Philips-MCB-395-Service-Manual(1) 电路图 维修手册.pdf

《Philips-MCB-395-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-MCB-395-Service-Manual(1) 电路图 维修手册.pdf（37页珍藏版）》请在收音机爱好者资料库上搜索。

1、 MCB395/05 Copyright 2008 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior pe

2、rmission of Philips. Published by SL 0820 Service Audio Printed in The Netherlands Subject to modification DAB Micro System Version 1.0 CLASS 1 LASER PRODUCT 3141 785 32850 TABLE OF CONTENTS Page PCBs Location & Version Variations .1-2 Specifi cations .1-3 Measurement Setup .1-4 Service Aids, Safety

3、 Instruction, etc .1-5 to 1-7 Software Version Checking .2 Set Block Diagram .3 Set Wiring Diagram .4 Main Board & MCU Board .5 Key & LCD Board .6 Power Board .7 Power AMP Board .8 ECO Power Board .9 Headphone & AUX & USB Board .10 Set Mechanical Exploded View & Parts List . 11 RadioFans.CN 收音机爱 好者资

4、料库 KEY & LCD BOARD ECO POWER BOARD MAIN BOARD POWER BOARD POWER AMP BOARD /12 /58 n iRDC/n ixuA Line Out Video Out Subwoofer Out Digital Out Karaoke Features Voltage Selector ECO Power Standby (LCD Display Off) USB Direct Type /Versions: MCB395 Features in used: /05 VERSION VARIATIONS Type /Versions

5、: Board in used: MCB395 Service policy MAIN BOARD POWER BOARD POWER AMP BOARD ECO POWER BOARD * TIPS : C - Component Lever Repair. M - Module Lever Repair - Used C /12 /05855/9/16/85/ Feature diffrence KEY & LCD BOARD C C C DAB MODULEM x x x 1 - 2 PCBS LOCATION USB & AUX & HP BOARDC C MCU BOARD MCU

6、BOARDC RadioFans.CN 收音机爱 好者资料库 1 - 3 AMPLIFIER Output power .2 x 50 W RMS .100 W + 100 W MPO Signal-to-noise ratio. ? 62 dBA (IEC) Frequency response .40 15000 Hz, 3 dB Impedance loudspeakers . 4 ? Impedance headphones .32 ? -1000 ? CD/MP3-CD PLAYER Number of programmable tracks . 20 Frequency range

7、 . 20 20000 Hz Signal-to-noise ratio. 75 dBA Channel separation .? 50 dBA (1 kHz) Total harmonic distortion.? 0.5% MPEG 1 Layer 3 (MP3-CD) .MPEG AUDIO MP3-CD bit rate . 32-256 kbps (128 kbps advised) Sampling frequencies .32, 44.1, 48 kHz USB PLAYER USB . 12Mb/s, V1.1 Number of albums/folders .maxim

8、um 99 Number of tracks/titles.maximum 999 TUNER FM wave range .87.5 108 MHz Sensitivity at 75 ? mono, 26 dB signal-to-noise ratio . 2.8 V stereo, 46 dB signal-to-noise ratio . 61.4 V Total harmonic distortion. ? 5% Frequency response . 63 12500 Hz ( 3 dB) Signal-to-noise-ratio . ? 50 dBA DAB wave ra

9、nge .174-240 MHz SPEAKERS 2-way Bass reflex system GENERAL INFORMATION AC Power .220 230 V / 50 Hz Standby Power Consumption .? 7W ECO Standby Power Consumption .? 1W Dimensions (w x h x d) Main unit (w x h x d) . 152 x 228 x 285 mm Speaker box (w x h x d) 152 x 228 x 257 mm Weight With Packing . 8.

10、92 kg Main Unit . 3.66 kg Speaker box . 4.13 kg Specifications and external appearance are subject to change without notice. SPECIFICATIONS RadioFans.CN 收音机爱 好者资料库 1 - 4 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion meter e.g. Sound Technology ST1700B L R DUT CD Use Audio Sign

11、al Disc (replaces test disc 3) SBC429 4822 397 30184 Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT S/N and distortion meter e.g. Sound Technology ST1700B Frame aerial e.g. 7122 707 89001 Tuner AM (MW,LW) To avoid atmospheric interference all AM-measurements have to be carried

12、 out in a Faradays cage. Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz). RF Generator e.g. PM5326 Ri=50 Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST17

13、00B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Ri=50 Tuner FM MEASUREMENT SETUP 1 - 5 SERVICE AIDS GBWARNING All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling during repair can redu

14、ce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential. ESD CLASS 1 LASER PRODUCT GB Safety regulations require that the set be restored to its original co

15、ndition and that parts which are identical with those specified, be used Safety components are marked by the symbol !. Lead free Set remains closed! N Y Play a CD for at least 10 minutes Y playability ok ? N playability ok ? add Info for customer SET OK check playability N Y playability ok ? check p

16、layability check playability return set Customer complaint CD related problem fast lens cleaning 1 2 3 For flap loaders (= access to CD drive possible) cleaning method 4 is recommended INSTRUCTIONS ON CD PLAYABILITY 1 - 6 Exchange CDM 1- 4 For description - see following pages 1 PLAYABILITY CHECK Fo

17、r sets which are compatible with CD-RW discs use CD-RW Printed Audio Disc.7104 099 96611 TR 3 (Fingerprint) TR 8 (600 Black dot) maximum at 01:00 playback of these two tracks without audible disturbance playing time for: Fingerprint10seconds Black dot from 00:50 to 01:10 jump forward/backward (searc

18、h) within a reasonable time For all other sets use CD-DA SBC 444A.4822 397 30245 TR 14 (600 Black dot) maximum at 01:15 TR 19 (Fingerprint) TR 10 (1000 wedge) playback of all these tracks without audible disturbance playing time for: 1000 wedge10seconds Fingerprint10seconds Black dot from 01:05 to 0

19、1:25 jump forward/backward (search) within a reasonable time 2 CUSTOMER INFORMATION It is proposed to add an addendum sheet to the set which informs the customer that the set has been checked carefully - but no fault was found. The problem was obviously caused by a scratched, dirty or copy-protected

20、 CD. In case problems remain, the customer is requested to contact the workshop directly. The lens cleaning (method 3) should be mentioned in the addendum sheet. The final wording in national language as well as the printing is under responsibility of the Regional Service Organizations. 4 LIQUID LEN

21、S CLEANING Because the material of the lens is synthetic and coated with a special anti-reflectivity layer, cleaning must be done with a non-aggressive cleaning fluid. It is advised to use “Cleaning Solvent The actuator is a very precise mechanical component and may not be damaged in order to guaran

22、tee its full function. Clean the lens gently (dont press too hard) with a soft and clean cotton bud moistened with the special lens cleaner. The direction of cleaning must be in the way as indicated in the picture below. Before touching the lens it is advised to clean the surface of the lens by blow

23、ing clean air over it. This to avoid that little particles make scratches on the lens. INSTRUCTIONS ON CD PLAYABILITY 1 - 7 1) MCU version : at standby mode, press and hold ALBUM - & STOP buttons at the same time. e.g. V2.01G Software checking: SOFTWARE VERSION CHECKING 2 - 1 2 - 1 SET BLOCK DIAGRAM

24、 3 - 1 3 - 1 SET WIRING DIAGRAM 4 - 1 4 - 1 5 - 15 - 1 CIRCUIT DIAGRAM - MAIN BOARD CD PART 5 - 25 - 2 CIRCUIT DIAGRAM - MAIN BOARD DAB PART 5 - 35 - 3 CIRCUIT DIAGRAM - MAIN BOARD TUNER PART 5 - 45 - 4 CIRCUIT DIAGRAM - MAIN BOARD INTERFACE PART LAYOUT DIAGRAM - MAIN BOARD TOP VIEW 5 - 5 5 - 5 LAYO

25、UT DIAGRAM - MAIN BOARD BOTTOM VIEW 5 - 6 5 - 6 5 - 7 PCB LAYOUT - MCU BOARD 5 - 7 5 - 8 CIRCUIT DIAGRAM - MCU BOARD 5 - 8 5 - 9 CIRCUIT DIAGRAM - MCU BOARD MEMORY PART 5 - 9 CIRCUIT DIAGARM - KEY & LCD BOARD KEY PART 6 - 16 - 1 CIRCUIT DIAGARM - KEY & LCD BOARD LCD PART 6 - 26 - 2 LAYOUT DIAGARM -

26、KEY & LCD BOARD TOP VIEW 6 - 36 - 3 LAYOUT DIAGARM - KEY & LCD BOARD BOTTOM VIEW 6 - 46 - 4 CIRCUIT DIAGARM - POWER BOARD PART 1 7 - 17 - 1 CIRCUIT DIAGARM - POWER BOARD SUB MCU PART 7 - 27 - 2 LAYOUT DIAGARM - POWER BOARD TOP VIEW 7 - 37 - 3 LAYOUT DIAGARM - POWER BOARD BOTTOM VIEW 7 - 47 - 4 CIRCU

27、IT DIAGARM - POWER AMP BOARD 8 - 18 - 1 LAYOUT DIAGARM - POWER AMP BOARD 8 - 28 - 2 9 - 19 - 1 CIRCUIT DIAGRAM - ECO POWER BOARD LAYOUT DIAGRAM - ECO POWER BOARD 9 - 29 - 2 10 - 110 - 1 CIRCUIT DIAGRAM - HEADPHONE BOARDCIRCUIT DIAGRAM - AUX BOARD LAYOUT DIAGRAM - HEADPHONE BOARDLAYOUT DIAGRAM - AUX

28、BOARD CIRCUIT DIAGRAM - USB BOARD 10 - 210 - 2 LAYOUT DIAGRAM - USB BOARD 5A 5 2 151413 4 3 CDM 43 CDMECH 30 37 SET MECHANICAL EXPLODED VIEW 11 - 1 56 5354 55 12 1110976 49 SPR DAMP 11 - 1 MECHANICAL & ACCESSORIES PARTS LIST 2996510012826 DECORATION LENS BOTT PANELREM 996510003938 REMOTE CONTROL 399

29、6510012799 CD DOOR SPK996510016285 WOODEN SPEAKER BOX(L+R) 4996510016270 DECORATION LENS MIDD PANEL W2996510016286 FFC R/A TYPE 16PIN L=230MM 5996510012851 VOLUME KNOB W3996510016287 FFC CABLE L=160MM 26PINS 6996510016271 DECORATION LENS TOP PANEL W4996510016288 FFC CABLE 20PINS L=140MM 799651001280

30、6 DISPLAY LENSW7!996510016289BS POWER SUPPLY CORD 1980mm 9996510016272 DECORATION RING W9996510001906 AUX STEREO CORD BLACK 10996510016273 CONTROL KNOB-PRESETS(DN) DAB500996510003725 DAB TUNER MODULE 11996510016274 CONTROL KNOB-PLAY/PAUSE 12996510016275 CONTROL KNOB-FB 13996510016276 FRONT CABINET 1

31、4996510016277CONTROL KNOB-TOP-LEFT 15996510016278 CONTROL KNOB-TOP-RIGHT 30996510012849 TOP CABINET 37996510016280 REAR CABINET 43996510016281 BOTTOM CABINET 49996510012827 USB LIGHT GUIDE 53996510016282CONTROL KNOB-STOP 54996510016283 CONTROL KNOB-PRESETS(UP) 55996510016284 CONTROL KNOB-FF 56996510

32、012824 USB DOOR 5A996510012828 VOLUME KNOB LIGHT GUIDE SPR996510012846 USB DOOR SPRING CDM994000003392 CD MECHANISM DA11B3VF (SANYO) CDMECH996510000871 CD TRAY LOADER CDSP996510001074 CD SPRING DIM:0.5MM DAMP 996510000868CD DAMPER PINK 658F Note: Only these parts mentioned in the list are normal ser

33、vice parts. 11 - 2 ELECTRICAL PARTS LIST C402996510016290 E.CAP 3300UF 16V 13X26MM M%IC502 994000003215 RDS IC SAA6581T C627 996510012837 CBB CAP HMFS-5 0.68UF 63VIC503 996510003731 IC V REGULATOR LD1117-3.3 C628 996510012837 CBB CAP HMFS-5 0.68UF 63VIC600 996510012838 I.C TDA8920BTH SOT566-3 C636 9

34、96510012836 E.CAP. 3300UF 35VIC801 996510003730 IC SAA7824HL/M1A 557 C637 996510012836 E.CAP. 3300UF 35VIC802 994000005753 IC D9258PH C642 996510012836 E.CAP. 3300UF 35VIC803 996510003896 IC TA7291S(M) (MOTOR DRIVER) C643 996510012836 E.CAP. 3300UF 35VIR701 996510016297 INFRARED RECEIVER SM3385JB C6

35、46 996510004554 CBB CAP HMFS-5 0.47UF 63VJK750 996510003842 USB CONNECTOR 4PINS CN600 996510000380 PUSH TERMINAL JACK PST-418LCD701996510016326LCD DISPLAY D302996510011332DIODE 1N4148Q408996500039268TRANSISTOR KTC-8050C D304996510003726BARRIER DIODE PRLL5817Q409996510012833TRANSISTOR BC857B D3059965

36、10011332DIODE 1N4148Q500996510012793TRANSISTOR BC847B D306996510003726BARRIER DIODE PRLL5817Q501996510003718TRANSISTOR KTC-8550C D400 996510016291 DIODE 1N4007Q502996510012793TRANSISTOR BC847B D401996510016291DIODE 1N4007Q510996510003718TRANSISTOR KTC-8550C D402996510011340DIODE 1N5819 DO-41Q5119965

37、10012793TRANSISTOR BC847B D403 996510011332 DIODE 1N4148Q520 996510012793 TRANSISTOR BC847B D404 996510011332 DIODE 1N4148Q531 996510012793 TRANSISTOR BC847B D406 996510016292 ZENER DIODE 3V6 1/2W (TC3V6)Q532 996510012793 TRANSISTOR BC847B D407 996510011332 DIODE 1N4148Q600 996510015685 TRANSISTOR B

38、C807-25 SOT23 D408 996510016291 DIODE 1N4007Q601 996510010776 TRANSISTOR BC817-25 SOT23 D409 996510016291 DIODE 1N4007Q602 996510010776 TRANSISTOR BC817-25 SOT23 D600 996510012835 ZENER DIODE 5V6 1/2W (TC5V6)Q801 996510012793 TRANSISTOR BC847B D701 996510016293 LED RED/GRN 3RG9SW-1-AQ802 99651000371

39、8 TRANSISTOR KTC-8550C D704 996510001422 LED INDICATOR BLUEQ803 996510003718 TRANSISTOR KTC-8550C D705996510001422LED INDICATOR BLUEQ804996510012793TRANSISTOR BC847B D706996510001422LED INDICATOR BLUESW701996500039269TACT SWITCH D707996510001423LED INDICATOR 3mm WHITESW702996500039269TACT SWITCH D70

40、8996510001423LED INDICATOR 3mm WHITESW703996500039269TACT SWITCH D709996510001423LED INDICATOR 3mm WHITESW704996500039269TACT SWITCH D750996510016294LED INDICATOR BLUE 3X5MMSW705996500039269TACT SWITCH DB600 994000003223 DIODE BRIDGE RECTIFIER GBU6BSW706 996500039269 TACT SWITCH F950! 996510000390 F

41、USE 3.15A 250VSW707 996500039269 TACT SWITCH F951! 996510000390 FUSE 3.15A 250VSW708 996500039269 TACT SWITCH HP750 996510001073 EARPHONE CKX3.5-19S (3PIN)SW709 996500039269 TACT SWITCH HP751994000001456STEREO HEADPHONE JACKSW710996500039269TACT SWITCH IC300996510016295IC ATMEGA88-20AU FOR MCB395 SW

42、711996500039269TACT SWITCH IC301996510003731IC V REGULATOR LD1117-3.3SW712996500039269TACT SWITCH IC402 996510003846 IC SC7314 SELECTOR & E_VOLT950! 996510012812 TRASFO EI-76 230V/50Hz IC403 996510003845 IC LP2950ACZ-3.3 TO-92T951! 996510001418 TRASFO STANDBY IC404 996510001055 IC BA4558 SOP8TC530 9

43、94000002418 TRIMMER CAP 220VDC 50%-0% IC407 996510005007 IC LM2576 T-5.0 TO-220U1996510003740IC WM8725ED 14-PIN SOIC IC431 996510016296 IC YD7000U2996510016298IC SST39VF800A-70 PROGRAMMED IC500 996510003733 IC UTCLD1117/A 1.8V SOT-223U4996510016299IC HY57V641620FTP-7 64M SDRAM IC501 996510003732 IC TB2132FNGU5996510003739IC TCC760 11 - 3 ELECTRICAL PARTS LIST U7996510003738IC MAX809STR SOT-23 VD533996510003727DIODE 1SV262 VD534996510003727DIODE 1SV262 VR701996510001059ENCODER EC121102X2B-HA1-082 X