Philips-MCM-330-Service-Manual(1) 电路图 维修手册.pdf

《Philips-MCM-330-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-MCM-330-Service-Manual(1) 电路图 维修手册.pdf（29页珍藏版）》请在收音机爱好者资料库上搜索。

1、Version 1.1 MCM330 3141 785 33951 Micro Hi-Fi System -/12 Published by LX 0915 Service Audio Subject to modification Copyright 2009 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmi

2、tted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. CONTENTS Technical specification .1-2 Version variation.1-2 Service measurement setup.1-3 Service aids .1-4 Instructions on CD playability .2-1. 2-2 Block diagram .3-1 Wirin

3、g diagram .4-1 Disassembly diagram. .5-1 Power board Circuit diagram .6-1.6-3 Layout diagram .6-4.6-5 CD board Circuit diagram .7-1 Layout diagram .7-2.7-3 Display board Circuit diagram .8-1 Layout diagram .8-2.8-3 MCU board Circuit diagram .9-1 Layout diagram .9-2.9-3 Key board Circuit diagram .10-

4、1 Layout diagram .10-2 Exploded view diagram .11-1 Mechanical parts list .11-2 Electrical parts list.12-1.12-2 RadioFans.CN 收音机爱 好者资料库 Disc Laser typeSemiconductor Disc diameter12cm/8cm Support discCD-DA, CD-R, CD-RW, MP3-CD, WMA-CD Audio DAC24Bits / 44.1kHz Total harmonic distortion 75dBA Tuner Tun

5、ing rangeFM: 87.5 - 108MHz Tuning grid50KHz Number of presets20 FM Speakers Speaker Driver3.5”woofer+0.8” tweeter Sensitivity82dB/m/W General information AC power (power adaptor) Input: 100-240V, 50/60Hz, 1.5A Max.; Output: 18V 2.5A; Brand name: Philips; Model: OH- 1048B1802500U-VDE Operation Power

6、Consumption 20W Standby Power Consumption 2W Eco Power Standby Power Consumption 65dB MP3 link input0.5 V RMS 20kohm TECHNICAL SPECIFICATION 1 - 2 Type /Versions: Features Board in used: MCM330 Service policy DISPLAY BOARD * TIPS : C - Component Lever Repair. M - Module Lever Repair - Used /05/12/55

7、 89/16/85/ Feature diffrence RDS & DAB VOLTAGE SELECTOR ECO STANDBY - DARK Type /Versions: /05/12/55 89/16/85/ VERSION VARIATION 39/ 39/ C CD BOARD KEY BOARD POWER BOARD USB & SD CARD BOARD MCU BOARD C C C C C MCM330 RadioFans.CN 收音机爱 好者资料库 1-3 LF Generator e.g. PM5110 Recorder Use Universal Test Ca

8、ssette CrO2SBC419 4822 397 30069 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion mete e.g. Sound Technology ST170 L R DUT or Universal Test Cassette FeSBC420 4822 397 30071 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion meter e.g. Sound Technology ST1700B L

9、 R DUT CD Use Audio Signal Disc (replaces test disc 3) SBC429 4822 397 30184 Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT S/N and distortion meter e.g. Sound Technology ST1700B Frame aerial e.g. 7122 707 89001 Tuner AM (MW,LW) To avoid atmospheric interference all AM-measure

10、ments have to be carried out in a Faradays cage. Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz). RF Generator e.g. PM5326 Ri=50? Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT RF Generator e.g. PM5326 S/N and distortion meter e

11、.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Ri=50? Tuner FM MEASUREMENT SETUP RadioFans.CN 收音机爱 好者资料库 1-4 SERVICE AIDS GBWARNING All ICs and many other semi-conductors are susceptible to electrostatic discharges

12、 (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential. ESD CLASS 1 LASER PRODUCT GB Safety regulations req

13、uire that the set be restored to its original condition and that parts which are identical with those specified, be used Safety components are marked by the symbol !. Lead free Set remains closed! N Y Play a CD for at least 10 minutes Y playability ok ? N playability ok ? add Info for customer SET O

14、K check playability N Y playability ok ? check playability check playability return set Customer complaint CD related problem fast lens cleaning 1 2 3 For flap loaders (= access to CD drive possible) cleaning method 4 is recommended INSTRUCTIONS ON CD PLAYABILITY 2 - 1 Exchange CDM 1- 4 For descript

15、ion - see following pages 1 PLAYABILITY CHECK For sets which are compatible with CD-RW discs use CD-RW Printed Audio Disc.7104 099 96611 TR 3 (Fingerprint) TR 8 (600 Black dot) maximum at 01:00 playback of these two tracks without audible disturbance playing time for: Fingerprint10seconds Black dot

16、from 00:50 to 01:10 jump forward/backward (search) within a reasonable time For all other sets use CD-DA SBC 444A.4822 397 30245 TR 14 (600 Black dot) maximum at 01:15 TR 19 (Fingerprint) TR 10 (1000 wedge) playback of all these tracks without audible disturbance playing time for: 1000 wedge10second

17、s Fingerprint10seconds Black dot from 01:05 to 01:25 jump forward/backward (search) within a reasonable time 2 CUSTOMER INFORMATION It is proposed to add an addendum sheet to the set which informs the customer that the set has been checked carefully - but no fault was found. The problem was obviousl

18、y caused by a scratched, dirty or copy-protected CD. In case problems remain, the customer is requested to contact the workshop directly. The lens cleaning (method 3) should be mentioned in the addendum sheet. The final wording in national language as well as the printing is under responsibility of

19、the Regional Service Organizations. 4 LIQUID LENS CLEANING Because the material of the lens is synthetic and coated with a special anti-reflectivity layer, cleaning must be done with a non-aggressive cleaning fluid. It is advised to use “Cleaning Solvent The actuator is a very precise mechanical com

20、ponent and may not be damaged in order to guarantee its full function. Clean the lens gently (dont press too hard) with a soft and clean cotton bud moistened with the special lens cleaner. The direction of cleaning must be in the way as indicated in the picture below. Before touching the lens it is

21、advised to clean the surface of the lens by blowing clean air over it. This to avoid that little particles make scratches on the lens. INSTRUCTIONS ON CD PLAYABILITY 2 - 2 SET BLOCK DIAGRAM PICK-UP MECHA SANYO : DA23Z1 4 CH MOTOR DRIVER (BA5826) ROHM RF AMP+SSP+DSP (BU9543) MCS LOGIC BX8804 MP3/WMA

22、D/E + MCU +USB SOUND CONTROL SW+VOL+EQ (PT2314) POWER AMP ( TDA8932 ) ( 2x10W ) AUX INTPUT DISPLAY VFD SD/USB Device NOR FLASH SST39VF400A SDRAM 16Mbit TUNER(FM+RDS) ( Si4703 ) VFD DRIVER PT6324 VFD VOLTAGE Circuit KEY Function LIVING SOUND ( TL072 ) LIVING SOUND POWER AMP ( TDA8932 ) ( 2X6W ) AC AD

23、APTER CD PCB KEY PCB USB PCB MCU PCB POWER PCB DISPLAY(VFD) PCB USB PCB 3-1 POWER BOARD SPK L SPK R MCU BOARD KEY BOARD VFD BOARD CN4 CN8 CN6 CON3 CON4 CON6 CN1 CN2 J204 J205CN1 CN01 USB/SD CARD BOARD CD BOARD CDM CONNECT BOARD DC JACK BOARD J2 CM3 CN602 CN807 CN804 CM1 CN5 CN401 CON3 CM2 MOTOR SWIT

24、CH BOARD IR BOARD CN806 CN402 CN4 CON1 SET WIRING DIAGRAM 4-1 ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? CIRCUIT DIAGRAM - POWER BOARD PART1 6-16-1 CIRCUIT DIAGRAM - POWER BOARD PART2 6-26-2 CIRCUIT DIAGRAM - POWER BOARD PART3 6-36-3 LAYOUT DIAGRAM - POWER BOARD TOP SIDE 6-46-4 LAYOUT DIAGRAM - P

25、OWER BOARD BOTTOM SIDE 6-5 6-5 CIRCUIT DIAGRAM - CD BOARD 7-17-1 LAYOUT DIAGRAM - CD BOARD TOP SIDE 7-27-2 LAYOUT DIAGRAM - CD BOARD BOTTOM SIDE 7-37-3 CIRCUIT DIAGRAM - DISPLAY (VFD) BOARD 8-18-1 LAYOUT DIAGRAM - DISPLAY BOARD TOP SIDE 8-28-2 LAYOUT DIAGRAM - DISPLAY BOARD BOTTOM SIDE 8-38-3 CIRCUI

26、T DIAGRAM -MCU BOARD 9-19-1 LAYOUT DIAGRAM - MCU BOARD TOP SIDE 9-2 9-2 LAYOUT DIAGRAM - MCU BOARD BOTTOM SIDE 9-3 9-3 CIRCUIT DIAGRAM - KEY BOARD AND SOME SMALL BOARD 10-110-1 SD PART USB PART HD OUTPUT PART KEY PART LAYOUT DIAGRAM - KAY BOARD AND SOME SMALL BOARD 10-210-2 SET EXPLODED VIEW DIAGRAM

27、 11-111-1 11 - 2 MECHANICAL PARTSLIST 080994000002822CD MECHANISM DA23Z1 129996510023933USB SPRING 201996510023968MOVE PANEL 202996510023969FRONT PANEL 203996510023916REAR HOUSING 204996510023938MOVE UP HOLDER 205996510023935MOVE DOWN HOLDER 206996510023926DOUBLE CD HOLDER 207996510023903CD TRAY 208

28、996510023907ROLLER HOLDER 209996510023937TRACK UP 210996510023936TRACK DOWN 211996510023919TRACK DOWN HOLDER 212996510023953RIGHT WALL 213996510023947LEFT WALL 214996510023942FRAME 215996510023904USB BRACKET 216996510023944CD DOOR 217996510023932USB DOOR 218996510023927COSMETIC COVER 219996510023945

29、USB COVER 220996510023931ROLLER BOTTOM GEAR 221996510023911ROLLER TOP GEAR 222996510023901TOP GEAR 223996510023939DRIVER GEAR-1 224996510023906TOP BUTTONS 225996510023913LED LIGHTGUIDE LENS 226996510023921DOOR LENS 228994000002818DOOR MOTOR PULLY 229996510023929BUTTONS RING 230996510023951STAND(PC+A

30、BS) J00199400000194216P FFC 1MM L80MM J0029965100239548 FFC. 1mm L=120mm J00399651002394824P FFC. 1mm L=160mm J0049965100125885P FFC 1MM L=150MM J00599651002392316P FFC. 1mm L=180mm J00699651002390816P FFC. 1mm L=210mm S001996510023946SPEAKER 1.5 10W 4 S002996510025345SPEAKER 2.5 4 15W ACCESSORIES T

31、001996510023934AC ADAPTER 100-240V RC996510029727REMOTE CONTROL J009996510002103CONN. CORD 3.5 ST/PLUGx2 500mm Note:Only these parts mentioned in the list are normal service parts. ELECTRICAL PARTSLIST POWER BOARD ASSEMBLY F994000000245BAND PASS FILTER L14996510023922CHIP FERRITE BEAD 1800 +-25% L15

32、996510023922CHIP FERRITE BEAD 1800 +-25% L16996510023922CHIP FERRITE BEAD 1800 +-25% L17996510023922CHIP FERRITE BEAD 1800 +-25% L901996510023922CHIP FERRITE BEAD 1800 +-25% Q902996510023918SMD TRANSISTORS AOD413 Q904996510023918SMD TRANSISTORS AOD413 U1996510019882IC D4558 U101996510023928IC SI4703

33、-C19-GM U2996510023941IC TL072 (S08) SMD LOW NOISE U200996510012038IC TDA8932BT U201996510012038IC TDA8932BT U202996500039806IC ET2314 (SOP28) U206994000001201IC NJM4556AM U59996510012555IC 74HC4052D U62996510019882IC D4558 U901996510023943IC AP1509SL (SOP-8) U902996510023949IC LM1117S- 5V SOT-223 X

34、101996500042441XTAL 32.768KHZ -20PPM DISPLAY BOARD ASSEMBLY T1 ! 996510023899TRANSFORMER(only for bare PCB:48-04MM33000320) VFD401996510023915VFD DISPLAY KEY BOARD ASSEMBLY D1996510023952LED LAMP (BLUE) 2x1.75x0.74mm USB & SD CARD BOARD ASSEMBLY J101996510023909USB SOCKET (USB-4PW) 90C J108994000004

35、369PHONE JACK TC38-063-05-0 J206996510012048PHONE JACK D3.6mm J403996510023914SD CARD 7SDCN-X0-X101-E 12 - 1 T1 ! 996510035474TRANSFORMER H00601A(only for bare PCB:48-04MM33000321) ELECTRICAL PARTSLIST MCU BOARD ASSEMBLY IC601996510020772IC SI636165TS IC603996510021319IC BX8804 IC605996510020761IC X

36、C6206P122PR 1.2V IC607996510020771IC SST39VF800A J600996510023917FLAT PIN 2mm 26P L=8mm J601996510023917FLAT PIN 2mm 26P L=8mm X600996510008326CRYSTAL 12 MHzHC-49/US H=3.5mm CD BOARD ASSEMBLY F401! 996510002426 FUSE RADIAL T5A 250V J401996510008148DC JACK TC-18-013-23-V0 UL APP JK801996510023925PCB

37、CONNECTOR 2mm 26P JK802996510023925PCB CONNECTOR 2mm 26P Q803994000004145TRANSISTORS B772Y (160-320) Q901994000004145TRANSISTORS B772Y (160-320) Q902994000004145TRANSISTORS B772Y (160-320) R131! 994000004478FUSE RESISTORS 1R 1W +-5% R704! 994000004478FUSE RESISTORS 1R 1W +-5% R901! 994000004478FUSE

38、RESISTORS 1R 1W +-5% REM1996510023905OPTIC SENSER FM-9038TM2-5AN S701994000004552DETECT SWITCH S702994000004552DETECT SWITCH S703994000004552DETECT SWITCH S704994000004552DETECT SWITCH U117996510018962IC UTC7805 U118996510018852IC UTC7808 U501996510023902IC S3F84H5 (SOP28) U502996510009316IC KIA7025

39、AP/AF TO-92 U60996510002119IC TA7291S U61996510002119IC TA7291S U801996510009310IC BA5826FP U802996510009311IC BU9543KV (SMD) U903996510012556IC XC6214P332 X501994000004451CRYSTAL 8.000MHZ +-20PPM X502996510012559CRYSTAL 32.768KHZ X801994000004551CRYSTAL 16.9344MHZ +-20PPM Note:Only these parts mentioned in the list are normal service parts. 12 - 2