Sony-TAFE600R-int-sm 电路图 维修手册.pdf

《Sony-TAFE600R-int-sm 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Sony-TAFE600R-int-sm 电路图 维修手册.pdf（20页珍藏版）》请在收音机爱好者资料库上搜索。

1、 1 MICROFILM AEP ModelSERVICE MANUAL TA-FE600R SPECIFICATIONS INTEGRATED STEREO AMPLIFIER +0 3 RadioFans.CN 收音机爱 好者资料库 2 TABLE OF CONTENTS 1. GENERAL .3 2. ELECTRICAL ADJUSTMENT.4 3. DIAGRAMS 3-1.Circuit Boards Location .5 3-2.IC Pin Function IC902 Input Control LED Driver (TMP47C103N-JP47) .6 3-3.S

2、chematic Diagram Panel Section .7 3-4.Printed Wiring Board Panel Section .9 3-5.Schematic Diagram Main Section .12 3-6.Printed Wiring Board Main Section .15 4. EXPLODED VIEWS 4-1.Front Panel Section .19 4-2.Chassis Section.20 5. ELECTRICAL PARTS LIST .21 SAFETY-RELATED COMPONENT WARNING ! COMPONENTS

3、 IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. RadioFans.CN 收音机爱 好者资料库 3 SECTION 1 GENERAL

4、 This section is extracted from instruction manual. LOCATION OF PARTS AND CONTROLS FRONT PANEL 1 POWER switch 2 INPUT SELECTOR indicator 3 SUBSONIC switch 4 EON LINK switch 5 EON LINK indicator 6 VOLUME control 7 SOURCE DIRECT indicator 8 SOURCE DIRECT switch 9 INPUT SELECTOR control 0 TAPE 1 MONITO

5、R indicator ! TAPE 1 MONITOR switch ! LOUDNESS switch ! BALANCE control ! TONE (BASS, TREBLE) control ! SPEAKERS selector ! Remote control sensor ! PHONES jack REAR PANEL 1 23 4 5 6 790! ! 5 467890! 123 RadioFans.CN 收音机爱 好者资料库 4 SECTION 2 ELECTRICAL ADJUSTMENT Bias Adjustment 1. Rotate fully the bia

6、s adjusting semi-fixed resistors (RV301, RV351) to the MIN position (counterclockwise). 2. Connect a digital voltmeter to the CN406 and CN407. 1 pin3 pin + + CN406 CN407 3. Set the slide regulator to 0V, and press the POWER button (ON) on the set. 4. Raise gradually the slide regulator voltage up to

7、 the rated volt- age (230 V). 5. At this time, confirm that the SP relay is turned on (it will click). 6. Adjust the RV301 and RV351 so that a reading of digital voltmeter is 10 mV to 15 mV. 7. Return the slidack to 0 V, and press the POWER button (OFF) on the set. Adjustment Location : MAIN A BOARD

8、 COMPONENT SIDE C322C372 RV351 RV301 BIAS Adjustment Test Point Location : MAIN B BOARD COMPONENT SIDE CN406 13 C409C459 CN407 13 + + DIGITAL VOLTMETER DIGITAL VOLTMETER 5 SECTION 3 DIAGRAMS 3-1. CIRCUIT BOARDS LOCATION MAIN B board TRANS board PANEL board LED board MAIN A board INPUT board OUTLET b

9、oard PRO IND board HP board SP SW board EON board VOL board SP TM board 6 I/OFunction IC902 Input Control LED Drive (TMP47C103N-JP47) Pin No. 3-2. IC PIN FUNCTION Pin Name O I I I O O I I I I O O O O O O O O I I I O O O O I 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 X

10、 OUT X IN RESET PMD VOL + VOL SW 0 SW 1 SW 2 EON PHONO TUNER CD GND AUX DAT TAPE MON PRY PKY MON SIRCS MUTE SCE SDT SCK STOP +3V System clock. (4MHz) Reset input. Mode select input. Motor drive output (+). Motor drive output (). Rotary switch input (CD). Rotary switch input (TUNER). Rotary switch in

11、put (PHONO). EON signal input. PHONO LED drive output. TUNER LED drive output. CD LED drive output. Ground. AUX LED drive output. TAPE “2” LED drive output. TAPE “1” LED drive output. MONITOR output. Power relay output. Power key input. MONITOR input. SIRCS input. Muting output. Chip enble output. S

12、erial data output. Serial clock output. STOP input. +3V Power supply. 19 SECTION 4 EXPLODED VIEWS NOTE: -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be a

13、nticipated when ordering these items. The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and pack- ing materials are given in the last of this parts list. Abbreviation G: German model The components identified by mark ! or dot

14、ted line with mark ! are critical for safety. Replace only with part number speci- fied. Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 1X-4946-920-1KNOB (VOL) ASSY 2X-4947-025-1FOOT ASSY 34-980-766-21PANEL, FRONT 44-980-775-01LENS, LED 54-980-771-01KNOB (DIA. 47) (SELECTOR) 64-9

15、80-204-01KNOB (DIA. 24) (TONE) 74-965-651-01EMBLEM (MOS) 84-979-587-01EMBLEM, SONY 9X-4946-923-1PANEL ASSY, BASE 104-980-773-01BUTTON (DIA. 6) (EON) * 111-660-566-11EON BOARD 124-980-776-01WINDOW, REMOTE CONTROL * 131-662-376-11HP BOARD * 141-660-562-11LED BOARD * 15A-4389-795-A PANEL BOARD, COMPLET

16、E * 161-660-565-11VOL BOARD * 171-660-564-11SP SW BOARD 184-980-199-01BUTTON (POWER) * 191-660-567-11PRO IND BOARD 203-704-366-01SCREW (CASE) (M3X8) 214-979-945-41CASE (412032) 224-967-961-01SCREW (3X8) 234-951-620-01SCREW (2.6X8), +BVTP 247-682-548-04SCREW +BVTT 3X8 (S) !S11-554-920-11SWITCH, PUSH

17、(AC POWER)(1 KEY)(POWER) 4-1. FRONT PANEL SECTION 1 2 2 3 4 4 4 6 7 8 9 10 10 11 12 13 14 15 16 17 18 19 20 20 20 21 23 23 23 23 23 24 24 22 22 22 22 22 5 Supplied with RV203 Supplied with S901 not supplied not supplied not supplied S1 24 Supplied with J701 not supplied Supplied with RV200, RV201, R

18、V203 20 4-2. CHASSIS SECTION 51 52 52 51 51 51 51 51 51 51 51 54 55 56 57 59 60 60 60 61 63 F801 F802 T1 Q406B Q403 Q454 Q404 CNP801 CNJ801 CNJ802 CNJ803 not supplied not supplied 62 not supplied Q453 58 57 64 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark The components identifi

19、ed by mark ! or dotted line with mark ! are critical for safety. Replace only with part number speci- fied. !CNJ801 1-526-794-11OUTLET, AC (AC OUTLET SWITCHED 100W MAX) !CNJ802 1-526-794-11OUTLET, AC (AC OUTLET SWITCHED 100W MAX) !CNJ803 1-526-794-11OUTLET, AC (AC OUTLET SWITCHED 100W MAX) !CNP801 1

20、-777-185-11CORD, POWER !F8011-532-388-51FUSE, TIME LAG (2.0A 250V) !F8021-532-464-51FUSE, TIME LAG (2.5A 250V) Q4038-729-232-45TRANSISTOR 2SK1529-Y Q4048-729-232-46TRANSISTOR 2SJ200-Y Q4538-729-232-45TRANSISTOR 2SK1529-Y Q4548-729-232-46TRANSISTOR 2SJ200-Y Q406B8-729-209-15TRANSISTOR 2SD2012 !T11-42

21、9-492-11TRANSFORMER, POWER 514-967-961-01SCREW (3X8) 524-967-960-01SCREW (4X8) * 53A-4389-792-A MAIN A BOARD, COMPLETE * 541-660-563-11INPUT BOARD * 551-660-573-11OUTLET BOARD * 564-980-768-21PANEL, BACK 573-905-609-11SCREW (TRANSISTOR) * 58A-4389-793-A MAIN B BOARD, COMPLETE 594-947-010-01SCREW, FE

22、EDER FIXED 604-981-016-01SCREW (H) * 613-703-244-00BUSHING (2104), CORD * 621-660-571-11SP TM BOARD * 631-660-574-11TRANS BOARD 643-704-515-41SCREW (BV/RING) 53 not supplied not supplied 21 Note: Due to standardization, replacements in the parts list may be different from the parts specified in the

23、dia- grams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked “*” are not stocked since they are sel- dom required for routine service. Some delay should be anticipated when ordering these items. RESISTORS All resi

24、stors are in ohms METAL: Metal-film resistor METAL OXIDE: Metal Oxide-film resistor F : nonflammable SEMICONDUCTORS In each case, u: , for example: uA.: A., uPA.: PA., uPB.: PB., uPC.: PC., uPD.: PD. CAPACITORS uF : F COILS uH : H Abbreviation G: German model The components identified by mark ! or d

25、otted line with mark ! are critical for safety. Replace only with part number speci- fied. SECTION 5 ELECTRICAL PARTS LIST When indicating parts by reference number, please include the board name. IC1018-759-805-13IC LC7821 * J1011-573-142-11JACK, PIN 4P (INPUT TUNER,PHONO) * J1021-573-142-21JACK, P

26、IN 4P (INPUT AUX,CD) * J1031-573-142-21JACK, PIN 4P (TAPE 1/DAT REC OUT,IN) * J1041-573-142-21JACK, PIN 4P (TAPE 2/MD REC OUT,IN) Q9248-729-620-05TRANSISTOR 2SC2603-EF Q9258-729-620-05TRANSISTOR 2SC2603-EF Q9268-729-620-05TRANSISTOR 2SC2603-EF R1011-249-995-11CARBON1M5%1/4W R1021-249-995-11CARBON1M5

27、%1/4W R1031-249-995-11CARBON1M5%1/4W R1041-247-713-11CARBON1K5%1/4W R1051-249-995-11CARBON1M5%1/4W R1061-247-713-11CARBON1K5%1/4W R1071-249-995-11CARBON1M5%1/4W R1101-249-995-11CARBON1M5%1/4W R1111-249-995-11CARBON1M5%1/4W R1511-249-995-11CARBON1M5%1/4W R1521-249-995-11CARBON1M5%1/4W R1531-249-995-1

28、1CARBON1M5%1/4W R1541-247-713-11CARBON1K5%1/4W R1551-249-995-11CARBON1M5%1/4W R1561-247-713-11CARBON1K5%1/4W R1571-249-995-11CARBON1M5%1/4W R1601-249-995-11CARBON1M5%1/4W R1611-249-995-11CARBON1M5%1/4W R9451-249-429-11CARBON10K5%1/4W R9461-249-429-11CARBON10K5%1/4W R9471-249-429-11CARBON10K5%1/4W R9

29、571-249-425-11CARBON4.7K5%1/4W RY1011-515-614-11RELAY * Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark *1-660-566-11EON BOARD * CN9521-691-766-11PLUG (MICRO CONNECTOR) 4P D9018-719-313-72DIODE SEL3810A-CD (EON LINK) R9011-249-397-11CARBON225%1/4W S9021-571-112-21SWITCH, PUSH (1 K

30、EY) (EON LINK) * *1-662-376-11HP BOARD * J7011-750-735-11JACK (LARGE TYPE) (PHONES) * *1-660-563-11INPUT BOARD * C9501-162-294-31CERAMIC0.001uF10%50V C9521-164-159-11CERAMIC0.1uF50V C9531-164-159-11CERAMIC0.1uF50V C9601-126-963-11ELECT4.7uF20%50V CN161-564-320-00PIN,CONNECTOR (B2P-VH)2P CN2001-691-7

31、66-11PLUG (MICRO CONNECTOR) 4P CN9041-691-773-11PLUG (MICRO CONNECTOR) 11P D9508-719-987-63DIODE 1N4148M D9518-719-987-63DIODE 1N4148M INPUTEONHP 22 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark *1-660-562-11LED BOARD * CNJ902 1-766-796-11CONNECTOR, BOARD TO BOARD 12P D6008-719-

32、313-72DIODE SEL3810A-CD (SOURCE DIRECT) D6018-719-313-72DIODE SEL3810A-CD (TAPE 1/DAT) D6028-719-313-72DIODE SEL3810A-CD (TAPE 2/MD) D6038-719-313-72DIODE SEL3810A-CD (AUX) D6048-719-313-72DIODE SEL3810A-CD (CD) D6058-719-313-72DIODE SEL3810A-CD (TUNER) D6068-719-313-72DIODE SEL3810A-CD (PHONO) D607

33、8-719-313-72DIODE SEL3810A-CD (TAPE 1 MONITOR) R9261-247-751-11CARBON8205%1/2W R9401-249-414-11CARBON5605%1/4W S2031-554-303-21SWITCH, TACTILE (TAPE 1 MONITOR) * *A-4389-792-A MAIN A BOARD, COMPLETE * C3011-102-978-00CERAMIC220PF5%50V C3021-126-059-11ELECT10uF20%50V C3041-106-359-00MYLAR4700PF5%200V

34、 C3051-136-162-00FILM0.056uF5%50V C3061-137-471-11FILM0.016uF5%50V C3071-126-059-11ELECT10uF20%50V C3081-126-022-11ELECT47uF20%25V C3091-126-013-11ELECT1000uF20%16V C3101-126-023-11ELECT100uF20%25V C3111-102-973-00CERAMIC100PF5%50V C3121-126-059-11ELECT10uF20%50V C3131-164-079-11CERAMIC330PF10%50V C

35、3151-102-230-00CERAMIC4PF0.25PF 500V C3161-126-023-11ELECT100uF20%16V C3171-126-023-11ELECT100uF20%16V C3181-126-023-11ELECT100uF20%16V C3191-126-023-11ELECT100uF20%16V C3201-110-392-11ELECT47uF20%63V C3211-164-040-11CERAMIC4PF0.25PF 50V C3221-126-056-11ELECT1000uF20%50V C3511-102-978-00CERAMIC220PF

36、5%50V C3521-126-059-11ELECT10uF20%50V C3541-106-359-00MYLAR4700PF5%200V C3551-136-162-00FILM0.056uF5%50V C3561-137-471-11FILM0.016uF5%50V C3571-126-059-11ELECT10uF20%50V C3581-126-022-11ELECT47uF20%25V C3591-126-013-11ELECT1000uF20%16V C3601-126-023-11ELECT100uF20%25V C3611-102-973-00CERAMIC100PF5%5

37、0V C3621-126-059-11ELECT10uF20%50V C3631-164-079-11CERAMIC330PF10%50V C3651-102-230-00CERAMIC4PF0.25PF 500V C3661-126-023-11ELECT100uF20%16V C3671-126-023-11ELECT100uF20%16V C3681-126-023-11ELECT100uF20%16V C3691-126-023-11ELECT100uF20%16V C3701-110-392-11ELECT47uF20%63V C3711-164-040-11CERAMIC4PF0.

38、25PF 50V C3721-126-056-11ELECT1000uF20%50V CN3011-691-769-11PLUG (MICRO CONNECTOR) 7P CN3021-691-765-11PLUG (MICRO CONNECTOR) 3P D3018-719-310-60DIODE SEL1510C-C D3028-719-933-88DIODE HZS16-2L D3038-719-933-41DIODE HZS6C3L D3048-719-987-63DIODE 1N4148M D3058-719-987-63DIODE 1N4148M D3068-719-310-60D

39、IODE SEL1510C-C D3078-719-987-63DIODE 1N4148M D3088-719-987-63DIODE 1N4148M D3098-719-987-63DIODE 1N4148M D3518-719-310-60DIODE SEL1510C-C D3528-719-933-88DIODE HZS16-2L D3538-719-933-41DIODE HZS6C3L D3548-719-987-63DIODE 1N4148M D3558-719-987-63DIODE 1N4148M D3568-719-310-60DIODE SEL1510C-C D3578-7

40、19-987-63DIODE 1N4148M D3588-719-987-63DIODE 1N4148M D3598-719-987-63DIODE 1N4148M IC3018-759-636-74IC M5218AP-22 L3011-411-925-11COIL, AIR-CORE L3511-411-925-11COIL, AIR-CORE Q3018-729-281-54TRANSISTOR 2SC1815-BL LEDMAIN A 23 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark Q3028-

41、729-281-54TRANSISTOR 2SC1815-BL Q3038-729-281-54TRANSISTOR 2SC1815-BL Q3048-729-620-17TRANSISTOR 2SC2259-FG Q3058-729-201-53TRANSISTOR 2SA1015-GR Q3068-729-201-53TRANSISTOR 2SA1015-GR Q3078-729-201-53TRANSISTOR 2SA1015-GR Q3088-729-021-74TRANSISTOR 2SA949-OY-TPE6 Q3098-729-202-67TRANSISTOR 2SK246-GR

42、3 Q3108-729-021-73TRANSISTOR 2SC2229-OY-TPE6 Q3118-729-281-54TRANSISTOR 2SC1815-BL Q3128-729-281-54TRANSISTOR 2SC1815-BL Q3518-729-281-54TRANSISTOR 2SC1815-BL Q3528-729-281-54TRANSISTOR 2SC1815-BL Q3538-729-201-53TRANSISTOR 2SA1015-GR Q3548-729-620-17TRANSISTOR 2SC2259-FG Q3558-729-201-53TRANSISTOR

43、2SA1015-GR Q3568-729-201-53TRANSISTOR 2SA1015-GR Q3578-729-201-53TRANSISTOR 2SA1015-GR Q3588-729-021-74TRANSISTOR 2SA949-OY-TPE6 Q3598-729-202-67TRANSISTOR 2SK246-GR3 Q3608-729-021-73TRANSISTOR 2SC2229-OY-TPE6 Q3618-729-281-54TRANSISTOR 2SC1815-BL Q3628-729-281-54TRANSISTOR 2SC1815-BL R3011-259-215-

44、21CARBON100K5%1/4W R3021-249-911-11CARBON3305%1/4W R3031-259-215-21CARBON100K5%1/4W R3041-249-900-11CARBON1101%1/4W R3051-259-161-21CARBON5605%1/4W R3061-259-161-21CARBON5605%1/4W R3071-259-143-21CARBON1005%1/4W R3081-259-191-21CARBON10K5%1/4W R3091-249-844-11CARBON56K1%1/2W R3101-249-818-11CARBON4.

45、7K1%1/2W R3111-259-167-21CARBON1K5%1/4W R3131-249-943-11CARBON6.8K5%1/4W R3141-249-198-11CARBON3305%1/3W R3151-249-198-11CARBON3305%1/3W R3161-249-198-11CARBON3305%1/3W R3171-249-198-11CARBON3305%1/3W R3181-259-167-21CARBON1K5%1/4W R3191-259-151-21CARBON2205%1/4W R3201-259-151-21CARBON2205%1/4W R321

46、1-259-151-21CARBON2205%1/4W R3221-259-215-21CARBON100K5%1/4W R3231-259-179-21CARBON3.3K5%1/4W R3241-249-931-11CARBON2.2K5%1/4W R3251-259-444-11CARBON4.7K5%1/6W R3261-249-490-11CARBON27K5%1/3W R3271-259-151-21CARBON2205%1/4W R3281-259-151-21CARBON2205%1/4W R3291-249-899-11CARBON1005%1/4W R3301-247-749-11CARBON5605%1/2W R3311-249-496-11CARBON100K5%1/3W R3321-259-171-21CARBON1.5K5%1/4W R3331-259-167-21CARBON1K5%1/4W R3341-124-995-11CARBON1M5%1/4W R3351-259-143-21CARBON1005%1/4W R3511-259-215-21CARBON100K5%1/4W R3521-249-911-11CARBON3305