4 is output changed from 6K8 to 2K1 RA HOME_SW Moto_VCC X1 MOTOR2 VREF VREF F SLE+ RAD+ VCC1 MOT- SLE- SLE- C E VREF D MD SL D 1V7 RAD+ SLE- MOT- A B A SLE+ Moto_VCC VR FO FOC- VCC1 SLE+ MOT- B VCC1 C VREF FOC- VREF F LD FOC+ MOT+ MOT+ VR MD RAD- FO

22、C+ MOT+ RAD- LD E DAC_RN STATUS V5 DAC_BLCK HOME_SW V5 V4 SE_DATA SE_SDA DAC_LP DAC_DATA SE_LRCK SE_CFLG DAC_RP SE_EF V4 SE_BLCK DAC_LRCK SE_RESET SE_CLK SE_SCL DAC_LN 3V3_CD 3V3_CDA VB CD_3V3 3V3_CDA 3V3_CD 3V3_CD 3V3_CDA 3V3_CD 3V3_CD 3V3_CDA3V3_CDA 3V3_CD Moto_VCC 6V C400.1uF R34 3K3 R41 5K6 + C3

23、5 47uF/6.3V 12 C31 100uF/6.3VC32 0.1uF + C5547uF/6.3V 12 R37 12K C38 0.1uF C33100pF + C46 100uF/6.3V 12 + C60 100uF/6.3V 12 C26 0.1uF R40 3K9 R67100K C540.1uF C43 0.1uF R36 5K1 R542R2 C36 0.1uF FB6 2K5100MHz R7018R C30 2.2nF IC4 SAA7824HL 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 2

24、4 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 LPWR EXTF MONITOR SENSE VSSA1 IREF VDDA1 VRFO D1 D2 D3 D4 R1 R2 CEQ VDDA2 VSSA2 OSCO OSCIN VSSA3 DACGND DARP DARN DAREF DALN DALP

25、DAVP BUVP BUIR BUOR BUOL BUIL BUGND LKILL RKILL CRDY CDAT CCLK CFLG VSSD VDDD SDI WCLI SCLI EF DATA WCLK SCLK CLK16 CLK12 RESET SDA SCL RAB SILD STATUS RCK SUB SFSY SBSY VSD2 DOBM VDD1 RA FO SL MOTO1 MOTO2 VSD3 VDD2 V1 V2 V3 V4 V5 TEST1 TEST2 TEST3 TEST4 LASE CN9- KSM213C(SONY)/DA11(SANYO) 1 2 3 4 5

26、 6 7 8 9 10 11 12 13 14 15 16 VREF VCC E D A B C F GND LD VR PD FCS+ TRK+(-) TRK-(+) FCS- C39 0.1uF + C49 470uF/10V 12 R442K7 R39 6K8 R6524K R630R R49 8K2 R38 3K9 C29 0.1uF R574K7 R5510K R532R2 Q4BC807-25 R2630R R642R2 R45 2R2 CN1 ph6 1 2 3 4 5 6 R35 0R C440.1uF T309 C5922nF R42100K C42 0.1uF + C534

27、7uF 12 C1060.1uF T308 C4822nF R66 0R C51 0.1uF Q1BC817-25 1 23 R69 1K IC3 MM1469PH/D9258 PH 3.3V 1 2 3 4 5 6 7 8 9 10 11 12 13 1415 16 17 18 19 20 21 22 23 24 25 26 27 28 DO1.1 DO1.2 DI1.1 DI1.2 REG REO MUTE GND1 DI2.1 DI2.2 DO2.1 DO2.2 GND2 OPOUTOPIN- OPIN+ DO3.1 DO3.2 DI3.1 DI3.2 VCC1 VCC2 VREF DI

28、4.1 DI4.2 DO4.1 DO4.2 GND3 T310 L7100uH C450.1uF R51100R C28 100uF/6.3V R594K7 R58 2R2 T311 C27 0.1uF + C58100uF/6.3V 12 L5 100uH/1A C50 0.1uF C47 47nF C34 2.2nF T312 C520.1uF R46 10K R5610K HOME_SW CIRCUIT DIAGRAM - WMA BOARD to EJECT H Tuner_ON L Tuner_OFF SOT-323 AUDIO GND volume+/- swith new add

29、ed JOG_B JOG_A TUNER_ST_MO SCL1 ROTARY1 KEY1 JOG_B JOG_A STANDBY LOW_BATT CD_RCH TUNER_DATA ROTARY2 SDA1 CD_CTRL Serial LCD_CS0 POWER_KEY POWER_AMP_MUTE LCD_CLK AF_MUTE CD_LCH Tuner_ON TUNER_CLK TUNER_RW Tuner_ON LCD_DATA open/close KEY0 REMOTE_INT AC_DETECT AF_MUTE JOG_B JOG_A LCD_Backlight 7V5 MAI

30、N_VCC MAIN_VCC 6V 6V 3.3V MAIN_VCC MAIN_VCC 7V5 MAIN_VCC MAIN_VCC MAIN_VCC CD_3V3 3V3 6V MAIN_VCC 6V MAIN_VCC C0160.1uF R271KR0201K R070 100K J3-3 DIP pitch1.25mm 1 2 3 4 5 C65 220uF/10V R3390R FB0121A R0221K R04247R C10010nF FB132K5100MHz R74 4K7 R7110K Q2BC807-25 CN2 DIP pitch2.0mm 1 2 3 4 5 6 7 Q

31、6 BC817-25 1 23 C810.1uF R281K Q16HE8550D C711uF C9910nF R30100R R33310K C640.1uF FB141A C051220uF/16V R62R10K R31100R Q8BC807-25 FB0331A R71 100K R03315K R32100R R050100K R026100R C5190.1uF R524K7 R0134K7 R015100R R04915K R48100RR0251K FB0321A R014100R R04047R CN6 DIP pitch2.0mm 1 2 3 4 5 6 7 8 C05

32、20.1uF D1PDZ3.9B R03115K R04147R J1-2 DIP pitch2.0mm 1 2 3 C890.1uF C940.1uF R68 2R2 CN5 DIP pitch2.0mm 1 2 3 4 5 6 7 C10110uF/16V R02110K R011100R J2-3 DIP pitch2.0mm 1 2 3 4 R60 10K Q52SD1664R 1 23 R61R10K R43100K R214K7 R0324R7 FB0102K5100MHz J7-3 DIP pitch2.0mm 1 2 3 R33100R R0191K R47100R C0172

33、20uF/16V R0751K R7975R R02310K CIRCUIT DIAGRAM - WMA BOARD AUDIO SECTION Notes: The C79 ,C91 must be placed as near to the CD18 as possible AMP_VCC DAC_RP DAC_LN DAC_RN DAC_LP CD_LCH AMP_Mute CD_RCH MAIN_VCC AMP_VCC 7V5 C75220pF C84 1.5nF C83100uF/16V Q3BC807-25 R8610R C77100uF/6.3V R75 47K C95220pF

34、 C78 1.5nFR031K R93 18K R92 1K Q02 BC817-25 1 23 R8218K R8422K C93 100pF R8822K Q01 BC817-25 1 23 C91 1.5nF C370.1uF C80 100pF C870.1uF C92 1.5nF R9522K R874K7 R110620R C86 100uF/16V R911K C88 220pF - + IC11A D4558 3 2 1 84 R834K7 C90100uF/6.3V R111620R R90 18K R9918K R112 47K R944K7 R072 10K - + IC

35、11B D4558 5 6 7 84 C85 220pF C820.1uF R721K R041K C96 1.5nF R9822KR974K7 C79 1.5nF R109 47K CIRCUIT DIAGRAM - WMA BOARD S0-8 Package /RESET CTRL_RET OP CL M- M+ M+ M- SDA1 Tray_in /RESET Tray_out CL D2 SCL1 CL OP CTRL_RET M- D1 OP CTRL_RET M+ Tray_open Tray_close Moto_VCC MAIN_VCC MAIN_VCC MAIN_VCC

36、MAIN_VCC MAIN_VCC MAIN_VCC R11918R C98 100uF/10V R102 10K C561uF R1004K7 R77 10K R11810K C97 0.1uF R20 10K C571uF TSSOP/SOIC IC6M24C02 1 2 3 45 6 7 8 A0 A1 A2 GNDSDA SCL WP VCC IC5 OPT30 1 2 3 8 7 6 54 GND RST_IN D1 VDD ADJUST CAP RST_OUTD2 R17100R IC12D6208 1 2 3 45 6 7 8 VCC BOUT GND AOUTBIN NC GN

37、D AIN C680.1uF C70 2.2uF R78 10K FB15 1A R2 10K R26 150K R11510K R154K7 CN05 5 HEADER 1 2 3 4 5 R16100R R5010R C0680.1uF C69 10uF/6.3V Q7 BC817-25 1 23 R29 39K R7610R CIRCUIT DIAGRAM - WMA BOARD SOT-323 D16 A1 D- D26 D19 D28 D17 A1 D27 x1 D25 D20 D31 D23 DP1 D24 D22 X1 DM1 D21 D30 D29 X2 DP1 DM1 USB

38、_3V3 D18 H_OC1_N D+ x2 5250_IDE_W USB_INT 5250_IDE_R USB_/RESET A1 USB_CS D31:16 USB_H_WAKEUP USB_VCC USB_5V USB_VCC USB_VCC 6V USB_5V USB_3V3 D8PDZ5.6B IC500 isp1160BM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47

39、 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 DGND0 D2 D3 D4 D5 D6 D7 DGND1 D8 D9 D10 D11 D12 D13 DGND2 D14 D15 DGND3 Vhold1 NC CS RD WR Vhold2 DREQ NC DACK H-TESET INT NC NC RESET NDP_SEL EOT DGND4 NC TESET0 NC TESET1 H_wakeup NC H_suspend XTAL1 XTAL2 DGND5 H-PSW1-N H-PSW2-N NC NC H-DM1 H-DP1

40、 H-DM2 H-DP2 H-CO1-N H-OC2-N VCC AGND VREG3.3V A0 LOW-PW NC DGND D0 D1 C5350.1uF C512 18PF R327 10K R500 10K R515100R C50847pF R326 4K7 Q508HE8050D 1 23 C411nF C5550.1uF R328 10K FB5011AFB0531A C511 18PF R50222R C5560.01uF R516100R J6-2DIP pitch1.25MM 1 2 3 4 5 VB D- D+ GND Indication R50710K FB5052

41、K5100MHz R329 15K R3251K C5100.1uF R51110K FB5042K5100MHz R514100R R1491K C53347uF/10V C5160.1uF R509100R R5061M Q511 BC807-25 C630.1uF Q501 FND338P 3 1 2 C0320.1uF C5340.1uF C50947pF R555100K FB5021A C5150.1uF R510100R Y5006MHz C5041uF R5041M R50122R Q512 BC817-25 1 23 C503100uF/10V C5011uF R50810K

42、 R7375R CIRCUIT DIAGRAM - WMA BOARD LAYOUT DIAGRAM - WMA BOARD LAYOUT DIAGRAM - WMA BOARD Service parts list 996510000868 CD DAMPER PINK COLOR 658F HARDNESS 40JIS 996500042070 BATTERY DOOR-INJ ABS 996510000869 HANDLE-INJ HIGH FLOW HIPS 996510000870 CD DOOR-INJ PMMA 994000005786 CD MECHANISM DA11VF (

43、SANYO) 996510000871 CD TRAY LOADER 994000002364 ROD ANTENNA 2 SECTIONS 996510000872 SPEAKER 77MM 8OHM 6W 996510000873 SPEAKER 77MM 8OHM 6W 996510000874 VOLTAGE SELECTOR WS-12J01-GC7 996510000875 TRANSFORMER EI-57 120/230V 996510000876 5 FEET VDE APPRROVED POWER CORD 996500042071 REMOTE CONTROL FOR #AZ3830 Note: Only these parts mentioned in the list are normal service parts.