Philips-HDD-6330-Service-Manual(1) 电路图 维修手册.pdf

《Philips-HDD-6330-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-HDD-6330-Service-Manual(1) 电路图 维修手册.pdf（26页珍藏版）》请在收音机爱好者资料库上搜索。

1、Micro Audio Jukebox HDD6320/00/05HDD6330/17 All version 3141 785 30710 Version 1.0 TABLE OF CONTENTS Chapter Technical Specification and Service hints. 1 Safety Instructions 2 Instructions for Use . 3 Mechanical Instructions . 4 Exploded view and Service parts list . . 5 Troubleshooting flow . 6 Ove

2、rall Block diagram . 7 Overall Electrical diagram . 8 Revision list 9 Service Manual Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any mean

3、s, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips RadioFans.CN 收音机爱 好者资料库 1.0 TECHNICAL SPECIFICATION and SERVICE HINTS General Dimensions (WxLx H) : 64 x 104 x 16.8 mm (2.52 x 4.09 x 0.66 inch) Weight : 150g Output power : 2 x 5 mW (16 Ohm) Frequency res

4、ponse : 20 16000 Hz Equalizer : 5-bands Hard disk : 1.8” 30GB HDD Capacity : 30GB Display : 220 x 176 pixels, 65K color Backlight : White Battery : 830 mAh Li-ion internal rechargeable battery Battery life time: 15 hours File transfer rate using USB : 4MB/s Battery charging current 450mA Maximum cha

5、rging time : 4 hours (Full) Battery cutoff voltage: 3.5V Connections: Stereo headphone DC charger input Battery level detection Detection Level Typ. 4-step to 3-step voltage 3.6V 3.7V 3-step to 2-step voltage 3.53V3.6V 2-step to 1-step voltage 3.48V3.53V Force Power Off voltage 3.5V Current consumpt

6、ion DC-IN SUPPLY (4.5V) Battery Charging Current 450mA BATT. SUPPLY (3.7V) Power Off 300uA Idle 3mA Playback without HDD reading 41mA Playback with HDD reading 390mA File transfer using USB2.0 400mA Headphone out (headphone output load 2x16 ohm) Maximum output power : 10mW Frequency response : 45Hz-

7、16kHz 16 load 20Hz-16kHz 15k load SNR (A-wght) : 85dB THD (1kHz) : 0.1% 0.6% Left-Right Channel Separation : 40dB Left-Right Channel Balance : Programs-Philips Device Manager-Philips Device Manager on your PC 5. Click Update in the dialogue box the Philips Device Manager will detect the connection o

8、f your GoGear and the application will automatically check on the server to see if an update RadioFans.CN 收音机爱 好者资料库 1.0 TECHNICAL SPECIFICATION and SERVICE HINTS is available and prompt user to download the updated firmware. Click YES to start the downloading. 6. A status bar will show the download

9、ing progress of the firmware. Once the downloading is complete the application will prompt you to install the update onto your GoGear. Click YES to confirm 7. The application will show the status of updating and at the end you need to click OK to complete the update. (Please do not disconnect the ju

10、kebox during the upgrading process as this interruption may damage the firmware!) 8. Follow all screen instructions to complete the firmware upgrade. 9. The Device Manager will close automatically once the success message is displayed. Close all opened application and then unplug your GoGear. 10. On

11、ce the GoGear micro jukebox is disconnected from the computer, the display will show “Firmware Upgrading” for a couple of seconds and then start up as usual. If the message does not disappear after 2 minutes, do a soft reset by pressing and holding the Power on/off key and the volume + key for a cou

12、ple of seconds. Repair the firmware with Device Manager 1. If you have not already installed the Device Manager download the latest version of the Device Manager from You may need to enter your language preference and the model number e.g.HDD1630, to access the Device/Firmware Manager upgrade file.

13、2. Download the zip file into a temp folder in your computer. Unzip the file and then double click the Setup.exe file to start the installation of the Device Manager. 3. Once the installation is complete, connect the GoGear to the power supply with the AC/DC adapter. 4. Make sure all other applicati

14、ons such as Philips Device plug-in, Windows Media Player or Windows Explorer that accessing the device are closed or else Device Manager will not recognize the device. Launch the Philips Device Manager at Start- Programs-Philips Device Manager-Philips Device Manager on your PC. RadioFans.CN 收音机爱 好者资

15、料库 1.0 TECHNICAL SPECIFICATION and SERVICE HINTS 5. Click YES to start the downloading. A status bar will show the downloading progress of the firmware. Once the downloading is complete the application will prompt you to install the update onto your GoGear. 6. Once the repair is complete a dialogue

16、box will pop up; click OK and unplug the GoGear from the computer. IMPORTANT: All music fr Reparaturen sind Original-Ersatzteile zu verwenden. I Le norme di sicurezza esigono che lapparecchio venga rimesso nelle condizioni originali e che siano utilizzati i pezzi di ricambio identici a quelli specif

17、icati. After servicing and before returning set to customer perform a leakage current measurement test from all exposed metal parts to earth ground to assure no shock hazard exist. The leakage current must not exceed 0.5mA. CLASS 1 LASER PRODUCT 3122 110 03420 GBWarning ! Invisible laser radiation w

18、hen open. Avoid direct exposure to beam. SVarning ! Osynlig laserstrlning nr apparaten r ppnad och sprren r urkopplad. Betrakta ej strlen. SFVaroitus ! Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiina nkymttmlle laseristeilylle. l katso steeseen! DKAdvarse ! Usynlig laserstrling ved

19、 bning nr sikkerhedsafbrydere er ude af funktion. Undg udsaettelse for strling. 3.0 INSTRUCTIONS FOR USE Power Connector 4.0 MECHANICAL INTRUCTIONS Set Disassembly 1. Remove 2 screws at the bottom by screwdriver. 2. Use finger nail or screwdriver to carefully lift up the back cover of the device. 3.

20、 Gently open up the back cover. 4. Remove the volume button. 4.0 MECHANICAL INTRUCTIONS 5. Remove the 6 screws on two sides. 6. See pointed arrow. There are 2 screws at the bottom side and 4 screws at the top side. 7. Open up and remove the bottom part. 8. Disconnect the flex cable from the front to

21、uch screen module carefully. 4.0 MECHANICAL INTRUCTIONS 9. Turn to the back. 10. Open up the shielding carefully. 11. Be careful on the L-shape PCBA / LCD module. 12. Disconnect the flex cable of battery part from PCBA module. 4.0 MECHANICAL INTRUCTIONS 13. Disconnect the flex cable of hard disk fro

22、m PCBA module. 14. Remove the PCBA module. 15. Separate the battery from the hard disk. 5.0 EXPLODED VIEW & SERVICE PARTS LIST 102 110 111 109 108 101 106 105 104 116 115 103 107 113 114 112 MECHANICAL PARTS 100 994000003526 T-ADHESIVE TAPE HDD SPACER 101 994000003528SCREW M1,7L4WH CBZ 102 994000003

23、529 SCREW M1.7L4WH FM CBZ 103 994000003562 BACK CABINET ASSY 104 994000003536 CRADLE HOLDER ARIZONA 105994000003533SHIELDING ARIZONA 106 994000003531 HOUSING TOUCHPAD ARIZONA 107 994000003548 TACT TOPPER ARIZONA 108 994000003534 LCD ASSY ARIZONA 109994000003539 994000003541 PCBA W/Z RADIO ARIZONA (H

24、DD6330/17) PCBA W/O RADIO ARIZONA (HDD6320/00/05) 110 994000003546 BATTERY PACK 840MAH ARIZONA 111994000003549FFC ARIZONA 112 994000003535 HDD SPACER ARIZONA 113 994000003537 HDD TOP DAMPER ARIZONA 114 994000003538 HDD BOTTOM DAMPER ARIZONA 115 282206200102 HDD 1.8” 30GB ARIZONA 116 994000003542 HDD

25、 FPC ARIZONA MISCELLENEOUS 994000003543 994000003544 994000003545 AC ADAPTOR AD7130/00 AC ADAPTOR AD7133/17 AC ADAPTOR AD713B/05 994000003527 EARPHONE SHE9500 5.0 EXPLODED VIEW & SERVICE PARTS LIST 106 111 106 MECHANICAL PARTS 100 994000003526 T-ADHESIVE TAPE HDD SPACER 101 994000003528SCREW M1,7L4W

26、H CBZ 102 994000003529 SCREW M1.7L4WH FM CBZ 103 994000003562 BACK CABINET ASSY BOTTOM 104 994000003536 CRADLE HOLDER ARIZONA 105994000003533SHIELDING ARIZONA 106 994000003531 HOUSING TOUCHPAD ARIZONA 107 994000003548 TACT TOPPER ARIZONA 108 994000003534 LCD ASSY ARIZONA 109994000003539 994000003541

27、 PCBA W/Z RADIO ARIZONA (HDD6330/17) PCBA W/O RADIO ARIZONA (HDD6320/00/05) 110 994000003546 BATTERY PACK 840MAH ARIZONA 111994000003549FFC ARIZONA 112 994000003535 HDD SPACER ARIZONA 113 994000003537 HDD TOP DAMPER ARIZONA 114 994000003538 HDD BOTTOM DAMPER ARIZONA 115 282206200102 HDD 1.8” 30GB AR

28、IZONA 116 994000003542 HDD FPC ARIZONA MISCELLENEOUS 994000003543 994000003544 994000003545 AC ADAPTOR AD7130/00 AC ADAPTOR AD7133/17 AC ADAPTOR AD713B/05 994000003527 EARPHONE SHE9500 104 108 106 101 107 110 109 112 102 114 115 116105 102 113 103 103 6.0 TROUBLESHOOTING FLOW SYMPTOM 1: NO POWER 6.0

29、 TROUBLESHOOTING FLOW SYMPTOM 2: JUKEBOX FREEZES / HANGS UP Open up the unit, unplug battery connector and reconnect again 6.0 TROUBLESHOOTING FLOW SYMPTOM 3: ERROR MESSAGE SCROLLS ON THE DISPLAY 6.0 TROUBLESHOOTING FLOW SYMPTOM 4: NO SOUND 7.0 OVERALL BLOCK DIAGRAM 5 5 4 4 3 3 2 2 1 1 DD CC BB AA D

30、elete TP510 Delete C534 MBID2 w/o FMwith FM L L L L L MBID1 MBID0 H Change form 5% to 1% Modify Ref. error TP1-TP537 PP5022 R01 C 39Thursday, August 04, 2005 Arizona Title Size Document Number Rev Date:Sheetof GND_CORE_PLL GND_CORE_PLL ADC_EN XM2_MIO.RDY XM2_ROM.RDY XTAL_33M.IN I2S_SDIN GND_USB_PLL

31、GND_USB_PLL USB_VDDA XM2_MA12 XM2_MD6 DTV_PD4 LCD_D1 AT3_HD2 XM2_MD2 XM2_MD5 LCD_CS# XM2_MA1.15 XM2_MA17/CAS0# XM2_MA8 XM2_MA10 XM2_MA6 XM2_MA11 LCD_D6 LCD_RS AT3_HD8 Power_ON_Crd MBID1 GND_USB_IO MBID2 XM2_MD10 XM2_MD4 XM2_MA14 XM2_MA1 USB_RBIAS AT3_HD11 XM2_MA2 OC_USB.PWR# ADC_EN ENA_USB.PWR AT3_H

32、D4 XM2_MA25 XM2_MD11 XM2_MA18/WE# XM2_MD14 DTV_PD6 DTV_PD2 AT3_HD15 ACC_AC ACC_AC LCD_RD# LCD_D3 AT3_HD6 AT3_HD7 XM2_MA5 XM2_MIO.RDY XM2_MA26 DTV_PD5 LCD_D5 AT3_HD9 XM2_MA16/RAS0# DTV_PD7 LCD_D4 CLK_SYS.OUTR XM2_MA13 XM2_MD1 XM2_MA3 XTAL_33M.IN AT3_HD13 ANT_SW1# Vol- AT3_HD10 XM2_MA4 MBID0 XM2_MD0 H

33、old_Key# XM2_MD7 XM2_MD13 XM2_MA9 XM2_MA15 AT3_HD3 Vol+ USB_D MBID0 AT3_HD14 ACC_USB LCM_SE XM2_MA19 XM2_MD12 DTV_PD1 LCD_D7 AT3_HD5 MBID1 GND_USB_IO XM2_MD0.15 XM2_MA7 XM2_MD3 DTV_PD0 AT3_HD0 MEP_DATA_1 USB_P MBID2 ACC_USB XM2_MD8 DTV_PD3 LCD_R/W# LCD_D2 AT3_HD1 VBUS_SENSE XM2_MD15 XM2_MD9 MEP_CLK_

34、1 AT3_HD12 VCC_BATR LCD_D0 LCM_SE8 DBG3_TCK4 DBG3_TDO4 Hold_Key#6 DBG3_TMS4 XM2_DQML#4 XM2_ROM.RD#4 XM2_MA18/WE#4 XM2_MD0.154 DBG3_TRST4 DBG3_TDI4 XM2_MA20_14 XM2_MA254 XM2_ROM.RDY4 XM2_MA17/CAS0#4 PWR_OFF#6 XM2_MA264 XM2_MA194 XM2_CKE4 XM2_MA16/RAS0#4 XM2_SDR_CS0#4 CLK_SYS.OUT4 XM2_ROM.CS1#4 PSEL15

35、 XM2_MA1.154 BZZ_ON7 LCD_ON8 AT3_HA08 I2S_LRC6 AT3_HRESET# 8 XTAL_24M.IN4 XTAL_24M.OUT 4 I2S_SCLK6 I2S_SDIN6 I2C_DAT4,6,7,8 XTAL_32K.IN4 AT3_HIOR#8 AT3_HIORDY8 AT3_HA18 AT3_HIOW#8 AT3_HD0:158 CLK_24M.CODEC6 ACK6 Cradle_in#7 I2S_DOUT6 USB_DP7 USB_CHRG_CUR5 DTV_27MHZ8 DTV_PD0:78 Wake_up#7 GPIO27 GPIO1

36、7 BKL_ON8 I2C_CLK4,6,7,8 LCD_RST8 XM2_SDR_CS1#4 Line_in_SW6 RTC_ACT#5 LCD_RD#8 LCD_R/W#8 OC_USB.PWR#7 ENA_USB.PWR5,7 27M_ON8 RESET#4,7 TP_PWR#6 Cradle_REMOTE 7 MUTE6 MEP_DATA6 MEP_CLK6 AC_PWR5 LCD_CS#8 BZZ_MIXER6 EXT_ANT#6 STAT25 AT3_PWR.OFF5 LCD_D48 LCD_D38 ANT_SW1#6 REMOTE_INT7 STAT15 AT3_HIRQ.08

37、Vol-6 XM2_ROM.WR#4 BKLT_PWM#8 LCD_RS8 AT3_HCS0#8 LCD_D78 Power_Request#7 LCD_D68 LCD_D18 LEARNING5 LCD_D08 AT3_HDMACK# 8 Vol+6,7 DC-DC_RUN5 USB_DN7 XM2_DQMH#4 OC_CRL.PWR#7 REMOTE_JACK 6,7 I2C_C_EN7 AT3_HIRQ.18 LCD_D28 AT3_HDMARQ 8 Power_ON_Crd7 AT3_HCS1#8 LCD_D58 AT3_HA28 DTV_Reset#8 USBID-DEV/HOST#

38、5,7 VBUS +1.2V +1.2V+1.2V +3.3V +3.3V +1.8V +3.3V VCC_BAT +1.8V VBUS +1.8V +1.2V +3.3V +3.3V +3.3V C694 1000P 0402 50V 10% 12 C38 0.1U 0402 16V +80-20% 12 R55322 0402 5% 12 C535 0.1U 0402 16V +80-20% 12 C12 10U 0805 10V +80-20% 12 R5680 0402 12 R316.81K 0402 1% 12 R635220402 12 R540/NA0402_DFS 12 C5

39、46 1000P 0402 50V 10% 12 C538 0.1U 0402 16V +80-20% 12 TP3 1 R54922 0402 12 R558 1M 0402 1% 12 R618 0 0402 12 C531 0.1U 0402 16V +80-20% 12 C536 0.1U 0402 16V +80-20% 12 G1 S1 D1 Q6A AO7600 SC70_6_EIAJ 6 2 1 R54733 0402 5% 12 R636220402 12 C33 10U 6.3V 0805 10% 12 C552 0.1U 0402 16V +80-20% 12 R521

40、5.76K 0402 1% 12 TP513 1 R6410 0402 12 C695 1000P 0402 50V 10% 12 C540 1000P 0402 50V 10% 12 C549 0.1U 0402 16V +80-20% 12 C543 0.1U 0402 16V +80-20% 12 C533 0.1U 0402 16V +80-20% 12 C4 10P 0402 50V +/-10% 12 R648 100K 0402 12 TP503 1 C537 0.1U 0402 16V +80-20% 12 C542 0.1U 0402 16V +80-20% 12 C562

41、0.1U 0402 16V +80-20% 12 C563 0.1U 0402 16V +80-20% 12 R647 100K/NA 0402 12 R26 10K 0402 1% 12 R537100K0402 5% 12 R5240 0402 12 C21 10U 6.3V 0805 10% 12 C564 0.1U 0402 16V +80-20% 12 R21 1M 0402 1% 12 PP5022 U4 BGA240_21_065MM E7 E10 E11 K14 N5 G5 R6 U5 L2 P4 N4 M2 P3 N2 G11 P9 J3 R1 K1 L4 U1 T3 U2

42、R4 L3 G1 G2 G3 E4 D17 E13 E6 G7 N1 P2 K3 E17 G14 H14 U7 T8 R8 P8 E8 E9 T9 U8 R9 U9 K4 A17 M14 E12 P6 G16 G15 F14 E15 D12 F5 C16 F4 H2 P5 U3 T5 T4 U4 F13 U6 R5 R7 T7 N13 R3 T1 J2 H3 J4 J1 R2 T2D7 G9 K2 M4 L1 M3 M1 P1 G13 N3 H5 H8 H10 P7 U14 R15 T15 T14 U16 U15 T16 U17 K17 J15 J14 L17 K16 K15 L14 L15

43、J16 N17 C17 E16D16 H16 H15 B16 A16 B15 A15 M17 L16 P14 N15 P16 N14 R17 M15 N16 P17 M16 D13 F15 R14 B6 A10 B12 A9 H17 R13 T13 P12 C1 B1 U10 B11 A4 C13 E2 R12 D14 B4 A6 B14 R10 F1 C3 B5 P10 D3 A1 B2 A13 C10 T10 C7 T11 B10 G17 U13 C11 F3 C12 B9 J17 U12 D1 A11 D11 A14 C5 B7 A3 A12 C9 C14 U11 R11 C4 T12

44、A2 C6 E3 C2 B3 F16 F2 E1 D2 R16 T17 P15 T6 G4 H1 C15 A7 C8 B13 A8 B8 A5 P11 P13 B17 F6 F9 F12 J5 J6 J12 J13 E14 H13 J7 J9 J11 K5 K8 K10 K13 D15 F17 M6 M9 M12 N9 L5 L7 L9 L11 L13 M5 M13 N6 N7 N8 N10 N11 N12 D4 D5 D6 D8 D9 D10 E5 H4 VSS2 VSS4 VSS5 VDD_IO_5 VDD_IO_7 VSS9 RM3_SCL RM3_SDA AT3_HD04 AT3_HD

45、07 AT3_HD06 AT3_HD09 AT3_HD11 AT3_HD12 VSS12 VDD_IO_10 AT3_HA0 AT3_HD14 AT3_HA2 AT3_HCS0# AT3_S.HDMACK# AT3_H.DMARQ AT3_S.HIOR# AT3_S.HIOW# AT3_HCS1# UA3_TXD UA3_RTS UA3_RXD UA3_CTS USB_DM VDD_IO_1 VSS1 VSS10 AT3_HD10 AT3_HD15 AT3_HA1 USB_DP VDD_IO_2 VDD_IO_3 BM3_KSI.00 BM3_KSI.01 BM3_KSI.02 BM3_KSI

46、.03 VSS3 VDD_CORE_1 BM3_KSI.04 BM3_KSI.05 BM3_KSI.06 BM3_KSI.07 VDD_IO_4 USB_VSSP VDD_IO_6 VSS6 CLK_DEV.OUT XTAL_24M.IN XTAL_24M.OUT XTAL_32K.OUT XTAL_32K.IN CLK_SUS.OUT VSS7 RESERVED SPDIF_OUT SPDIF_IN I2S_RST I2S_DIN I2S_LRC I2S_DOUT I2S_SCLK VSS8 BM3_KSO.00 BM3_KSO.01 BM3_KSO.02 BM3_KSO.03 VDD_IO

47、_8 AT3_HIOW# AT3_HIOR# AT3_HIORDY AT3_HRESET# AT3_HIRQ.0 AT3_HIRQ.1 AT3_HDMARQ AT3_HDMACK#CLK_SYS.OUT VSS11 AT3_HD00 AT3_HD01 AT3_HD02 AT3_HD03 AT3_HD05 AT3_HD13 VSS13 AT3_HD08 VSS14 VSS15 VSS16 VDD_IO_9 OT3_Y.UD OT3_X.CK PM3_PWM0 OT3_Y.CK ADC_AIN.0 OT3_X.UD PM3_PWM1 ADC_AIN.1 FW3_D7 FW3_D6 FW3_D5 F

48、W3_D4 FW3_D3 FW3_D2 FW3_D1 FW3_D0 FW3_SCLK FW3_LREQ USB_RREF USB_VDDAUSB_VSSA XTAL_33M.IN XTAL_33M.OUT CD3_BCLK CD3_C2PO CD3_DATA CD3_LRCK FW3_CTL1 FW3_CTL0 DTV3_XCLK DTV3_PD.3 DTV3_PD.2 DTV3_PD.1 DTV3_PD.0 DTV3_PD.7 DTV3_PD.6 DTV3_PD.5 DTV3_PD.4 XM2_MA02 DBG3_TMS LCD3_DB7 XM2_MD05 XM2_MA10 XM2_MA00 XM2_MA14 DBG3_TDI LCD3_DB4 LCD3_DB5 LCD3_DB0 XM2_MD14 XM2_MD12 LCD