Philips-AZ-127-Service-Manual(1) 电路图 维修手册.pdf

《Philips-AZ-127-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-AZ-127-Service-Manual(1) 电路图 维修手册.pdf（33页珍藏版）》请在收音机爱好者资料库上搜索。

1、Version 1.0 AZ127/73/93CD Soundmachine Published by ZH 1311 Service Audio Subject to modification Copyright 2012 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form o

2、r by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. CONTENTS Technical specification .1 Service measurement setup.1-3 Service aids .1-4 Instructions on CD playability .2 Block diagram.3 Wiring diagram .4 Circuit diagram .5 Layout diagram.6 Expl

3、oded view diagram .7 Revision list .8 3140 038 60050 RadioFans.CN 收音机爱 好者资料库 Philips Consumer Lifestyle BU AVM Philips Electronics (China) Ltd. No.12 ShiHua Road, FuTian Free Trade Zone, ShenZhen, China . PHILIPS - - 2012-07-18 2 - 2012-10-24 3 AZ127/320/328/329 - 2012-11-11 NAME Tang Bing 18 10 190

4、 - 1 A4 CHECK DATE 2012-11-16 BU HAV Consumer Lifestyle, Philips AZ127/320/328/329 Technical Specifications (Sheet-190) Type: CD sound machine Performance Class: According to PQR (Product Quality and Reliability) Class Tuner Power Supply + AMP CD/MP3 Cassette USB/SD card Speaker Box X X X X X Commer

5、cial Set Type/Stroke Versions: Set Type Number Stroke Versions 12NC Region/Countries AZ127 /12 Europe AZ320 /12 Europe AZ328 /12 Europe AZ329 /98 APAC Prepared: Cheeked: ( R 198264V 98 APAC AC 207253V 94 India AC 170280V All requirements per defined for each country should be met with sufficient tes

6、ting. 3.1.2 Surge Immunity (Lightning Test) The product shall withstand mains interferences of: Differential mode: 2kV/2 ohm criteria C for Europe. 6kV/12 ohm criteria C for NAFTA. Parameters: Bi-wave Open circuit voltage: 2/50us Short circuit current: 8/20us From +/1kV to +/-2kV (for Europe) or +/-

7、6kV (for Nafta) in steps of 1kV. 10 shots per combination. One shot per minute. Serial impedance: 2 Ohm for Europe, 12Ohm for Nafta. Polarity and phase: Positive (phase 90) Rin 22k Output Power(*1) At THD=10%, 1kHz sine wave AZ127/320/328/329 Main Operation for / all version (rms) Pannel Subwoofer 2

8、 x1W1dB Na ( At Cold Condition with 10% THD ) Tuner output power(rms) Pannel Subwoofer 2x1W1dB Na ( At Cold Condition with 10% THD ) Frequency Response(3dB) 70Hz-20kHz Loudspeaker(Boxes): Separable speaker box NA Speaker driver Impedance: Right/Left: Subwoofer: 4 70 Hz 20kHz(3db) Na REMARKS: Electri

9、cal Parameters are to be measured at Speaker Terminals across rated impedance Load(4ohm) with Rated Input Signal in CD Mode setting in DBB/Loudness Off and Pre-eq at Flat unless specified otherwise. Philips Consumer Lifestyle BU AVM Philips Electronics (China) Ltd. No.12 ShiHua Road, FuTian Free Tra

10、de Zone, ShenZhen, China . PHILIPS - - 2012-07-18 2 - 2012-10-24 3 AZ127/320/328/329 - 2012-11-11 NAME Tang Bing 18 10 190 - 14 A4 CHECK DATE 2012-11-16 BU HAV Consumer Lifestyle, Philips 3.3 TUNER GENARAL PART FM only , and use IC TA2003 WAVE RANGE VERSION TOLERANCE TUNING GRID FM 87.5 108.00 MHz /

11、05/12 QUARTZ PRECISION NA AERIAL FM : telescope 700mm Execution - Rotational 180 ELECTRICAL DATA AM Nor. Limit Unit FM Nor. LimitUnit - 3 dB Limiting Point 20 26 dBf Search Tuning Sensitivity(at stereo mode) 35 41 Search time digital tuning system. - 60 S IF 10.7 MHz Stereo - 46 dB Quieting 48 51 dB

12、 Modulation Hum 50 45 S/N Ratio 50 45 Amplification Reverse(f=67.5kHz) 0 -4 dB Distortion ( RF 1mV, Frq Dev.75 kHz ) 2 3 % Overall Frequency Response: 63Hz 12.5KHz - 3 dB NA Channel separation:400 / 1000 / 5000 Hz. RF input: 68 dBf 26/30/ 20 20/2 6/18 dB Frequency (MHz) Noise Limited Sensitivity 26

13、dB Image Rejectio n IF Rejection Large Signal Handling Selectivity S9/300 kHz Nom.18 30 64 1000 22 FM 88.0Mhz Lim.22 25 45 500 18 (*1) Nom.18 30 64 1000 22 FM 98.0Mhz Lim.22 25 45 500 18 (*1) Nom.18 30 60 116 dBf 45 FM 107.0Mhz Lim.22 25 65 108 dBf 25 Units dBf dB dB mV/m dB Limited(d B) Normal(d B)

14、 Remark Susceptibility to unwanted signals(CPU,SMPS,AMP,DSP ): -15dB -20dB Refer to self pollution curve REMARKS: Philips Consumer Lifestyle BU AVM Philips Electronics (China) Ltd. No.12 ShiHua Road, FuTian Free Trade Zone, ShenZhen, China . PHILIPS - - 2012-07-18 2 - 2012-10-24 3 AZ127/320/328/329

15、- 2012-11-11 NAME Tang Bing 18 10 190 - 15 A4 CHECK DATE 2012-11-16 BU HAV Consumer Lifestyle, Philips 3.4 CD Technical description AZ127 AZ320 AZ328 AZ329 Active components Silan SC9637 Ali M5676 Ali M5677 Ali M5677 Passive components Richly R801 Richly R801 Richly R801 Richly R801 Indicators/Displ

16、ay/Keys: Display: 2 Digits LCD for Track No., and REPEAT/SHUFFLE . Keys: AZ127 - 8 total on unit, 7 for CD: PLAY, STOP, PREVIOUS/NEXT(Search up/down), PROGRAM/PROGRAM review, REPEAT and 1 for ON/STANDBY AZ320/AZ328/AZ329 - 8 total on unit all for CD: PLAY, STOP, PREVIOUS/NEXT(Search up/down), PROGRA

17、M/PROGRAM review, MODE(Repeat, Shuffle) and ALBUM(+/1). Playability (acc. to AR 30-05-239) Limit Typical Test disc Wedge 600 m 900 m TNO 7,9 of SBC 444A (7104 099 24990) Eccentric 150 m 200 m TNO 1,24 of 200m disc (7104 099 24960) Fingerprint No audible defect TNO 11of Subchassis 8A Black dot 500 m

18、800 m TNO 13 of SBC 444A (7104 099 24990) Skew 0.6mm No audible defect TNO 1,6 of 0.6mm skew (7104 099 28260) Bad HF track No audible defect TNO 8 of Subchassis 8A Heavy fingerprint No track jumps/plops TNO 10 of Subchassis 8A Playback position Horizontal, Normal position (Set is located on a flat s

19、urface, floor) - Playback of above mentioned tracks possible without track loss or audible defects. - Double black dot, max. diameter, thin/thick disk is according to PQR or AR 30-05-239) - Detail result, refer to Playability KOP report ELECTRICAL DATA Typ. Limit Output level (TNO1) 1 SNR unwtd. 60

20、dB 50 dB 2 SNR wtd. dBA 65 dBA 57 dBA 3 Crosstalk (1kHz) 40 dB 26 dB 4 Crosstalk (10kHz) 30 dB 16 dB 5 Frequency response Vol.max.20dB (DBB on) +9dB +3dB 2dB at 100Hz 2dB at 10kHz 6 THD (1kHz, -6 dB) 0.2 % 1 % 7 THD (10 kHz, -20 dB) 1 % 3 % 8 Channel difference 2 dB 3 dB 9 Frequency accuracy - +/-0.

21、5 % 1 0 De-emphasis 15s / 50s Switchable via Subcode information 1 1 Philips Consumer Lifestyle BU AVM Philips Electronics (China) Ltd. No.12 ShiHua Road, FuTian Free Trade Zone, ShenZhen, China . PHILIPS - - 2012-07-18 2 - 2012-10-24 3 AZ127/320/328/329 - 2012-11-11 NAME Tang Bing 18 10 190 - 16 A4

22、 CHECK DATE 2012-11-16 BU HAV Consumer Lifestyle, Philips 3.5 TAPE (Jiansheng JS-21VB8885-SGS) General description: Tape transport Jian sheng JS-21VB8885-SGS 1 2 Inputs Outputs Motor/control Logic control Active components Mabuchi EG530AD-9B 3 Passive components 4 5 Noise suppression Erase head Reco

23、rding/PB 6 Active components None NA 7 Passive components NA 8 Mechanical specification: Tape speed 4.76 cm/s Auto stop Yes 9 Speed control % Auto reverse No 10 Wow and flutter 0.48% JIS wtd. % WUN Wind/rewind Yes 11 Fast wind/rewind (C60) Nom=110s, Lim170s Mono: REC/PB No 12 No. of tracks 1 (stereo

24、) Stereo: REC/PB PB 13 Mech. noise (ISO 1996) 38 dBA (play mode) Mixing No 14 Noise overall 15 dB at 1kHz 28 Track separation (IEC1) 55 dB at 1kHz 29 Frequency response (PB) 125 to 8000 for IEC I 125 to 8000 for IEC II at 10dB (6dB for the range of 250Hz to 4kHz) 30 SNR 250nWb/m 36dB for IEC I * 36d

25、B for IEC II * 31 Philips Consumer Lifestyle BU AVM Philips Electronics (China) Ltd. No.12 ShiHua Road, FuTian Free Trade Zone, ShenZhen, China . PHILIPS - - 2012-07-18 2 - 2012-10-24 3 AZ127/320/328/329 - 2012-11-11 NAME Tang Bing 18 10 190 - 17 A4 CHECK DATE 2012-11-16 BU HAV Consumer Lifestyle, P

26、hilips Signal/hiss 250nWb/m for IEC I for IEC II 32 Signal/hum 250nWb/m for IEC I for IEC II 33 Channel difference (PB) 5 dB (IEC I) 34 Distortion 250nWb/m 7 % (IEC I) 35 ALC attack time 5 sec. (typ. 15 sec.) 37 Crosstalk Between forward to reverse track 38 REMARKS: 31: * not according to PQR clause

27、 18.5 class I 31: * Chromium performance not fulfilled Amplification Reserve for Tape = 1dB 2dB For details, please see specification SH-190 of ECO-MTF-PA-SD (3140 117 14890). 39 3.6 USB/SD CARD: Same as CD(TBC) 3.7 Audio Signal Processing(TBC) Philips Consumer Lifestyle BU AVM Philips Electronics (

28、China) Ltd. No.12 ShiHua Road, FuTian Free Trade Zone, ShenZhen, China . PHILIPS - - 2012-07-18 2 - 2012-10-24 3 AZ127/320/328/329 - 2012-11-11 NAME Tang Bing 18 10 190 - 18 A4 CHECK DATE 2012-11-16 BU HAV Consumer Lifestyle, Philips 4. MECHANICAL 4.1.1 Shock Sensitivity Refer to Quality plan for th

29、e details of the test discs and testing method. Requirement: No muting, plop sounds, picture freeze/jerk or audible/visible interference when impacting with force of - ? In the X and Y directions: F 3g / 3ms, V = 0.06m/s ? In the Z direction: F 2g / 3ms, V = 0.04m/s Where g = acceleration due to gra

30、vity. 4.1.2 Thermal Performance Refer to Quality plan for the details of the testing method. Requirements: 1. Set should function normally 2. Temperature rise of accessible parts such as metallic enclosures (casing) shall not exceed 40C above the ambient temperature. 3. Temperature rise of PCB print

31、s shall not exceed 85C 4. Temperature readings of all mechanical / electrical components and modules shall not exceed their specification limits. The calculated junction temperature of semiconductors shall also not exceed spec limits. 4.1.3 Noise Specifications Test Conditions: Measurements are to b

32、e made inside an Anechoic Chamber (echo-free environment) with ambient noise of less than 16dBA. Measurements are to be taken at the following positions: - (a) Top-Surface and at center of Front-Cabinet (b) Front-Surface and at center of Front-Cabinet. The microphone is to be positioned 10cm from ab

33、ove mentioned surfaces. Set Functional State Requirement Normal Idle State Standby Mode 20 dBA Set On and No Disc mode 20 dBA Tray Open/Close Start/End peak noise 65 dBA Tray running noise (RMS) 50 dBA CDDA & SACD Stop to Play peak noise 35 dBA (Stereo & Multichannel) Play (first & last tracks) 30 d

34、BA Search Forward & Backward (all speeds) 33 dBA Pause (first & last tracks) 28 dBA Jump Forward (first to last track) 38 dBA Jump Backwards (last to first track) 38 dBA Commercial Disc Stop to Play peak noise 35 dBA Play (inner & outermost title, Layer 0) 30dBA(TBC) Search Forward & Backward (all s

35、peeds) 35 dBA Pause (inner & outermost title, Layer 0) 30 dBA Jump Forward (inner to outermost title) 40 dBA Jump Backwards (outer to innermost title) 40 dBA Layer Jump (layer 0 to layer 1) 40 dBA 1-3 LEVEL METER e.g. Sennheiser UPM550 with FF- S/N and distortion meter e.g. Sound Technology ST1700B

36、L R DUT CD Use Audio Signal Disc (replaces test disc 3) SBC429 4822 397 30184 Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance fro

37、m the pilottone (19kHz, 38kHz). Ri=50 Tuner FM MEASUREMENT SETUP 1-4 SERVICE AIDS GBWARNING All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connected with the

38、 same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential. ESD CLASS 1 LASER PRODUCT GB Safety regulations require that the set be restored to its original condition and that parts which are identical with those specified, be used Safet

39、y components are marked by the symbol !. Lead free Set remains closed! N Y Play a CD for at least 10 minutes Y playability ok ? N playability ok ? add Info for customer SET OK check playability N Y playability ok ? check playability check playability return set Customer complaint CD related problem

40、fast lens cleaning 1 2 3 For flap loaders (= access to CD drive possible) cleaning method 4 is recommended INSTRUCTIONS ON CD PLAYABILITY 2 - 1 Exchange CDM 1- 4 For description - see following pages 1 PLAYABILITY CHECK For sets which are compatible with CD-RW discs use CD-RW Printed Audio Disc.7104

41、 099 96611 TR 3 (Fingerprint) TR 8 (600 Black dot) maximum at 01:00 playback of these two tracks without audible disturbance playing time for: Fingerprint10seconds Black dot from 00:50 to 01:10 jump forward/backward (search) within a reasonable time For all other sets use CD-DA SBC 444A.4822 397 302

42、45 TR 14 (600 Black dot) maximum at 01:15 TR 19 (Fingerprint) TR 10 (1000 wedge) playback of all these tracks without audible disturbance playing time for: 1000 wedge10seconds Fingerprint10seconds Black dot from 01:05 to 01:25 jump forward/backward (search) within a reasonable time 2 CUSTOMER INFORM

43、ATION It is proposed to add an addendum sheet to the set which informs the customer that the set has been checked carefully - but no fault was found. The problem was obviously caused by a scratched, dirty or copy-protected CD. In case problems remain, the customer is requested to contact the worksho

44、p directly. The lens cleaning (method 3) should be mentioned in the addendum sheet. The final wording in national language as well as the printing is under responsibility of the Regional Service Organizations. 4 LIQUID LENS CLEANING Because the material of the lens is synthetic and coated with a special anti-reflectivity layer, cleaning must be done with a non-aggressive cleaning fluid. It is advised to use “Cleaning Solvent The actuator is a very precise mechanical component and may not be damaged in order to guarantee its full functi