Philips-FWD-154-Service-Manual(1) 电路图 维修手册.pdf

《Philips-FWD-154-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-FWD-154-Service-Manual(1) 电路图 维修手册.pdf（30页珍藏版）》请在收音机爱好者资料库上搜索。

1、Version 1.0 FWD154 3141 785 33780 DVD Mini Hi-Fi System /98 Published by LX 0913 Service Audio Subject to modification Copyright 2009 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or trans

2、mitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. CONTENTS Technical specification .1-2 Service measurement setup.1-3 Service aids .1-4 Instructions on CD playability .2-1.2-2 Disassembly diagram. .3-1 Block diagram .4-1

3、Wiring diagram .4-2 Display board Circuit diagram .5-1.5-3 Layout diagram .5-4.5-5 AMP board Circuit diagram .6-1 Layout diagram .6-2.6-3 Cassette board Circuit diagram .7-1 Layout diagram .7-2.7-3 USB/Line in/Video out board Circuit diagram .8-1 Layout diagram .8-2 DVD board Circuit diagram .9-1.9-

4、4 Layout diagram .9-5 Exploded view diagram .10-1 Mechanical parts list .10-2 Electrical parts list.11-1 RadioFans.CN 收音机爱 好者资料库 Tuner FM Tuning Range87.5 - 108 MHz Tuning grid50 KHz Sensitivity - Mono, 26dB S/N Ratio - Stereo, 46dB S/N Ratio 22 dBu 45 dBu Search Selectivity28 dBu Total Harmonic Dis

5、tortion45 dB MW Tuning Range531 - 1602 kHz Tape deck Frequency Response - Normal tape (type I) 63-8000Hz (8dB) S/N Ratio - Normal tape (type I) 35dBA Wow and flutter82 dB/m/W Amplifier Rated Output Power2X20W RMS Frequency Response63 - 16000 Hz, 3dB Signal to Noise Ratio62dB Disc Laser TypeSemicondu

6、ctor Disc Diameter12cm/8cm Video DecodingMPEG-2/MPEG-1 Video DAC10 Bits Signal SystemPAL/NTSC Video Format4:3/16:9 Video S/N56 dB (minimum) Composite Video Output1.0 Vp-p, 75 ohm Audio DAC24Bits / 96 kHz Total Harmonic Distortion1% Frequency Response 4 Hz - 20 kHz (44.1 kHz) 4 Hz - 22 kHz (48 kHz) 4

7、 Hz - 44 kHz (96 kHz) Total harmonic distortion65 dBA General information AC power110-127V/220 - 240V, 50/60 Hz Operation power consumption 50W Standby power consumption 10W USB directVersion 2.0/1.1 Dimensions - Main Unit (W x H x D) - Speaker Box (W x H x D) 220 x 290 x 271 mm 189 x 290 x 175 mm W

8、eight - With Packing - Main Unit - Speaker Box 8.5 kg 3.8 kg 2 x 1.7 kg TECHNICAL SPECIFICATION 1 - 2 RadioFans.CN 收音机爱 好者资料库 1-3 LF Generator e.g. PM5110 Recorder Use Universal Test Cassette CrO2SBC419 4822 397 30069 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion mete e.g. Sou

9、nd Technology ST170 L R DUT or Universal Test Cassette FeSBC420 4822 397 30071 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion meter e.g. Sound Technology ST1700B L R DUT CD Use Audio Signal Disc (replaces test disc 3) SBC429 4822 397 30184 Bandpass 250Hz-15kHz e.g. 7122 707 480

10、01 LF Voltmeter e.g. PM2534 DUT S/N and distortion meter e.g. Sound Technology ST1700B Frame aerial e.g. 7122 707 89001 Tuner AM (MW,LW) To avoid atmospheric interference all AM-measurements have to be carried out in a Faradays cage. Use a bandpass filter (or at least a high pass filter with 250Hz)

11、to eliminate hum (50Hz, 100Hz). RF Generator e.g. PM5326 Ri=50? Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilotton

12、e (19kHz, 38kHz). Ri=50? Tuner FM MEASUREMENT SETUP RadioFans.CN 收音机爱 好者资料库 1-4 SERVICE AIDS GBWARNING All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connect

13、ed with the same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential. ESD CLASS 1 LASER PRODUCT GB Safety regulations require that the set be restored to its original condition and that parts which are identical with those specified, be

14、 used Safety components are marked by the symbol !. Lead free Set remains closed! N Y Play a CD for at least 10 minutes Y playability ok ? N playability ok ? add Info for customer SET OK check playability N Y playability ok ? check playability check playability return set Customer complaint CD relat

15、ed problem fast lens cleaning 1 2 3 For flap loaders (= access to CD drive possible) cleaning method 4 is recommended INSTRUCTIONS ON CD PLAYABILITY 2 - 1 Exchange CDM 1- 4 For description - see following pages 1 PLAYABILITY CHECK For sets which are compatible with CD-RW discs use CD-RW Printed Audi

16、o Disc.7104 099 96611 TR 3 (Fingerprint) TR 8 (600 Black dot) maximum at 01:00 playback of these two tracks without audible disturbance playing time for: Fingerprint10seconds Black dot from 00:50 to 01:10 jump forward/backward (search) within a reasonable time For all other sets use CD-DA SBC 444A.4

17、822 397 30245 TR 14 (600 Black dot) maximum at 01:15 TR 19 (Fingerprint) TR 10 (1000 wedge) playback of all these tracks without audible disturbance playing time for: 1000 wedge10seconds Fingerprint10seconds Black dot from 01:05 to 01:25 jump forward/backward (search) within a reasonable time 2 CUST

18、OMER INFORMATION It is proposed to add an addendum sheet to the set which informs the customer that the set has been checked carefully - but no fault was found. The problem was obviously caused by a scratched, dirty or copy-protected CD. In case problems remain, the customer is requested to contact

19、the workshop directly. The lens cleaning (method 3) should be mentioned in the addendum sheet. The final wording in national language as well as the printing is under responsibility of the Regional Service Organizations. 4 LIQUID LENS CLEANING Because the material of the lens is synthetic and coated

20、 with a special anti-reflectivity layer, cleaning must be done with a non-aggressive cleaning fluid. It is advised to use “Cleaning Solvent The actuator is a very precise mechanical component and may not be damaged in order to guarantee its full function. Clean the lens gently (dont press too hard)

21、with a soft and clean cotton bud moistened with the special lens cleaner. The direction of cleaning must be in the way as indicated in the picture below. Before touching the lens it is advised to clean the surface of the lens by blowing clean air over it. This to avoid that little particles make scr

22、atches on the lens. INSTRUCTIONS ON CD PLAYABILITY 2 - 2 DISASSEMBLY DIAGRAM VIEW 3 - 13 - 1 Loosen 8 screws PT312 in both sides. a.Plug in the 220V AC power cord , set the menu to CD function, and press STANDBY-ON button , Press OPEN/CLOSEto open CD door. b.Pull out CD door c.Press OPEN/CLOSE butto

23、n to close the CD tray, power off the mainset and unplug the AC power cord. 4) Remove top cabinet. 5) Loosen 2 screws PA3x18 to remove CD tray. 6) Loosen 6 screws T310 and 14 screws PT3x10 to remove Main board. 1 2 3 4 5 6 8 7 3) Loosen 6 screws BT312 in rear cabinet . CD DOOR 1 2 1 2 3 4 5 6 1 2 3

24、PT 3x6螺 TUNER FM/MW TAPE L/R REC L/R L/R EQ/VOL PT2314 I2C LCD DISPLAY PT1621 IR SENSOR KHS-313AAD MECHANISMS LOADER 5-CHANNELS DRIVER MCU CONTROLLER DVD/USB DECODER /SERVO AMPLIFIER 4558+TDA8948 INPUT/OUTPUT TERMINALS AUX ,LINE-IN ,USB-PORT YUV , S-VHS ,CVB ,COAXIAL,HEADPHONE TU_VCC(+9V) PWR_VCC VC

25、C_+5V MCU_VCC(3.3V) MCU_VCC(3.3V) M+5V AU_VCC +30V AU_VCC POWER MANAGEMENT +12V/+30V MCU_VCC(3.3V) VCC_+5V USB_+5V PWR_VCC(+9V) TU_VCC(+9V)AU_VCC(+9V) USB_+5V SPHE8202LQ PIC18F44J10 D5888S (TDA8947 x 2) PT7312 LV23010 120V/240V SET BLOCK DIAGRAM 4 - 14 - 1 SET WIRING DIAGRAM 4 - 24- 2 5 - 15 - 1 CIR

26、CUIT DIAGRAM - DISPLAY BOARD EQ/VOL PART CIRCUIT DIAGRAM - DISPLAY BOARD LCD PART 5 - 25 - 2 CIRCUIT DIAGRAM - DISPLAY BOARD MCU PART 5 - 35 - 3 LAYOUT DIAGRAM - DISPLAY BOARD COMPONENT SIDE VIEW 5 - 45 - 4 LAYOUT DIAGRAM - DISPLAY BOARD COPPER SIDE VIEW 5 - 55 - 5 CIRCUIT DIAGRAM - AMP BOARD 6 - 16

27、 - 1 LAYOUT DIAGRAM - AMP BOARD COMPONENT SIDE VIEW 6 - 2 6 - 2 LAYOUT DIAGRAM - AMP BOARD COPPER SIDE VIEW 6 -36 - 3 CIRCUIT DIAGRAM - CASSETTE BOARD Cassette is not repaired,diagram for referrence only. 7 - 17 - 1 LAYOUT DIAGRAM - CASSETTE BOARD COMPONENT SIDE VIEW 7 - 27 - 2 LAYOUT DIAGRAM - CASS

28、ETTE BOARD COPPER SIDE VIEW 7 - 3 7 - 3 8 - 18 - 1 CIRCUIT DIAGRAM - USB/LINE IN/VIDEO OUT BOARD 8 - 28 - 2 LAYOUT DIAGRAM - USB/LINE IN/VIDEO OUT BOARD CIRCUIT DIAGRAM - DVD BOARD DVD is not repaired,diagram for referrence only. 9 - 19 - 1 CIRCUIT DIAGRAM - DVD BOARD DVD is not repaired,diagram for

29、 referrence only. 9 - 29 - 2 CIRCUIT DIAGRAM - DVD BOARD DVD is not repaired,diagram for referrence only. 9 - 3 9 - 3 CIRCUIT DIAGRAM - DVD BOARD DVD is not repaired,diagram for referrence only. 9 - 49 - 4 LAYOUT DIAGRAM - DVD BOARD DVD is not repaired,diagram for referrence only. 9 - 59 - 5 EXPLODE

30、D VIEW DIAGRAM 10 - 110 - 1 17 27/28/29/30/31/32 36 35 19 33 25 20 26 22 24 18 40 23 45 21 49 42 41 46 16 PCB4 48 43 10 - 2 MECHANICAL PARTSLIST 16994000004734CASS DECK CS-21SC-820T 17996510022762FRONT CABINET 18996510021213CD DOOR 19996510022772CASS KEY DOOR BLACK 20996510022744CASS DOOR BLACK 2199

31、40000047027871 CASS DOOR BRACKET 22996510021198PROG. BUTTON 23996510021196POWER BUTTON 24996510021207OPEN/CLOSE BUTTON 25996510021219CLOCK BUTTON 26996510021197VOLUME BUTTON 27996510022749PAUSE BUTTON 28996510022755PLAY BUTTON 29996510022764REC BUTTON 30996510022771F.FWD BUTTON 31996510022761F.B BUT

32、TON 32996510022748STOP BUTTON 33996510022754CASS KEYS BRACKET 34996510002263FWM185 PU CASSETTE KEYS DOOR 359940000047267831 GEAR (MODE:0.8) 369940000047277831 GEAR STAND (MODE:0.8) 37996500038818RECORD SPRING 38996510021221CASS DOOR SPING D0.8mm 39996510002265FWM185 CASS KEYS DOOR SPRING 40996510022

33、843LCD BRACKET 41994000004736SLIDE SWITCH (SSV-12-8700S) 42996510022765REAR CABINET 43996510022759DVD MECH:SONY KHM-313AAD 4499651002276824 PIN FFC FLAT FLEXIBLE CABLE 45996510022756DVD LOADER(COMPLETED)WXD-8213 46996510022766TRANSFORMER UL EML662335MT 47996510022767AC CORD VDE-APP L=1650mm BLK 4899

34、65100022407671 TOP CAB 49996510002305FWM185 BASE CABINET PCB7996510022769FWD154/98 DVD MAIN BOARD ASSY PCB4996510022752CASSETTE BOARD ASSY ACCESSORIES 11996510022758RCA SINGLE WIRE #28 L=1500mm 12996510020741AUX WIRE 400mmW/3.5 STEREO BLK 13996510025191FWD154 SPEAKER BOX (L) 14996510025192FWD154 SPE

35、AKER BOX (R) 15996510022745REMOTE HANDSET Note:Only these parts mentioned in the list are normal service parts. ELECTRICAL PARTSLIST DISPLAY BOARD ASSEMBLY LCD301996510022842LCD DISPLAY :SDH-A1226-TN4A LED301996510002275LED WHITE D5mm (DL5NWCH) Q301994000003973CHIP TR MMBT9015C Q302994000003973CHIP

36、TR MMBT9015C Q307994000004004CHIP TR NPN 8050C Q401994000003973CHIP TR MMBT9015C SW301996510021215TACT SW: 6x6mmH3.5 SW302996510021215TACT SW: 6x6mmH3.5 SW303996510021215TACT SW: 6x6mmH3.5 SW304996510021215TACT SW: 6x6mmH3.5 SW305996510021215TACT SW: 6x6mmH3.5 SW307996510021215TACT SW: 6x6mmH3.5 SW3

37、08996510021215TACT SW: 6x6mmH3.5 U301996510022747IC:PIC18F45J10 (TQFP-44) U302996510013449IC FT24C02 (EEPROM) (SOP8)(EP) U304996510002274SENSOR AT136BV3 (36KHz) (3.3V) U305996510013420IC 7314 (SOP 28P)(ANGUS)(EP) U306996510002294IC D4558 (SOP8) U308996510022763IC CW1117CB-3.3V (SOT-223EP) U401994000

38、003955IC ET8861S LCD DRIVER 48P VR301996510018244ENCODER:EC121102X2B-HA1-137 XT301996500038822CRYSTAL JF32.768kHz JU2x6 XT302996500038823CRYSTAL 8MHz(HC-49US) AMP BOARD ASSEMBLY F501! 994000004782FUSE 50T D5X20 1.6A 250V(S.B.) F502! 996510002287FUSE T6.3A 250V 5x20 IC501996510009066IC TDA8948J (DBS1

39、7P)(PHILIPS) IC503996510002294IC D4558 (SOP8) Q501996510021217TR PNP 2SB1274 (TO-220F) (EP) Q502996510021406MOSFET TR IRF640N (TO-220) Q503994000004004CHIP TR NPN 8050C Q504994000004004CHIP TR NPN 8050C Q505994000003972CHIP TR MMBT9014C Q506994000004005CHIP TR PNP 8550D Q507994000003972CHIP TR MMBT9

40、014C Q508994000003972CHIP TR MMBT9014C Q509994000004004CHIP TR NPN 8050C USB BOARD ASSEMBLY J1996510022757USB JACK 5070AS-04-WH-F1 SW901996510021215TACT SW: 6x6mmH3.5 LINE IN BOARD ASSEMBLY ACK001996510002273ST PHONES JACK 3.5mm TC38 SW001996510021215TACT SW: 6x6mmH3.5 AMP EXPORT BOARD ASSEMBLY OUT101996510022746RCA JACK:3P WHITE/YELLOW/RED Note:Only these parts mentioned in the list are normal service parts. 11 - 1