Sony-TAFE200-int-sm 电路图 维修手册.pdf

《Sony-TAFE200-int-sm 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Sony-TAFE200-int-sm 电路图 维修手册.pdf（11页珍藏版）》请在收音机爱好者资料库上搜索。

1、MICROFILM TA-FE200 INTEGRATED STEREO AMPLIFIER AEP Model UK Model SERVICE MANUAL SPECIFICATIONS Amplifier section DIN power output 40 W+40 W (8 ohms at 1 kHz) Frequency response PHONO (20 Hz-20 kHz): RIAA equalization curve0.5 dB TUNER, CD, TAPE1/DAT, TAPE2/MD : 7 Hz-70 kHz dB S/N (network A) PHONO:

2、 80 dB TUNER, CD, TAPE1/DAT, TAPE2/MD : 105dB Output voltage/impedance REC OUT: 200 mV, 1 kilohm PHONES: 5 mW (at 8 ohms) Speakers impedance 8-16 ohms General System Power amplifier: Pure-complementary SEPP OCL power amplifier with all stages directly coupled Preamplifier: Low-noise, equalizer ampli

3、fier Power requirements 220-230 V AC, 50/60 Hz Power consumption 120 W Dimensions (approx.) (w/h/d) 430105290 mm incl. projecting parts and controls Mass (approx.) 4.2 kg Design and specifications are subject to change without notice. +0 3 RadioFans.CN 收音机爱 好者资料库 2 TABLE OF CONTENTS 1.GENERAL.3 2.DI

4、AGRAMS 2-1.Schematic Diagram.6 2-2.Printed Wiring Boards .9 3.EXPLODED VIEWS. 13 4.ELECTRICAL PARTS LIST. 15 SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMP

5、ONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- LISHED BY SONY. MODEL IDENTIFICATION Specification Label Printed on Back Panel MODEL NO. TA-FE200 INTEGRATED STEREO AMPLIFIER AEP, German model: AC: 220 230 V 50/60 Hz UK model: AC: 220 230 V 50 Hz RadioF

6、ans.CN 收音机爱 好者资料库 3 SECTION 1 GENERAL Location of Controls Front Panel Descriptions POWER switchINPUT SELECTOR indicator INPUT SELECTOR control VOLUME control PHONES jackTONE controls (BASS/TREBLE) BALANCE controlLOUDNESS switch RadioFans.CN 收音机爱 好者资料库 4 SECTION 2 DIAGRAMS Circuit Boards Location MA

7、IN board CN DC board AC IN board AC SW board HEADPHONE board CONTROL board 5 IC Block Diagrams IC101NJM2068L-D IC103LC7818 IC601PC1237HA 13 NOTE: -XX and -X mean standardized parts, so they may have some difference from the original one. Color Indication of Appearrance Parts Example: KNOB, BALANCE (

8、WHITE) . . . (RED) Parts ColorCabinets Color The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ord

9、ering these items. The mechanical parts with no reference num- ber in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of the electrical parts list. Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 1X-4946-800-1

10、 KNOB (VOL) ASSY 2X-4947-336-1 KNOB (DIA. 47) ASSY 34-980-204-01 KNOB (DIA. 24) 4X-4946-799-3 PANEL ASSY, FRONT 54-963-404-21 EMBLEM (5-A), SONY 64-951-620-01 SCREW (2.6X8), +BVTP * 71-659-952-11 AC SW BOARD 84-980-199-01 BUTTON (POWER) * 91-659-953-11 HEADPHONE BOARD * 104-980-777-41 CASE (409526)

11、113-704-366-01 SCREW (CASE)(M3X8) * 12A-4389-375-A CONTROL BOARD, COMPLETE 134-980-189-01 KNOB (DIA. 6) 141-773-154-11 WIRE (FLAT TYPE)(21 CORE) (1) CASE, FRONT PANEL SECTION 11 11 11 8 4 3 2 1 6 12 14 13 6 6 9 10 5 supplied with S801 supplied with RV202 not supplied #1 not supplied supplied with J5

12、01 #1 #1 7 6 #2 rA not supplied not supplied SECTION 3 EXPLODED VIEWS 14 (2) CHASSIS SECTION The components identified by mark ! or dotted line with mark ! are criti- cal for safety. Replace only with part number speci- fied. Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 51X-494

13、7-207-1 FOOT ASSY (F50150S) * 521-659-954-11 AC IN BOARD * 531-659-955-11 CN DC BOARD * 54A-4389-374-A MAIN BOARD, COMPLETE * 553-703-244-00 BUSHING (2104), CORD 564-956-370-02 BAND, PLUG FIXED (UK) 573-704-515-11 SCREW (BV/RING) * 584-980-202-01 PANEL, BACK (AEP, German) * 584-980-202-11 PANEL, BAC

14、K (UK) !CP11-575-651-21 CORD, POWER (AEP, German) !CP11-696-586-11 CORD, POWER (UK) !T11-429-447-11 TRANSFORMER, POWER #1 #1 #1 not supplied T1 #3 #1 #1 #1 #2 51 51 58 57 55 54 AEP, German UK CP1 CP1 UK 56 #4 53 52 not supplied (including rA) 15 NOTE: Due to standardization, replacements in the part

15、s list may be different from the parts speci- fied in the diagrams or the components used on the set. -XX and -X mean standardized parts, so they may have some difference from the original one. RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F

16、: nonflammable Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when order- ing these items. SEMICONDUCTORS In each case, u: , for example: uA. .: A. .uPA. . : PA. . uPB. .: PB. .uPC. . : PC. . uPD. .: PD. . CAPACITORS uF: F COILS

17、uH: H Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark The components identified by mark ! or dotted line with mark ! are criti- cal for safety. Replace only with part number speci- fied. When indicating parts by reference number, please include the board. *1-659-954-11 AC IN BOARD

18、 * !T11-429-447-11 TRANSFORMER, POWER * *1-659-952-11 AC SW BOARD * 1-533-293-11 FUSE HOLDER * CN11-580-230-31 PIN, CONNECTOR (PC BOARD) 2P CN21-564-321-00 PIN, CONNECTOR 2P !F11-532-502-51 FUSE,TIME-LAG (T1.25A 250V) !S11-554-920-11 SWITCH, PUSH (1 KEY) (POWER) * *1-659-955-11 CN DC BOARD * C9011-1

19、06-379-12 MYLAR0.033uF5%200V C9021-106-379-12 MYLAR0.033uF5%200V * CN9011-564-241-11 PIN, CONNECTOR (B4P-VH) 4P D9018-719-028-23 DIODE D3SBA20-4101 D9068-719-200-82 DIODE 11ES2 R9111-249-431-11 CARBON15K5%1/4W * *A-4389-375-A CONTROL BOARD, COMPLETE * C2011-136-153-00 FILM0.01uF5%50V C2021-136-165-0

20、0 FILM0.1uF5%50V C2031-130-477-00 MYLAR0.0033uF5%50V C2041-136-159-00 FILM0.033uF5%50V C2051-130-473-00 MYLAR0.0015uF5%50V C2511-136-153-00 FILM0.01uF5%50V C2521-136-165-00 FILM0.1uF5%50V C2531-130-477-00 MYLAR0.0033uF5%50V C2541-136-159-00 FILM0.033uF5%50V C2551-130-473-00 MYLAR0.0015uF5%50V CN8011

21、-568-838-11 SOCKET, CONNECTOR 21P CN8021-562-087-00 SOCKET, CONNECTOR 4P D8028-719-313-72 DIODE SEL3810A-CD (TAPE1/DAT) D8038-719-313-72 DIODE SEL3810A-CD (TAPE2/MD) D8048-719-313-72 DIODE SEL3810A-CD (CD) D8058-719-313-72 DIODE SEL3810A-CD (TUNER) D8068-719-313-72 DIODE SEL3810A-CD (PHONO) R2011-24

22、9-433-11 CARBON22K5%1/4W R2021-249-421-11 CARBON2.2K5%1/4W CONTROLCN DC AC SW SECTION 4 ELECTRICAL PARTS LIST AC IN 16 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark R2031-249-427-11 CARBON6.8K5%1/4W R2041-249-415-11 CARBON6805%1/4W R2051-249-421-11 CARBON2.2K5%1/4W R2061-249-441

23、-11 CARBON100K5%1/4W R2511-249-433-11 CARBON22K5%1/4W R2521-249-421-11 CARBON2.2K5%1/4W R2531-249-427-11 CARBON6.8K5%1/4W R2541-249-415-11 CARBON6805%1/4W R2551-249-421-11 CARBON2.2K5%1/4W R2561-249-441-11 CARBON100K5%1/4W R3171-247-750-11 CARBON6805%1/2W R3671-247-750-11 CARBON6805%1/2W R8011-249-4

24、15-11 CARBON6805%1/4W R8021-249-415-11 CARBON6805%1/4W R8031-249-415-11 CARBON6805%1/4W R8041-249-415-11 CARBON6805%1/4W R8051-249-415-11 CARBON6805%1/4W RV2011-223-396-11 RES, VAR, CARBON 100K/100K (BALANCE) RV2021-241-408-11 RES, VAR, CARBON 100K/100K (VOLUME) RV2031-223-397-11 RES, VAR, CARBON 10

25、0K/100K (BASS) RV2041-223-397-11 RES, VAR, CARBON 100K/100K (TREBLE) S2011-571-112-21 SWITCH, PUSH (1 KEY) (LOUDNESS) S8011-762-626-11 SWITCH, ROTARY (INPUT SELECTOR) * *1-659-953-11 HEADPHONE BOARD * CN8031-560-941-11 PIN, CONNECTOR 4P J5011-774-933-11 JACK (LARGE TYPE) (PHONES) * *A-4389-374-A MAI

26、N BOARD, COMPLETE * *1-537-738-21 TERMINAL, EARTH C1011-162-286-31 CERAMIC220PF10%50V C1021-124-903-11 ELECT1uF20%50V C1031-162-282-31 CERAMIC100PF10%50V C1041-126-967-11 ELECT47uF20%16V C1051-130-480-00 MYLAR0.0056uF5%50V C1061-130-473-00 MYLAR0.0015uF5%50V C1071-126-963-11 ELECT4.7uF20%50V C1081-1

27、24-903-11 ELECT1uF20%50V C1511-162-286-31 CERAMIC220PF10%50V C1521-124-903-11 ELECT1uF20%50V C1531-162-282-31 CERAMIC100PF10%50V C1541-126-967-11 ELECT47uF20%16V C1551-130-480-00 MYLAR0.0056uF5%50V C1561-130-473-00 MYLAR0.0015uF5%50V C1571-126-963-11 ELECT4.7uF20%50V C1581-124-903-11 ELECT1uF20%50V

28、C3011-126-964-11 ELECT10uF20%50V C3021-162-290-31 CERAMIC470PF10%50V C3051-126-933-11 ELECT100uF20%10V C3061-126-967-11 ELECT47uF20%50V C3071-126-965-11 ELECT22uF20%50V C3081-126-965-11 ELECT22uF20%50V C3091-126-965-11 ELECT22uF20%50V C3101-126-968-11 ELECT100uF20%50V C3111-136-495-11 FILM0.068uF5%5

29、0V C3121-136-495-11 FILM0.068uF5%50V C3131-126-967-11 ELECT47uF20%16V C3141-162-195-31 CERAMIC4.7PF10%50V C3511-126-964-11 ELECT10uF20%50V C3521-162-290-31 CERAMIC470PF10%50V C3551-126-933-11 ELECT100uF20%10V C3561-126-967-11 ELECT47uF20%50V C3611-136-495-11 FILM0.068uF5%50V C3621-136-495-11 FILM0.0

30、68uF5%50V C3631-126-967-11 ELECT47uF20%16V C3641-162-195-31 CERAMIC4.7PF10%50V C6011-124-925-11 ELECT2.2uF20%100V C6021-126-923-11 ELECT220uF20%10V C6031-126-967-11 ELECT47uF20%16V C7021-164-159-11 CERAMIC0.1uF50V C7031-161-494-00 CERAMIC0.022uF25V C7041-126-964-11 ELECT10uF20%50V C9031-126-224-11 E

31、LECT4700uF20%42V C9041-126-224-11 ELECT4700uF20%42V C9051-126-948-11 ELECT100uF20%35V C9061-126-948-11 ELECT100uF20%35V C9081-126-967-11 ELECT47uF20%16V C9091-126-967-11 ELECT47uF20%16V C9101-126-967-11 ELECT47uF20%16V C9111-126-967-11 ELECT47uF20%16V C9121-124-925-11 ELECT2.2uF20%100V C9161-126-963

32、-11 ELECT4.7uF20%50V CN7011-568-838-11 SOCKET, CONNECTOR 21P * CN9021-564-241-11 PIN, CONNECTOR (B4P-VH) 4P CONTROLHEADPHONEMAIN 17 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark D3018-719-987-63 DIODE 1N4148M D3028-719-987-63 DIODE 1N4148M D3518-719-987-63 DIODE 1N4148M D3528-71

33、9-987-63 DIODE 1N4148M D6018-719-987-63 DIODE 1N4148M D9028-719-001-15 DIODE UZL-9M2 D9038-719-001-15 DIODE UZL-9M2 D9098-719-987-63 DIODE 1N4148M IC1018-759-184-02 IC NJM2068L-D IC1028-759-000-49 IC MC14066BCP IC1038-759-802-52 IC LC7818 IC3018-749-941-52 IC STK-4152II IC6018-759-111-68 IC uPC1237H

34、A J1011-774-411-11 JACK, PIN 6P (PHONO,TUNER,CD) J1021-695-188-31 JACK, PIN 4P (TAPE2/MD) J1031-695-188-31 JACK, PIN 4P (TAPE1/DAT) L3011-420-872-00 COIL, AIR-CORE L3511-420-872-00 COIL, AIR-CORE Q1018-729-141-26 TRANSISTOR 2SC3622A-LK Q1518-729-141-26 TRANSISTOR 2SC3622A-LK Q3018-729-140-82 TRANSIS

35、TOR 2SA988-PAFAEA Q3518-729-140-82 TRANSISTOR 2SA988-PAFAEA Q7018-729-119-76 TRANSISTOR 2SA1175-HFE Q7028-729-900-36 TRANSISTOR DTC124ES Q7038-729-900-63 TRANSISTOR DTA124ES Q7048-729-900-36 TRANSISTOR DTC124ES Q7058-729-900-63 TRANSISTOR DTA124ES Q7068-729-900-89 TRANSISTOR DTC144ES Q7078-729-119-7

36、6 TRANSISTOR 2SA1175-HFE Q9018-729-281-54 TRANSISTOR 2SC1815-BL Q9028-729-201-53 TRANSISTOR 2SA1015-GR R1011-247-807-31 CARBON1005%1/4W R1021-249-417-11 CARBON1K5%1/4W R1031-249-417-11 CARBON1K5%1/4W R1041-249-417-11 CARBON1K5%1/4W R1051-249-417-11 CARBON1K5%1/4W R1061-249-417-11 CARBON1K5%1/4W R107

37、1-249-417-11 CARBON1K5%1/4W R1081-249-411-11 CARBON3305%1/4W R1091-249-437-11 CARBON47K5%1/4W R1101-249-416-11 CARBON8205%1/4W R1111-247-897-11 CARBON560K5%1/4W R1121-249-437-11 CARBON47K5%1/4W R1131-249-441-11 CARBON100K5%1/4W R1141-249-409-11 CARBON2205%1/4W R1151-249-427-11 CARBON6.8K5%1/4W R1511

38、-247-807-31 CARBON1005%1/4W R1521-249-417-11 CARBON1K5%1/4W R1531-249-417-11 CARBON1K5%1/4W R1541-249-417-11 CARBON1K5%1/4W R1551-249-417-11 CARBON1K5%1/4W R1561-249-417-11 CARBON1K5%1/4W R1571-249-417-11 CARBON1K5%1/4W R1581-249-411-11 CARBON3305%1/4W R1591-249-437-11 CARBON47K5%1/4W R1601-249-416-

39、11 CARBON8205%1/4W R1611-247-897-11 CARBON560K5%1/4W R1621-249-437-11 CARBON47K5%1/4W R1631-249-441-11 CARBON100K5%1/4W R1641-249-409-11 CARBON2205%1/4W R1651-249-427-11 CARBON6.8K5%1/4W R2071-249-425-11 CARBON4.7K5%1/4W R2571-249-425-11 CARBON4.7K5%1/4W R3011-249-439-11 CARBON68K5%1/4W R3021-249-41

40、7-11 CARBON1K5%1/4W R3031-249-415-11 CARBON6805%1/4W R3041-249-439-11 CARBON68K5%1/4W R3051-249-421-11 CARBON2.2K5%1/4W R3061-260-103-11 CARBON2.2K5%1/2W R3071-249-405-11 CARBON1005%1/4W R3081-260-099-11 CARBON1K5%1/2W R3091-260-099-11 CARBON1K5%1/2W R3101-249-405-11 CARBON1005%1/4W R3121-249-419-11

41、 CARBON1.5K5%1/4W R3131-249-431-11 CARBON15K5%1/4W !R3141-217-151-00METAL PLATE0.2210%2WF R3151-249-437-11 CARBON47K5%1/4W R3161-247-727-11 CARBON105%1/2W R3181-249-393-11 CARBON105%1/4W R3201-249-393-11 CARBON105%1/4W R3211-249-393-11 CARBON105%1/4W R3511-249-439-11 CARBON68K5%1/4W R3521-249-417-11

42、 CARBON1K5%1/4W R3531-249-415-11 CARBON6805%1/4W R3541-249-439-11 CARBON68K5%1/4W The components identified by mark ! or dotted line with mark ! are criti- cal for safety. Replace only with part number speci- fied. MAIN 18 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark TA-FE200 R

43、3551-249-421-11 CARBON2.2K5%1/4W R3561-260-103-11 CARBON2.2K5%1/2W R3621-249-419-11 CARBON1.5K5%1/4W R3631-249-431-11 CARBON15K5%1/4W !R3641-217-151-00METAL PLATE0.2210%2WF R3651-249-439-11 CARBON68K5%1/4W R3661-247-727-11 CARBON105%1/2W R3681-249-393-11 CARBON105%1/4W R6011-247-745-11 CARBON3305%1/

44、2W R6021-247-745-11 CARBON3305%1/2W R6031-249-417-11 CARBON1K5%1/4W R6041-249-441-11 CARBON100K5%1/4W R6051-249-437-11 CARBON47K5%1/4W R6061-249-429-11 CARBON10K5%1/4W R7011-247-903-00 CARBON1M5%1/4W R7021-249-437-11 CARBON47K5%1/4W R7031-249-433-11 CARBON22K5%1/4W R7041-249-433-11 CARBON22K5%1/4W R

45、7051-249-433-11 CARBON22K5%1/4W R7061-249-437-11 CARBON47K5%1/4W R7071-249-433-11 CARBON22K5%1/4W R7081-249-433-11 CARBON22K5%1/4W R7091-249-435-11 CARBON33K5%1/4W R7101-249-433-11 CARBON22K5%1/4W R7111-249-433-11 CARBON22K5%1/4W R7121-249-433-11 CARBON22K5%1/4W R9021-247-750-11 CARBON6805%1/2W R903

46、1-247-750-11 CARBON6805%1/2W R9041-247-750-11 CARBON6805%1/2W R9051-247-750-11 CARBON6805%1/2W R9071-247-752-11 CARBON1K5%1/2W R9081-247-752-11 CARBON1K5%1/2W R9101-249-429-11 CARBON10K5%1/4W R9121-249-429-11 CARBON10K5%1/4W R9131-249-433-11 CARBON22K5%1/4W RY6011-515-920-11 RELAY (24V) TM3011-537-238-11 TERMINAL BOARD (SPEAKERS) * MISCELLANEOUS * 141-773-154-11 WIRE (FLAT TYPE)(21 CORE) !CP11-575-651-21 CORD, POWER (AEP, German) !CP11-696-586-11 CORD, POWER (UK) !T11-429-447-11 TRANSFORMER, POWER * * HARDWARE LIST * #17-685-646-01 SCREW +BVTP 3X8 TYPE1 #27-682-548-04 SCREW +BVTT 3X8 (S) #3