Philips-HTS-5000-W-Service-Manual(1) 电路图 维修手册.pdf

《Philips-HTS-5000-W-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-HTS-5000-W-Service-Manual(1) 电路图 维修手册.pdf（61页珍藏版）》请在收音机爱好者资料库上搜索。

1、Published by KC-TE 0519 AV Systems Printed in he Netherlands Subject to modifi cation EN 3139 785 31180 HTS5000W/51/12DVD Receiver CLASS 1 LASER PRODUCT 1 Technical Specifi cations and Connection Facilities 2 2 Measurements Setup, Service Aid fr Reparaturen sind Original-Ersatzteile zu verwenden. Si

2、cherheitsbauteile sind durch das Symbol ! markiert. I Le norme di sicurezza esigono che lapparecchio venga rimesso nelle condizioni originali e che siano utilizzati i pezzi di ricambio identici a quelli specificati. Componenty di sicurezza sono marcati con ! GB After servicing and before returning s

3、et to customer perform a leakage current measurement test from all exposed metal parts to earth ground to assure no shock hazard exist. The leakage current must not exceed 0.5mA. EN 7HTS5000WMeasurements Setup, Service Aid the class D keeps on oscillating, the status led stays green but no sound is

4、produced on the outputs. The control line (F22; connector 1102-pin 3) to the power supply stays low. 3. The RX module initiates STANDBY or powersavemode. When this module does not receive a valid signal for a time 4minutes (time set in Eeprom of the RX module), pin 16 of 1103 drops low, 7109 saturat

5、es and the mode pin of the TDA8920 is pulled low by 7101 to about 0.15V. (level to be checked on F39). At this level the amplifi erchip is in standbymode, all references are disabled, the oscillator stops. At the same moment the level on STBY_OUT becomes high (6Vdc) and disables the main +/- 27Vdc s

6、upply. Also the green led is switched off and the red led is switched on. In this condition the average power consumption (with the specifi ed supply AC6632) out of the mains is about 1W 230V EN 53HTS5000W9.Exploded View these lines are on 3.3Vdc logic level. However, the volumechip operates on 5V l

7、ogic. Therefore, transistors 7120 and 7121 form a level converter. The chip M62429 from Renesas has to receive a serial 10 bits data signal to set the desired attenuation (see below datapattern + volume code) Note: At start-up the chip is in its initial maximum attenuation of 83dB / so, when powerin

8、g up the surroundreceiver with the mains plug, no sound at all will be heard in the speakers. The transmitter in the DVD player has to send a valid volume data and clockstream to the receiver to set a volume. Of course, if the surroundreceiver starts up from standby, the volumesetting will be at its

9、 last value (The volumechip is continuously powered from the 5Vdc when the surroundreceiver is in standby condition) The DVD set sends every 4 seconds the last volumesetting to the receiver, this assures reliable volumesetting under all conditions. EN 55HTS5000W9.Exploded View & Module PWR 04-01 Non

10、-Wireless Module PWR 04-01 Non-Wireless: Circuit Diagram (Part 1) 1 2 3 4 5 6 7 seY :noi tpO B HP -7x1 2111 1 2 3 B HP 3x1 2011 1 2 3 4 B HV 4x1 1011 2114 3114 4114 5114 9114 7114 6114 Fn001 4112 Fn001 2212 Fn1 5112 F074 8812 Fn001 2112 Fn001 3112 H22 3015 R033 4113 F001 4812 R033 5113 R033 6013 R03

11、3 7013 F001 7812 K01 8013 K01 1013 K01 4013 R74 2113 K74 0113 7K4 0013 K65 3113 8K1 1213 K65 3213 K22 2213 R074 2313 613SAB 1016 NNKGKHC1LTL 0216 V6+V6+ R028 3313 613SAB 2016 613SAB 3016 613SAB 4016 NNKEKHC1LTL 1216 1 MM2. 3 ELOH 1HPN 1 MM2. 3 ELOH 2HPN HPN X 2 4110 4111 Fn1 0612 Fn022 6512 Fn074 45

12、12 R22 5413 Fn1 1612 Fn1 7512 Fn1 8512 Fn074 5512 Fn022 9512 R22 2413 Fn022 3512 Fp022 7412 Fn51 3412 R01 8413 F22 1912 F0022 9812 H22 0015 Fn022 2512 F0022 0912 H22 1015 Fp022 5412 Fp022 8412 Fp022 6412 R01 9313 Fn51 4412 Fp001 7012 Fp001 9012 V6+ GOLANA- V51- V51+ GOLANA+ REWOP+ R074 seY :noi tpO

13、8213 2K2 5213 VDDA2 3 VDDA1 10 VDDP1 14 VDDP2 23 VSSP2 20 VSSP1 17 VSSA2 1 VSSD 24 SUB/VSSD 19 VSSA1 12 -1NI 9 +1NI 8 TORP 31 1DNGS 11 CSO 7 EDOM 6 -2NI 4 +2NI 5 IBATS 81 2DNGS 2 1TOOB 51 1TUO 61 2TUO 12 2TOOB 22 REVIRD REVIRD REVIRD HGIH REVIRD WOL WOL HGIH ROSNES PMET TORP TNERRUC &LRTC -DNAH EKAH

14、S MWP DOM MWP DOM REGANAM CSO EDOM IBATS PNI EGATS &LRTC -DNAH EKAHS PNI EGATS ETUM ETUM 1PSSV 2PDDV B0298ADT 0117 Fp001 0412 Fn074 1412 Fn001 7312 Fn074 9312 Fn001 6312 Fn022 7112 K03 4413 R074 seY :noi tpO 0313 V51+ V51+ V51- V51- F74 0812 Fn001 3312 Fp022 8312 seY :noi tpO 0014 seY :noi tpO 2014

15、Fp74 1212 Fp74 0212 THGIR TFEL Fn022 9112 Fn022 6112 Fn022 8112 K93 2513 K93 3413 Fn001 3212 Fn001 4212 7K2 0513 F74 3812 Fn001 1312 Fn001 5312 Fn001 4312 5n1 7212 Fn074 9212 Fn074 8212 Fp001 2412 GOLANA+ GOLANA- GOLANA- GOLANA- GOLANA- GOLANA- REWOP- REWOP-REWOP+ REWOP+REWOP- REWOP+ 1 2 3 4 5 F2010

16、-5123RQL 0011 8B 0011 2C 1011 2D 2011 1B 3011 8A 0111 7C 1111 1C 2111 1A 0012 1B 1012 2C 2012 2C 3012 2C 4012 2C 5012 2C 6012 2B 7012 2C 8012 2B 9012 2C 0112 2A 1112 2C 2112 2C 3112 2D 4112 2D 5112 3B 6112 3A 7112 3B 8112 3A 9112 3B 0212 3A 1212 3D 2212 3A 3212 3A 4212 3D 5212 4B 6212 4A 7212 4B 821

17、2 4A 9212 3D 0312 4A 1312 4D 2312 4A 3312 4A 4312 4B 5312 5A 6312 5B 7312 5A 8312 5A 9312 5A 0412 5B 1412 5B 2412 6B 3412 6A 4412 6B 5412 6A 6412 6B 7412 6A 8412 6C 9412 6A 0512 7A 1512 7B 2512 7A 3512 7A 4512 7B 5512 7A 6512 7A 7512 7B 8512 7B 9512 7A 0612 7B 1612 2A 2612 2B 3612 5D 4612 4D 5612 4A

18、 0812 2A 1812 2B 2812 4B 3812 3C 4812 6C 5812 4D 6812 3C 7812 3D 8812 7A 9812 7B 0912 6A 1912 2C 2912 2C 3912 5D 4912 1B 1F 1B 2F 1B 3F 1B 4F 1B 5F 1B 6F 1B 7F 1B 8F 1B 9F 1B 01F 1B 11F 1B 21F 1B 31F 1C 41F 1C 51F 1C 61F 2C 71F 2C 81F 2C 91F 2D 02F 2D 12F 2D 22F 8A 32F 8B 42F 7A 52F 7C 62F 7C 72F 5C

19、 82F 5D 92F 2A 03F 2B 13F 2A 23F 3A 33F 3A 43F 3A 53F 3B 63F 4A 73F 4B 83F 4A 93F 5B 04F 5A 14F 6B 24F 6A 34F 7 5 6 2 84 M0654MJN B1117 1 3 2 1 84 M0654MJN A1117 4 4 3 3 2 2 1 1 seY :noi tpO B HP 4x1 1111 V6+ F001 5812 12MLB 7015 12MLB 8015 seY :noi tpO TKG171C-TSTL 2216 seY :noi tpO TKC171C-TSTL 32

20、16 V6+ Fn074 seY :noi tpO 9412 GOLANA+ V6+ cdV 5 :YALP : r e i f i lpmA cdV 5 .2 :ETUM r e i f i lpmA AcdV 510 :YBDNATS r e i f i lpm 1 2 3 4 5 6 7 8 9 01 11 21 31 41 51 61 N-T/NMF 61x1 3011 THGIR TFEL 1 2 3 4 5 seY :noi tpO B HV 5x1 0111 hg i h ybdna tS V2. 0 : l amroN NI 2 1 TUO 3 DNG 1TH33CF87CM

21、2117 3V3+ Fn001 5212 Fn001 0312 12MLB 6015 Fn001 2312 V05/F2 .2 1812 V05/F2 .2 2812 Fn001 1112 V5+ V5+ F001 6812 seY :noi tpO 3014 seY :noi tpO 4014 K22 3513 K22 7313 NI TFEL OIDUA NI THGIR OIDUA V6+ 3V3+ NI TFEL OIDUA NI THGIR OIDUA XR_ETUM YBDNATS KLC_LOV TAD_LOV 8114 KLC_LOV TAD_LOV Fn1 2012 Fn1

22、3012 Fn1 4012 Fn1 5012 Fn1 6012 Fn1 8012 Fn1 0112 NWODREWOP DVD_ETUM NWODREWOP YBDNATS 3V3+ K01 0213 K01 7113 K01 4213 PMA_EDOM PMA_EDOM XRETUM K01 6113 TUO_YBTS TUO_YBTS K01 2013 R001 5013 R001 3013 Fp74 0012 Fp74 1012 R001 6213 R001 7213 R001 1313 R001 4313 Option: Yes BZX384- C5V1 0116 DVD_ETUM 5

23、1C-483XZB 1116 51C97XZB 2116 51C97XZB 3116 2K2 1113 R001 9013 Fn001 0512 Fn001 1512 REWOP- H22 2015 Vin1 1 Vout1 2 GND 3 Data 4 Clock 5 Vcc 6 Vout2 7 Vin2 8 Vref LOGIC Control 2pmA loV 1pmA loV pmA f eR 2RV 1RV PF/P92426M 3117 K22 4613 K01 0613 K01 3613 K22 1613 K01 5613 K01 2613 3V3+ 3V3+ 3V3+ 3V3+

24、 V5+ V5+ B758CB 7017 3V3+ 613SAB 5016 B748CB 4017 B748CB 1017 B748CB 2017 B748CB 3017 B748CB 8017 B748CB 6017 B748CB 5017 B748CB 0217 B748CB 1217 V6+ 2K2 0713 7V4C-483XZB 4116 3F 2F 1F 4F 5F 6F 7F 8F 9F 01F 11F 21F 31F 41F 51F 61F 71F 81F 91F 02F 12F 22F 32F 42F 52F 62F 72F 82F 92F 03F 13F 23F 33F 4

25、3F 53F 63F 73F 83F 93F 04F 14F 24F 34F V6+ K65 2713 F74 2912 F74 3912 Fp074 2612 Fp074 3612 B758CB 9017 3V3+3V3+ K01 8113 K01 9113 5D 0013 4C 1013 5D 2013 4D 3013 5D 4013 4D 5013 3C 6013 3C 7013 6D 8013 7C 9013 7C 0113 7C 1113 6C 2113 5C 3113 3C 4113 3C 5113 5C 6113 5C 7113 6D 8113 6D 9113 5C 0213 5

26、C 1213 7C 2213 7C 3213 5C 4213 5C 5213 2C 6213 2C 7213 7C 8213 7C 0313 2B 1313 7B 2313 7B 3313 2B 4313 3B 5313 5B 6313 2B 7313 1B 8313 6B 9313 3B 0413 3B 1413 7B 2413 3A 3413 4A 4413 7A 5413 3A 6413 5A 7413 6A 8413 3A 9413 3A 0513 1A 1513 3A 2513 2A 3513 3A 4513 3B 5513 3B 0613 3B 1613 3C 2613 3C 36

27、13 3C 4613 3C 5613 5D 0713 6D 2713 4C 5713 4D 6713 5D 0813 6C 1813 4D 2813 2A 0014 3A 1014 2B 2014 2B 3014 2A 4014 3B 5014 5B 0114 6B 1114 2B 2114 2B 3114 2B 4114 2B 5114 2B 6114 2C 7114 2C 8114 2C 9114 3C 0214 3D 1214 6A 0015 6B 1015 3D 2015 3C 3015 4D 6015 3D 7015 3D 8015 5C 1016 6D 2016 3D 3016 5

28、C 4016 5C 5016 5C 6016 6C 0116 4C 1116 3C 2116 3C 3116 5D 4116 7B 0216 7B 1216 7B 2216 8B 3216 7D 1017 7C 2017 5D 3017 5C 4017 7C 5017 7C 6017 5C 7017 5D 8017 6D 9017 5A 0117 3A 1117 3B 1117 3D 2117 2A 3117 3B 0217 3C 1217 4C 0317 6D 1317 K1 5513 K1 4513 Fn1 4612 K01 5713 K01 6713 V6+ B748CB 0317 Fn

29、1 5612 613SAB 6016 B748CB 1317 2K2 0813 R74 1813 V6+ V05/F7 .4 4912 0214 1214 def fut s s i 5080 repmu j mho orez a * 3016 edo id fo no i t i sop eh t no K1 2813 7K4 1513 7K4 8313 K93 9413 K93 0413 K1 1014 K1 5014 5K1 6413 5K1 5313 7K2 1413 7K2 7413 7K2 6313 5n1 6212 310413700173_Sheet130_1_2005_03_

30、08.pdf_030805 EN 56HTS5000W9.Exploded View & Module PWR 04-01 Non-Wireless Module PWR 04-01 Non-Wireless: Circuit Diagram (Part 2) Conn 1100: Speaker - out Blue: left + Black: left - Grey: right + Black: right - 1 16 7113 M62429FP 7111 NJM4560 AUDIO LEFT IN 7110 TDA8920B 5100 & 2154 5101 & 2155 4 1

31、Data & Clock Levelconverter 7120 & 7121 LED GREEN 6120 & 7106 Mode - level conditioning 7104 Standby circuitry 7109, 7101, 7102 Mute circuitry 7107 Powerdown detection 7103, 7130, 713 Powerdown pulse conditioning 7108, 2194 Power supply conditioning & decoupling circuitry 6113, 6112, 7112 Power Grou

32、nd Power Ground +POWER +27Vdc +ANALOG +27Vdc -ANALOG -27Vdc -POWER -27Vdc + 6V + 5V + 3.3V + 15V - 15V +6V +3.3V _ POWERDOWN _ MUTE RX _ MUTE DVD VOL_DATA VOL_CLOCK _ STANDBY DIGITAL GROUND ANALOG GROUND ANALOG GROUND POWER GROUND +6dB _ POWERDOWN +6V _ MUTE RX _ MUTE DVD +ANALOG +6V + ANALOG+ POWER

33、 - ANALOG- POWER Connector 1103 Connector 1102 Connector 1101 1 4 1 3 AUDIO RIGHT OUT AUDIO LEFT OUT STBY_OUT F1AUDIO RIGHT IN F2 F3 F4 F5 F6 F8 F9 F10 F11 F12 F13 F14 F16 F37 F38 F39 MODE_AMP F41F43 F33 VOL_CLOCK F32 +5V F34 VOL_DATA F36 -15Vdc F35 +15Vdc F42F40 F23 F24 F25 F20 +6Vdc F22 F21 F17 +2

34、7Vdc F18 Power Ground F19 -27Vdc LED RED 6121 & 7105 “Fxx “ are testpoints as marked on the bottomside of the board +6dB Attenuator 0 to -83dB both channels +30dB +30dB 310413700173_Sheet130_2_2005_03_15.pdf_030805 EN 57HTS5000W9.Exploded View & Module PWR 04-01 Non-Wireless Module PWR 04-01 Non-Wir

35、eless: Circuit Diagram (Part 3) 1100 6A 1101 1A 1102 1D 1103 4I 1110 6B 1111 10I 1112 4I 2100 7I 2101 6H 2102 5I 2103 4H 2104 4H 2105 4H 2106 4H 2107 3I 2108 3H 2109 3H 2110 5H 2111 8H 2112 2A 2113 1B 2114 1D 2115 1D 2116 8G 2117 7F 2118 8G 2119 7F 2120 8F 2121 8E 2122 1D 2123 8E 2124 7F 2125 2G 212

36、6 8G 2127 8E 2128 8G 2129 7E 2130 3G 2131 4G 2132 3G 2133 4G 2134 6H 2135 4G 2136 5H 2137 5E 2138 6F 2139 5H 2140 5G 2141 5H 2142 5G 2143 4E 2144 5E 2145 4E 2146 6E 2147 4E 2148 6E 2149 10D 2150 4E 2151 6E 2152 4E 2153 6E 2154 7C 2155 4C 2156 7B 2157 6C 2158 5C 2159 4B 2160 6C 2161 5C 2162 8I 2163 8

37、H 2164 8A 2165 10A 2180 2C 2181 6I 2182 7H 2183 2C 2184 1I 2185 10D 2186 9I 2187 2I 2188 2D 2189 5D 2190 7D 2191 6C 2192 3A 2193 2B 2194 8C 3100 8A 3101 9A 3102 8B 3103 10H 3104 8A 3105 10H 3106 2E 3107 2F 3108 9F 3109 9B 3110 9C 3111 10C 3112 10C 3113 9F 3114 2E 3115 2F 3116 9G 3117 9F 3118 10G 311

38、9 9F 3120 9F 3121 10C 3122 10G 3123 10F 3124 9G 3125 10C 3126 6H 3127 6I 3128 10F 3130 10F 3131 6H 3132 10F 3133 10F 3134 6H 3135 8F 3136 5H 3137 6H 3138 6H 3139 5E 3140 7F 3141 8G 3142 4C 3143 8G 3144 5H 3145 7C 3146 7E 3147 5H 3148 5E 3149 7E 3150 8E 3151 6I 3152 7F 3153 7I 3154 8I 3155 8H 3160 7G

39、 3161 8H 3162 7G 3163 9I 3164 8I 3165 9I 3170 8A 3172 9G 3175 10B 3176 10A 3180 9B 3181 9A 3182 3G 4100 6I 4101 8E 4102 7H 4103 7H 4104 7I 4105 8F 4110 3G 4111 6G 4112 3I 4113 3H 4114 3H 4115 3H 4116 4H 4117 4I 4118 4H 4119 4H 4120 3C 4121 3C 5100 8D 5101 3D 5102 3B 5103 3B 5106 3G 5107 1D 5108 1C 6

40、101 9B 6102 10G 6103 10H 6104 9G 6105 9G 6106 9B 6110 10C 6111 9B 6112 3F 6113 2F 6114 8A 6120 10E 6121 10E 6122 10E 6123 10E 7101 9F 7102 9C 7103 8A 7104 9E 7105 10F 7106 10G 7107 9F 7108 8B 7109 9G 7110 5F 7111 8F 7112 2G 7113 8H 7120 8G 7121 8I 7130 10B 7131 9A F1 2I F2 2H F3 2I F4 3H F5 3I F6 3H

41、 F7 3I F8 4H F9 4I F10 6H F11 4I F12 5H F13 4I F14 5I F15 5I F16 5I F17 1A F18 1A F19 1B F20 1D F21 1D F22 1C F23 6A F24 5A F25 5C F26 10G F27 10F F28 9F F29 8B F30 7I F31 7H F32 9I F33 8I F34 8H F35 7G F36 7H F37 7G F38 6G F39 7G F40 4G F41 5G F42 5F F43 5F 310413700173_Sheet132_1_2005.03.10.pdf_03

42、1005 EN 58HTS5000W9.Exploded View & Module PWR 04-01 Non-Wireless Layout: Module PWR 04-01 Non-Wireless (Topview) 1100 6A 1101 1A 1102 1D 1103 4I 1110 6B 1111 10I 1112 4I 2100 7I 2101 6H 2102 5I 2103 4H 2104 4H 2105 4H 2106 4H 2107 3I 2108 3H 2109 3H 2110 5H 2111 8H 2112 2A 2113 1B 2114 1D 2115 1D 2

43、116 8G 2117 7F 2118 8G 2119 7F 2120 8F 2121 8E 2122 1D 2123 8E 2124 7F 2125 2G 2126 8G 2127 8E 2128 8G 2129 7E 2130 3G 2131 4G 2132 3G 2133 4G 2134 6H 2135 4G 2136 5H 2137 5E 2138 6F 2139 5H 2140 5G 2141 5H 2142 5G 2143 4E 2144 5E 2145 4E 2146 6E 2147 4E 2148 6E 2149 10D 2150 4E 2151 6E 2152 4E 2153

44、 6E 2154 7C 2155 4C 2156 7B 2157 6C 2158 5C 2159 4B 2160 6C 2161 5C 2162 8I 2163 8H 2164 8A 2165 10A 2180 2C 2181 6I 2182 7H 2183 2C 2184 1I 2185 10D 2186 9I 2187 2I 2188 2D 2189 5D 2190 7D 2191 6C 2192 3A 2193 2B 2194 8C 3100 8A 3101 9A 3102 8B 3103 10H 3104 8A 3105 10H 3106 2E 3107 2F 3108 9F 3109

45、 9B 3110 9C 3111 10C 3112 10C 3113 9F 3114 2E 3115 2F 3116 9G 3117 9F 3118 10G 3119 9F 3120 9F 3121 10C 3122 10G 3123 10F 3124 9G 3125 10C 3126 6H 3127 6I 3128 10F 3130 10F 3131 6H 3132 10F 3133 10F 3134 6H 3135 8F 3136 5H 3137 6H 3138 6H 3139 5E 3140 7F 3141 8G 3142 4C 3143 8G 3144 5H 3145 7C 3146

46、7E 3147 5H 3148 5E 3149 7E 3150 8E 3151 6I 3152 7F 3153 7I 3154 8I 3155 8H 3160 7G 3161 8H 3162 7G 3163 9I 3164 8I 3165 9I 3170 8A 3172 9G 3175 10B 3176 10A 3180 9B 3181 9A 3182 3G 4100 6I 4101 8E 4102 7H 4103 7H 4104 7I 4105 8F 4110 3G 4111 6G 4112 3I 4113 3H 4114 3H 4115 3H 4116 4H 4117 4I 4118 4H

47、 4119 4H 4120 3C 4121 3C 5100 8D 5101 3D 5102 3B 5103 3B 5106 3G 5107 1D 5108 1C 6101 9B 6102 10G 6103 10H 6104 9G 6105 9G 6106 9B 6110 10C 6111 9B 6112 3F 6113 2F 6114 8A 6120 10E 6121 10E 6122 10E 6123 10E 7101 9F 7102 9C 7103 8A 7104 9E 7105 10F 7106 10G 7107 9F 7108 8B 7109 9G 7110 5F 7111 8F 7112 2G 7113 8H 7120 8G 7121 8I 7130 10B 7131 9A F1 2I F2 2H F3 2I F4 3H F5 3I F6 3H F7 3I F8 4H F9 4I F10 6H F11 4I F12 5H F13 4I F14 5I F15 5I F16 5I F17 1A F18 1A F19 1B F20 1D F21 1D F22 1C F23 6A F24 5A F25 5C F26 10G F27 10F F28 9F F29 8B F30 7I F31 7H F32 9I F33 8I F34 8H F35 7G F36 7H F3