Philips-HTS-3530-Service-Manual(1) 电路图 维修手册.pdf

《Philips-HTS-3530-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-HTS-3530-Service-Manual(1) 电路图 维修手册.pdf（64页珍藏版）》请在收音机爱好者资料库上搜索。

1、TABLE OF CONTENTS Page Service Manual . Mechanical and Dismantling Instructions.3-1 . Software Upgrades .4-1 . Trouble Shooting Chart.5-1 . Wiring Diagram.6-1 . Electrical Diagrams and Print-layouts.7-1 . Set Mechanical Exploded view 50 Hz Power consumption: 100 W Standby power consumption: 65 dB (C

2、CIR) / (A-weighted) Input sensitivity: AUX: 1 mV CountryDVD Europe, United Kingdom Latin America Australia, New Zealand Russia, India China Asia Pacific, Taiwan, Korea Weight: HTS3510: 0.68 kg HTS3520: Center: 0.77 kg Front/Rear: 0.56 kg/each Cable length: Center: 3 m Front: 4 m Rear: 10 m Laser spe

3、cifi cation Type: Semiconductor laser GaAIAs (CD) Wave length: 645 - 665 nm (DVD), 770 - 800 nm (CD) Output power: 6 mW (DVD), 7 mW (VCD/CD) Beam divergence: 60 degrees. HTS3530/05: 1-3 RadioFans.CN 收音机爱好者资料库 Video Signal system: PAL / NTSC HDMI output: 480i/576i, 480p/576p, 720p, 1080i, 1080p Audio

4、 Sampling frequency: MP3: 32 kHz, 44.1 kHz, 48 kHz WMA: 44.1 kHz, 48 kHz Constant bit rate: MP3: 112 kbps - 320 kbps WMA: 48 kbps - 192 kbps Radio Tuning range: FM 87.5-108 MHz (50/100 kHz) Signal-to-noise ratio: FM 50 dB Frequency response: FM 180 Hz 10 kHz / 6dB USB Compatibility: Hi-Speed USB (2.

5、0) Class support: UMS (USB Mass Storage Class) File system: FAT12, FAT16, FAT32 Maximum memory support: 65 dB (CCIR) / (A-weighted) Input sensitivity: AUX: 2 V CountryDVD Europe, United Kingdom Latin America Australia, New Zealand Russia, India China Asia Pacific, Taiwan, Korea HTS3530/98: 1-4 Speak

6、ers System: full range satellite Speaker impedance: 8 ohm (center), 4 ohm (Front/Rear) Speaker drivers: 3” full range Frequency response: 150 Hz-20 kHz Dimensions (WxHxD): Center: 160.9 x 95 x 92 (mm) Front: 95 x 160.9 x 87 (mm) Rear: 254mm x 1001.5mm x 254 (mm) Weight: Center: 0.77 kg Front: 0.56 k

7、g/each Rear: 3.25 kg/each Cable length: Center: 3m Front: 4 m Rear: 10 m Laser specifi cation Type: Semiconductor laser GaAIAs (CD) Wave length: 645 - 665 nm (DVD), 770 - 800 nm (CD) Output power: 6 mW (DVD), 7 mW (VCD/CD) Beam divergence: 60 degrees. 1-5 Note Specifi cation and design are subject t

8、o change without notice. Region code The type plate on the back or bottom of the home theater shows which regions it supports Playback media DVD-Video, DVD+R/+RW, DVD-R/-RW, DVD+R DL, CD-R/CD-RW, Audio CD, Video CD/SVCD, Picture CD, MP3-CD, WMA-CD, DivX-CD, USB storage device File Format Audio: .mp3

9、, .wma Video: .divx, .divx ultra, .mpeg, .mpg, .wmv (simple profi le) Picture: .jpeg, .jpg Amplifi er Total output power: 600 W RMS (30% THD) Frequency response: 20 Hz-20 kHz Signal-to-noise ratio: 65 dB (CCIR) / (A-weighted) Input sensitivity: AUX: 2 V CountryDVD Europe, United Kingdom Latin Americ

10、a Australia, New Zealand Russia, India China Asia Pacific, Taiwan, Korea Video Signal system: PAL / NTSC HDMI output: 480i/576i, 480p/576p, 720p, 1080i, 1080p Audio Sampling frequency: MP3: 32 kHz, 44.1 kHz, 48 kHz WMA: 44.1 kHz, 48 kHz Constant bit rate: MP3: 112 kbps - 320 kbps WMA: 64 kbps - 192

11、kbps Radio Tuning range: FM 87.5-108 MHz (50/100 kHz) Signal-to-noise ratio: FM 50 dB Frequency response: FM 180 Hz-10 kHz USB Compatibility: Hi-Speed USB (2.0) Class support: UMS (USB Mass Storage Class) File system: FAT12, FAT16, FAT32 Maximum memory support: 160GB Main Unit Power supply: 220-240V

12、; 50 Hz Power consumption: 100 W Standby power consumption: ? 0.9 W Dimensions (WxHxD): 360 x 58 x 320 (mm) Weight: 2.84 kg Subwoofer Impedance: 8 ohm Speaker drivers: 165 mm (6.5”) woofer Frequency response: 20 Hz-150 Hz Dimensions (WxHxD): 122.6 x 307 x 369 (mm) Weight: 3.84 kg Cable length: 3 m P

13、roduct specifications 1-6 HTS3530/12: Speakers System: full range satellite Speaker impedance: 8 ohm (center), 4 ohm (Front/Rear) Speaker drivers: 3” full range Frequency response: 150 Hz-20 kHz Dimensions (WxHxD): Center: 160.9 x 95 x 92 (mm) Front: 95 x 160.9 x 87 (mm) Rear: 254 x 1001.5 x 254 (mm

14、) Weight: Center: 0.77 kg Front: 0.56 kg/each Rear: 3.25 kg/each Cable length: Center: 2 m Front: 3 m Rear: 10 m Laser specifi cation Type: Semiconductor laser GaAIAs (CD) Wave length: 645 - 665 nm (DVD), 770 - 800 nm (CD) Output power: 6 mW (DVD), 7 mW (VCD/CD) Beam divergence: 60 degrees. English

15、1-7 Safety instruction 1. General safety Safety regulations require that during a repair: . Connect the unit to the mains via an isolation transformer. . Replace safety components indicated by the symbol , only by components identical to the original ones. Any other component substitution (other tha

16、n original type) may increase risk of fire or electrical shock hazard. Safety regulations require that after a repair, you must return the unit in its original condition. Pay, in particular, attention to the following points: . Route the wires/cables correctly, and fix them with the mounted cable cl

17、amps. . Check the insulation of the mains lead for external damage. . Check the electrical DC resistance between the mains plug and the secondary side: 1) Unplug the mains cord, and connect a wire between the two pins of the mains plug. 2) Set the mains switch the “on” position (keep the mains cord

18、unplug). 3) Measure the resistance value between the mains plug and the front panel, controls, and chassis bottom. 4) Repair or correct unit when the resistance measurement is less than 1M?. 5) Verify this, before you return the unit to the customer/user (ref. UL-standard no. 1492). 6) Switch the un

19、it “off”, and remove the wire between the two pins of the mains plug. 2.Laser safety This unit employs a laser. Only qualified service personnel may remove the cover, or attempt to service this device (due to possible eye injury). Laser device unit Type : Semiconductor laser GaAlAs Wavelength : 650n

20、m (DVD) : 780nm (VCD/CD) Output power : 7mW (DVD) : 10mW (DVD /CD) Beam divergence: 60 degree Note: Use of controls or adjustments or performance of procedure other than those specified herein, may result in hazardous radiation exposure. Avoid direct exposure to beam. Safety instruction, Warning pre

21、ss up or down to fi ne tune a radio frequency. f INFO Displays information about what is playing. gPlayback buttons Control playback. hSURR ( Surround Sound ) Switches to surround sound or stereo sound. iAUDIO SYNC Selects an audio language or channel. Press and hold to synchronize audio with video.

22、 Use with +/- . jNumeric buttons Selects an item to play. kSUBTITLE Selects subtitle language for video. l SCREEN FIT Fits the picture format to the TV screen. mCREATE MP3 /ZOOM Accesses the menu to create MP3. Zooms into a video scene or picture. nREPEAT A-B Marks two points within a chapter or tra

23、ck for repeat play, or turns off repeat mode. oREPEAT / PROGRAM Selects a repeat or shuffl e mode. In radio mode, programs radio stations. pANGLE Displays options for different camera angles. qSOUND Selects a sound mode. rVOL +/- Increases or decreases volume. s ( Mute ) Mutes or restores volume. t

24、BACK Returns to a previous menu screen. uOK Confi rms an entry or selection. vSource buttons AUDIO SOURCE : Selects an audio input source. RADIO : Switches to FM radio. USB : Switches to USB storage device. DISC: Switches to disc source. 2-16 Your home theater Congratulations on your purchase, and w

25、elcome to Philips! To fully benefi t from the support that Philips offers, register your home theater at www. Main unit aDisc compartment b ( Open/Close ) Opens or closes the disc compartment. c ( Play/Pause ) Starts, pauses or resumes play. d ( Stop ) Stops play. In radio mode, erases the current p

26、reset radio station. e ( Standby-On ) Switches the home theater on or to standby. fSOURCE Selects an audio/video source for the home theater. g / Skips to the previous or next track, chapter or fi le. In radio mode, selects a preset radio station. hDisplay panel iVolume control wheel 2-17 HTS3520/98

27、: e ( Navigation buttons ) Navigate menus. In video mode, press left or right to fast backward or fast forward. In radio mode, press left or right to search a radio station; press up or down to fi ne tune a radio frequency. f INFO Displays information about what is playing. gPlayback buttons Control

28、 playback. hSURR ( Surround Sound ) Switches to surround sound or stereo sound. iAUDIO SYNC Selects an audio language or channel. Press and hold to synchronize audio with video. Use with +/- . jNumeric buttons Selects an item to play. kSUBTITLE Selects subtitle language for video. lVOCAL Turns off t

29、he vocal by changing the audio channel. mMIC VOL +/- Increases or decreases microphone volume. nKARAOKE Accesses or exits the karaoke menu. oCREATE MP3 / ZOOM Accesses the menu to create MP3. Zooms into a video scene or picture. pSOUND Selects a sound mode. qVOL +/- Increases or decreases volume. r

30、( Mute ) Mutes or restores volume. s BACK Returns to a previous menu screen. tOK Confi rms an entry or selection. uSource buttons AUDIO SOURCE : Selects an audio input source. RADIO : Switches to FM radio. USB : Switches to USB storage device. DISC: Switches to disc source. Remote control a ( Standb

31、y-On ) Switches the home theater on or to standby. b OPEN/CLOSE Opens or closes the disc compartment. cREPEAT / PROGRAM Selects a repeat or shuffl e mode. In radio mode, programs radio stations. d SETUP Accesses or exits the setup menu. o a b c d e f g h i j k n p s t u r q l m 2-18 Remote control n

32、 q r s t u v m a b c d f g h i j k l p o e Congratulations on your purchase, and welcome to Philips! To fully benefi t from the support that Philips offers, register your home theater at www. Main unit aDisc compartment b ( Open/Close ) Opens or closes the disc compartment. c ( Play/Pause ) Starts,

33、pauses or resumes play. d ( Stop ) Stops play. In radio mode, erases the current preset radio station. e ( Standby-On ) Switches the home theater on or to standby. fSOURCE Selects an audio/video source for the home theater. g / Skips to the previous or next track, chapter or fi le. In radio mode, se

34、lects a preset radio station. hDisplay panel iVolume control wheel English Your home theater HTS3530/12: 2-19 qSOUND Selects a sound mode. rVOL +/- Increases or decreases volume. s ( Mute ) Mutes or restores volume. t BACK Returns to a previous menu screen. uOK Confi rms an entry or selection. vSour

35、ce buttons AUDIO SOURCE : Selects an audio input source. RADIO : Switches to FM radio. USB : Switches to USB storage device. DISC: Switches to disc source. a ( Standby-On ) Switches the home theater on or to standby. b OPEN/CLOSE Opens or closes the disc compartment. cSLEEP Switches the home theater

36、 to standby after the preset time selected. d SETUP Accesses or exits the setup menu. e ( Navigation buttons ) Navigate menus. In video mode, press left or right to fast backward or fast forward. In radio mode, press left or right to search a radio station; press up or down to fi ne tune a radio fre

37、quency. f INFO Displays information about what is playing. gPlayback buttons Control playback. hSURR ( Surround Sound ) Switches to surround sound or stereo sound. iAUDIO SYNC Selects an audio language or channel. Press and hold to synchronize audio with video. Use with +/- . jNumeric buttons Select

38、s an item to play. kSUBTITLE Selects subtitle language for video. l SCREEN FIT Fits the picture format to the TV screen. mCREATE MP3 /ZOOM Accesses the menu to create MP3. Zooms into a video scene or picture. nREPEAT A-B Marks two points within a chapter or track for repeat play, or turns off repeat

39、 mode. oREPEAT / PROGRAM Selects or turns off repeat mode. In radio mode, program radio stations. pANGLE Displays options for different camera angles. 2-20 Mechanical and Dismantling Instructions Dismantling Instruction The following guidelines show how to dismantle the player. Step1: Remove 6 screw

40、s around the Top Cover, and then remove the Top Cover (Figure 1). Figure 1 Step2: If it is necessary to dismantle Loader or Front Panel, the Front door should be removed first. (Figure 2) Note: Make sure to operate gently otherwise the guider would be damaged. Figure 2 3-1 Please kindly note that di

41、smantle the front door assembly carefully to avoid damage tray and the front door. Detailed information please refer to the model set. Mechanical and Dismantling Instructions Dismantling Instruction Step3: If the tray cant open in normal way, you can make it through the instruction as below (Figure

42、3). Note: Make sure to operate gently otherwise the guider would be damaged. Figure 3 Step4: Dismantling Front Panel, disconnect the connectors (XP16, XP20, XP9), need release 2 snaps of Front Panel 2.Then Copy the renamed bin file(upgrade file) to the root menu of USB device; 3. Connect the USB dev

43、ice to HTS, and Press “USB” on remote control switch to USB state;. 4.If the upgrade file is renamed correctly, It will display the Upgrade Menu on TV, press “OK” key on the remote control to start upgrade; 5.After a while,the tray will open automatically ,but must not power off the player, and you

44、can remove your USB device now; 6.Dont power off, wait until the player auto standby. The whole upgrade process may need 2 minutes. 7.After the LED light get red(HTS standby, upgrade completely),press “DISC” key on remote control to power on, then you can check the software version information as be

45、low steps; B. Read out the software versions to confirm upgrading 1) Power on the set and press Setup button on the remote control. 2) Press 1379 button or press down cursor on remote control to select Preferences and press right & down cursor to select Version Info. The software version and other i

46、nformations will be displayed on the TV screen as follows: File Name HTSXXXX_XX.BIN Version XX.XX.XX.XX (Main version) Sub-Ver XX.XX.XX.XX (version of applicaton software) RISC XX.XX.XX.XX Servo XX.XX.XX.XX (software version of Servo) Region Code X HDCP PASS MCU XX Caution: The set must not be power off during upgrading, Otherwise the Main board will be damaged entirely.