Philips-FWD-17-Service-Manual(1) 电路图 维修手册.pdf

《Philips-FWD-17-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-FWD-17-Service-Manual(1) 电路图 维修手册.pdf（49页珍藏版）》请在收音机爱好者资料库上搜索。

1、Version 3.0 FWD16, FWD17 3141 785 30412 Mini System all versions Published by YT 0747 Service Audio Subject to modification Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or

2、transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. From week 619 onwards, the DVD Drive was changed from KSM310AAA to DM3151-B. New MPEG Board and Display Borad Assy are used to match with the new DVD Drive. Please re

3、fer chapter 6 to 12 for sets produced before week 618 and chapter 13 to 19 for sets produced in or after week 619. RadioFans.CN 收音机爱 好者资料库 For sets produced before week 618 (GW1006180 xxxxx) Block diagram .6-1 Wiring diagram .6-2 Display / Tuner board circuit diagram .7-1 layout diagram .7-2 Main an

4、d Power board circuit diagram .8-1 layout diagram .8-2.8-3 Cassette board circuit diagram. .9-1 layout diagram .9-2 DVD / MPEG board circuit diagram .10-1 layout diagram .10-2.10-3 Exploded view diagram . 11-1 Mechanical partslist . 11-2 Electrical partslist .12-1 TABLE OF CONTENTS Handling chip com

5、ponents .1-1 Service tools .1-1 Leadfree and safety information .1-2 Technical specification .2-1 Service measurement setup .2-2 Connections and controls .3-1.3-5 Disassembly diagram .4-1.4-2 Service Test Program .5-1 For sets produced in or after week 618 (GW2006190 xxxxx up) Block diagram .13-1 Wi

6、ring diagram .13-2 Display / Tuner board circuit diagram .14-1 layout diagram .14-2 Main and Power board circuit diagram .15-1 layout diagram .15-2.15-3 Cassette board circuit diagram. .16-1 layout diagram .16-2 DVD / MPEG board circuit diagram .17-1.17-4 layout diagram .17-5 Exploded view diagram .

7、18-1 Mechanical partslist .18-2 Electrical partslist .19-1.19-3 Revision .20-1 RadioFans.CN 收音机爱 好者资料库 1 - 1 HANDLING CHIP COMPONENTS RadioFans.CN 收音机爱 好者资料库 1 - 2 2 - 1 GENERAL Mains voltage -/21/21M : 120 / 230 V Mains frequency -/21/21M : 50 / 60 Hz Battery remote : 3V (R06 x 2) Power consumption

8、 Max. : 70 W (max.) Standby : 15 W Dimension (W x H x D) : 436 x 86 x 337 mm Weight : 5.5 Kg No voltage selection is available in sets, which are produced after week 619. AMPLIFIER Output power : 2 x 30 W RMS : 1200 W PMPO Speaker impedance : 2 x 6 ohm Frequency response : 63 Hz - 16 kHz (3dB) Aux i

9、nput sensitivity : 500mV (600 ohm) Line Out : 1 2 V RMS (10 Kohm) TUNER - FM SECTION Tuning range : 87.5 108.5 MHz IF frequency : 10.7 MHz 0.2 MHz Sensitivity : 22 dBf at 46dB S/N Selectivity : 20 dB at 300kHz IF rejection : 50 dB Image rejection : 20 dB PECIFICATION TUNER - AM SECTION Tuning range

10、AM(MW) : 515 - 1646 kHz IF frequency : 455 kHz 3 kHz Sensitivity MW : 3250 V/m at 26dB S/N Selectivity MW : 20 dB IF rejection MW : 24 dB Image rejection MW : 28 dB AUDIO CASSETTE RECORDER Number of tracks : 1 stereo Tape speed : 4.76 cm/sec 3% Wow & flutter : 0.4% DIN Fast wind/rewind C60 : 170 sec

11、. Frequency response P/B : 80 12.5 Hz S/N ratio : 50 dB Bias frequency : 73 10 kHz DVD / MP3 / CD Laser Type : Semiconductor Disc Diameter : 12cm / 8cm Video Decoding : MPEG-2 / MPEG-1 Signal System : PAL / NTSC Video S/N : 56 dB (min.) Composite Video Output : 1.0 Vp-p, 75 ? S-Video Output : Y - 1.

12、0 Vp-p, 75 ? C - 0.286 Vp-p, 75 ? Audio DAC : 24 Bits / 96 kHz Frequency Response : 4 Hz - 20 kHz (44.1kHz) 4 Hz - 22 kHz (48kHz) 4 Hz - 44 kHz (96kHz) Digital Output : SPDIF (Sony Philips digital interface) Coaxial No. of programmable tracks : 20 Signal-to-noise ratio : ? 50 dBA Channel separation

13、: ? 40 dB (1 kHz) Total harmonic distortion : 0.02% (1 kHz) LOUDSPEAKERS 2-way bass reflex system Dimension (W x H x D) : 185 x 310 x 235 mm Weight : 2.5 Kg Note: Specification of FWD16 loudspeakers may be different SPECIFICATION 2 - 2 SERVICE MEASUREMENT Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF

14、Voltmeter e.g. PM2534 DUT RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Tuner FW Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Ri=50 Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT S/N a

15、nd distortion meter e.g. Sound Technology ST1700B Frame aerial e.g. 7122 707 89001 Tuner AM (MW,LW) To avoid atmospheric interference all AM-measurements have to be carried out in a Faradays cage. Use a bandpass filter (or at least a high pass filter with 250kHz) to eliminate hum (50Hz, 100Hz). RF G

16、enerator e.g. PM5326 Ri=50 L R LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion meter e.g. Sound Technology ST1700B DUT CDRECORDER Use Audio Signal Disc SBC429 4822 397 30184 (replaces test disc 3) Use Universal Test Cassette Fe SBC420 4822 397 30071 L R LEVEL METER e.g. Sennheis

17、er UPM550 with FF-filter S/N and distortion meter e.g. Sound Technology ST1700B DUT LF Generator e.g. PM5110 Ri=50 3 - 1 CONNECTION AND CONTROLS 3 - 2 CONNECTION AND CONTROLS 3 - 3 CONNECTION AND CONTROLS 3 - 4 CONNECTION AND CONTROLS 3 - 5 CONNECTION AND CONTROLS For more information onoperation in

18、struction please visit Philips Audio internet site : 4 - 14 - 1 DISASSEMBLY INSTRUCTION A2 A1 A2 A. Remove Top Cover A1 remove screws M3x6 - 4 pcs. A2 remove screws M3x6 - 4 pcs. A3 A3 lift up the top cover. B. Remove Cassette mechanism B1 remove screws T3x10 - 4 pcs. B1 C1 C. Remove DVD Loader C1 r

19、emove screws M3x8 - 4 pcs. E1 D D. Remove Cassette mechanism D1 remove screws M3x6 - 6 pcs. D. Remove Cassette mechanism D1 remove screws M3x6 - 6 pcs. 4 - 24 - 2 DISASSEMBLY INSTRUCTION F1 F. Remove DVD / MPEG board F1 remove screws M3x6 - 4 pcs. G1 G2 G2 H. Remove Front Panel Assembly H1 remove sc

20、rews M3x8 (+ fi bre washers) - 9 pc. G2 remove screws M3x8 (C-head) - 2 pc. H1 G. Remove Front Panel Assembly G1 remove screws M3x6 - 1 pc. 5 - 1 N Y REPEAT SHUFFLE button pressed? PLAY button pressed? N Y Display shows all segments and flags for checking open circuits. see figure 1 DISPLAY TESTFACT

21、ORY RESET VERSION CHECK MACROVISION CHECK Display shows BLANK fig. 1 N Y Display shows EEPROM is cleared and default values are stored. This test should be done at the end of the production process so that every set is customised before leaving factory. Software Version is also display on the TV scr

22、een. FWD17_V0.02.21M.R3 : The model number is FWD17. Software version is V0.02. Distination region is 21M. Region code for DVD disc is Region 3. Display shows software version. X:XX is the software version, eg. U 0:02 FWD17_V0.02.21M.R3 N Y PLAY button pressed? STOP button pressed? Macrovision versi

23、on number is display on the TV screen. MV.05.01.28.01 To enter Service Test program, hold PLAY & STOP buttons depressed while switch the source to DISC. U X:XX SERVICE TEST PROGRAM 5 - 1 6 - 16 - 1 SET BLOCK DIAGRAM 6 - 2 6 - 2 SET WIRING DIAGRAM 7 - 17 - 1 CIRCUIT DIAGRAM - DISPLAY / TUNER BOARD 7

24、- 27 - 2 LAYOUT DIAGRAM - DISPLAY / TUNER BOARD COMPONENT SIDE COPPER SIDE 8 - 18 - 1 CIRCUIT DIAGRAM - MAIN AND POWER BOARD 8 - 28 - 2 LAYOUT DIAGRAM - MAIN AND POWER BOARD (SIDE A) 8 - 38 - 3 LAYOUT DIAGRAM - MAIN BOARD (SIDE B) 9 - 19 - 1 R IN L IN GND R OUT L OUT + TAPE ? ? ? ? ? ? ? ? ? ? ? ? ?

25、 ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? DECK M + MOTOR GND +1 LEFT MOTOR EL

26、ECTROLYTIC CAPACITOR MYLAR CAPACITOR PLATE CERAMIC CAPACITOR ALL TUBULAR CERAMIC CAPACITORS UNLESS OTHERWISE STATED. ALL CARBON RESISTORS E12 SERIES G = 50V f = 25V 0.33W 5% UNLESS OTHERWISE STATED. ? 123456987101112131415181716 PLAYRECORD 1707 RECORD PLAY -V 5V 5V1 0V 0V 1V5 1V7 2V6 4V2 1V5 0V 0V 2

27、V6 0V REC INFO (REC=L) OPT OPT OPT OPT = OPTIONAL / Used for some Versions d = 10V E = 16V OPT 1725 FE 1 2 3 4 5 6 ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? 74 1 2 3 2710 ? 100u 2703 22u ? 2704 22u ? 2706 ? 47u 2707 ? 220u 2708 ? 47u 2709 ? 47u 2711 22u ? 2799 ?

28、 470u 2760 ? 47u T708 T707 T710 T722 T725 T712 T709 T706 T711 T723 T724 T718 T717 T701 T721 T702 T705 T719 T716 ? ? ? 8704 8704 8705 8705 k01 3734 73 1 2 71 1 2 3762 6k5 3761 6k5 3747 150R 3701 100R 3703 R051 3704 220 3706 330k 3707 470k 3710 k72 3712 12k 3713 R051 3714 220 3716 330k 3719 k72 3720 1

29、2k 3722 k22 3723 k22 3726 2k2 3727 2k2 3730 R051 3731 K65 3732 R51 3733 7M4 3743 R074 3744 R074 3748 R074 3749 R074 5701 b a d c 87024 87023 87022 87021 1702 1 2 3 4 ? ? 7705 12 8 9 11 5 10 13 14 AN7323 NF2 IN2 RF Vcc REF1 ALC2 REF2 OP2 7705 3 2 1 7 6 4 AN7323 NF1 IN1 GND ALC-TC ALC1 OP1 -V 3V4 V78

30、0V3 ? ? 1707 R 14 P 13 15 1707 R 17 P 16 18 1707R 5 P 4 6 1707R 2 P 1 3 1707 R 8 P 7 9 12 10 11 1707 R P 7702 BC337-25 1709 1 2 3 4 5 6 CIRCUIT DIAGRAM - CASSETTE BOARD 9 - 29 - 2 LAYOUT DIAGRAM - CASSETTE BOARD ECO- MTF- SD R- 1 98- 12- 15 98- 12- 15 3140 113 31231 ECO- MTF- SD A RP 3140 113 31231

31、9758 98- 12- 15 C 2730 7702 9754 9755 9762 2703 2710 2711 2731 2732 2733 3732 3747 5701 2734 2760 3742 71 74 37203721 3735 9757 1707 9751 2727 9756 9701 9702 9703 9705 9707 3733 3744 3761 3762 6704 7705 3712 3713 3716 3719 3730 3731 2723 2726 2750 2751 3706 3707 3711 2713 2715 2716 2720 2721 2722 27

32、00 2707 2708 2709 2712 3726 3727 3743 6715 7703 7704 9760 2704 2706 2719 2735 3701 3710 27383734 72 9706 9752 9753 9759 9761 3740 3748 3749 3750 7701 3703 3704 3714 3722 3723 3736 3737 3738 27012714 2728 2729 2739 2740 1702 1709 17211722 1725 1701 3724 3728 3739 73 RSH +M RW 2717 2718 - M YSH 12345

33、12345 D C B A D C B A 71 A 1 72 D 5 73 A 5 74 A 1 1701 A 5 1702 B 5 1707 D 3 1709 C 5 1721 B 5 1722 B 5 1725 C 5 2700 B 4 2701 B 5 2703 C 2 2704 A 3 2706 A 3 2707 B 2 2708 B 4 2709 C 3 2710 B 1 2711 B 2 2712 D 1 2713 B 3 2714 B 4 2715 B 3 2716 B 3 2717 C 3 2718 B 3 2719 A 3 2720 C 3 2721 C 4 2722 C

34、2 2723 C 2 2726 C 2 2727 D 2 2728 C 5 2729 C 5 2730 D 1 2731 C 1 2732 B 1 2733 C 1 2734 A 1 2735 A 1 2738 D 4 2739 C 4 2740 C 4 2750 B 3 2751 C 2 2760 A 2 3701 A 2 3703 B 4 3704 B 4 3706 B 3 3707 B 2 3710 A 3 3711 C 3 3712 D 1 3713 C 3 3714 C 4 3716 C 3 3719 C 2 3720 D 2 3721 D 3 3722 D 5 3723 C 5 3

35、724 A 5 3726 A 3 3727 A 3 3728 A 4 3730 B 1 3731 B 1 3732 B 1 3733 B 2 3734 D 5 3735 D 3 3736 B 5 3737 C 5 3738 C 5 3739 A 5 3740 B 4 3742 B 1 3743 A 2 3744 B 2 3747 B 1 3748 D 4 3749 C 5 3750 D 4 3761 C 2 3762 B 3 5701 C 1 6704 B 2 6715 A 2 7701 B 4 7702 B 1 7703 A 4 7704 A 4 7705 B 3 9701 D 2 9702

36、 D 3 9703 D 3 9705 C 4 9706 D 5 9707 C 2 9751 D 3 9752 D 5 9753 D 5 9754 C 1 9755 D 1 9756 C 3 9757 D 3 9759 D 4 9760 A 2 9761 B 5 9762 D 1 T701 C 5 T702 C 5 T705 B 5 T706 B 5 T709 A 5 T710 C 1 T711 B 5 T712 C 2 T713 A 5 T714 D 5 T715 D 5 T716 D 1 T719 B 1 T720 A 5 T721 C 5 T722 C 2 T725 D 2 T7707 A

37、 4 T7708 A 4 CASSETTE ADJUSTMENT AdjustmentCassetteSK .Deck 1MeasureReadAdjustAdjust ononwithto Left hand Azimuth 10 kHz SBC420* SBC420* TapePlayH/P JackmV meterScrewmax. R/P head 3150 kHz Wow and TapePlayH/P Jackflutter Preset in motor *a meter *a The maximum permissible speed deviation is 3%. * SB

38、C420 : 4822 397 30071 Morever, the wow and flutter value can be read. Motor Speed 10 - 110 - 1 CIRCUIT DIAGRAM - DVD MPEG BOARD 10 - 210 - 2 LAYOUT DIAGRAM - DVD MPEG BOARD 10 - 310 - 3 LAYOUT DIAGRAM - DVD MPEG BOARD 11 - 111 - 1 EXPLODED VIEW DIAGRAM 11 - 2 ACCESSORIES 9940 000 02594REMOTE CONTROL

39、 (FWD17) 9940 000 02595AM LOOP ANT 9940 000 02596RCA CABLE COMP VIDEO (R/B/G) 9940 000 02597RCA CABLE VIDEO (YELLOW) 9940 000 02598RCA CABLE AUDIO (RED/WHITE) 9940 000 02599SPEAKER BOX 4 6OHM 30W (for FWD17 only) MECHANICAL PARTS LIST 19940 000 02619KNOB VOLUME 29940 000 02618KNOB TUNING 39940 000 0

40、2617KNOB SOURCE 49940 000 02629KNOB MIC VOLUME 69940 000 02602DOOR CD (DVD) 79940 000 02601PANEL FRONT 99940 000 02626LENS LIGHT GUIDE 109940 000 02625BRACKET LCD DISPLAY 11N/ADISPLAY/TUNER PCB 129940 000 02623GEAR PVC 169940 000 02632CDM LOADER WXD-8213 18N/APOWER PCB 209940 000 02614BRACKET CASSETTE KEY 219940 000 02605CASSETTE PWB BRACKET 229940 000 02628KNOB DBB 239940 000 02616BUTTON-FUNCTION B 249940 000 02698CASS DECK VW CS-21SC-820 259940 000 02603BRACKET CASSETTE DECK 269940 000 02604DOOR CASSETTE 279940 000