Panasonic-SAVK660EE-cs-sm 电路图维修手册.pdf

上传人：cc518

文档编号：257688

上传时间：2025-10-13

格式：PDF

页数：124

大小：13.95MB

《Panasonic-SAVK660EE-cs-sm 电路图维修手册.pdf》由会员分享，可在线阅读，更多相关《Panasonic-SAVK660EE-cs-sm 电路图维修手册.pdf（124页珍藏版）》请在收音机爱好者资料库上搜索。

1、? ? ? ? AMPLIFIER SECTION RMS Output Power Stereo mode: Front Channel 115 W per channel (3 ), 1 kHz, 10% THD Subwoofer Channel 115 W per channel (3 ), 1 kHz, 10% THD Total RMS Stereo mode power345 W PMPO output power3700 W ? ? ? ? FM/AM TUNER, TERMINALS SECTION Preset stationFM 20 stations AM 15 sta

2、tions Frequency Modulation (FM) Frequency range87.50 to 108.00 MHz (50 kHz step) Sensitivity2.5 V (IHF) S/N 26dB1.3 V Antenna terminals75 (unbalanced) Amplitude Modulation (AM) Frequency range522 to 1629 kHz (9 kHz step) AM Sensitivity S/N 20dB at 999 kHz 505 V/m Digital audio output Coaxial digital

3、 outputPin jack Music Port Input Jack Sensitivity100 mV, 4.7 k 2007 Matsushita Electric Industrial Co. Ltd. All rightsreserved.Unauthorizedcopyingand distribution is a violation of law. SA-VK660EE Colour (K). Black Type TerminalStereo, 3.5 mm jack Phone jack TerminalStereo, 3.5 mm jack Mic jack Sens

4、itivity0.7 mV, 600 TerminalMono, 6.3 mm jack (2 system) Aux Sensitivity2V, 8K TerminalStereo, RCA jack ? ? ? ? CASSETTE DECK SECTION Type1 way, Auto reverse Track system4 Track, 2 Channel Heads Record/playbackSolid permalloy head ErasureDouble gap ferrite head MotorDC servo motor Recording systemAC

5、bias 100 kHz Erasing systemAC erase 100 kHz Tape speed4.8 cm/s Overall frequency response (+3, -6 dB) at DECK OUT Normal35 Hz to 14 kHz S/N ratio50 dB (A-Weighted) Wow and flutter0.18 % (WRMS) Fast forward and rewind timeApprox. 120 seconds with C-60 cassette tape DVD Stereo System Notes: This model

6、s DVD/CD mechanism changer unit is CRS1D. Please refer to the original service manual (Order No. MD0603065A3) for this mechanism. Specifications ORDER NO. MD0707008CE RadioFans.CN 收音机爱好者资料库 ? ? ? ? VIDEO SECTION Video systemPAL625/50, PAL525/60, NTSC Composite video output Output level1 Vp-p (75 )

7、TerminalPin jack (1 system) Component video output NTSC : 480p/480i, PAL : 576p/576i Y output level1 Vp-p (75 ) PBoutput level0.7 Vp-p (75 ) PRoutput level0.7 Vp-p (75 ) Terminal Pin jack (Y: green, PB: blue, PR: red) (1 system) ? ? ? ? DISC SECTION Disc played 8 cm or 12 cm (1) DVD (DVD-Video, DivX

8、* 6,*7) (2) DVD-RAM (DVD-VR, JPEG* 4,*7, MP3* 2,*7, MPEG4* 5,*7, DivX* 6,*7) (3) DVD-R (DVD-Video, DVD-VR, JPEG* 4,*7, MP3* 2,*7, MPEG4* 5,*7, DivX* 6,*7) (4) DVD-R DL (DVD-Video, DVD-VR) (5) DVD-RW (DVD-Video, DVD-VR, JPEG* 4,*7, MP3* 2,*7, MPEG4* 5,*7, DivX* 6,*7) (6) +R/ +RW (Video) (7) +R DL (Vi

9、deo) (8) CD,CD-R/RW CD-DA, Video CD, SVCD* 1, MP3* 2,*7, WMA* 3,*7, JPEG* 4,*7, MPEG4* 5,*7, DivX* 6,*7, HighMAT Level 2 (Audio and Image) * 1 Conforming to IEC62107 * 2 MPEG-1 Layer 3, MPEG-2 Layer 3 * 3 Windows Media Audio Ver 9.0 L3 Not compatible with Multiple Bit Rate (MBR) * 4 Exif Ver 2.1 JPE

10、G Baseline files Picture resolution: between 160 x 120 and 6144 x 4096 pixels (Sub sampling is 4:0:0, 4:2:0, 4:2:2 or 4:4:4). Extremely long and narrow pictures may not be displayed. * 5 MPEG4 data recorded with the Panasonic SD multi cameras or DVD video recorders. Conforming to SD VIDEO specificat

11、ions (ASF standard)/ MPEG4 (Simple Profile) video system/ G.726 audio system. * 6 Plays all versions of DivXvideo (including DivX6) with standard playback of DivXmedia files. Certified to the DixVHome Theater Profile. GMC (Global Motion Compensation) is not supported. * 7 The total combined maximum

12、number of recognizable audio, picture and video contents and groups: 4000 audio, picture and video contents and 400 groups. Pick up Wavelength CD785 nm DVD662 nm Laser Power CDCLASS 1M DVDCLASS 1 Audio output (Disc) Number of channels(FL, FR) 2 channel ? ? ? ? GENERAL Power supply AC 230 V, 50 Hz Po

13、wer consumption125 W Power consumption in standby mode: 0.9 W (approx.) Dimensions (W x H x D)250 mm x 330 mm x 333.6 mm Mass7.5 kg Operating temperature range+5C to +35C Operating humidity range5% to 90% RH (no condensation) ? ? ? ? SYSTEM SC-VK660(EE)Music Center: SA-VK660 (EE) Speaker: SB-PF660 (

14、GC) Subwoofer: SB-WVK660 (GC) For information on speaker system, please refer to the original Service Manual (Order No. MD0707005CE) for SB-PF660GC-K and Service Manual (Order No. MD0707006CE) for SB-WVK660GC-K. Notes: 1. Specifications are subject to changes without notice. Mass and dimensions are

15、approximate. 2. Total harmonic distortion is measured by the digital spectrum analyzer. 2 SA-VK660EE RadioFans.CN 收音机爱好者资料库 1 Safety Precautions 5 1.1. General Guidelines 5 1.2. Before Repair and Adjustment 5 1.3. Protection Circuitry 5 1.4. Safety Parts Information 6 2 Precaution of Laser Diode 7

16、CONTENTS Page Page 3 SA-VK660EE RadioFans.CN 收音机爱好者资料库 3 Prevention of Electro Static Discharge (ESD) to Electrostatically Sensitive (ES) Devices 7 4 About Lead-Free Solder (PbF) 9 4.1. Service caution based on legal restrictions 9 5 Handling Precautions for Traverse Unit 10 5.1. Handling Optical P

17、ickup 10 5.2. Replacing Precautions for Optical Pickup Unit 10 5.3. Grounding for Preventing Electrostatic Destruction 10 6 Accessories 11 7 Operation Procedures 12 7.1. Main Unit Operation Control 12 7.2. Remote Control Operation Control 13 7.3. Disc Information 14 7.4. DivX VOD Content 16 8 DVD/CD

18、 Mechanism Changer Unit 17 8.1. CRS1D Mechanism Overview 17 8.2. Music Port 20 9 Self diagnosis and special mode setting 21 9.1. Service Mode Summary Table 21 9.2. Service Mode Table 21 9.3. Optical Pick-up Breakdown Diagnosis 31 9.4. DVD Self-Diagnostic Function Error Code 33 9.5. Sales Demostratio

19、n Lock Function 39 9.6. Service Precautions 39 10 Assembling and Disassembling 41 10.1. Caution 41 10.2. Disassembly flow chart 43 10.3. Main Parts Location 44 10.4. Disassembly of Top Cabinet 45 10.5. Disassembly of DVD/CD Mechanism Changer Unit 45 10.6. Disassembly of Rear Panel 46 10.7. Disassemb

20、ly of Main P.C.B. 46 10.8. Disassembly of SMPS P.C.B. 47 10.9. Disassembly of D-Amp P.C.B. 48 10.10. Disassembly of Front Panel Unit 49 10.11. Disassembly for Mic P.C.B. 50 10.12. Disassembly for Panel P.C.B. 50 10.13. Disassembly of Tact Switch P.C.B. 50 10.14. Disassembly of Deck mechanism unit 51

21、 10.15. Disassembly of Deck P.C.B. 51 10.16. Disassembly for Deck Mechanism 52 10.17. Disassembly of Traverse Unit 54 10.18. Disassembly of DVD Module P.C.B. 56 10.19. Disassembly of Deck Mechanism P.C.B. 56 10.20. Replacement for cassette lid 56 10.21. Rectification for tape jam problem 57 11 Servi

22、ce Positions 58 11.1. Checking and Repairing of Main P.C.B. 58 11.2. Checking and Repairing of SMPS P.C.B. 58 11.3. Checking and Repairing of Panel P.C.B. 59 11.4. Checking and Repairing of D-Amp P.C.B., Deck P.C.B. QZZCWAT 12.1.1. Head Azimuth Adjustment (Deck 1/2) Caution: Please replace both azim

23、uth adjustment screw and springs simultaneously when readjusting the head azimuth. (shown in Fig. 2) Even if you wish to readjust the head azimuth without replacing the acrews and springs, a fine adjustment to the azimuth screw and spring. Please remove the screw-locking bond left on the head base w

24、hen replacing the azimuth screw. If you wish to readjust the head azimuth, be sure to adjust with adhering the cassette tape closely to the mechanism by pushing the center of cassette tape with your finger. (shown in Fig. 3) 1. Playback the azimuth adjustment portion (8 kHz, -20dB) of the test tape

25、(QZZCFM) in the forward play mode. Vary the azimuth adjustment screw until the output of the R-CH (PB OUT-R) are maximized. 2. Perform the same adjustment in the reverse play mode. 3. After the adjustment, apply screwlock to the azimuth adjusting screw. 12.1.2. Tape Speed Adjustment (Deck 1/2) 1. Se

26、t the tape edit button to “NORMAL” position. 2. Insert the test tape (QZZCWAT) to DECK 2 and playback (FWD side) the middle portion of it. 3. Adjust Motor VR (DECK 2) for the output value shown below. Adjustment target: 2940 3060 Hz (NORMAL speed) 4. After alignment, assure that the output frequency

27、 of the DECK 1 FWD are within 60 Hz of the value of the output frequency of DECK 2 FWD. Fig. 1 12.1.3. Bias Voltage Check 1. Set the unit “AUX” position. 2. Insert the Normal blank tape (QZZCRA) into DECK 2 and the unit to “REC” mode (usekey). 3. Measure and make sure that the output is within the s

28、tandard value. Bias voltage for Deck 2144mV (Normal) Fig. 2 Fig. 3 12 Adjustment Procedures 61 SA-VK660EE 12.1.4. Bias Frequency Adjustment (Deck 1/2) 1. Set the unit to “AUX” position. 2. Insert the Normal blank tape (QZZCRA) into DECK 2 and set the unit to “REC” mode (usekey). 3. Adjust L1002 so t

29、hat the output frequency is within the standard value. Standard Value: 89 110 kHz 1. Connect the instrument as shown in Fig. 5. 2. Set the unit to AM mode. 3. Apply signal as shown in Fig. 5 from AM-SG. 4. Adjust Z2602 so that the output frequency is maximized in Fig. 6. Fig. 5 Fig. 6 12.2.2. AM RF

30、Adjustment 1. Connect the instrument as shown in Fig. 7. 2. Set the unit to AM mode. 3. Set AM-SG to 520kHz. 4. Receive 520kHz in the unit. 5. Adjust L2601 (OSC) so that the EVM-AC is maximized. 6. Set AM-SG to 600Hz. 7. Receive 600Hz in the unit. 8. Adjust L2601 (ANT) so that the EVM-SG is maximize

31、d. 9. Set AM-SG to 520kHz. 10. Receive 520kHz in the unit. 11. Adjust L2602 (OSC) so that the EVM-DC value is with 1.10.5V. Fig. 4 Fig. 7 12.2. Tuner Section 12.2.1. AM-IF Alignment 62 SA-VK660EE 12.3.1. Cassette Deck Section 12.3. Alignment Points 63 SA-VK660EE 13 Illustration of ICs, Transistors a

32、nd Diodes ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ?

33、? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? 64 SA-VK660EE 14 Voltage and Waveform Chart Note: Circuit voltage and waveform described herein shall be regarded as reference information when probing defect point, because it may

34、 differ from an actual measuring value due to difference of Measuring instrument and its measuring condition and product itself. 14.1. DVD Module P.C.B. Ref No. MODE1234567891011121314151617181920 CD PLAY1.30.91.51.203.41.31.203.4111.11.803.41.31.501.3 Ref No. MODE21222324252627282930313233343536373

35、83940 CD PLAY1.812.20.51.92.21.21.11.51.43.403.40.71.91212.11.9 Ref No. MODE4142434445464748495051525354555657585960 CD PLAY2.21.801.303.43.43.43.3003.41.92.733.33.32.900 Ref No. MODE6162636465666768697071727374757677787980 CD PLAY0000.90.11.91.703.43.33.43.43.40000000 Ref No. MODE818283848586878889

36、90919293949596979899100 CD PLAY001.23.30.92.401.900.41.83.31.41.41.81.91.71.71.71.7 Ref No. MODE101102103104105106107108109110111112113114115116117118119120 CD PLAY000.40.10.21.93.302.31.72.72.72.72.72.72.72.52.52.52.5 Ref No. MODE121122123124125126127128129130131132133134135136137138139140 CD PLAY1

37、.921.71.701.71.73.41.90.90.43.32.4112.400.40.90 Ref No. MODE141142143144145146147148149150151152153154155156157158159160 CD PLAY3.43.400.1003.41.61.71.70.91.703.41.51.601.333 Ref No. MODE161162163164165166167168169170171172173174175176177178179180 CD PLAY2.93.12.93.103.43.23.1333.1303.43.2032.92.72.

38、7 Ref No. MODE181182183184185186187188189190191192193194195196197198199200 CD PLAY3.301.63.41.601.33.33.23.23.301.9003.41.70.101.5 Ref No. MODE201202203204205206207208209210211212213214215216 CD PLAY1.51.70.203.41.70.21.61.601.32.62.22.20.90.9 Ref No. MODE1234567891011121314151617181920 CD PLAY3.42.

39、93.43.13.103.13.33.43302.93.42.73.33.33.23.21.9 Ref No. MODE2122232425262728293031323334353637383940 CD PLAY1.700.10.20.21.63.401.61.61.61.50.100-3.41.62.7- Ref No. MODE4142434445464748495051525354 CD PLAY02.93.43.13.1033.13.42.92.9030 Ref No. MODE1234567812345 CD PLAY3.4-0.1-4.4-4.72.52.501.30.8 Re

40、f No. MODE12345678910 CD PLAY1.71.71.72.42.4205.13.30 Ref No. MODE1112131415161718192021222324252627282930 CD PLAY2.62.62.62.65.65.64.94.90011.511.51.71.71.71.705.100 Ref No. MODE12345678910111213141516 CD PLAY03.32.93.31.60.91.71.7-5.202.62.52.55.1 Ref No. MODE12341234512345678 CD PLAY3.31.3003.33.

41、400-00003.43.403.4 Ref No. MODE1234567891011121314151617181920 CD PLAY0.92.10.51.72.21.11.11.41.403.43.33.43.40.70.71.8121 Ref No. MODE2122232425262728293031323334353637383940 CD PLAY23.42.21.82.62.202.21.10.91.50.81.61.21.31.33.41.80.91.1 Ref No. MODE41424344454647481234512345 CD PLAY1.21.31.61.41.

42、503.41.73304.65.12.72.704.15.1 Ref No. MODEECBECBECBECBECB CD PLAY1.100.41.500.91.100.41.600.91.500.9 Ref No. MODEECBECBECBECB CD PLAY0.14.60.10.14.64.61.93.51.3 3.54.14.1 Ref No. MODE123456ECBECB CD PLAY0.10.11.4 0.1 0.14.400.14.03.43.30.1 IC8420 IC8601IC8606IC8611 SA-VK660EE DVD MODULE P.C.B. IC86

43、91IC8695IC8651 Q8321 IC8051 IC8001 IC8001 IC8001 IC8001 IC8001 IC8051 IC8001 IC8001 IC8651 IC8651 Q8341 Q8551 IC8251 IC8251 IC8111 IC8051 IC8151 IC8001 IC8001 IC8001 IC8001 QR8420QR8571 Q8325Q8331Q8335 Q8561Q8562Q8552 QR8111 65 SA-VK660EE 14.2. Main P.C.B. Ref No. MODE1234567891011121314151617181920

44、 CD PLAY4.64.64.54.64.54.54.54.54.54.54.54.54.54.54.604.909.13.4 STANDBY4.64.64.64.64.54.54.54.54.54.54.54.54.54.54.604.909.13.4 Ref No. MODE212223242526272829303132 CD PLAY4.64.64.64.64.64.64.64.64.64.64.64.6 STANDBY4.64.64.64.64.64.64.64.64.64.64.64.6 Ref No. MODE1234567812345 CD PLAY0.100-3.8000.

45、13.815.75.2013.9 STANDBY0.100-3.8000.13.815.95.2013.9 Ref No. MODE12345678 CD PLAY0.10.10.1-90009.1 STANDBY0.10.10.1-90009.1 Ref No. MODE12345678910111213141516 CD PLAY5.22.12.31.65.21.602.12.102.12.11.51.51.52.1 STANDBY5.22.12.31.65.21.602.12.102.12.11.51.51.52.1 Ref No. MODE1234567891011121314151617181920 CD PLAY2.62.62.62.62.602.62.62.62.62.62.62.62.62.62.60.60.60.62.6 STANDBY2.62.62.62.62.602.62.62.62.62.62.62.62.62.62.60.60.60.62.6 Ref No. MODE2122232425262728293031323334353637383940 CD PLAY2.62.605.200001.45.1000000002.62.6 STANDBY2.62.605.20