Onkyo-CR305TX-rec-sm 电路图 维修手册.pdf

《Onkyo-CR305TX-rec-sm 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Onkyo-CR305TX-rec-sm 电路图 维修手册.pdf（20页珍藏版）》请在收音机爱好者资料库上搜索。

1、CR-305TX SERVICE MANUALSERVICE MANUAL CD RECEIVER Silver model MODEL CR-305TX 120V AC, 60Hz 220-230V AC, 50Hz 230-240V AC, 50Hz UDD,UDT UGT,UGR, UPP Ref. No. 3723 062002 RC-421S DISPLAY TUNING/PRESET STANDBY/ONMEMORY FM MODE CLEAR PHONES A C O U S T I C P R E S E N C E INPUT A C O U S T I C P R E S

2、E N C E V O L U M E M A X M I N V O L U M E U P V O L U M E D O W N REMOTE CONTROLLER STANDBY/ON INPUT TIMERENTER RANDOM MEMORY REPEAT CD PLAY MODE SLEEPA.PRESENCE CLOCK CALLMUTING REPEAT MD VOLUME PLAY MODEREPEAT TUNER PRESET CDR TAPE SCROLL RC-421S SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDEN

3、TIFIED BY MARK ON THE SCHEMATIC DIAGRAM AND IN THE PARTS LIST ARE CRITICAL FOR RISK OF FIRE AND ELECTRIC SHOCK. REPLACE THESE COMPONENTS WITH ONKYO PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL. MAKE LEAKAGE-CURRENT OR RESISTANCE MEASUREMENTS TO DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY

4、INSULATED FROM THE SUPPLY CIRCUIT BEFORE RETURNING THE APPLIANCE TO THE CUSTOMER. RadioFans.CN 收音机爱 好者资料库 CR-305TX SERVICE PROCEDURES-1 PROTECTION OF EYES FROM LASER BEAM DURING SERVICING This set employs a laser. Therefore, be sure to follow carefully the instructions below when servicing. WARNING!

5、 SERVICE WARNING : DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION, BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 30cm FROM THE SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL PICKUP BLOCK. Laser Diode Properties Material: GaAS/GaAlAs Wa

6、velength: 780nm Laser output: max. 0.5mW* Emission Duration: continuous *This output is the value measured at a distance about 1.8mm from the objective lens surface on the Optical Pickup Block. LASER WARNING LABEL The labels shown below are affixed. 1. Warning label 2. Class 1 label LUOKAN 1 LASERLA

7、ITE KLASS 1 LASER APPARAT DANGER: INVISIBLE LASER RADIATION WHEN OPEN AND INTERLOCK FAILED OR DEFEATED. AVOID DIRECT EXPOSURE TO BEAM. CLASS 1 LASER PRODUCT Printed on rear panel CAUTION: HAZARDOUS LASER AND ELECTROMAGNETIC RADIATION WHEN OPEN AND INTERLOCK DEFEATED. ATTENTION: RAYONNEMENT LASER ET

8、ELECTROMAGNETIQUE DANGEREUX SI OUVERT AVEC LECLENCHEMENT DE SECURITE ANNULE. RadioFans.CN 收音机爱 好者资料库 CR-305TX SERVICE PROCEDURES-2 SERVICE PROCEDURES 1. Replacing the fuses 3. Safety-check out (Only U.S.A. model) After correcting the original service problem perform the follwing safety check before

9、releasing the set to the customer Connect the insulating-resistance tester between the plug of power supply cord and terminal GND on the back panel. Specifications: More than 10Mohm at 500V REF.NO.PART NO.DESCRIPTION F901 2521571.25A-UL/T-237, Fuse 2520830.4A-SE-EAW, FUSE NOTE : : 120 V model only :

10、 230 V model only This symbol located near the fuse indicates that the fuse used is show operating type, For continued protection against fire hazard, replace with same type fuse , For fuse rating, refer to the marking adjest to the symbol. Ce symbole indique que le fusible utilise est e lent. Pour

11、une protection permanente, nutiliser que des fusibles de meme type. Ce demier est indique la qu le present symbol est apposre. 2. To initialize the unit 4. Memory Preservation This unit does not require memory preservation batteries. A built-in memory power back-up system preserves the contents of t

12、he memory during power failures and even when the unit is un-plugged. The unit must be plugged in order to charge the back-up system. The memory preservation period after the unit has been unplugged varies depending on climate and placement of the unit. On the average, memory contents are protected

13、over a period of a few weeks after the last time the unit has been unplugged. This period is shorter when the unit is exposed to a highly humid cli-mate. 5. Changing the AM band step With the exception of the worldwide models, a tuning step selector switch is not provided. When you change the band s

14、tep, change the parts as shown below. To 10kHz To 9kHz R705 3.3k 10k R706 5.6k open 1. Press and hold the MEMORY button and press the DISPLAY button. All segments light up. 2. Press the STANDBY/ON button. When CLEAR appears on the display, the preset memory and each mode stored in the memory are ini

15、tialized and will return to the factory setting. RadioFans.CN 收音机爱 好者资料库 CR-305TX U.S. and Canadian models Asian and European models (White) (Red) Audio connection cable (White) (Red) Improper connection Insert completely L RL RL REMOTE CONTROL OPTICAL SPEAKERS TAPE CDR DIGITAL OUTPUT SUBWOOFER PRE

16、OUT ANTENNA AM FM 75 R OUT (REC) (PLAY) IN OUT (REC) (PLAY) IN L RL RL REMOTE CONTROL SPEAKERS TAPE CDRMD ANTENNA AM FM 75 DIGITAL OUTPUT R OUT (REC) (PLAY) IN OUT (REC) (PLAY) IN OUT (REC) (PLAY) IN RL OPT I CAL Stereo cassette tape deck CD recorder MD recorder Stereo cassette tape deck CD recorder

17、 INPUT (REC) OUTPUT (PLAY) INPUT (REC) OUTPUT (PLAY) : Signal flowTo wall outlet Protective cap for the optical digital audio connector Do not connect the AC power cord (mains lead) to the wall outlet (the mains) until you have completed all the other connections including the connections on page 7,

18、 and the speaker connections on page 8. On each pair of connectors, a red connector (marked R) corresponds to the right channel, and a white connector (marked L) to the left channel. Connect white plugs of audio connection cables to L connectors and connect red plugs of audio connection cables to R

19、connectors . Please refer to the instruction manual for each component when you make any connections. Insert the plug securely. If the connection is incomplete, noise or malfunction may result. DIGITAL OPTICAL NPUT To wall outlet INPUT (REC) OUTPUT (PLAY) INPUT (REC) OUTPUT (PLAY) DIGITAL OPTICAL NP

20、UT DIGITAL OPTICAL INPUT OUTPUT (PLAY) INPUT (REC) : Signal flow Remove the protective cap before you use the OPTICAL DIGITAL OUTPUT connector. Please retain it for future use. If you do not use the optical digital audio connector, make sure to replace the cap. To L connector To R connector To L con

21、nector To R connector PANEL VIEW REAR PANEL CR-305X CR-305X 1 7 9 8 10 9 12 14 20 22 24 25 31 41 43 46 47 F901 P302 P303 P351 P352 P701 P778 P901 (DD,DT type) Q557 Q558 Q559 Q560 Q557A Q557B T901 Z1 Z2 Z5 Z3 Z6 52 54 53 U1 U2 U3 U4 U5 U6 U8 U9 U10 33 6 6 6 6 6 23 6 6 16 6 6 P901 (PP type) 26 50 42 4

22、4 15 EXPLODED VIEW CR-305TX CR-305TX EXPLODED VIEW PARTS LIST-1 NOTE: THE COMPONENTS IDENTIFIED BY MARK ARE CRITICAL FOR RISK OF FIRE AND ELECTRIC SHOCK. REPLACE ONLY WITH PART NUMBER SPECIFIED. NOTE: : USA and Canadian model only : European model only : Taiwanese model only : Asian model only : Chi

23、nese model only CAUTION: Replacement of the transistor of mark , if necessary, must be made from the same beta group(HFE) as the original type. 1 6 7 8 9 10 12 14 15 16 20 22 23 24 25 26 31 33 41 42 43 44 46 47 50 52 53 54 3217210171000 838130088 3200210996000 27190693A 27191112 4070210311000 271752

24、53-1A 27300750 830440069 831430088 4310210401000 3000210266000 838930088 5087210571000 4317210391000 27150456 3207211006000 3207211006100 838430068 3067210858000 3067210858011 5127210262000 4357210031000 5070210851000 3710210333000 5077210843000 880009 5507100500450 5507100500470 5507100500480 55071

25、00500460 5507100500510 5507100500520 5507100500440 FRAME FRONT 3TTB+8B, Self tapping screw MAIN CHASSIS KGLS-6RF, Holder KGPS-6RF, Holder SUPPORTER CD MECHA Leg Busing, cord 4TTC+6C(BC), Self tapping screw 3TTW+8B(BC), Self tapping screw COVER HEAT SINK CABINET COVER 3TTB+8B(UN), Self tapping screw

26、KNOB VOLUME DOOR CD Shield plate BACK CHASSIS BACK CHASSIS 3TTB+6B(BC), Self tapping screw AL PANEL FRONT AL PANEL FRONT DECORATION VOLUME GUIDE VOLUME WINDOW REMOCON LENS INDICATOR WINDOW DISPLAY Plastic rivet, NRP-345 LABEL RATING LABEL RATING LABEL RATING LABEL RATING LABEL FCC and WARNING LABEL

27、FCC and WARNING LABEL LASER CAUTION F901 P302 P303 P351 P352 P701 P778 P901 Q557,Q558 Q559,Q560 Q557A Q557B T901 Z1 Z2 Z3 Z5 Z6 252157 252083 2009990500 20022391210 2047161012 2042161022 2047360612 2047151012 253294HDK 253287HIT 253237HIT 2203384 or 2203383 2203394 or 2203393 2120210418000 801433 23

28、01452 2301454 2301453 24800018A 24840133 24840135 838120080 838426088 1.25A-UL/T-237, Fuse 0.4A-SE-EAW, Fuse NSAS-10P0654, Socket NSAS-12P0723, Socket NCFC7-161012, Flexible flat cable NCFC2-161022, Flexible flat cable NCFC7-360612, Flexible flat cable NCFC7-151012, Flexible flat cable AS-UC-2#18, P

29、ower supply cord AS-CCEE, Power supply cord AS-CEE, Power supply cord 2SC3851-Y or 2SC3851-O, Transistor 2SA1488-Y or 2SA1488-O, Transistor HEAT SINK 3SMS8W.SW+14B(BC), Special screw NPT-1391D, Power transformer NPT-1391G, Power transformer NPT-1391P, Power transformer NCD-170S, CD mechanism Boss, P

30、CB Boss, PCB3 2TTB+8P, Self tapping screw 2.6TTB+8B(BC), Self tapping screw REF NO.PART NO.DESCRIPTIONREF NO.PART NO.DESCRIPTION CR-305TX CR-305TX EXPLODED VIEW PARTS LIST-2 NOTE: THE COMPONENTS IDENTIFIED BY MARK ARE CRITICAL FOR RISK OF FIRE AND ELECTRIC SHOCK. REPLACE ONLY WITH PART NUMBER SPECIF

31、IED. NOTE: : USA and Canadian model only : European model only : Taiwanese model only : Asian model only : Chinese model only REF NO.PART NO.DESCRIPTION U1 U2 U3 U4 U5 U6 U8 U9 U10 7028061541010 7028061542010 7028061542030 7028061542040 7028061543010 7028061546010 7028061544010 7028061544030 7028061

32、545010 7028061545030 7028061551010 7028061551030 7028061551040 7028061552010 240134 240135 PCB AUDIO ASSY PCB SUPPLY ASSY PCB SUPPLY ASSY PCB SUPPLY ASSY FRONT PCB ASSY AMP BOARD ASSY SPEAKER BOARD ASSY SPEAKER BOARD ASSY PCB DIGITAL ASSY PCB DIGITAL ASSY CD PCB ASSY CD PCB ASSY CD PCB ASSY CONNECTO

33、R PCB ASSY TFCE1U114A, Tuner unit TFCE1E512A, Tuner unit DD. CR-305TX 6 13 20 19 12 2 1 3 4 29 22 16 16 28 27 26 21 16 12 18 25 24 23 13 16 7 9 8 10 6 11 6 6 14 15 NCD-170S 5 NCD-170S 17 PARTS LIST The mechanical parts with no part number in the exploded views are not supplied. REF. NO.PART NO.DESCR

34、IPTION 12646-290-01Tray 2Stopper 32625-544-01Gear cover 42625-535-01Tray Gear 52625-546-01Chucking plate 6PTPWH2.6 x 7, Screw 72625-537-01Chucking yoke 81452-493-21Magnet 92625-541-02Damper 102646-291-01Chucking pulley 112646-288-01Sub chassis 122627-236-01Coil spring (front) 132627-235-01Coil sprin

35、g (back) 142646-289-01Washer 15P2.6 x 10, Screw - - - 16Insulator 17Drive unit 18Main chassis 19PTPWH2.6 x 16, Screw 20Drive Gear 21Control cam 22Leaf switch 23Socket 24Loading PC board 25Loading motor 26Middle gear 27Loading pulley 28 2627-234-01 2625-552-06 3319-501-51 2625-547-01 2625-545-04 1692

36、-667-11 1564-721-11 1640-523-11 X2625-117-1 2625-274-02 2625-536-02 3653-387-00LM belt 29B2.6 x 2.5, Screw- - REF. NO.PART NO.DESCRIPTION EXPLODED VIEWS OF MECHANISM-1 CD MECHANISM:WSL-2130CCM -Different parts to NCD-170S * The parts which constitute NCD-170S can use it as substitution parts. Model

37、No. CD Mechanism CR-305X NCD-170S CR-305TX WSL-2130CCM NCD-170S and WSL-2130CCM consist of almost same parts. Refer to EXPLODED VIEWS OF MECHANISM-2 CR-305TX 51 54 5553 56 57 58 61 52 PARTS LIST REF. NO.PART NO.DESCRIPTION 51 52 53 54 55 56 57 58 61 Motor chassis assy Motor gear assy Sled shaft Gear

38、 (A) (S) P2 x 3, Screw Leaf switch Motor PC board Connector 6pin KSS-213C, Pickup EXPLODED VIEWS OF MECHANISM-2 CD MECHANISM:WSL-2130CCM (CD DRIVE UNIT) X2625-877-1 X2625-769-1 2626-908-01 24810023 7621-255-15 24840008 1639-678-12 1564-722-11 8848-483-05 CR-305TX CR-305TX TAPE REC PLAY CDR PLAY REC

39、MD PLAY REC P405 SUBWOOFER PREOUT FM AM P551 SPEAKERS L R Q181-Q183 TUNER MUTE VOLUME M Q704 MOTOR VOLUME DRIVER TA7291S Q603,Q405 MUTING Q601,Q602 AMP. MUTE M A B CD E F M M FOCUS COIL TRACKING COIL SPINDLE MOTOR SLED MOTOR 21 VO3- 20 VO3+ 25 VO4+ 26 VO4- 10 VO2+ 11 VO2- 5 VO1+ 6 VO1 - Q105 FOCUS/T

40、RACKING & SLED/SPINDLE MOTOR DRIVER LA6541D Q101 RF SIGNAL PROCESSING SERVO AMP. CXA1992BR LD 36 LD 37 PD A,C B,D E,F 38 PD1 39 PD2 41,42 1 FEO FOCUS GAIN ADJ. Q301 CD DIGITAL SIGNAL PROCESSOR CXD2589Q CLK 20 XLT 21 DATA 22 COUT 24 SENS1 25 14 CLK 13 XLT 12 DAT 11 CNIN 10 SEIN FOK 27 18 FOK CLOCK XL

41、AT DATA SQCK SENS SQSO Q701 MICROPROCESSOR MPD78042GF LOUT1 67 LOUT2 74 Rch DOUT 53 9 8 7 6 4 5 9 10 11 15 14 16 TUNER UNIT SENS2 26 12 SENS20 SCOR 5744 XRST 23 XRST 79 55 XRST SSTOP 15 SPOA TRAY MOTOR 3 OUT2 7 OUT1 Q103 TRAY MOTOR DRIVER TA7291S VIN4 28 VG3 19 VIN1 3 VIN2 13 6 FEO 16 SLO FC SLD TR

42、SPDL 13 TAO 21 MDP + + + 25 IN/OUT OPEN/ CLOSE VOLDN 21 VOLUP 22 S751-S762 KEY SWITCH Q751 FL TUBE 10-BT-167GK U751 REMOTE SENSOR STEREO SD SIGNAL CK 14 DATA 15 ST 16 Q401 INPUT SELECTOR TC9273N-007 13 ST 15 CK 16 DATA 27 K0 38 K1 Q402 ACOUSTIC PRESENCE CONTROL TC9162 POWER AMPLIFIER ANG MUTE 51 POW

43、ER 41 P553 PHONES VCC VCC 18 53 POWER CD Q901 78M12 +12V TO FL TUBE Q903 78M56 +5.6V POWER FAILURE DETECTOR +22V -22V P901 T901 POWER TRANSFORMER F901 RL901 Q902 -27V Q902 AC IN REMIN 47 60-77 P1-P10 U691 OPTICAL OUTPUT Excluding USA & Canadian models OUT Q184-Q186 CD MUTE 5.6V Q110 ,Q111 1-7,78-80

44、G1-G9 R425 Q403,Q404 ACOUSTIC PRESENCE CONTROL 18 STEREO 19 SD 26 SIGNAL USA & Canadian models only 42 RDS DATA 43 RDS SIG 45 RDSCLK 50 TU MUTE 13 DSP MUTE 40 PLL 36 RCLK 37 RDATA 39 FCE PLL RCLK RDATA Q180 RDS DECODER BU1923 RDS 2 1 16 4 European Model only CD MECHANISM POFF 31 Q702 BUFFER SYS IN 4

45、6 SYS OUT 49 RI +12V 57 OPEN 58 CLOSE BLOCK DIAGRAM A 1 2 3 4 5 BCDEFGH CR-305TXCR-305TX +5.6 -27.0 +12 -1.1 0.6 -0.6 -22.2 1.1 22.2 -13 +13 -20.2 -21.3 -1.1 1.1 21.1 -0.7 -21.3 -21.0 -20.6 21.120.4 20.4 U751 PIC-26043TH2 Q901 78M12HF GI O Q903 78M56 GI O RL901 RL901 P901B P404B P400 P401 JL504B JL5

46、04A JL501B JL501A P904 P912 P701B Q904 DTC123JSQ782 RN1404 S757 S751 S762 S756 S755 S758 S759 S760 S761 S752 S753 S754 Q75110-BT-167GK 10G5 1G14 2G13 3G12 4G11 5G10 6G9 7G8 8G7 9G6 F11 F12 F249 F250 P146 P1037 P1136 P1235 P1334 P1433 P1532 P1631 P1720 P245 P344 P443 P542 P641 P740 P839 P938 D782 SEL

47、2210R P406 P403B JL903B JL405B JL405A CK DATA GND ST COM4 S7 COM3 S6 S5 COM2 S4 S3 COM1 S2 S1 VSSVDD Q402TC9162AF 1 2 3 4 5 6 7 8 9 10 11 12 13 1415 16 17 18 19 20 21 22 23 24 25 26 27 28 RL901 NRL-2P5A-DC12-155 CD MD-P MD-R T-PLAY T-REC VDD DATA ST CK GND COM COM TUNER CDR-P CDR-R VEE Q401 TC9273N-

48、007 1 2 3 4 5 6 7 8 9 10 11 12 13 1415 16 17 18 19 20 21 22 23 24 25 26 27 28 C418 683 C416 683 C417 683 C415 683 C421 153 C425 154 C426 154 C422 153 P405B P405B P402 U691 U691 220K L691 220K L691 L552 S-1.3C L551 S-1.3C Q403 NJM4565MD 5 6 7 Q404 NJM4565M 5 6 7 JL551A JL551B Q406 RN1441 Q405 RN1441

49、Q603 RN2402 Q403 NJM4565M 3 8 2 4 1 Q404 NJM4565M 3 8 2 4 1 D910 UDZ5.1B D909 UDZ27D D492 UDZ13B D491 UDZ13B D911 1SS352 D908 D907 D906 D905 D904 D902 D903 D601 D501 1SS352 D503 1SS352 D504 1SS352 D5021SS352 D901 RBA402 D3SBA20 5 68 9 10 11 12 13 14 15 2 F901 1.25A/125V P902 P901 UDD TYPE AC120V UPP TYPE AC230V UGT, UGR TYPE AC220V P553 JL552B JL552A Q601 2SC2712 Q518 2SC1815GR Q517 2SC1815