Philips-HTS-3271-Service-Manual(1) 电路图 维修手册.pdf

《Philips-HTS-3271-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-HTS-3271-Service-Manual(1) 电路图 维修手册.pdf（65页珍藏版）》请在收音机爱好者资料库上搜索。

1、TABLE OF CONTENTS Page Service Manual . Mechanical and Dismantling Instructions.3-1 . Software Upgrades .4-1 . Trouble Shooting Chart.5-1 . Wiring Diagram.6-1 . Electrical Diagrams and Print-layouts.7-1 . Set Mechanical Exploded view MP3.2/3.1/3.0 20 Mbps (peak 40 Mbps) ?20 Mbps ? Audio codec Video

2、codecBit rate PCM, Dolby Digital, MP3, ? MPEG 4 ASP10 Mbps max H.264/AVC HP4.1/4.0; MP3.2/3.1/3.0 20 Mbps (peak 40 Mbps) ?20 Mbps ? Audio codec Video codecBit rate PCM, DTS core, MPEG, MP3 MPEG 1, MPEG 2 20 Mbps (peak 40 Mbps) MPEG 1, MPEG 2 20 Mbps (peak 40 Mbps) ? ? ? Audio codec Video codecBit ra

3、te PCM, Dolby Digital, DTS core, MP3, ? DivX 3.11, DivX 4. x, DivX 5.x, DivX 6.x 10 Mbps max MPEG 1, MPEG 220 Mbps (peak 40 Mbps) MPEG 4 ASP10 Mbps max H.264/AVC HP4.1/4.0; MP3.2/3.1/3.0 20 Mbps (peak 40 Mbps) ?20 Mbps ? Audio codec Video codecBit rate PCM, Dolby Digital, MP3, ? DivX 3.11, DivX 4. x

4、, DivX 5.x, DivX 6.x 10 Mbps max MPEG 1, MPEG 220 Mbps (peak 40 Mbps) MPEG 4 ASP10 Mbps max ? Audio codec Video codecBit rate Dolby Digital, MPEG, MP3, AAC, ? MPEG 1, MPEG 2 20 Mbps (peak 40 Mbps) MPEG 4 ASP10 Mbps max H.264/AVC HP4.1/4.0; MP3.2/3.1/3.0 20 Mbps (peak 40 Mbps) 1-4 Main unit Power sup

5、ply: ? V, 50 Hz ? ? ? ? ? mm ? Subwoofer ? Impedance: 3 ohm ? ? mm ? Cable length: 3 m Speakers ? THD) Speaker impedance: 6 ohm ? range woofer ? ? Cable length: 4 m Remote control batteries ? Audio codec Video codec Bit rate AAC, ? RV30, RV40 20 Mbps (peak 40 Mbps) ? ? THD) ? dB ? ? Input sensitivit

6、y: AUX1, AUX2: 2 V Music iLink: 1 V Video Signal system: PAL / NTSC HDMI output: 480i/576i, 480p/576p, 720p, 1080i, 1080p, 1080p24 Audio S/PDIF Digital audio input: ? ? Sampling frequency: MP3: 32 kHz, 44.1 kHz, 48 kHz ? Constant bit rate: ? ? Radio Tuning range: ? MHz (50 kHz) ? 108 MHz (50/100 kHz

7、) ? ? ? USB ? Class support: USB Mass Storage Class (MSC) File system: FAT16, FAT32, NTFS Maximum memory support: AdvancedVersion Info. While it shows the dialog box, we can see some information like below: For example: Model：HTSxxxx/xx System SW:x.xx.xx Subsystem SW:xx-xx-xx-xx Ethernet MAC:xx:xx:x

8、x:xx:xx;xx EUI64:xxxxxxxxxxxxxxx Caution: The set must not be power off during upgrading, Otherwise the Main board will be damaged entirely. 5-1 Trouble shooting Chart VFD No display on Front Control Board VFD No display on Front Control Board Go Yes Refer to CN502 on Power Board No Fix the connecti

9、on HTS3271:XP8 on Front Control Board and XP8 on Main Board No Replace U4 on Main Board, or replace the Main Board No HTS3271:Check the CON607 ON Front Control Board pin 1 2 arrive the condition XP8 PIN1 PIN2 No Yes Yes Yes Correct connection No Yes Replace U135 or VFD Check every supply voltage on

10、Main Board whether normal or not. (XP8 PIN4:-24V, PIN5: 12V, PIN6: 3.3V) Check voltage -24V, +5V,+12V on Power Board at CN502 position and Front Control Board (HTS3271:XP8 PIN4:-24V PIN5:+12V PIN6:+5V) Check the power key(HTS3271: PAD607), open/closed key(HTS3271: PAD603), source key(HTS3271: PAD606

11、) on Touch Board whether work normally or not Check Front Control Board signals SCL,SDA (HTS3271:XP8 PIN1: SCL PIN2:SDA) Check whether bad solder exists on HTS3271:XP8 on Front Control Board and VFD135 of VFD, 5-2 Trouble shooting Chart Touch keys do not work Touch keys do not work Go No HTS3271: Fi

12、x the connection CON607 on Front Control Board and CON606 on Touch Board Yes Replace U4 on Main Board, or replace Main Board No Yes Replace Touch Board Check voltage +3.3V on Touch Board HTS3271:(U603 PIN27) and Font Board(CON607 PIN3) Check Front Control Board and Touch Board signals SCL(TOUCH Boar

13、d U603 PIN19),SDA(U603 PIN18) 5-3 Trouble shooting Chart Remote control does not work Remote control does not work Go No Replace the battery for remote control Yes Check the +3.3V net on Front Control Board HTS3271:XP8 No Yes Replace IR601 Check battery of remote control whether exhausted or not. Ch

14、eck power supply of IR601 on Front Control Board whether normal or not HTS3271:XP8 PIN9 3.3V 5-4 Trouble shooting Chart No audio output No audio output Go No Yes Yes Yes Replace Amplifier Board No Replace U4 on Main Board,or replace Main Board Yes Refer to CON502 on Power Board No Check voltage +32V

15、 whether normal or not at XP702 on Amplifier Board Check the 24pin FFC connection XP13 on Main Board and XP703 on Amplifier Board whether right or not between Main Board and Amplifier Board Check the control signal whether right or not at the U4 PIN6,PIN7,PIN36,on Main Board and the signal at the XP

16、13 PIN9 PIN10 PIN22 Check XP13 pin 14&16 3.3V on Main Board whether normal or not 5-5 Trouble shooting Chart No video output No video output Go Add L456, R619 on Main Board Yes No No Replace Main Board Check L456,R619 whether right on Main Board Check the video signal whether right at U7: PINF27 PIN

17、F28 PINE28 5-6 Trouble shooting Chart Cant read disc or cant open the disk door 、 Cant read disc or cant open the disk door Go Check XP7 on Main Board No Yes Fix 45pin 8pin and 4pin cable No Replace Loader Yes Check loader whether work normally or not Check 45pin 8pin and 4pin cable from Main Board

18、to Loader whether connect right or not 5-7 Trouble shooting Chart Tuner FM does not work Tuner FM does not work Go Yes Refer to Power Board CN502 No Check Main Board tuner power supply circuit. No Change the Tuner module No Yes Yes No Yes Replace Main Board Check Main Board U5 power supply circuit C

19、heck voltage +3.3V at Tuner module (TUN1 pin5) whether right or not Check Tuner module pin7,pin8,pin9,I2S output whether normal or not Check voltage at Q27 C:+5V on Main Board whether normal or not Check the U4 PIN25,PIN26, I2C output on Main Board whether normal or not 5-8 Trouble shooting Chart AU

20、X in does not work AUX in does not work Go No Refer to Power Board CN502 Yes Check AUX Input Board No Yes Replace U33 74HC4052 Check Main Board U4 No Yes Check Main Board U1 power supply and out circuit No Yes Check voltage at U27 PIN16:12V on Main Board whether normal or not Check Main Board U27 PI

21、N1,PIN5 PIN12 PIN14 signal input whether right or not Check voltage at U33 74HC4052 PIN16, +12V, on Main Board Whether normal or not Check U33 74HC4052 whether broken Or not 5-9 Trouble shooting Chart MP3 Link does not work MP3 Link does not work Go No Refer to Main Board XP6 Yes Check Main Board C3

22、58, C349, R340, R457, No Yes Replace U33 74HC4052 Check Main Board U4 No Yes Check Main Board U1 power supply and out circuit No Yes HTS3271:Check signal at P803 PIN2/4:MP3_R PIN8/9:MP3_L ON front board whether normal or not Check Main Board U33 74HC4052 PIN2,PIN4 L/R signal input whether right or n

23、ot Check U33 74HC4052 whether broken Or not Check voltage at U33 74HC4052 PIN16,VDD +12V, on Main Board Whether normal or not 5-10 Trouble shooting Chart COAX in does not work COAX in does not work Go No Refer to Power Board CN502 Yes Check Main Board C355, C370, C381, R368 ,L11, No Replace U22 CS84

24、22 Check Main Board U4 Yes Yes No Check voltage at U22 PIN3/PIN18:3.3V on Main Board whether normal or not Check Main Board U22 CS8422 PIN2 signal input whether right or not Check U22 CS8422 whether broken. Or not XP8(HTS3271) CON607(HTS3271) CON606(HTS3271) HTS3271 5 5 4 4 3 3 2 2 1 1 DD CC BB AA T

25、PIC_LOAD+ MGND TPIC_LOAD- TPIC_COMMON TPIC_V TPIC_U TPIC_B+ TPIC_W TPIC_A- TPIC_A+ TPIC_B- 4P/2.0mm 4P/2.0mm 8P/1.0mm 8P/1.0mm Front Board USB WT5700 VOL+VOL-POWEROPEN I2S SOURCEPALYSTOP ASCLK ALRCLK SDIN IMCLK ISCLK ILRCLK POWER_DER I2S L/R L/RL/R L/R SUB PWM WT61P8S MCLK I2S MT8555 SDO1 SDO0 SCLK

26、LRCLK MOTOR DRIVER +TI1391 AUX1 RJ45 CVBS 11.FO_IN 2.TILT+ IND PDIC INA HDMI (1.4) PVCC/8P SD CO_B+ FR+ ING INB INH GND CARD OPTI COAX 10.CO_A- 1.TILT- CO_A+ CO_B- FR- SPI VFD DRIVER TR- 21.DRFO- 20.DRFO+ TR+ RFO- LOADER (WIFI) RFO+ GND INC GND INF HAVC GND MODEA 30.GND 31.GND GND VFD DISPLAY BD_LD(

27、8V) INE MODEB FPDODVD 41.GIO7 CS16312 GND LDD_CLK LDD_SDIO VCC_LD 45.MODEC 40.LDD_SEN GND TRAYIN# BD BOARD 30V -24V 12V 5V MUTE I2C RESET MUTE Touch KEY Board MCU SDIN1 AUDIO PROCESSOR SPK SUB AMP BOARD POWER BOARD AC IN 6P/2.5MM8P/2.5mm TAS5342*2 SPK L SPK R L/R PWM RESET VFD_CLK VFD_DI/O VFD_CS TI

28、5508 IPOD 4052*2 CS8422 ARC TX RX I2S L/R 4558 GND Separate L/R I2C CS TUNER IR POWER DERATING AK5358 L/R PDN I/O*3 I2C ASA L9829+SANYO_414H08 AMP_DET AMP_MUTE POWER_DER AMP_DET FLASH DDR3x4 NAND 2Gbit 64Mx16x4pcs I2S_LRCK I2S_MCLK 3.3V GND I2S_SDATA2 I2S_SDATA1 I2C_SDA I2S_SDATA0 I2S_SCLK AMP_DET /

29、PDN RESET AMP_MUTE GND 3.3V BKND_ERR GND I2C_SCL 12V GND POWER_DER GND NC 12V PDD PDD DGND DGND PDD DGND STB5V POWER_ON GND ST12V GND STB5V GND -24V PVCC/8P 24P/0.5mm 24P/0.5mm GND IR VSTB VDAT VFD-CLK MP3_L -24V MP3_R +5V -STB GND 12V I2C 14P/1.0mm INT POWER_ON CEC 45P/0.5mm 45P/0.5mm IR VFD_CLK VF

30、D_DI/O VFD_CS I2C IMCLK R2A30209SP PDN /PDN GND SCL SDA IR 14P/1.0mm CN502 1 8 1 8 XP1 CON502 11 66 XP702 XP703XP13 1 241 24 CN501 XP8XP5 1 4 XP10 1 8 XP7 1 45 GND SDA SCLK +3.3V NC 5P/1.0mm 5P/1.0mm 1 51 5 11 1414 AUX2 AUX1 L/R L/R AUX2 AUX1L/R XP11 XS1 1 6 16 L/RL/R AUX2_R AUX2_L AUX1_R AUX1_L GND

31、 GND AUX Board 6-16-1 BLOCK / WIRING DIAGRAM A A B B C C D D E E 11 22 33 44 To main board To main board To main board 01UUSBJAK-101 5701_SCLSCL_MCU SDA_MCU5701_SDA GND USB_DP 5701_SDA 5701_SCL +3.3V +3.3V USB_DM +12V MP3_R MP3_L +12V USB_VCC GND VSDA VSTB -24V VSCLK SCL_MCU SDA_MCU MP3_L USB_DM USB

32、_DP USB_DP USB_VCCUSB_VCC USB_DM MP3_R 5V_STB IR +3.3V AC2AC1 VSCLK VSTB +5V AC2 +12V +12V -24V +5V VSDA IR 5V_STB 5V_STB 5V_STB A A A -24V +5V +5V R1561KR1561K XS605 3PIN/2.0mm/440mm XS605 3PIN/2.0mm/440mm 1 1 2 2 3 3 R639100R639100 R158 10K R158 10K C626 10pF/50V/NP0 C626 10pF/50V/NP0 R137 10K R13

33、7 10K FB612500/800mAFB612500/800mA R689 47K R689 47K Q138 NPN_3DG3904M Q138 NPN_3DG3904M R144 10K R144 10K IR601 IRM_14mm IR601 IRM_14mm IR 1 GND 2 VCC 3 GND 4 GND 5 XS604 4PIN/2.0mm/200mm XS604 4PIN/2.0mm/200mm 1 1 2 2 3 3 4 4 R638100R638100 R640100R640100 R162100R162100 FB614500/800mAFB614500/800m

34、A R1434.7KR1434.7K R6 0 R6 0 R1551KR1551K R684 10K R684 10K R10R10 R3 0 R3 0 R688 47K R688 47K XP8 14PIN/1.0mm XP8 14PIN/1.0mm 1 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 9 9 10 10 11 11 12 12 13 13 14 14 FB616500/200mAFB616500/200mA R157 10K R157 10K R686 10K R686 10K C763 100pF/50V/NP0 C763 100pF/50V/NP0 R159

35、 10K R159 10K R164100R164100 CON607 5PIN/2.0mm CON607 5PIN/2.0mm 1 1 2 2 3 3 4 4 5 5 +CE606 47uF/16V +CE606 47uF/16V R163100R163100 FB613500/800mAFB613500/800mA FB610500/800mAFB610500/800mA Q139 NPN_3DG3904M Q139 NPN_3DG3904M C764 100pF/50V/NP0 C764 100pF/50V/NP0 Q137 PNP_3CG3906M Q137 PNP_3CG3906MR

36、4 0 R4 0 P803 MIC JACK P803 MIC JACK GND 1 SIN 2 SGND 3 GND 4 GND 5 DET 6 GND 7 GND 8 GND 9 ZD136 BZX79C5V1 ZD136 BZX79C5V1 R681150R681150 R1541KR1541K Q621 NPN_3DG3904M Q621 NPN_3DG3904M P802 USB-A/WT P802 USB-A/WT VCC 1 D- 2 D+ 3 GND 4 Shell B 6 Shell A 5 R139470R139470 Q135 NPN_3DG3904M Q135 NPN_

37、3DG3904M C618 47pF/50V/NP0 C618 47pF/50V/NP0 C765 100pF/50V/NP0 C765 100pF/50V/NP0 R683 10K R683 10K R63710KR63710K Q136 NPN_3DG3904M Q136 NPN_3DG3904M R145 1K R145 1K VFD135 - VFD135 - F1 1 F1 2 P14 5 P13 6 P12 7 NC(2G) 8 P11 9 P10 10 P9 11 NC(2G) 12 P8 13 3G 27 2G 28 1G 29 NP 30 F2 31 F2 32 4G 26

38、5G 25 6G 24 7G 23 8G 22 NC(6G) 21 P6 15 P7 14 NP 3 NC(1G) 4 P5 16 P4 17 P3 18 P2 19 P1 20 C617 0.1uF/16V/Y5V C617 0.1uF/16V/Y5V LED1 LED_RED+WHITE LED1 LED_RED+WHITE 1 2 3 R14218KR14218K C1520.1uF/50V/X7RC1520.1uF/50V/X7R ZD137 BZX79C3V3 ZD137 BZX79C3V3 C767 100pF/50V/NP0 C767 100pF/50V/NP0 R147 1K

39、R147 1K + 3.3uF/50VCE138 + 3.3uF/50VCE138 R171 4.7K R171 4.7K R682150R682150 R8 0 R8 0 C223 4.7uF/16V/Y5V C223 4.7uF/16V/Y5V R5 0 R5 0 R140330R140330 R641100R641100 C766 100pF/50V/NP0 C766 100pF/50V/NP0 FB609500/800mAFB609500/800mA Q620 NPN_3DG3904M Q620 NPN_3DG3904M + 3.3uF/50V CE135 + 3.3uF/50V CE

40、135 C148 0.1uF/50V/X7R C148 0.1uF/50V/X7R R1415.6R1415.6 R135 470 R135 470 C614 0.1uF/16V/Y5V C614 0.1uF/16V/Y5V R685 2K R685 2K C768 100pF/50V/NP0 C768 100pF/50V/NP0 R2 0 R2 0 R687 20K R687 20K R146 10K R146 10K R138 470 R138 470 C135 1000pF/50V/X7R C135 1000pF/50V/X7R C625 10pF/50V/NP0 C625 10pF/5

41、0V/NP0 U135 DRIVER_VFD_CS6312EN U135 DRIVER_VFD_CS6312EN SW1 1 SW2 2 SW3 3 SW4 4 SDout 5 SDin 6 GND 7 SCLK 8 /CS 9 KEY1 10 KEY2 11 KEY3 12 KEY4 13 VDD 14 SEG1/K1 15 SEG2/K2 16 SEG3/K3 17 SEG4/K4 18 SEG5/K5 19 SEG6/K6 20 SEG7 21 SEG8 22 SEG9 23 SEG10 24 SEG11 25 SEG12 26 VEE 27 SEG13 28 SEG14 29 SEG1

42、5 30 SEG16 31 G6 32 G5 33 G4 34 G3 35 G2 36 G1 37 VDD 38 LED4 39 LED3 40 LED2 41 LED1 42 GND 43 OSC 44 ESD1 PRTR5V0U2X ESD1 PRTR5V0U2X 1 23 4 +CE610 47uF/16V +CE610 47uF/16V R136 2.2 R136 2.2 R148 51K R148 51K FB611500/800mAFB611500/800mA C769 100pF/50V/NP0 C769 100pF/50V/NP0 ZD135 BZX79C6V2 ZD135 BZX79C6V2 C761 100pF/50V/NP0 C761 100pF/50V/NP0 C222 4.7uF/16V/Y5V C222 4.7uF/16V/Y5V Front Control Board Circuit Diagram: 7-1 7-1 A A B B C C D D E E 11 22 33 44 WT5701-UG321 PREV NEXT SOURCE STANDBY PLAY/PAUSE STOP OPEN/CLOSES2 S0 S1 SCL5701_SCL_A SDA5701_SDA_A S3 S4 S5 S6 VCC3V3 5701_SCL_A 5701_S