Teac-AD800-cdtape-sm 电路图 维修手册.pdf

《Teac-AD800-cdtape-sm 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Teac-AD800-cdtape-sm 电路图 维修手册.pdf（34页珍藏版）》请在收音机爱好者资料库上搜索。

1、Z SERVICE MANUAL AD-800/800E Compact Disc Player/Reverse Cassette Deck INSTRUCTIONS FOR SERVICE PERSONNEL BEFORE RETURNING APPLIANCE TO THE CUSTOMER, MAKE LEAKAGE-CURRENT OR RESISTANCE MEASUREMENTS TO DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY INSULATED FROM THE SUPPLY CIRCUIT. CONTENTS 1. Safety I

2、nformation .2 2. Specifications .3 3. Dimensional drawings .4 4. Adjustment and Checks (Cassette Section) .5 5. Updating of System firmware .10 6. Product ErP2 Instructions.15 7. Wiring Diagram .16 8. Exploded Views and Parts List.17 9. PC Boards and Parts List .22 10. Included Accessories.34 11. Ap

3、pendix .34 目次 1. 安全規格.2 2. 仕様.3 3. 寸法図.4 4. 調整確認（ 部） .5 5. .10 6. 本機ErP対応説明.15 7. 結線図.16 8. 分解図.17 9. 基板図.22 10.付属品.34 11.付録.34 Effective : October, 2013S-0242 RadioFans.CN 收音机爱 好者资料库 - 2 - TEAC AD-800/800E 1. Safety Information 安全規格 0CAUTIONS ABOUT LASER RADIATION This product has been designed and

4、 manufactured according to FDA regulations “title 21, CFR, chapter 1, subchapter J, based on the Radiation Control for Health and Safety Act of 1968“, and is classified as class 1 laser product. There is not hazardous invisible laser radiation during operation because invisible laser radiation emitt

5、ed inside of this product is completely confined in the protective housings. The label required in this regulation is as follows: 0Cautions i DO NOT REMOVE THE EXTERNAL CASES OR CABINETS TO EXPOSE THE ELECTRONICS. NO USER SERVICEABLE PARTS ARE WITHIN. i IF YOU ARE EXPERIENCING PROBLEMS WITH THIS PRO

6、DUCT, CONTACT TEAC FOR A SERVICE REFERRAL. DO NOT USE THE PRODUCT UNTIL IT HAS BEEN REPAIRED. i USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE. Optical pickup : Type: SF-P101VZ Manufacturer: SANYO ELECTRIC CO.,

7、 LTD. Laser output : Less than 1 mW on the objective lens Wavelength: 790 30 nm 0CAUTION for products that use replaceable lithium batteries: There is danger of explosion if a battery is replaced with an incorrect type of battery. Replace only with the same or equivalent type For U.S.A. RadioFans.CN

8、 收音机爱 好者资料库 - 3 - TEAC AD-800/800E CD Player Pickup : 3-beam, semiconductor laser Digital filter : 8-times oversampling Frequency response : 20Hz20kHz 2dB Total harmonic distortion : Less than 0.02% (1kHz) Signal-to-noise ratio (S/N) : More than 87dB (IHF-A) Analog output : 2.0V (RCA) Cassette tape

9、player Track system : 4-track, 2-channel stereo Heads : Record/playback x 1 (rotary reverse), erase x 1 Type of tape : Cassette tape C-60 Tape speed : 4.76 cm/sec. Motor : DC servo motor x 1 Pitch control : 10% (playback only) Wow and flutter : 0.25% (W. RMS) Frequency response (overall) : 5012,000H

10、z 3dB, chrome : 5012,000Hz 3dB, normal Signal-to-noise ratio (overall) : 59dB (Dolby NR off, 3% THD level, weighted), : 69dB (DOLBY NR on, over 5kHz) Rewinding time : Approx. 120sec. (with C-60) Input : Line: 87mV (input impedance of 50k or more) Output : Line: 0.46V (load impedance of 50k or more)

11、Headphones : 10mW/32ohms USB USB bus-power output : 5V, 0.2A Playback Frequency response : 20Hz20,000Hz (2dB) Signal-to-noise ratio : more than 85dB Playback bit rate : 8k-320kbps Recording Frequency response : 20Hz15,000Hz (2dB) Signal-to-noise ratio : more than 85dB Record bit rate : 128kbps GENER

12、AL Power requirement : AC 230V, 50Hz (Europe model) : AC 220V, 60Hz (Korea model) : AC 120V, 60Hz (USA/Canada model) : AC 120V/230V, 50-60Hz (General export model) Power consumption : 14W Dimensions (W x H x D) : 435 x 145 x 288mm (17 1/8” x 5 11/16” x 11 5/16”) (including protrusions) Weight (Net)

13、: 5.1kg (11 1/8lbs) Operating temperature : +5C +35C Operating humidity : 5% to 85% (no condensation) Storage temperature : 20C +55C CD部 :3、半導体 :8倍 周波数特性:20Hz 20kHz2dB 全高調波歪率:0.02%以下(1kHz) S/N比:87dB以上(IHF-A) 出力:2.0V(RCA) 部 形式:42 構成:録音再生1 （回転式） 消去1 :C-60 速度:4.76cm/秒 :DC1 :約10 (再生) :0.25%(W.RMS) 周波数特性

14、（総合） :50 12,000Hz3dB: 50 12,000Hz3dB: SN比（総合） :59dB （ NR、3%THDWTD） 69dB( NR、 5kHz以上） 早巻時間:約120秒（C-60） 入力(RCA):87mV（入力50k以上） 出力(RCA):0.46V（負荷50k以上） 出力:10mW/32 USB 定格出力:5V、0.2A 再生 周波数特性:20Hz20,000Hz(2dB) S/N比:85dB以上 再生:8k 320kbps 録音 周波数特性:20Hz15,000Hz(2dB) S/N比:85dB以上 録音:128kbps 一般 電源:100VAC、50-60Hz 消

15、費電力:14W 外形寸法(幅、高、奥行):435x145x288mm(突起部含) 質量:5.1kg 許容動作温度:535 許容動作湿度:5 85 (結露) 許容保管温度:2055 2. Specifications 仕様 RadioFans.CN 收音机爱 好者资料库 - 4 - TEAC AD-800/800E 3. Dimensional drawings 寸法図 435 6.9269.111.5 287.5 145 13213 - 5 - TEAC AD-800/800E 4. Adjustment and Checks (Cassette Section) 調整確認（部） 4-1. M

16、ECHANICAL ADJUSTMENT 4-1-1. Tape speed (1)Connect a frequency counter to the deck as shown in Fig.1. Fig. 1 (2)Load a MTT-111N test tape and play in FWD direction the- beginning of the test tape. (3)Adjust the variable resistor VR1 on the CONTROL PCB(Fig. 2). Fig. 2 4-1.機構部調整 4-1-1.速度 (1)Fig.1図周波数接続

17、。 (2)MTT-111N巻始部FWD方向 再生。 (3)周波数値3000Hz10HzCD/MCU PCBVR601（Fig.2）調整。 AD-800/800E LINE OUT (UNBALANCED) ? - 6 - TEAC AD-800/800E 4-1-2. Wow and flutter (1)Connect a wow-and-flutter meter to the deck as shown in Fig. 1. (2)Load and play a MTT-111N test tape. (3)Check that the readings on the wow-and-f

18、lutter meter iswith in 0.25 % (WRMS). 4-1-3. Pitch control Play back the test tape MTT-111N, turn the PITCH CON- TROLknob to the maximum and minimum positions so- that the tape speed variations are as follows:Standard : 10 % or more (2730 Hz or less, 3270 Hz ormore) 4-2. ELECTRICAL ADJUSTMENT AND CH

19、ECKS 4-2-1. Precautions (1)Before performing adjustments and checks clean andde- magnetize the entire tape path. (2)In general, adjustments and checks are made in the order- of Lch then Rch. Double REF. Nos. indicate Lch /Rch. (Example ; VR151/VR251) (3)0 dBu is referenced to 0.775 V. (4)The AC volt

20、meter used in the procedures must have anin- put impedance of 1 M or more. (5)Unless specified otherwise, adjustments and checks are made in FWD direction. CAUTION When the “COMMON OUT” setting in the menu is setto “MIX” change the setting to “AUTO” or “TAPE”before pro- ceeding to the AMP adjustment

21、. To input the signal from the transmitter, connect itto the “UNBALANCED” input and set “TAPE INPUT” inthe menu to “UNBAL”. 4-2-2. Adjustment and check locations Fig. 3 4-1-2. (1)Fig.1接続。 (2)MTT-111N再生。 (3)値0.25%（WRMS）以内。 4-1-3.確認 MTT-111N再生、PITCHCONTROL 最大、最小回、可変幅10%以上 （MAX:3270Hz以上、MIN:2730Hz以下）。

22、4-2.部調整確認 4-2-1.注意 (1)部調整確認前、走行系消磁 清掃行。 (2)特指定限、調整Lch、Rch順序行 。尚、VR151/VR251記 回路番号Lch/Rch示。 (3)0dBu0.775V表記。 (4)測定使用計、入力 1M以上。 (5)特指定場合、調整確認FWD方向 行。 注意 MENU“COMMONOUT”設定“MIX”場合 “AUTO”“TAPE”設定変更AMP調 整行。 発信器信号入力場合“UNBALANCED”入力 接続、MENU“TAPEINPUT”“UNBAL”設定 。 4-2-2.調整測定箇所 ? ? ? ? ? ? - 7 - TEAC AD-800/80

23、0E 4-2-3. Playback performance Mode: PLAY Measurement point: LINE OUT 2 DOLBY NR switch: OFF No ITEM 項目 SETTING 設定 TESTTAPE ADJUSTMENT 調整 MEASUREMENT 測定 REMARKS 備考 1 REC/PLAY head azimuth 録/再 Connection : Fig. 5 Check/adjust in FWD, REV respectively FWD, REV 実施 MTT-25702 (12.5 kHz) Azimuth screws of

24、 R/P head (Fig. 7) 録/再 調整 Max. output at L LOUT;230V3E0844700AWIRE ASSY,3PIN POWER GEUR,Erp,*1 P001E0178160TERMINAL,LAPPING 2P G P105, P105A3E0824400AWIRE ASSY,8P AUDIO AD-800 G P116E0150690CONNECTOR,16FMN-BTRK G P1183E0824200AWIRE ASSY,6P POWER AD-800 G PCB,GATHER AD-800 G TAPE/PHONE/TRANS/PWR-SW.基

25、板 *1 : to J201 on PCBA, ErP2 STANDBY / “11. Appendix” on page 34 TEAC AD-800/800E - 33 - CAUTION Part with numbers in parentheses ( ) cannot be ordered. If you want to order service parts, be sure to use Child part numbers (numbers in Bold), which refer to individual parts of a parent part. 注意 ( )付品

26、番、発注。補修部品発注際、太字品番発注。 REF.NO.PARTS NO.DESCRIPTION .REMARKS P551E0111890CONN,B2P3S-VH(LF)(SN)V SW551E0151430SW,POWER SFDLB 11B7U G TP101E0127550PIN,TEST G TP201E0127550PIN,TEST G U001S0069960IC,BA05CC0T G U002S0075052IC,TA7807SB(TP,Q) G U003S0075072IC,TA79007SB(TP,Q) G U151E01523300AVAR COIL,MPX 07941

27、8007 G U251E01523300AVAR COIL,MPX 079418007 G U3013S000280GIC, UPC4570C-A G U302S0064550IC,NJM4558D G U351S0061754IC,HA12134AFEL-E G U352S0078210IC,BU4066BC G U353S0064550IC,NJM4558D G U901S0064550IC,NJM4558D G U902S0064550IC,NJM4558D G U903S0064550IC,NJM4558D G U9043S038924IC,LC75348M G U905S006455

28、0IC,NJM4558D G U906S0078210IC,BU4066BC G U907S0064550IC,NJM4558D G U908S0064550IC,NJM4558D G U909S0064550IC,NJM4558D G U9103S000840IC, BA4560 G VR941R0202790VAR REG,50KAX2 RK09K12AG W551E0123271JUMPER WIRE,7.5MM GJPN W553E0123271JUMPER WIRE,7.5MM GKOR, UK Q101S0065482TR,2SC1815-GR(TPE2.F) GZO Q102S0

29、094422TRANSISTOR,DTC124ESA G Q103S0065482TR,2SC1815-GR(TPE2.F) GZO Q151S0094422TRANSISTOR,DTC124ESA G Q152S0094422TRANSISTOR,DTC124ESA G Q153S0096582TRANSISTOR,KTC3200GR G Q201S0065482TR,2SC1815-GR(TPE2.F) GZO Q202S0094422TRANSISTOR,DTC124ESA G Q203S0065482TR,2SC1815-GR(TPE2.F) GZO Q251S0094422TRANS

30、ISTOR,DTC124ESA G Q252S0094422TRANSISTOR,DTC124ESA G Q253S0096582TRANSISTOR,KTC3200GR G Q301S0096582TRANSISTOR,KTC3200GR G Q302S0065482TR,2SC1815-GR(TPE2.F) GZO Q303S0065482TR,2SC1815-GR(TPE2.F) GZO Q304S0066842TRANSISTOR,2SA1015GR-T G Q305S0066842TRANSISTOR,2SA1015GR-T G Q306S0094422TRANSISTOR,DTC1

31、24ESA G Q307S0094422TRANSISTOR,DTC124ESA G Q351S0094422TRANSISTOR,DTC124ESA G Q353S0094402TRANSISTOR,DTA124ESA G Q354S0094402TRANSISTOR,DTA124ESA G Q355S0094422TRANSISTOR,DTC124ESA G Q356S0094402TRANSISTOR,DTA124ESA G Q357S0094422TRANSISTOR,DTC124ESA G Q358S0094402TRANSISTOR,DTA124ESA G Q359S0094402

32、TRANSISTOR,DTA124ESA G REF.NO.PARTS NO.DESCRIPTION .REMARKS Q360S0094422TRANSISTOR,DTC124ESA G Q361S0094402TRANSISTOR,DTA124ESA G Q362S0094422TRANSISTOR,DTC124ESA G Q371S0094402TRANSISTOR,DTA124ESA G Q372S0094422TRANSISTOR,DTC124ESA G Q373S0066842TRANSISTOR,2SA1015GR-T G Q374S0094422TRANSISTOR,DTC12

33、4ESA G Q701S0074832TRANSISTOR,KTC2874BAT/PG Q761S0074832TRANSISTOR,KTC2874BAT/PG Q801S0074832TRANSISTOR,KTC2874BAT/PG Q861S0074832TRANSISTOR,KTC2874BAT/PG Q901S0094422TRANSISTOR,DTC124ESA G Q902S0094402TRANSISTOR,DTA124ESA G (E95335700A)GATHER PCBA,SER 222SL2 G E95335800A PCB ASSY,SENSOR 222SL2 G PC

34、B,SENSOR 222SLMK2 G P23E007850GCONNEC,B3B-PH-SM4-TB(LF)G U1S0075300PHOTO SNSR,RPR-220 G (3E8500900A)GATHER PCBA,STANDBY AD-800 GEUR, Erp 3E8500601A PCBA,ErP2 STANDBY AD-800GEUR, Erp PCB,STANDBY G D201S0071811DI,1N4003-F TAPINGW=52 G D202S0071811DI,1N4003-F TAPINGW=52 G D203S0071811DI,1N4003-F TAPING

35、W=52 G D204S0071811DI,1N4003-F TAPINGW=52 G D205S0071811DI,1N4003-F TAPINGW=52 G F2013E082340FUSE ICP,T250mAL 250VUL/CSA/VDEMARK G GND2M01510100A BRACKET,PCB-A G J2013E0845200ACONNECTOR,B3P5VH(LF)(SN) GV J2033E0844900AWIRE ASSY,3P CONTROL G Q201S0074832TRANSISTOR,KTC2874BAT/PG T2013E0845300ATRANS Er

36、P2 T09172B GV PCB,GATHER AD-800 G TAPE/PHONE/TRANS/PWR-SW.基板 GATHER PCBA, SER 222SL2 G SENSOR 基板 GATHER PCBA, STANDBY AD-800G STANDBY 基板 - 34 - TEAC AD-800/800E Jumper Power requirement REMARKS AC100VAC120VAC230V W5510- JPN W553-0 KOR , UK (S553)-00 T/C , EUR , Switch by S553(3E040130) 10. Included

37、Accessories 付属品 Included Items REF.NO.PARTS NO.DESCRIPTION .REMARKS 3E0824800ARMT CONT,RC-1257 EUR , JPN , T/C , KOR , UK E0155030BATTERY,UM4(ENGLISH)G EUR , JPN , T/C , KOR , UK 3E000380PIN CORD, G EUR , JPN , T/C , KOR , UK D00822001CWARR CARD,ENG/FRE C A G EUR , UK 5700139901WARR CARD,T/C G T/C D

38、00729700EWARR CARD,(JPN) G JPN 3D0789700COWN MNL,AD-800 EFS G EUR , T/C , UK 3D0789800COWN MNL,AD-800 DIH G EUR 3D0789600COWN MNL,AD-800 JPN G JPN 3D0791200COWN MNL,AD-800 KOR G KOR 3D0790710AOUTLINE MNL,AD-800 EFS G EUR , T/C , UK 3D0790720AOUTLINE MNL,AD-800 GIN G EUR 3D0790700AOUTLINE MNL,AD-800

39、J G JPN NOTES注意 0PCboardsshownareviewedfrompartsside. 0Partsmarkedwith*requirelongerdeliverytime. 0Thepartswithnoreferencenumberornoparts numberintheexplodedviewsarenotsupplied. 0Asregardstheresistorsandcapacitors,refertothe circuitdiagramscontainedinthismanual. 0VPartsmarkedwiththissignaresafetycri

40、ticalcom- ponents.Theymustbereplacedwithidenticalcompo- nents-refertotheappropriatepartslistandensure exactreplacement. 0Partsofmarkcanbeusedonlywiththeversion designated. JPN : JAPAN T/C : U.S.A./CANADA KOR : KOREA EUR : EUROPE UK : U.K. AUS : AUSTRALIA TM :TAIWAN CHI : CHINA 0基板図部品面示。 0*印部品納期若干。了承 。 0分解図部番部品品番部品供給 。 0標準抵抗、省略。回路図 参照。 0V印安全重要部品。交換時必指定部 品使用。 0仕向先 JPN : JAPAN T/C : U.S.A./CANADA KOR : KOREA EUR : EUROPE UK : U.K. AUS : AUSTRALIA TM :TAIWAN CHI : CHINA 11. Appendix 付録 L IN L OUT 3E0844700A WIRE ASSY,3PIN POWER G 230V