Sony-TAFE610R-int-sm 电路图 维修手册.pdf

《Sony-TAFE610R-int-sm 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Sony-TAFE610R-int-sm 电路图 维修手册.pdf（20页珍藏版）》请在收音机爱好者资料库上搜索。

1、TA-FE610R AEP ModelSERVICE MANUAL INTEGRATED STEREO AMPLIFIER MICROFILM SPECIFICATIONS RadioFans.CN 收音机爱 好者资料库 2 TABLE OF CONTENTS 1. GENERAL .3 2. ELECTRICAL ADJUSTMENT.4 3. DIAGRAMS 3-1.Circuit Boards Location .5 3-2.IC Pin Function IC902 Input Control LED Driver (TMP47C103N-JP47) .6 3-3.Schematic

2、 Diagram Panel Section .7 3-4.Printed Wiring Board Panel Section .9 3-5.Schematic Diagram Main A Section .11 3-6.Printed Wiring Board Main A Section .13 3-7.Schematic Diagram Main B Section .15 3-8.Printed Wiring Board Main B Section .17 4. EXPLODED VIEWS 4-1.Front Panel Section .19 4-2.Chassis Sect

3、ion.20 5. ELECTRICAL PARTS LIST .21 SAFETY-RELATED COMPONENT WARNING ! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL

4、 OR IN SUPPLEMENTS PUBLISHED BY SONY. RadioFans.CN 收音机爱 好者资料库 3 SECTION 1 GENERAL location of parts and controls FRONT PANEL 1 POWER switch 2 INPUT SELECTOR indicator 3 SUBSONIC switch 4 EON LINK switch 5 EON LINK indicator 6 VOLUME control 7 SOURCE DIRECT indicator 8 SOURCE DIRECT switch 9 INPUT SE

5、LECTOR control 0 TAPE MONITOR indicator ! TAPE MONITOR switch ! LOUDNESS switch ! BALANCE control ! TONE (BASS, TREBLE) control ! SPEAKERS selector ! Remote control sensor ! PHONES jack REAR PANEL 1 23 4 5 6 790 ! ! 5 467890! 123 This section is extracted from instruction manual. RadioFans.CN 收音机爱 好

6、者资料库 4 SECTION 2 ELECTRICAL ADJUSTMENT Bias Adjustment 1.Rotate fully the bias adjusting semi-fixed resistors (RV301, RV351) to the MIN position (counterclockwise). 2.Connect a digital voltmeter to the CN406 and CN407. 1 pin3 pin + + CN406 CN407 3.Set the slide regulator to 0V, and press the POWER b

7、utton (ON) on the set. 4.Raise gradually the slide regulator voltage up to the rated voltage (230 V). 5.At this time, confirm that the SP relay is turned on (it will click). 6.Adjust the RV301 and RV351 so that a reading of digital voltmeter is 10 mV to 15 mV. 7.Return the slidack to 0 V, and press

8、the POWER button (OFF) on the set. Adjustment Location : MAIN A BOARD COMPONENT SIDE C322C372 RV351 RV301 BIAS Adjustment Test Point Location : MAIN B BOARD COMPONENT SIDE CN406 13 C409C459 CN407 13 + + DIGITAL VOLTMETER DIGITAL VOLTMETER SECTION 3 DIAGRAMS 3-1. CIRCUIT BOARDS LOCATION MAIN B board

9、TRANS board PANEL board LED board MAIN A board INPUT board OUTLET board PRO IND board HP board SP SW board EON board VOL board SP TM board I/OFunction IC902 Input Control LED Drive (TMP47C103N-JP47) Pin No. 3-2. IC PIN FUNCTION Pin Name O I I I O O I I I I O O O O O O O O I I I O O O O I 1 2 3 4 5 6

10、 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 X OUT X IN RESET PMD VOL + VOL SW 0 SW 1 SW 2 EON PHONO TUNER CD GND AUX DAT TAPE MON PRY PKY MON SIRCS MUTE SCE SDT SCK STOP +3V System clock. (4MHz) Reset input. Mode select input. Motor drive output (+). Motor drive output (). Rotary

11、 switch input (CD). Rotary switch input (TUNER). Rotary switch input (PHONO). EON signal input. PHONO LED drive output. TUNER LED drive output. CD LED drive output. Ground. AUX LED drive output. TAPE “2” LED drive output. TAPE “1” LED drive output. MONITOR output. Power relay output. Power key input

12、. MONITOR input. SIRCS input. Muting output. Chip enble output. Serial data output. Serial clock output. STOP input. +3V Power supply. 5 6 SECTION 4 EXPLODED VIEWS 4-1. FRONT PANEL SECTION 1 2 2 3 4 4 4 6 7 8 9 25 10 11 12 13 14 15 16 17 18 19 20 20 20 21 23 23 23 23 23 24 24 22 22 22 22 22 5 24 Not

13、e: -XX, -X mean standardized parts, so they may have some differences from the original one. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The mechanical parts with no reference number in the exploded

14、views are not supplied. Accessories and packing materials are given in the last of this parts list. Color Indication of Appearrance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) Parts Color Cabinets Color The components identified by mark ! or dotted line with mark ! are critical for safety. Repl

15、ace only with part number specified. Ref. No.Part No.DescriptionRemarksRef. No.Part No.DescriptionRemarks 1X-4946-920-1KNOB (VOL) ASSY (VOLUME) 2X-4947-025-1FOOT ASSY 34-980-766-52PANEL, FRONT 44-980-775-01LENS, LED 54-980-771-01KNOB (DIA. 47)(INPUT SELECTOR) 64-980-204-01KNOB (DIA. 24)(TONE,BALANCE

16、,SPEAKERS) 74-965-651-01EMBLEM (POWER MOS) 84-979-587-01EMBLEM (NO.5)(SONY) 9X-4946-923-1PANEL ASSY, BASE 104-980-773-01BUTTON (DIA. 6) * 111-660-566-11EON BOARD 124-980-776-01WINDOW, REMOTE CONTROL * 131-662-376-11HP BOARD * 141-660-562-11LED BOARD * 15A-4389-795-A PANEL BOARD, COMPLETE * 161-660-5

17、65-11VOL BOARD * 171-660-564-11SP SW BOARD 184-980-199-01BUTTON (POWER) * 191-660-567-11PRO IND BOARD 203-704-366-01SCREW (CASE) (M3X8) * 214-989-460-11CASE 224-967-961-01SCREW (3X8) 234-951-620-01SCREW (2.6X8), +BVTP 247-685-872-09SCREW +BVTT 3X8 (S) 254-980-189-01KNOB (DIA. 6)(EON LINK) !S11-554-9

18、20-11SWITCH, PUSH (AC POWER)(1 KEY) 4-2. CHASSIS SECTION 51 52 52 51 51 51 51 51 51 51 51 54 55 56 57 59 60 60 60 61 63 F801 F802 T1 Q406B Q403 Q454 Q404 CNP801 CNJ801 CNJ802 CNJ803 not supplied not supplied 62 not supplied Q453 58 57 64 53 not supplied not supplied Ref. No.Part No.DescriptionRemark

19、sRef. No.Part No.DescriptionRemarks 514-967-961-01SCREW (3X8) 524-967-960-01SCREW (4X8) * 53A-4398-035-A MAIN A BOARD, COMPLETE * 541-660-563-11INPUT BOARD * 551-660-573-11OUTLET BOARD * 564-982-977-32PANEL, BACK 573-905-609-11SCREW (TRANSISTOR) * 58A-4398-036-A MAIN B BOARD, COMPLETE 594-947-010-01

20、SCREW, FEEDER FIXED 604-981-016-01SCREW (H) * 613-703-244-00BUSHING (2104), CORD * 621-660-571-11SP TM BOARD * 631-660-574-11TRANS BOARD 643-704-515-41SCREW (BV/RING) !CNJ801 1-526-794-11OUTLET, AC !CNJ802 1-526-794-11OUTLET, AC !CNJ803 1-526-794-11OUTLET, AC !CNP801 1-777-185-11CORD, POWER !F8011-5

21、32-388-51FUSE,TIME LAG 2.0A/250V !F8021-532-464-51FUSE,TIME LAG 2.5A/250V Q4038-729-232-45TRANSISTOR 2SK1529-Y Q4048-729-232-46TRANSISTOR 2SJ200-Y Q406B8-729-209-15TRANSISTOR 2SD2012 Q4538-729-232-45TRANSISTOR 2SK1529-Y Q4548-729-232-46TRANSISTOR 2SJ200-Y !T11-429-492-11TRANSFORMER, POWER The compon

22、ents identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. 19 20 not supplied S1 Supplied with J701 not supplied not supplied Supplied with RV200, RV201, RV203, S900 Supplied with S901 Supplied with RV203 22 b 22 a 20 b a not supplied Note:

23、 Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked “*” are not stocked since they are seldom require

24、d for routine service. Some delay should be anticipated when ordering these items. CAPACITORS: uF: F The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL

25、OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: H SEMICONDUCTORS In each case, u: , for example: uA.: A. , uPA. , PA. , uPB. , PB. , uPC. , PC. , uPD., PD. When indicating parts by reference number, please include the board naame. Ref. No.Part No.DescriptionRemarksRef. No.Part No.Descript

26、ionRemarks 21 SECTION 5 ELECTRICAL PARTS LIST *1-660-566-11EON BOARD * CN9521-691-766-11PLUG (MICRO CONNECTOR) 4P D9018-719-313-50DIODE SEL6810A-TH12 (EON LINK) R9011-249-397-11CARBON225%1/4WF S9021-571-112-21SWITCH, PUSH (1 KEY) (EON LINK) * *1-662-376-11HP BOARD * J7011-750-735-11JACK (LARGE TYPE)

27、(PHONES) * *1-660-563-11INPUT BOARD * C1011-162-286-31CERAMIC220PF10%50V C1021-162-286-31CERAMIC220PF10%50V C1031-162-286-31CERAMIC220PF10%50V C1041-162-286-31CERAMIC220PF10%50V C1051-162-286-31CERAMIC220PF10%50V C1061-162-286-31CERAMIC220PF10%50V C1071-162-286-31CERAMIC220PF10%50V C1511-162-286-31C

28、ERAMIC220PF10%50V C1521-162-286-31CERAMIC220PF10%50V C1531-162-286-31CERAMIC220PF10%50V C1541-162-286-31CERAMIC220PF10%50V C1551-162-286-31CERAMIC220PF10%50V C1561-162-286-31CERAMIC220PF10%50V C1571-162-286-31CERAMIC220PF10%50V C9501-162-294-31CERAMIC0.001uF10%50V C9521-164-159-11CERAMIC0.1uF50V C95

29、31-164-159-11CERAMIC0.1uF50V C9601-126-963-11ELECT4.7uF20%50V CN161-564-320-00PIN, CONNECTOR (B2P-VH) 2P CN2001-691-766-11PLUG (MICRO CONNECTOR) 4P CN9041-691-773-11PLUG (MICRO CONNECTOR) 11P D9508-719-987-63DIODE 1N4148M D9518-719-987-63DIODE 1N4148M IC1018-759-805-13IC LC7821 * J1011-573-142-11JAC

30、K, PIN 4P (INPUT TUNER,PHONO) * J1021-573-142-21JACK, PIN 4P (INPUT AUX,CD) * J1031-573-142-21JACK, PIN 4P (TAPE 1/DAT REC OUT,IN) * J1041-573-142-21JACK, PIN 4P (TAPE 2/MD REC OUT,IN) Q9248-729-620-05TRANSISTOR 2SC2603-EF Q9258-729-620-05TRANSISTOR 2SC2603-EF Q9268-729-620-05TRANSISTOR 2SC2603-EF R

31、1011-249-995-11CARBON1M5%1/4W R1021-249-995-11CARBON1M5%1/4W R1031-249-995-11CARBON1M5%1/4W R1041-249-923-11CARBON1K5%1/4W R1051-249-995-11CARBON1M5%1/4W R1061-249-923-11CARBON1K5%1/4W R1071-249-995-11CARBON1M5%1/4W R1101-249-995-11CARBON1M5%1/4W R1111-249-995-11CARBON1M5%1/4W R1511-249-995-11CARBON

32、1M5%1/4W R1521-249-995-11CARBON1M5%1/4W R1531-249-995-11CARBON1M5%1/4W R1541-249-923-11CARBON1K5%1/4W R1551-249-995-11CARBON1M5%1/4W R1561-249-923-11CARBON1K5%1/4W R1571-249-995-11CARBON1M5%1/4W R1601-249-995-11CARBON1M5%1/4W R1611-249-995-11CARBON1M5%1/4W R9451-249-429-11CARBON10K5%1/4W R9461-249-4

33、29-11CARBON10K5%1/4W R9471-249-429-11CARBON10K5%1/4W R9571-249-425-11CARBON4.7K5%1/4WF RY1011-515-614-11RELAY * EONHPINPUT Ref. No.Part No.DescriptionRemarksRef. No.Part No.DescriptionRemarks 22 *1-660-562-11LED BOARD * CNJ902 1-766-796-11CONNECTOR, BOARD TO BOARD 12P D6008-719-313-50DIODE SEL6810A-

34、TH12 (SOURCE DIRECT) D6018-719-313-50DIODE SEL6810A-TH12 (TAPE 1/DAT) D6028-719-313-50DIODE SEL6810A-TH12 (TAPE 2/MD) D6038-719-313-50DIODE SEL6810A-TH12 (AUX) D6048-719-313-50DIODE SEL6810A-TH12 (CD) D6058-719-313-50DIODE SEL6810A-TH12 (TUNER) D6068-719-313-50DIODE SEL6810A-TH12 (PHONO) D6078-719-3

35、13-50DIODE SEL6810A-TH12 (TAPE 1 MONITOR) R9261-247-751-11CARBON8205%1/2W R9401-249-414-11CARBON5605%1/4WF S2031-554-303-21SWITCH, TACTILE (TAPE 1 MONITOR) * *A-4398-035-A MAIN A BOARD, COMPLETE * C3011-102-978-00CERAMIC220PF5%50V C3021-126-059-11ELECT10uF20%50V C3031-164-062-11CERAMIC47PF5%50V C304

36、1-106-359-00MYLAR4700PF5%200V C3051-136-162-00FILM0.056uF5%50V C3061-137-471-11FILM0.016uF5%50V C3071-126-059-11ELECT10uF20%50V C3081-126-022-11ELECT47uF20%25V C3091-126-013-11ELECT1000uF20%16V C3101-126-023-11ELECT100uF20%25V C3111-102-973-00CERAMIC100PF5%50V C3121-124-721-11ELECT10uF20%50V C3131-1

37、64-083-11CERAMIC680PF10%50V C3141-164-062-11CERAMIC47PF5%50V C3151-107-589-91CERAMIC9PF0.5PF500V C3161-126-023-11ELECT100uF20%16V C3171-126-023-11ELECT100uF20%16V C3181-126-023-11ELECT100uF20%16V C3191-126-023-11ELECT100uF20%16V C3201-110-393-11ELECT100uF20%63V C3211-164-040-11CERAMIC4PF0.25PF 50V C

38、3221-126-056-11ELECT1000uF20%50V C3511-102-978-00CERAMIC220PF5%50V C3521-126-059-11ELECT10uF20%50V C3531-164-062-11CERAMIC47PF5%50V C3541-106-359-00MYLAR4700PF5%200V C3551-136-162-00FILM0.056uF5%50V C3561-137-471-11FILM0.016uF5%50V C3571-126-059-11ELECT10uF20%50V C3581-126-022-11ELECT47uF20%25V C359

39、1-126-013-11ELECT1000uF20%16V C3601-126-023-11ELECT100uF20%25V C3611-102-973-00CERAMIC100PF5%50V C3621-124-721-11ELECT10uF20%50V C3631-164-083-11CERAMIC680PF10%50V C3641-164-062-11CERAMIC47PF5%50V C3651-107-589-91CERAMIC9PF0.5PF500V C3661-126-023-11ELECT100uF20%16V C3671-126-023-11ELECT100uF20%16V C

40、3681-126-023-11ELECT100uF20%16V C3691-126-023-11ELECT100uF20%16V C3701-110-393-11ELECT100uF20%63V C3711-164-040-11CERAMIC4PF0.25PF 50V C3721-126-056-11ELECT1000uF20%50V CN3011-691-769-11PLUG (MICRO CONNECTOR) 7P CN3021-691-765-11PLUG (MICRO CONNECTOR) 3P D3018-719-310-61DIODE SEL1510C-D D3028-719-93

41、3-88DIODE HZS16-2L D3038-719-933-41DIODE HZS6C3L D3048-719-987-63DIODE 1N4148M D3058-719-987-63DIODE 1N4148M D3068-719-310-61DIODE SEL1510C-D D3078-719-987-63DIODE 1N4148M D3088-719-987-63DIODE 1N4148M D3098-719-987-63DIODE 1N4148M D3518-719-310-61DIODE SEL1510C-D D3528-719-933-88DIODE HZS16-2L D353

42、8-719-933-41DIODE HZS6C3L D3548-719-987-63DIODE 1N4148M D3558-719-987-63DIODE 1N4148M D3568-719-310-61DIODE SEL1510C-D D3578-719-987-63DIODE 1N4148M D3588-719-987-63DIODE 1N4148M D3598-719-987-63DIODE 1N4148M * EPT4014-924-264-21TERMINAL, MOUNT IC3018-759-636-74IC M5218AP-22 L1011-410-977-11INDUCTOR

43、 100uH L1021-410-977-11INDUCTOR 100uH L1511-410-977-11INDUCTOR 100uH L1521-410-977-11INDUCTOR 100uH L3011-428-203-11COIL, AIR-CORE L3511-428-203-11COIL, AIR-CORE Q3018-729-281-54TRANSISTOR 2SC1815-BL Q3028-729-281-54TRANSISTOR 2SC1815-BL Q3038-729-281-54TRANSISTOR 2SC1815-BL Q3048-729-620-17TRANSIST

44、OR 2SC2259-FG Q3058-729-201-53TRANSISTOR 2SA1015-GR LEDMAIN A Ref. No.Part No.DescriptionRemarksRef. No.Part No.DescriptionRemarks 23 Q3068-729-201-53TRANSISTOR 2SA1015-GR Q3078-729-201-53TRANSISTOR 2SA1015-GR Q3088-729-021-74TRANSISTOR 2SA949-OY-TPE6 Q3098-729-202-67TRANSISTOR 2SK246-GR3 Q3108-729-

45、021-73TRANSISTOR 2SC2229-OY-TPE6 Q3118-729-281-54TRANSISTOR 2SC1815-BL Q3128-729-281-54TRANSISTOR 2SC1815-BL Q3518-729-281-54TRANSISTOR 2SC1815-BL Q3528-729-281-54TRANSISTOR 2SC1815-BL Q3538-729-201-53TRANSISTOR 2SA1015-GR Q3548-729-620-17TRANSISTOR 2SC2259-FG Q3558-729-201-53TRANSISTOR 2SA1015-GR Q

46、3568-729-201-53TRANSISTOR 2SA1015-GR Q3578-729-201-53TRANSISTOR 2SA1015-GR Q3588-729-021-74TRANSISTOR 2SA949-OY-TPE6 Q3598-729-202-67TRANSISTOR 2SK246-GR3 Q3608-729-021-73TRANSISTOR 2SC2229-OY-TPE6 Q3618-729-281-54TRANSISTOR 2SC1815-BL Q3628-729-281-54TRANSISTOR 2SC1815-BL R1081-259-436-11CARBON2.2K5%1/6W R1581-259-436-11CARBON2.2K5%1/6W R3011-259-215-21CARBON100K5%1/4W R3021-249-911-11CARBON3305%1/4W R3031-259-215-21CARBON100K5%1/4W R3041-249-900-11CARBON1101%1/4W R3051-259-161-21CARBON5605%1/4W R3061-25