Sony-TAFE310R-int-sm 电路图维修手册.pdf

上传人：cc518

文档编号：239226

上传时间：2025-10-12

格式：PDF

页数：17

大小：2.34MB

《Sony-TAFE310R-int-sm 电路图维修手册.pdf》由会员分享，可在线阅读，更多相关《Sony-TAFE310R-int-sm 电路图维修手册.pdf（17页珍藏版）》请在收音机爱好者资料库上搜索。

1、TA-FE310R/FE510R AEP Model TA-FE310R/FE510R UK Model TA-FE310R SERVICE MANUAL INTEGRATED STEREO AMPLIFIER MICROFILM SPECIFICATIONS Photo : TA-FE510R Amplifier section DIN power output TA-FE510R: 80 W+80 W (4 ohms at 1 kHz) 60 W+60 W (8 ohms at 1 kHz) TA-FE310R: 55 W+55 W (4 ohms at 1 kHz) 45 W+45 W

2、(8 ohms at 1 kHz) Frequency response PHONO (20 Hz-20 kHz): RIAA equalization curve 0.5 dB TUNER, CD, AUX, TAPE1/DAT, TAPE2/MD: 7 Hz-70 kHz dB S/N (network A) PHONO: 80dB TUNER, CD, AUX, TAPE1/DAT, TAPE2/MD: 105 dB Output voltage/ impedance REC OUT: 200 mV, 1 kilohm PHONES: 5 mW (at 8 ohms) Speakers

3、impedance: 4-16 ohms, 8-16 ohms (SPEAKERS A+B) Damping factor 80 (8 ohms, 1 kHz) General System Power amplifier: Pure-complementary SEPP OCL power amplifier with all stages directly coupled Preamplifier. Low-noise, equalizer amplifier Power requirements Models not supplied with a voltage selector: 2

4、20-230 V AC, 50/60 Hz Power consumption TA-FE510R: 160 W TA-FE310R: 120 W Dimensions (approx.) (w/h/d): 430105300 mm incl. projecting parts and controls Mass (approx.) TA-FE510R: 4.8 kg TA-FE310R: 4.3 kg Supplied accessories Remote commander (remote) (1) RM-S315 Sony batteries SUM-3 (NS) (2) Design

5、and specifications are subject to change without notice. RadioFans.CN 收音机爱好者资料库 2 1.GENERAL 1-1.Index to Parts and Controls . 2 2.DIAGRAMS 2-1.Circuit Boards Location . 3 2-2.IC Pin Function Description. 4 2-3.Schematic Diagram Main Section . 5 2-4.Printed Wiring Boards Main Section . 7 2-5.Schemat

6、ic Diagram Panel Section . 9 2-6.Printed Wiring Boards Panel Section .11 2-7.Schematic Diagram Power Section . 13 3.EXPLODED VIEWS. 15 4.ELECTRICAL PARTS LIST.17 SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LI

7、ST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. SECTION 1 GENERAL 1-1.INDEX TO PARTS AND CONTROLS Front Panel Rear Panel 1234567 !09 8 1 SYSTEM POWER switch 2 BASS control 3 TREBLE cont

8、rol 4 BALANCE control 5 INPUT SELECTOR indicators 6 INPUT SELECTOR 7 VOLUME control 8 PHONES jack 9 LOUDNESS switch ! TAPE 1 MONITOR switch (TA-FE510R only) ! SOURCE DIRECT switch ! EON LINK switch (TA-FE510R only) This section is extracted from instruction manual. TABLE OF CONTENTS RadioFans.CN 收音机

9、爱好者资料库 SECTION 2 DIAGRAMS 2-1.CIRCUIT BOARDS LOCATION RELAY AC board SIRCS board HP board FUNCTION SW board CONTROL board EON board (FE510R) MAIN board AC board (AEP, Germany) SP board AC SW board RELAY DC board 2-2.IC PIN FUNCTION DESCRIPTION CONTROL BOARD IC801 TMP47C103N (INPUT CONTROL, LED DRIV

10、E) Pin No.Pin NameI/OFunction 1X OUTOSystem clock. (4 MHz) 2X INISystem clock. (4 MHz) 3RESETIRESET input. 4PMDIMODE select input. 5VOL+OMotor drive output (+). 6VOL OMotor drive output (). 7SW0IRotary switch input (CD). 8SW1IRotary switch input (TUNER). 9SW2IRotary switch input (PHONO). 10EONIEON s

11、ignal input. 11PHONOOPHONO LED drive output. 12TUNEROTUNER LED drive output. 13CDOCD LED drive output. 14GNDGround. 15AUXOAUX LED drive output. 16DATOTAPE “Z” LED drive output. 17TAPEOTAPE “1” LED drive output. 18MONOMONITOR output. 19PRYOPower relay output. 20PKYIPower key input. 21MONIMONITOR inpu

12、t. 22SIRCSISIRCS input. 23MUTEOMuting output. 24SCEOChip enable output. 25SDTOSerial data output. 26SCKOSerial clock output. 27STOPIStop input. 28+3 V+3 V power supply. 3 4 RadioFans.CN 收音机爱好者资料库 15 SECTION 3 EXPLODED VIEWS Note: -XX, -X mean standardized parts, so they may have some differences fr

13、om the original one. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The mechanical parts with no reference number in the exploded views are not supplied. Color Indication of Appearance Parts Example: KN

14、OB, BALANCE (WHITE) The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. Cabinets Color (1)CASE, FRONT PANEL SECTION Ref.

15、 No.Part No.DescriptionRemarksRef. No.Part No.DescriptionRemarks 12 11 12 12 7 8 not supplied #2 6 5 34 2 1 supplied with S801 supplied with RV202 17 14 14 15 13 9 not supplied 9 16 #1 9 #1 10 #1 FE510R 9 supplied with J501 not supplied 17 1X-4946-800-1KNOB (VOL) ASSY (VOLUME)(BLACK) 1X-4947-624-1KN

16、OB (VOL) ASSY (VOLUME)(SILVER) 2X-4947-336-1KNOB (DIA.47) ASSY (BLACK) (INPUT SELECTOR) 2X-4947-625-1KNOB (DIA.47) ASSY (SILVER) (INPUT SELECTOR) 34-980-204-01KNOB (DIA.24)(BLACK) (BALANCE TONE) 34-980-204-11KNOB (DIA.24)(SILVER)(BALANCE TONE) 4X-4948-253-1PANEL ASSY, FRONT (BLACK) 4X-4948-254-1PANE

17、L ASSY, FRONT (BLACK) 4X-4948-418-1PANEL ASSY, FRONT (SILVER) 54-963-404-21EMBLEM (5-A), SONY 64-980-199-01BUTTON (POWER)(BLACK) 64-980-199-11BUTTON (POWER)(SILVER) * 71-665-591-11SIRCS BOARD * 81-665-595-11AC SW BOARD 94-951-620-01SCREW (2.6X8), +BVTP * 101-659-964-11HP BOARD * 114-980-777-41CASE (

18、409526)(BLACK) * 114-980-777-61CASE (409526)(SILVER) 123-704-366-01SCREW (CASE)(M3X8)(BLACK) 123-704-366-71SCREW (CASE)(M3X8)(SILVER) * 131-665-596-11FUNCTION SW BOARD 141-769-983-11WIRE (FLAT TYPE) (13 CORE) * 15A-4398-021-A CONTROL BOARD, COMPLETE (FE510R) * 15A-4398-017-A CONTROL BOARD, COMPLETE

19、(FE310R) * 161-665-592-11EON BOARD (FE510R) 174-980-189-01KNOB (DIA. 6)(BLACK) 174-980-189-11KNOB (DIA. 6)(SILVER) 16 #1 not supplied #4 #1 #1 #1 #1 #1 53 52 #3 not supplied T1 51 51 55 54 56 57 60 CN7 AEP, GermanyUK 61 UK AEP, Germany CP1 CP1 #2 (2)CHASSIS SECTION Ref. No.Part No.DescriptionRemarks

20、Ref. No.Part No.DescriptionRemarks 59 CN8CN9 #1 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. 51X-4947-124-1FOOT ASSY (F50150S)(SILVER) 51X-4947-207-1FOOT ASSY (F50150S)(BLACK) * 521-665-597-11RELAY DC BOARD * 531-659

21、-962-11RELAY AC BOARD (UK) * 531-665-593-11RELAY AC BOARD (AEP,Germany) * 54A-4398-020-A MAIN BOARD, COMPLETE (FE510R) * 54A-4398-016-A MAIN BOARD, COMPLETE (FE310R) * 553-703-244-00BUSHING (2104), CORD 563-704-515-11SCREW (BV/RING) * 574-989-459-02PANEL, BACK (FE510R) * 574-989-462-02PANEL, BACK (F

22、E310R:AEP,Germany) * 574-989-462-12PANEL, BACK (FE310R:UK) * 591-665-599-11SP BOARD * 601-665-598-11AC BOARD (AEP,Germany) 614-956-370-12BAND, PLUG FIXED (UK) !CN71-526-794-11OUTLET, AC (AEP,Germany) !CN81-526-794-11OUTLET, AC (AEP,Germany) !CN91-526-794-11OUTLET, AC (AEP,Germany) !CP11-575-651-21CO

23、RD, POWER (AEP,Germany) !CP11-696-586-11CORD, POWER (UK) !T11-429-448-11TRANSFORMER, POWER (FE510R) !T11-429-452-11TRANSFORMER, POWER (FE310R) Note: Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX

24、, -X mean standardized parts, so they may have some difference from the original one. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. CAPACITORS: uF: F The components identified by mark ! or dotted line

25、with mark ! are critical for safety. Replace only with part number specified. RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: H SEMICONDUCTORS In each case, u: , for example: uA.: A. , uPA. , PA. , uPB. , PB. , uPC. , P

26、C. , uPD., PD. When indicating parts by reference number, please include the board naame. Ref. No.Part No.DescriptionRemarksRef. No.Part No.DescriptionRemarks 17 SECTION 4 ELECTRICAL PARTS LIST *1-665-598-11AC BOARD (AEP,Germany) * 1-533-293-11FUSE HOLDER !CN71-526-794-11OUTLET, AC !CN81-526-794-11O

27、UTLET, AC !CN91-526-794-11OUTLET, AC !F21-532-464-51FUSE,TIME LAG 2.5A/250V * *1-665-595-11AC SW BOARD * * CN9531-564-506-11PLUG, CONNECTOR 3P CN9551-564-505-11PLUG, CONNECTOR 2P S11-554-920-11SWITCH, PUSH (AC POWER)(1 KEY) * *A-4398-017-A CONTROL BOARD, COMPLETE (FE310R) * *A-4398-021-A CONTROL BOA

28、RD, COMPLETE (FE510R) * C2011-136-153-00FILM0.01uF5%50V C2021-136-165-00FILM0.1uF5%50V C2031-130-477-00MYLAR0.0033uF5%50V C2041-136-159-00FILM0.033uF5%50V C2051-130-473-00MYLAR0.0015uF5%50V C2511-136-153-00FILM0.01uF5%50V C2521-136-165-00FILM0.1uF5%50V C2531-130-477-00MYLAR0.0033uF5%50V C2541-136-15

29、9-00FILM0.033uF5%50V C2551-130-473-00MYLAR0.0015uF5%50V C8011-126-096-11ELECT10uF20%35V C8021-126-916-11ELECT1000uF20%6.3V C8031-164-159-11CERAMIC0.1uF50V C8061-162-294-31CERAMIC0.001uF10%50V C8071-126-096-11ELECT10uF20%35V C8081-124-463-00ELECT0.1uF20%50V C8091-126-301-11ELECT1uF20%50V * CN8011-568

30、-832-11SOCKET, CONNECTOR 13P CN8021-562-087-00SOCKET, CONNECTOR 4P CN8041-562-087-00SOCKET, CONNECTOR 4P CN8061-774-913-11PIN, CONNECTOR 4P * CN8141-568-832-11SOCKET, CONNECTOR 13P D8018-719-985-59DIODE HZS4CLL D8028-719-987-63DIODE 1N4148M D8038-719-987-63DIODE 1N4148M D8048-719-987-63DIODE 1N4148M

31、 D8058-719-987-63DIODE 1N4148M D8068-719-987-63DIODE 1N4148M D8078-719-313-50DIODE SEL6810A-TH12 (SOURCE DIRECT) D8088-719-313-50DIODE SEL6810A-TH12 (PHONO) D8098-719-313-50DIODE SEL6810A-TH12 (TUNER) D8108-719-313-50DIODE SEL6810A-TH12 (CD) D8118-719-313-50DIODE SEL6810A-TH12 (AUX) D8128-719-313-50

32、DIODE SEL6810A-TH12 (TAPE2/MD) D8138-719-313-50DIODE SEL6810A-TH12 (TAPE1/DAT) D8148-719-987-63DIODE 1N4148M D8168-719-987-63DIODE 1N4148M D8178-719-987-63DIODE 1N4148M D8198-719-987-63DIODE 1N4148M D8208-719-024-99DIODE 11ES2-NTA2B D8238-719-313-50DIODE SEL6810A-TH12 (TAPE1 MONITOR) (FE510R) IC8018

33、-759-392-41IC TMP47C103N IC8028-759-962-08IC BA6208 Q8018-729-119-78TRANSISTOR 2SC2785-HFE Q8028-729-620-05TRANSISTOR 2SC2603-EF Q8038-729-661-98TRANSISTOR RT1P141SK-TP (FE510R) Q8048-729-661-98TRANSISTOR RT1P141SK-TP Q8068-729-620-05TRANSISTOR 2SC2603-EF Q8078-729-620-05TRANSISTOR 2SC2603-EF Q8088-

34、729-620-05TRANSISTOR 2SC2603-EF Q8108-729-661-94TRANSISTOR RT1N141SK-TP Q8118-729-661-94TRANSISTOR RT1N141SK-TP R2011-249-433-11CARBON22K5%1/4W R2021-249-421-11CARBON2.2K5%1/4WF R2031-249-427-11CARBON6.8K5%1/4WF R2041-249-415-11CARBON6805%1/4WF R2051-249-421-11CARBON2.2K5%1/4WF AC AC SWCONTROL Ref.

35、No.Part No.DescriptionRemarksRef. No.Part No.DescriptionRemarks 18 R2061-249-441-11CARBON100K5%1/4W R2081-249-439-11CARBON68K5%1/4W R2511-249-433-11CARBON22K5%1/4W R2521-249-421-11CARBON2.2K5%1/4WF R2531-249-427-11CARBON6.8K5%1/4WF R2541-249-415-11CARBON6805%1/4WF R2551-249-421-11CARBON2.2K5%1/4WF R

36、2561-249-441-11CARBON100K5%1/4W R2581-249-439-11CARBON68K5%1/4W R3171-247-750-11CARBON6805%1/2WF R3671-247-750-11CARBON6805%1/2WF R8011-249-411-11CARBON3305%1/4W R8021-247-807-31CARBON1005%1/4W R8031-249-429-11CARBON10K5%1/4W R8041-249-429-11CARBON10K5%1/4W R8051-249-425-11CARBON4.7K5%1/4WF R8061-24

37、7-843-11CARBON3.3K5%1/4W R8071-247-843-11CARBON3.3K5%1/4W R8081-249-429-11CARBON10K5%1/4W R8091-249-429-11CARBON10K5%1/4W R8101-249-429-11CARBON10K5%1/4W R8111-249-429-11CARBON10K5%1/4W R8121-249-399-11CARBON335%1/4WF R8141-249-413-11CARBON4705%1/4WF (FE510R) R8151-249-429-11CARBON10K5%1/4W R8161-24

38、9-429-11CARBON10K5%1/4W R8171-249-429-11CARBON10K5%1/4W R8181-249-429-11CARBON10K5%1/4W R8191-249-429-11CARBON10K5%1/4W R8201-249-429-11CARBON10K5%1/4W R8211-249-429-11CARBON10K5%1/4W R8221-249-429-11CARBON10K5%1/4W R8231-249-437-11CARBON47K5%1/4W R8241-249-441-11CARBON100K5%1/4W R8261-249-399-11CAR

39、BON335%1/4WF R8271-249-393-11CARBON105%1/4WF (FE510R) R8281-249-429-11CARBON10K5%1/4W R8291-249-429-11CARBON10K5%1/4W R8301-249-429-11CARBON10K5%1/4W R8341-249-413-11CARBON4705%1/4WF R8371-249-407-11CARBON1505%1/4WF RV2011-223-396-11RES, VAR, CARBON 100K/100K (BALANCE) RV2021-241-426-11RES, VAR, CAR

40、BON 100KX2 (VOLUME) RV2031-223-397-11RES, VAR, CARBON 100K/100K (BASS) RV2041-223-397-11RES, VAR, CARBON 100K/100K (TREBLE) S2011-571-112-21SWITCH, PUSH (1 KEY)(LOUDNESS) S2021-571-828-11SWITCH, PUSH (1 KEY)(SOURCE DIRECT) S8021-762-750-11SWITCH, TACTILE (TAPE1 MONITOR)(FE510R) X8011-577-358-21VIBRA

41、TOR, CERAMIC 4MHz * *1-665-592-11EON BOARD (FE510R) * CN8101-564-506-11PLUG, CONNECTOR 3P D8218-719-313-50DIODE SEL6810A-TH12 (EON LINE) Q8098-729-661-94TRANSISTOR RT1N141SK-TP Q8128-729-620-05TRANSISTOR 2SC2603-EF Q8138-729-620-05TRANSISTOR 2SC2603-EF R8311-249-399-11CARBON335%1/4WF R8351-249-429-1

42、1CARBON10K5%1/4W R8361-249-425-11CARBON4.7K5%1/4WF R8381-249-407-11CARBON1505%1/4WF S8031-571-112-21SWITCH, PUSH (1 KEY) (EON LINE) * *1-665-596-11FUNCTION SW BOARD * CN8051-774-913-11PIN, CONNECTOR 4P S8011-692-974-11SWITCH, ROTARY (INPUT SELECTOR) * *1-659-964-11HP BOARD * CN8031-560-941-11PIN, CO

43、NNECTOR 4P J5011-774-933-11JACK (LARGE TYPE)(PHONES) (FE310R/FE510R:AEP (BLACK) J5011-580-903-11JACK, LARGE TYPE (PHONES) (FE510R:AEP (SILVER) * *A-4398-016-A MAIN BOARD, COMPLETE (FE310R) * *A-4398-020-A MAIN BOARD, COMPLETE (FE510R) * C1011-162-282-31CERAMIC100PF10%50V C1021-162-286-31CERAMIC220PF

44、10%50V C1031-126-963-11ELECT4.7uF20%50V C1041-126-967-11ELECT47uF20%16V CONTROLEONFUNCTION SWHPMAIN Ref. No.Part No.DescriptionRemarksRef. No.Part No.DescriptionRemarks 19 C1051-162-282-31CERAMIC100PF10%50V C1061-130-480-00MYLAR0.0056uF5%50V C1071-130-473-00MYLAR0.0015uF5%50V C1081-126-964-11ELECT10

45、uF20%50V C1091-126-964-11ELECT10uF20%50V C1121-162-294-31CERAMIC0.001uF10%50V C1141-162-306-11CERAMIC0.01uF20%16V C1151-126-963-11ELECT4.7uF20%50V C1511-162-282-31CERAMIC100PF10%50V C1521-162-286-31CERAMIC220PF10%50V C1531-126-963-11ELECT4.7uF20%50V C1541-126-967-11ELECT47uF20%16V C1551-162-282-31CE

46、RAMIC100PF10%50V C1561-130-480-00MYLAR0.0056uF5%50V C1571-130-473-00MYLAR0.0015uF5%50V C1581-126-964-11ELECT10uF20%50V C3011-126-964-11ELECT10uF20%50V C3021-162-290-31CERAMIC470PF10%50V C3031-162-282-31CERAMIC100PF10%50V C3051-126-933-11ELECT100uF20%10V C3061-126-967-11ELECT47uF20%50V C3071-126-965-11ELECT22uF20%50V C3081-126-965-11ELECT22uF20%50V C3091-126-965-11ELECT22uF20%50V C3101-126-968-11ELECT100uF20%50V (FE310R) C3101-126-969-11ELECT220uF20%50V (FE510R) C3111-136-495-11FILM0.068uF5%50V C3121-136-495-11FILM0.068uF5%50V C3131-